-
Weber 1500 - page 1
GENESIS ® 1500 Natural Gas Barbecue Serial Number Please use this number in registering your warranty and any correspondence with the factory . Owner’ s Manual 98635 10/97 ® FOR Y OUR SAFETY Do not store or use gasoline or other flammable v apors and liquids in the vicinity of this or any other appliance. NO TICE T O INST ALLER: These instructi ...
-
Weber 1500 - page 2
2 D ANGER Failure to f ollo w the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodil y injury or death, or in a fire or an explosion causing damage to property . W ARNINGS Do not store a spare or disconnected LP tank under or near this barbecue . Improper assemb ly ma y be dang erous. Ple ...
-
Weber 1500 - page 3
3 Weber-Stephen Products Co. (W eber) hereby warrants to the ORIGINAL PURCHASER of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Cooking Grates and Flavorizer Bars, 3 years, All Remaining Parts, 5 years, when assembled and operated in accordance ...
-
Weber 1500 - page 4
4 © 1997 Weber . Weber , , Genesis, Flavorizer and Crossover are registered U.S. trademarks; Perma-Mount, Gas Catcher , FlameCheck, Steam-N-Chips, Spider Stopper , and W arm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: ...
-
Weber 1500 - page 5
5 Contents WARNINGS ................................................................ 2 W arranty & Patents .................................................. 2-3 General Instructions .................................................... 6 Assembly ............................................................. 13-25 Operating Instructions Lighting ...
-
Weber 1500 - page 6
6 General Instructions Y our Weber Gas Barbecue is a stationary outdoor cooking appliance. With the Weber Gas Barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce that "outdoor" flavor in the food. The natural gas supply is ...
-
Weber 1500 - page 7
7 General Specifications f or Piping American National Standards Institute (ANSI) Recommendations for gas suppl y installations: Connections: ■ This barbecue is designed to operate at 7 inches of water column pressure (.2526 psi). ■ A manual shut-off valve must be installed outdoors, immediately ahead of any connections or change in pipe materi ...
-
Weber 1500 - page 8
8 T ypical natural gas supply installation to a concrete patio or pad View from behind barbecue Accessible Locking Shut off Outside Inside Gas Supply Indoor Shut off Figure 1 CA UTION: Follow "General Specifications for Piping" in this manual. We recommend that this installation be done by a professional. CA UTION: Combustib le ma ...
-
Weber 1500 - page 9
9 Recommended concrete pad requirements We recommend a pad a minimum of 40 inches left to right, 20 inches front to back and 4 inches deep (1.85 cubic feet). Figure 4. Note - Cubic f eet is determined by m ultiplying length times width times depth and dividing by 1728. 20” 4” 40” Figure 4 If you use a concrete bag mix, use the mix for maximum ...
-
Weber 1500 - page 10
10 Assembl y T ools needed Regular screwdriver Phillips screwdriver Hammer One 7/16 inch or an adjustable wrench Pliers T ape Measure Pencil Electric drill Supplies needed Y ou will need a soap and water solution to check for gas leaks. (See Step "Check for gas leaks.") Note - The hardware size of nuts , bolts, and scre ws is giv en. F or ...
-
Weber 1500 - page 11
11 Front Panel Cooking grate (2) Catch pan holder Catch Pan Drip pans (2) Thermometer Condiment basket Left frame Right frame Side frame (2) Accessory rack W arm-Up Basket W arming Rack Five long Flavorizer Bars Eight short Flavorizer Bars Side panel (2) Base panel ...
-
Weber 1500 - page 12
12 Check contents of hardware packs Three burner control knobs Three tool holders Three tubing plugs Manifold bracket T wo hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) One 1/4-20 x 2 inch bolts (actual size) Six 1/4-20 x 1/2 inch bolts (actual size) One 1/4-20 keps nut Seven nylon washers (actual size) T wo hair pin cotters ...
-
Weber 1500 - page 13
13 Step 2 Assemble the frame Y ou will need: left frame, right frame, two nylon washers, two 1/4-20 x 1/2 inch bolts and a 7/16 inch wrench. Note - W ork on car peted area (on grass, or on one of the bo x es) to protect the finish during frame assembly . Put the frame pieces so the leg tabs are up. Put the right frame to your right and left frame t ...
-
Weber 1500 - page 14
14 Figure 3 Figure 5 Figure 4 26 1/2 1 2 3 4 Step 4 Measure and drill holes Y ou will need: Completed frame assembly , base panel, tape measure, and pencil. CA UTION: Combustib le materials should never be within 24 inches of the top, bottom, bac k or sides of the barbecue. Do not locate under overhead combustib le construction. Note - With the ...
-
Weber 1500 - page 15
15 3/8-16 x 1 1/2 machine screw 3/8 inch flat washer Mount plate 3/8 inch screw anchor Drilled hole Figure 8 Concrete lag bolt 3/8 inch flat washer Mount plate Lag shield Drilled hole Figure 7 Strike anchor 3/8 inch nut 3/8 inch flat washer Mount plate Drilled hole Figure 6 Method 3 - Concrete A 3/8 inch machine screw anchor , using a 3/8-16 x 1 1/ ...
-
Weber 1500 - page 16
Step 6 Add front panel and tighten all frame bolts Y ou will need: front panel and two plastic buttons. Align the panel with the holes in the frame and insert the plastic buttons through the front panel and frame. Figure 1 1. 16 Figure 11 Figure 12 Figure 10 Plastic buttons shown from the rear of the barbecue 3/8 inch x 1 1/2 inch lag bolt 3/8 inch ...
-
Weber 1500 - page 17
17 Guide screw (a) (b) Wing nuts View from behind cooking box Figure 15 Figure 13 Burner tubes Frame brace Slide the cooking box to the left within the frame. Put nylon washer on bolt. Insert the bolt through the frame and cooking box with the head of the bolt outside the frame. Figure 14. Add the keps nut. T ighten by holding the bolt with pliers ...
-
Weber 1500 - page 18
Step 8 Connect barbecue gas supply line to the natural gas supply Note - W e recommend that the connection between the barbecue gas supply line and the natural gas supply be flare to flare. A 3/8-inch flare fitting has been included with the barbecue gas supply line of y our gas barbecue . The fitting is loosely connected f or shipping and should b ...
-
Weber 1500 - page 19
19 Figure 19 Igniter lock nut Keyhole in frame brace Small part of keyhole in frame brace Frame brace Frame brace (a) (b) (c) Figure 20 Step 11 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter . This was done to f actor y test the ignition system. The igniter lock nut is on the ignite ...
-
Weber 1500 - page 20
20 Figure 22 Figure 21 (a) Gas supply shut off at the house (c) (b) Step 13 Check for gas leaks D ANGER Do not use an open flame to chec k f or gas leaks. Be sure there are no sparks or open flames in the area while y ou chec k f or leaks. This will result in a fire or explosion which can cause serious bodil y injury or death and damage to pr o ...
-
Weber 1500 - page 21
21 Figure 23 Figure 24 (a) Base panel Left side panel top bottom Right side panel Step 14 Add base panel Y ou will need: Base panel. Put the right side in and down, tilt and set the left side in place. Figure 23. Step 15 Install side panels Y ou will need: two side panels, and eight plastic buttons. From the inside of the frame assembly , set the l ...
-
Weber 1500 - page 22
22 Figure 28 Figure 27 Figure 29 Bottom tray Finger grip on front edge of bottom tray Finger grip Front side of catch pan holder Figure 25 Figure 26 Step 16 Install Flavorizer Bars and Cooking Grates Y ou will need: five long Flavorizer Bars, eight short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower ...
-
Weber 1500 - page 23
23 Hair pin cotter Hinge pin Figure 30 Figure 31 T ool holders Control panel push-in buttons (a) (b) Step 18 Install Lid Y ou will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. ...
-
Weber 1500 - page 24
24 Figure 33 (b) (a) Slot in frame (view from below) Figure 32 (c) (b) Right side frame Left side frame slots Left hooks Wire end (a) Step 20 Install the condiment basket Y ou will need: condiment basket and end bracket. Insert one wire end of the condiment basket into the hole in the side frame. Figure 32 (a). Insert the opposite wire end of the c ...
-
Weber 1500 - page 25
25 Figure 34 (a) (b) (c) (d) (e) Step 22 Complete accessory installation Y ou will need: W arm -Up B asket, warming rack, work table, three tubing plugs, thermometer and a hammer . Insert one end of the Weber W arm-Up Basket into the hole in the right end of the lid and the other end into the slot in the left end of the lid. Figure 34 (a). Set the ...
-
Weber 1500 - page 26
26 26 1 2 7 5 4 6 Figure 1 Crosso ver Ignition System OPERA TING INSTR UCTIONS Lighting Summary lighting instructions are on the control panel. 1) Open the lid. Figure 1. 2) Make sure all burner control knobs are turned OFF . (Push each burner control knob down and turn clockwise.) 3) Turn gas supply valve on. W ARNING: Do not lean over open ba ...
-
Weber 1500 - page 27
27 1 2 7 5 4,6 Figure 2 Manual Lighting W ARNING: If the burner does not light, turn the Fr ont burner contr ol knob to OFF and wait 5 minutes to let the gas clear bef ore y ou try again or try to light with a match. 7) After the FRONT burner is lit you can turn on the other burners. Note - Alwa ys light the FR ONT b urner first. The other burn ...
-
Weber 1500 - page 28
28 Cooking Y ou can adjust the FRONT , CENTER and BACK burners as desired. The control settings High (H), Medium (M), Low (L), or Off (O) are described in your Weber cookbook. The cookbook uses these notations to describe the settings of the FRONT , CENTER, and BACK burners. For example, to sear steaks you would use (HHH) (all burners at high). The ...
-
Weber 1500 - page 29
29 (a) (c) (b) Figure 3 Annual Maintenance After a period of nonuse we recommend that you perform the following maintenance procedures f or y our saf ety . W ARNING: Check gas supply line bef ore each use of barbecue for nic ks or cracking. If the gas suppl y line is found to be dama ged in an y wa y , d o not use the barbecue. Replace using on ...
-
Weber 1500 - page 30
30 Burner inside cooking box Figure 6 Dark blue Light blue T ips occasionally yellowish Figure 4 V enturi Air shutter V enturi fin Weber Spider Stopper Guard Figure 5 Flames Figure 7 Figure 8 General Maintenance W eber Spider Stopper Guar ds Y our Weber Gas Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. T ...
-
Weber 1500 - page 31
31 View from behind cooking box Wing nuts Burner valve V alve orifice Figure 10 Guide screw Figure 11 Crossover tube Figure 12 V enturi fin Figure 14 Figure 13 (a) (b) Check fit around valve Check fit around burner Figure 9 d) Unlatch the Spider Stopper Guards and remove. Figure 9. e) Disconnect gas supply line. f) Remove the manifold bracket and u ...
-
Weber 1500 - page 32
32 Figure 15 White wire Black wire Crosso ver Ignition System Operations If the Crossover Ignition System fails to ignite the Front burner , light the Front burner with a match. If the Front burner lights with a match, then check the Crossover Ignition System. ■ Check that both the white and black ignition wires are attached properly . Figure 15. ...
-
Weber 1500 - page 33
33 Prob lem Burners b urn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: CA UTION: Do not line the bottom tray with aluminum f oil. Burner flame pattern is erratic. Flame is low when burner is on HIGH. Flames do not run the whole length of the ...
-
Weber 1500 - page 34
34 ® ® ® ® ® ® ® ® 1 2 3 6 7 8 10 9 19 20 13 14, 15 43-47 51 9 48 41 39 38 37 36 35 33 32 31 30 29 28 27 42 40 21 25 26 34 11 12 16 17 18 5 4 23 16 24 22 50 49 ...
-
Weber 1500 - page 35
35 1 Lid (assembly) 2 Lid handle 3 W arm-Up Basket 4 W arming rack 5 Short Flavorizer bars (8) 6 Long Flavorizer bars (5) 7 Cooking grates (2) 8 Work table 9 T ubing plugs (3) 10 1/4-20 x 2 inch bolts (5) 1 1 End bracket 12 Left frame 13 Condiment basket 14 1/4-20 x 1/2 inch bolts (6) 15 1/4 inch nylon washers (7) 16 Side panel (2) 17 Side frame (2 ...
-
Weber 1500 - page 36
A F INAL W ORD OF T HANKS hank you for choosing a W eber Barbecue. Our family here at W eber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur . Our knowledgeable Customer Service staff is prepar ed to help you with any problems with parts or as ...
Do you have a question concerning Weber 1500?
Use the form below
If you did not solve your problem by using a manual Weber 1500, ask a question using the form below. If a user had a similar problem with Weber 1500 it is likely that he will want to share the way to solve it.