English dropdown-ico

Manual Desa CGP10L

20 pages 0.31 mb
Download

Go to site of 20

Summary
  • Desa CGP10L - page 1

    Save this manual for future reference. BLUE FLAME VENT-FREE PROPANE/LP GAS HEATER OWNER’S OPERATION AND INSTALLATION MANUAL 10,000 and 6,000 Btu/Hr Manually Controlled Models: CGP10L and CGP6L ® WARNING: If the information in this manual is not followed exactly, a fire or explosion may result caus- ing property damage, personal injury, or loss o ...

  • Desa CGP10L - page 2

    2 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR SAFETY INFORMA TION WARNINGS IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, oper- ate, or service this heater. Im- proper use of this heater can cause serious injury or death from burns, fire, explosion, and car- bon monoxide poisoning. Carbon Monoxi ...

  • Desa CGP10L - page 3

    3 103547 OWNER’S MANUAL PRODUCT IDENTIFICA TION Figure 1 - Vent-Free Propane/LP Gas Heater (Model CGP10L Shown) Control Knob Heater Cabinet Grill Guard Glass Panel Front Panel Ignitor Button FRESH AIR FOR COMBUSTION AND VENTILA TION WARNING: This heater shall not be installed in a confined space unless provisions are pro- vided for adequate combu ...

  • Desa CGP10L - page 4

    4 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR WARNING: If the area in which the heater may be operated is smaller than that defined as an unconfined space, provide ad- equate combustion and ventila- tion air by one of the methods described in the National Fuel Gas Code, ANSI Z223.1, 1992, Section 5.3 or applicable local codes. VENTILATIO ...

  • Desa CGP10L - page 5

    5 103547 OWNER’S MANUAL FRESH AIR FOR COMBUSTION AND VENTILA TION Continued Or Remove Door into Adjoining Room, Option 3 Ventilation Grills Into Adjoining Room, Option 2 12" 12" Ventilation Grills into Adjoining Room, Option 1 Figure 2 - Ventilation Air from Inside Building Figure 3 - Ventilation Air from Outdoors Outlet Air Ventilated ...

  • Desa CGP10L - page 6

    6 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR For convenience and efficiency, install heater • where there is easy access for operation, inspection, and service • in coldest part of room Figure 4 - Mounting Clearances As Viewed From Front of Heater INSTALLING HEATER TO WALL Marking Screw Locations 1. Determine where y ou will locate ...

  • Desa CGP10L - page 7

    7 103547 OWNER’S MANUAL Installing Two Mounting Screws Note: Wall anchors and mounting screws are in hardware package. The hardware pack- age is provided with heater. Attaching to wall stud method For attaching mounting screw to wall stud 1. Drill hole at marked location using 9/64" drill bit. 2. Insert mounting screw into wall stud. 3. T ig ...

  • Desa CGP10L - page 8

    8 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR IMPORTANT: Hold pressure regulator with wrench when connecting it to gas pip- ing and/or fittings. Figure 13 - Gas Connection Tee Joint Reducer Bushing to 1/8" NPT 1/8" NPT Plug Tap Test Gauge Connection * Tee Joint Pipe Nipple Cap Pressure Regulator Heater Cabinet 3/8" NPT Pip ...

  • Desa CGP10L - page 9

    9 103547 OWNER’S MANUAL CHECKING GAS CONNECTIONS WARNING: Test all gas pip- ing and connections for leaks after installation or servicing. Correct all leaks at once. WARNING: Never use an open flame to check for a leak. Apply a mixture of liquid soap and water to all joints. Bubbles forming show a leak. Correct all leaks at once. CAUTION: Make su ...

  • Desa CGP10L - page 10

    10 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR GRH/OV 008 BAD PILOT/LP TO TURN OFF GAS TO APPLIANCE 1. Remove fr ont panel (see F igur e 10, page 7). 2. Follow steps 1 thr ough 5 under Light- ing Instructions . 3. With contr ol knob pr essed in, str ike match. Hold match to pilot until pi- lot lights. 4. Keep contr ol knob pressed in f o ...

  • Desa CGP10L - page 11

    11 103547 OWNER’S MANUAL BURNER FLAME PATTERN Figure 20 shows a correct burner flame pattern. Figure 21 shows an incorrect burner flame pattern. The incorrect burner flame pattern shows yellow tipping of the flame. It also shows the flame higher than 1/2 the glass panel height. NOTICE: Do not mistake orange flames with yellow tipping. Dust or oth ...

  • Desa CGP10L - page 12

    12 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR Note: All troubleshooting items are listed in order of operation. TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. POSSIBLE CAUSE 1. Ignitor electrode positioned wrong 2. Ignitor electrode broken 3. Igni ...

  • Desa CGP10L - page 13

    13 103547 OWNER’S MANUAL OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smoke or odor during initial opera- tion Heater produces a whistling noise when burner is lit Heater produces a clicking/ticking noise just after burner ...

  • Desa CGP10L - page 14

    14 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR You may have further questions about in- stallation, operation, or troubleshooting. If so, contact DESA International’s Techni- cal Service Department at 1-800-323-5190. TECHNICAL SER VICE SERVICE HINTS When gas pressure is too low • pilot will not stay lit • burner will have delayed i ...

  • Desa CGP10L - page 15

    15 103547 OWNER’S MANUAL CGP6L CGP10L Btu (Variable) 4,400/6,000 5,000/10,000 Type Gas Propane/LP Only Propane/LP Only Ignition Piezo Piezo Pressure Regulator Setting 8" W.C. 8" W.C. Inlet Gas Pressure (inches of water) Maximum 14" 14" Minimum 11" 11" Dimensions, Inches (H x W x D) Heater 20 1/2 x 13 1/2 x 5 20 1/2 x ...

  • Desa CGP10L - page 16

    16 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR 10 12 11 1 2 3 4 5 6 7 9 8 GRHpv014C CGP10 10 13 14 15 16 17 18 21 23 24 27 22 26 25 19 20 28 29 HEATER EXPLODED VIEW CGP10L CGP6L 12-2 12-1 ODS/PILOT ILLUSTRA TED P AR TS LIST ...

  • Desa CGP10L - page 17

    17 103547 OWNER’S MANUAL P AR TS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 15 of this manual. PART NUMBER FOR CGP6L CGP10L KEY NO. DESCRIPTION QTY. 1 098304-01 098304-01 Screw, #10 x 3/8" 2 2 099467-05 099467-05 Front Panel (Ivory) 1 3 09 ...

  • Desa CGP10L - page 18

    18 103547 PROP ANE/LP GAS HEA TER 10,000 AND 6,000 BTU/HR NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ ______________________________________________________________________________________________ ...

  • Desa CGP10L - page 19

    19 103547 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _____________________________ ...

  • Desa CGP10L - page 20

    KEEP THIS WARRANTY W ARRANTY INFORMA TION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty. We make no other warranty, expressed or implied. Model Serial No. Date Purchased LIMITED ...

Manufacturer Desa Category Electric Heater

Documents that we receive from a manufacturer of a Desa CGP10L can be divided into several groups. They are, among others:
- Desa technical drawings
- CGP10L manuals
- Desa product data sheets
- information booklets
- or energy labels Desa CGP10L
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa CGP10L.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa CGP10L, service manual, brief instructions and user manuals Desa CGP10L. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa CGP10L.

Similar manuals

A complete manual for the device Desa CGP10L, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa CGP10L by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa CGP10L.

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa CGP10L - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa CGP10L, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa CGP10L, that we can find in the current document
3. Tips how to use the basic functions of the device Desa CGP10L - which should help us in our first steps of using Desa CGP10L
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa CGP10L
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa CGP10L in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa CGP10L?

Use the form below

If you did not solve your problem by using a manual Desa CGP10L, ask a question using the form below. If a user had a similar problem with Desa CGP10L it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)