English dropdown-ico

Manual hussman Q1-DC

35 pages 2.41 mb
Download

Go to site of 35

Summary
  • hussman Q1-DC - page 1

    Q1-DC DELI SERVICE CASE P/N Q1-DC-0508 INST ALLA TION & OPERA TION GUIDE /CHINO Q1-DC DELI SERVICE CASE REV . 0508 Installation & Operation Manual ...

  • hussman Q1-DC - page 2

    Q1-DC-0508 2 /CHINO A publication of HUSSMANN ® Chino 13770 Ramona Avenue • Chino, California 91710 (909) 628-8942 F AX (909) 590-4910 (800) 395-9229 Keep this booklet with the case at all times for future reference. General Instructions T able of Contents General Instructions..................................................... 2 Cut and Plan V ...

  • hussman Q1-DC - page 3

    Rev . 0508 3 Cut and Plan Views 45 13/16" 45" 34 1/8" 11 7/8" 35" 11 5/16" 17 1/8" 8" 9 3/4" 24 3/8" 15 7/8" 27 3/4" 6 7/8" 11" 29 3/8" 4 3/8" Q1-DC Single Deck Deli - Curved Glass Scale = 1/2" 44 7/ 1 6" " 5 4 21 1/8" 39 1/ 8" 55 1/2 " 4 5 ...

  • hussman Q1-DC - page 4

    Q1-DC-0508 4 5. Apply liberal bead of case joint sealant (butyl) to rst case. Sealant area is shown using a dotted line in illustration in Step 8. Apply heavy amount to cover entire shaded area. DO NOT USE PERMAGUM! I t is t he c o nt ra ct or ’s re sp on si bi l it y to i ns t al l c as e( s) a cc o rd in g to l o ca l co ns tr u ct io n an d ...

  • hussman Q1-DC - page 5

    Rev . 0508 5 Plumbing W aste Outlet and P-TRAP The waste outlet is located off the center of the case on one side allowing drip piping to be run lengthwise under the xture. A 1-1/2” P-TRAP and threaded adapter are supplied with each xture. The P-TRAP must be installed to prevent air leakage and insect entrance into the xture. NOTE: PVC-D ...

  • hussman Q1-DC - page 6

    Q1-DC-0508 6 Electronic Expansion V alve (Optional) A wide variety of electronic expansion valves and case controllers can be utilized. Please refer to EEV and controller Hussmann’s information sheet. Sensors for ele ctron ic expan sion valv es will be inst alled on the coil inle t, coil outlet, and in the discharge air . (Some supermarkets requi ...

  • hussman Q1-DC - page 7

    Rev . 0508 7 Wiring and Serial Plate Amperage Fi eld Wi ring mus t be si zed fo r com pon ent am pere s st ampe d on the serial plate. Actual ampere draw may be less than spec ied. Fiel d wirin g from the refr igerati on con trol panel to the merch andiser s is requ ired for refr igerati on therm ostats. Case amperes are listed on the wiring dia ...

  • hussman Q1-DC - page 8

    Q1-DC-0508 8 7. Keep the service doors closed (when applicable). Refrigeration performance will be seriously affected if left open for a prolonged period of time. 8. Avoid the use of supplemental ood or spot lighting. Display light intensity has been designed for maximum visibility and product life at the factory . The use of higher output uo ...

  • hussman Q1-DC - page 9

    Rev . 0508 9 Non-Glare Glass The high optical clarity of this glass is possible due to spec ial coat ings on the glass surface itself . T o pres erve this coating and the optical clarity , keep the glass clean. W ater is the only solut ion recom mended for use in cleanin g non-glare glass. The damage to the glass from improper , caustic solutions i ...

  • hussman Q1-DC - page 10

    Q1-DC-0508 10 Maintenance FOR PROMPT SERVICEHave case Model and Serial Numberready! This information is located on thenameplate of the unit. BEFORE SERVICING ALWAYS DISCONNECT ELECTRICAL POWER AT THE MAIN DISCONNECT WHEN SERVICING OR REPLACING ANY ELECTRICAL COMPONENT. This includes (but not limited to) Fans, Heaters Thermostats, and Lights. Replac ...

  • hussman Q1-DC - page 11

    Rev . 0508 1 1 Electrical Wiring Diagrams Q1-DC Q1-DC-4R 4’ W1750001 Deli-Curve Glass Q1-DC-6R 6’ W1750002 RJ-45,Ledge Lights Q1-DC-8R 8’ W1750003 12’ W1750005 Q1-DC Q1-DC-4R 4’ W1750006 Q1-DC-5R 5’ W1750026 Deli-Curve Glass Q1-DC-6R 6’ W1750007 Standard Case Q1-DC-8R 8’ W1750008 Q1-DC-9R 9’ W1750009 Q1-DC-10R 10’ W1750009 Q1-DC ...

  • hussman Q1-DC - page 12

    Q1-DC-0508 12 Wiring Diagrams DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 12/01/05 F:W IRESCHEMATICSNEW-W IRING Q1 ...

  • hussman Q1-DC - page 13

    Rev . 0508 13 DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 03/29/06 ENGW IRESCHEMATICSNEW-W IRING Q1 DELI W 1750002 ...

  • hussman Q1-DC - page 14

    Q1-DC-0508 14 DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 11/18/05 F:W IRESCHEMATICSNEW-W IRING Q1 DELI W 1750003 ...

  • hussman Q1-DC - page 15

    Rev . 0508 15 DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 03/29/06 ENGW IRESCHEMATICSNEW-W IRING Q1 DELI W 1750005 ...

  • hussman Q1-DC - page 16

    Q1-DC-0508 16 DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 02/02/06 F:W IRESCHEMATICSNEW-W IRING Q1 DELI W 1750006 ...

  • hussman Q1-DC - page 17

    Rev . 0508 17 DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 07/11/06 ENGW IRESCHEMATICSNEW-W IRING Q1 DELI W 1750026 ...

  • hussman Q1-DC - page 18

    Q1-DC-0508 18 DATE: : # G W D : E L T I T T C E J O R P DRAWN BY: PRODUC TION ORDER #: DRAWI NG TITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCA T ION : D.QUAN --- PAGE OF HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 L I C .#: 644406 1 2 3 1 1 11/22/05 F:WIRESCHEMATICSNE W- WIRING Q1 ...

  • hussman Q1-DC - page 19

    Rev . 0508 19 DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 11/18/05 F:W IRESCHEMATICSNEW-W IRING Q1 DELI W 1750008 ...

  • hussman Q1-DC - page 20

    Q1-DC-0508 20 DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 07/11/06 ENGW IRESCHEMATICSNEW-W IRING Q1 DELI W 1750009 ...

  • hussman Q1-DC - page 21

    Rev . 0508 21 DATE: PROJECT TIT L E: DWG #: DRAW N BY: PRODUCTION ORDER #: DRAWING T ITLE: DATE: REVISIONS: : Y B D E K C E H C : N O I T P I R C S E D : # BY: FILE LOCATION: D.QUAN --- PAGE OF HUSSMAN N CORPORATION 13770 RAMONA AVE NUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 1 2 3 1 1 11/18/05 F:W IRESCHEMATICSNEW-W IRING Q1 DELI W 1750010 ...

  • hussman Q1-DC - page 22

    Q1-DC-0508 22 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TI TLE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? 1 11 03/8/07 A Updated dw g; removed ballast fuse 5/ 10/07 JR Q1-DC-X S ...

  • hussman Q1-DC - page 23

    Rev . 0508 23 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TIT LE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? 2 11 03/8/07 Q1-DC-X S/Q1-DS - X S Q1-DC-4S/Q1-DS-4S L LIGHT SW ITCH TI ...

  • hussman Q1-DC - page 24

    Q1-DC-0508 24 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TI TLE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? 3 11 03/8/07 Q1-DC-X S L LIGHT SW ITCH TIPPETTE 125-01-0311 CANOPY LIGH ...

  • hussman Q1-DC - page 25

    Rev . 0508 25 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TI TLE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? L LIGHT SW ITCH TIPPETTE 125-01-0311 CANOPY LIGHT AIR SWEEP FANS COMAIR ...

  • hussman Q1-DC - page 26

    Q1-DC-0508 26 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TI TLE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? L LIGHT SW ITCH TIPPETTE 125-01-0311 CANOPY LIGHT AIR SWEEP FAN COMAIR? ...

  • hussman Q1-DC - page 27

    Rev . 0508 27 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TI TLE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? L LIGHT SW ITCH TIPPETTE 125-01-0311 CANOPY LIGHT AIR SWEEP FANS COMAIR ...

  • hussman Q1-DC - page 28

    Q1-DC-0508 28 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TI TLE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? L LIGHT SW ITCH TIPPETTE 125-01-0311 CIRCUIT #1 EVAP FAN MOTOR (3)03924 ...

  • hussman Q1-DC - page 29

    Rev . 0508 29 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TI TLE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? L CIRCUIT #1 EVAP FAN MOTOR (4)0392457 .29A LEDGE LIGHT (OPTIONAL) SAFE ...

  • hussman Q1-DC - page 30

    Q1-DC-0508 30 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TIT LE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? L LIGHT SW ITCH TIPPETTE 125-01-0311 CANOPY LIGHT AIR SWEEP FAN COMAIR? ...

  • hussman Q1-DC - page 31

    Rev . 0508 31 DATE: PROJECT TIT LE: DRAWING #: DRAW N BY: PRODUCTION ORDER #: DRAWING TI TLE: DATE: Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 REVISIONS: #: DESCRIPTION: CHECKED BY: BY: FILE LOCATION: JESSE RIOS PAGE OF ? 10 11 03/8/07 Q1-DC-X S 03/8/07 Q1-DC-X S/Q1-DS - X S Q1-DC-12S/Q1-DS-1 ...

  • hussman Q1-DC - page 32

    Q1-DC-0508 32 Appendices Appendix A. - T emperature Guidelines - Refrigerated The refrigerators should be operated according to the manufacturer ’ s published engineering specications for en teri ng ai r te mper atu res fo r spe cic equ ipm ent app lica tio ns. T able 1 shows the typical temperature of the air entering the food zone one hou ...

  • hussman Q1-DC - page 33

    Rev . 0508 33 Appendices (Cont'd) 1.1 The following recommendations are made for the purpose of arriving at easily taken and understood data which, coupled with other observations, may be used to determine whether a display refrigerator is working as intended: a) INSTRUMENT - A stainless steel stem-type thermometer is recommended and it should ...

  • hussman Q1-DC - page 34

    Q1-DC-0508 34 Appendices (Cont'd) 1.1 Cleaning of non frozen food equipment should include a weekly cleaning of the food compartment as a minimum to prevent bacteria growth from accumulating. Actual use and products may dictate more frequent cleaning. Circumstances of use and equipment design must also dictate the frequency of cleaning the dis ...

  • hussman Q1-DC - page 35

    The MODE L NAM E and SERI AL NUMB ER is requ ired in ord er to prov ide you with the correct parts and information for your particular unit. They can be found on a small metal plate on the unit. Please note them below for future reference. MODEL: SERIAL NUMBER: /Chino Additional copies of this publication may be obtained by contacting: Hussmann® C ...

Manufacturer hussman Category Pill Reminder Device

Documents that we receive from a manufacturer of a hussman Q1-DC can be divided into several groups. They are, among others:
- hussman technical drawings
- Q1-DC manuals
- hussman product data sheets
- information booklets
- or energy labels hussman Q1-DC
All of them are important, but the most important information from the point of view of use of the device are in the user manual hussman Q1-DC.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals hussman Q1-DC, service manual, brief instructions and user manuals hussman Q1-DC. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product hussman Q1-DC.

Similar manuals

A complete manual for the device hussman Q1-DC, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use hussman Q1-DC by users. Manuals are usually written by a technical writer, but in a language understandable to all users of hussman Q1-DC.

A complete hussman manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual hussman Q1-DC - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the hussman Q1-DC, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the hussman Q1-DC, that we can find in the current document
3. Tips how to use the basic functions of the device hussman Q1-DC - which should help us in our first steps of using hussman Q1-DC
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with hussman Q1-DC
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of hussman Q1-DC in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning hussman Q1-DC?

Use the form below

If you did not solve your problem by using a manual hussman Q1-DC, ask a question using the form below. If a user had a similar problem with hussman Q1-DC it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)