English dropdown-ico

Manual Alto-Shaam ASC-4G

30 pages 2.13 mb
Download

Go to site of 30

Summary
  • Alto-Shaam ASC-4G - page 1

    W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONE: 262.251.3800 • 800.558.8744 USA / CANADA FAX: 262.251.7067 • 800.329.8744 U . S . A . ONLY www.alto-shaam.com M odel: ASC-4G Electronic Control Convection Oven Gas   • InstallatIon  • operatIon • MaIntenance MN-28663 • 01/11 p ...

  • Alto-Shaam ASC-4G - page 2

    i Delivery .................................. 1 Unpacking ................................ 1 Safety Procedures and Precautions ............. 2 Installation Site Installation .......................... 3 Clearance Requirements .................. 3 Installation Requirements .................. 4 Leveling ............................... 4 Dimension Dra ...

  • Alto-Shaam ASC-4G - page 3

    ASC-4G Gas Convection Oven - Electronic Control • 1 DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportation Damage and Claims section located in this manu ...

  • Alto-Shaam ASC-4G - page 4

    ASC-4G Gas Convection Oven - Electronic Control • 2 CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Used to indicate the presence of a hazard that can or will cause minor or moderate personal ...

  • Alto-Shaam ASC-4G - page 5

    ASC-4G Gas Convection Oven - Electronic Control • 3 INSTALLATION DANGER IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATH, OR CAUSE PROPERTY DAMAGE. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT. CAUTION DO NOT LIFT O ...

  • Alto-Shaam ASC-4G - page 6

    ASC-4G Gas Convection Oven - Electronic Control • 4 INSTALLATION INSTALLATION MINIMUM 6 INCH CLEARANCES FROM COMBUSTIBLES AND NON-COMBUSTIBLES Ne pas installer à une distance inférirure à celle indiquée ci-dessous d'une paroi en matiére combustible: Côtés 6 pouches, Arriére 6 pouches FOR USE ONL Y ON NON-COMBUSTIBLE FLOORS. Doit êtr ...

  • Alto-Shaam ASC-4G - page 7

    ASC-4G Gas Convection Oven - Electronic Control • 5 GAS SUPPLY & INSTALLATION GAS SUPPLY & INSTALLATION GAS PRESSURE CHART The gas valve and burner have been fitted according to the gas type specified on the identification name plate. DANGER CONNECTING TO THE WRONG GAS SUPPLY COULD RESULT IN FIRE OR AN EXPLOSION CAUSING SEVERE INJURY AND ...

  • Alto-Shaam ASC-4G - page 8

    ASC-4G Gas Convection Oven - Electronic Control • 6 GAS SUPPLY & INSTALLATION GAS REQUIREMENTS The gas inlet is located at the back of the oven. Code requires the installation of a manual gas shutoff valve to be installed in the gas line ahead of the oven. This oven is also equipped with fixed burner orifices determined by the elevation speci ...

  • Alto-Shaam ASC-4G - page 9

    ASC-4G Gas Convection Oven - Electronic Control • 7 GAS SUPPLY & INSTALLATION GAS CONNECTION � FOR OVENS ON CASTERS The oven must be supplied with a flexible connector that complies with The Standard for Connectors for Movable Gas Appliances, ANSI Z21.69, CGA 6.16 and addenda Z21.69a (latest editions). A quick disconnect device must be inst ...

  • Alto-Shaam ASC-4G - page 10

    ASC-4G Gas Convection Oven - Electronic Control • 8 INSTALLATION This appliance is equipped with a three-prong grounding plug. For your protection against shock hazard this appliance should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug. Plug the unit into a properly gr ...

  • Alto-Shaam ASC-4G - page 11

    ASC-4G Gas Convection Oven - Electronic Control • 9 INSTALLATION VENTILATION VENTILATION HOODS Proper venting along with a sufficient quantity of make-up air is essential for proper oven operation. A mechanically driven, canopy exhaust hood is the preferred method of ventilation and must conform to local codes along with the current version of NF ...

  • Alto-Shaam ASC-4G - page 12

    ASC-4G Gas Convection Oven - Electronic Control • 10 INSTALLATION CAUTION TO PREVENT PERSONAL INJURY, USE CAUTION WHEN MOVING OR LEVELING THIS APPLIANCE. STACKING KIT (5005783) STACKING INSTRUCTIONS A) Remove side panels. B) Knock out the mounting holes on top of the intended bottom oven. C) After legs or casters have been installed on the bottom ...

  • Alto-Shaam ASC-4G - page 13

    ASC-4G Gas Convection Oven - Electronic Control • 11 INSTALLATION STACKING, GAS PLUMBING & FLUE INTERCONNECT (5003788) 7 8 1 2 3 4 5 6 Rev 04/09 ASSEMBLY INSTRUCTIONS FIRST: Assemble plumbing items 2 thru 6 as shown NEXT: Assemble items 7, 8, & 1 as shown ITEM DESCRIPTION PART NO. QTY 1 SCREW, #10 SMS .5LG SC-26520 24 2 ELBOW 90 DEG STREE ...

  • Alto-Shaam ASC-4G - page 14

    ASC-4G Gas Convection Oven - Electronic Control • 12 INSTALLATION 8 1 1 7 3 4 2 9 1 2 34-5/16" (876mm) 5 6 2 38" (956mm) OVEN STAND ASSEMBLY ITEM DESCRIPTION PART NO. QTY 1 LEG SUPPORT ASSEMBLY 5003488 2 2 CHANNEL, SUPPORT 1004459 2 3 LEG LG-22185 4 *CASTERS, RIGID CS-25674 2 *CASTERS, SWIVEL W/BRAKE CS-25675 2 4 BRACKET, STAND 1004461 ...

  • Alto-Shaam ASC-4G - page 15

    OPERATING INSTRUCTIONS ASC-4G Gas Convection Oven - Electronic Control • 13 USER SAFETY INFORMATION The Platinum Series gas convection oven is intended for use in commercial establishments by qualified operating personnel where all operators are familiar with the purpose, limitations, and associated hazards of this appliance. Operating instructio ...

  • Alto-Shaam ASC-4G - page 16

    OPERATING INSTRUCTIONS ASC-4G Gas Convection Oven - Electronic Control • 14 START-UP OPERATION BEFORE INITIAL USE: Interior oven surfaces must be heated to remove surface oils and the accompanying odors produced during the first use of the oven. 1. Wipe all wire shelves, side racks and the full oven interior with a clean, damp cloth. 2. Close the ...

  • Alto-Shaam ASC-4G - page 17

    OPERATING INSTRUCTIONS ASC-4G Gas Convection Oven - Electronic Control • 15 1 3 5 6 9 M J O Q 4 7 8 P K R N L 1 PREHEAT INDICATOR B READY INDICATOR C LED DISPLAY D UP/DOWN ARROWS E COOK INDICATOR F TEMPERATURE INDICATOR G PROBE INDICATOR H PRESET INDICATOR I COOK KEY J PROBE KEY K TIME KEY L PRESET LOCK KEY M ? ...

  • Alto-Shaam ASC-4G - page 18

    OPERATING INSTRUCTIONS ASC-4G Gas Convection Oven - Electronic Control • 16 A. PRESS MAIN POWER R “ON.”  • Thedisplay 3 will alternate between last Cook Set Temperature and actual Cavity Temperature.  • Theoven willpreheat toprevious Cook  temperature, and the PREHEAT Indicator 1 will illuminat ...

  • Alto-Shaam ASC-4G - page 19

    OPERATING INSTRUCTIONS ASC-4G Gas Convection Oven - Electronic Control • 17 PROGRAMMING This Alto-Shaam electronic convection oven allows the operator to program up to seven cooking procedures. Each cooking program entered can be preset in any program function to cook by time (or probe, if a probe is included on the oven). Cooking programs are st ...

  • Alto-Shaam ASC-4G - page 20

    OPERATING INSTRUCTIONS ASC-4G Gas Convection Oven - Electronic Control • 18 Stop an Operation: Press Start/stop M Key. The oven will remain in a power-on state, and the operation will be cancelled. Press Cook 9 to set procedure again. Adding product after Start: If the door is opened during cook cycle, the heater, fan, and timer will disengage ...

  • Alto-Shaam ASC-4G - page 21

    ASC-4G Gas Convection Oven - Electronic Control • 19 CHEF OPERATING TIPS The Alto-Shaam convection oven will provide the best results and longest possible service with the utilization of the following suggestions and guidelines. NOTE : Moisture will escape around the doors when baking products with a heavy moisture content such as chicken, potato ...

  • Alto-Shaam ASC-4G - page 22

    CARE AND CLEANING ASC-4G Gas Convection Oven - Electronic Control • 20 PROTECTING STAINLESS STEEL SURFACES It is important to guard against corrosion in the care of stainless steel surfaces. Harsh, corrosive, or inappropriate chemicals can completely destroy the protective surface layer of stainless steel. Abrasive pads, steel wool, or metal impl ...

  • Alto-Shaam ASC-4G - page 23

    CARE AND CLEANING ASC-4G Gas Convection Oven - Electronic Control • 21 CLEAN THE OVEN ON A DAILY BASIS 1. After the oven has cooled, remove all detachable items such as wire shelves, side racks, and drip pan. Clean these items separately. 2. Remove any food scraps from shelves, shelf supports, and blower fan wheel. Convection baffle openings must ...

  • Alto-Shaam ASC-4G - page 24

    SERVICE ASC-4G Gas Convection Oven - Electronic Control • 22 Part numbers and drawings are subject to change without notice. Error Code Description Possible Cause E-10 Cavity air sensor shorted Cavity air sensor reading < 5°F. Verify sensor integrity. See sensor test instructions below. E-11 Cavity air sensor open Cavity air sensor reading &g ...

  • Alto-Shaam ASC-4G - page 25

    SERVICE ASC-4G Gas Convection Oven - Electronic Control • 23 Part numbers and drawings are subject to change without notice. SERVICE 2 3 4 5 7 6 12 11 14 9 10 8 18 19 13 1 15 16 17 ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 LATCH LT-26976 2 12 CORD CD-34094 1 2 DOOR ASSEMBLY, LH DR-27850 1 13 MODULAR BLOCK BK-34648 1 3 SIDE RAC ...

  • Alto-Shaam ASC-4G - page 26

    SERVICE ASC-4G Gas Convection Oven - Electronic Control • 24 Part numbers and drawings are subject to change without notice. INTERIOR OVEN COMPARTMENT ITEM DESCRIPTION PART NO. QTY 1 DOOR ASSEMBLY, LH DR-27850 1 2 BAFFLE, REAR 1004114 1 3 CONVECTION MOTOR 115V MO-34791 1 CONVECTION MOTOR ASSEMBLY 125V 5010354* 1 4 HEAT BOX 5033197 1 5 BLOWER WHEE ...

  • Alto-Shaam ASC-4G - page 27

    SERVICE ASC-4G Gas Convection Oven - Electronic Control • 25 Part numbers and drawings are subject to change without notice. LEG ASSEMBLY (5003784) 1 2 3 4 6 5 7 ITEM DESCRIPTION PART NO. QTY 1 SUPPORT, LEG, SIDE, ASSEMBLY 5009564 2 2 SUPPORT, LEG, REAR, ASSEMBLY 5009565 2 3 LEG ASSEMBLY, 25" LG-27829 4 4 NUT, 1/4-20 NYLON INSERT 18-8 S/S NU ...

  • Alto-Shaam ASC-4G - page 28

    SERVICE ASC-4G Gas Convection Oven - Electronic Control • 26 Part numbers and drawings are subject to change without notice. PARTS LIST P/N DESCRIPTION QTY EXTERIOR 1006623 PANEL, OUTER, SIDE/TOP ....................................... 1 1006671 PANEL, OUTER, RH .................................................. 1 1006672 PANEL, LOUVERED ACCESS . ...

  • Alto-Shaam ASC-4G - page 29

    ASC-4G Gas Convection Oven - Electronic Control • 27 ...

  • Alto-Shaam ASC-4G - page 30

    TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...

Manufacturer Alto-Shaam Category Oven

Documents that we receive from a manufacturer of a Alto-Shaam ASC-4G can be divided into several groups. They are, among others:
- Alto-Shaam technical drawings
- ASC-4G manuals
- Alto-Shaam product data sheets
- information booklets
- or energy labels Alto-Shaam ASC-4G
All of them are important, but the most important information from the point of view of use of the device are in the user manual Alto-Shaam ASC-4G.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Alto-Shaam ASC-4G, service manual, brief instructions and user manuals Alto-Shaam ASC-4G. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Alto-Shaam ASC-4G.

Similar manuals

A complete manual for the device Alto-Shaam ASC-4G, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Alto-Shaam ASC-4G by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Alto-Shaam ASC-4G.

A complete Alto-Shaam manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Alto-Shaam ASC-4G - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Alto-Shaam ASC-4G, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Alto-Shaam ASC-4G, that we can find in the current document
3. Tips how to use the basic functions of the device Alto-Shaam ASC-4G - which should help us in our first steps of using Alto-Shaam ASC-4G
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Alto-Shaam ASC-4G
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Alto-Shaam ASC-4G in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Alto-Shaam ASC-4G?

Use the form below

If you did not solve your problem by using a manual Alto-Shaam ASC-4G, ask a question using the form below. If a user had a similar problem with Alto-Shaam ASC-4G it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)