English dropdown-ico

Manual Thermos 465630003

32 pages 1.46 mb
Download

Go to site of 32

Summary
  • Thermos 465630003 - page 1

    WARNING CA UTION Some parts may contain sharp edges – especially as noted in the manual! Wear protective gloves if necessary. Failure to follow all manufacturer’s instructions could result in fire or explosion which could cause property damage, personal injury or death. Fire+Ice 465630003-E / 00-0000-000-000 (10-29-02) Read and follow all safet ...

  • Thermos 465630003 - page 2

    2 • Fire & Ice D ANGER WARNING CA UTION FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not be stored in the vicinity of this or any other appliance. FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance ...

  • Thermos 465630003 - page 3

    Fire & Ice • 3 LP (Liquefied Petroleum Gas) • For Your Safety • LP gas is highly flammable and may ignite unexpectedly when mixed with air. Is nontoxic, odorless and colorless when produced. , LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. CA UTION For residential use only. Do not use for commercial c ...

  • Thermos 465630003 - page 4

    4 • Fire & Ice Warranty THERMOS GRILLS Consumer Warranty / P.O. Box 1240 Columbus, GA 31902-1240 Thermos warrants to the original consumer-purchaser that this product shall be free from defects in workmanship and materials under normal and reasonable use and correct assembly (If assembled by consumer-purchaser) as follows: (1) The aluminized ...

  • Thermos 465630003 - page 5

    Fire & Ice • 5 For Your Safety .............................................................2 Safety Symbols LP (Liquefied Petroleum Gas) .................................................3 Grill Service Center Installation Safety Precautions Warranty Information Warranty ..................................................................4 Tabl ...

  • Thermos 465630003 - page 6

    6 • Fire & Ice FEATURES Heat indicator Level indicator Viewing glass Bottle opener Ignitor Lift handle Pull handle/Cooler shelf Cooler shelf support Foot pedal Cooler lid ...

  • Thermos 465630003 - page 7

    Fire & Ice • 7 FEATURES Tool set Grease bottle Lift handle Storage net Cup/can holders Tool holders Match lighting stick ...

  • Thermos 465630003 - page 8

    8 • Fire & Ice PARTS LIST Key Quantity Description Part Number 1 1 T orsion Bar 21-6047-009-200 2 2 Upper Hinge 22-6047-004-200 3 1 Grill Lid 65-6048-018-200 4 2 Side Lid Spacer 13-6047-397-200 5 1 Center Lid Spacer 13-6047-399-200 6 1 Upper Latch 22-6047-040-200 7 1 Handle Assembly 69-6047-246-200 8 1 Heat Shield 21-6047-082-200 9 1 Grate 65 ...

  • Thermos 465630003 - page 9

    Fire & Ice • 9 PARTS DIAGRAM 1 2 2 3 7 6 8 9 10 11 12 13 14 18 15 16 17 15 16 28 27 26 24 25 23 22 20 21 19 43 5 4 4 44 44 44 ...

  • Thermos 465630003 - page 10

    10 • Fire & Ice PARTS DIAGRAM 29 31 32 32 33 34 35 38 37 39 40 41 30 36 42 ...

  • Thermos 465630003 - page 11

    Fire & Ice • 11 ASSEMBLY Pedal To raise gril l... PRESS and foot pedal on front of cooler. Foot pedal once the grill begins to rise so that the grill will lock into position. RELEASE MUST BE RELEASED Press Release Slide cooler lid back to open and lift grill lid to remove packed components. Contents: Side shelves Tools (3) Grease bottle Regul ...

  • Thermos 465630003 - page 12

    12 • Fire & Ice To lower grill and begin assembly . . . Make sure cooler lid is in the closed position. PRESS foot pedal and push grill down by pressing on of grill lid. foot pedal BEFORE grill reaches the cooler so that it will lock into position. DO NOT attach gas regulator to grill at this point. Mechanism will not close if regulator is in ...

  • Thermos 465630003 - page 13

    Fire & Ice • 13 Attach grease bottle by sliding bottle bracket over tabs on left side of plinth. Twist 1 lb. LP gas cylinder (sold separately) into regulator. Grease bottle Regulator 1 lb. LP gas cylinder ...

  • Thermos 465630003 - page 14

    14 • Fire & Ice PRESS and foot pedal on front of cooler. Foot pedal once the grill begins to rise so that the grill will lock into position. RELEASE MUST BE RELEASED To install regulator/cylinde r... 1. Push and hold regulator lock to right. 2. Push and hold the gas interlock downward. 3. Insert regulator tube straight into burner tube. 4. Re ...

  • Thermos 465630003 - page 15

    Fire & Ice • 15 Attach side shelves by sliding shelf rods into holes on each side of grill. NOTE: Shelf with regulator cut-out attaches to right side. ...

  • Thermos 465630003 - page 16

    16 • Fire & Ice The pull handle on your cooler may converted for use as a shelf by utlizing the built-in support in the handle. To use the pull handle as a shel f... 1. Raise pull handle to horizontal position. 2. Lower the support wire (built into handle). 3. Place support wire into slot in cooler body. 1 2 3 ...

  • Thermos 465630003 - page 17

    Fire & Ice • 17 TABLETOP MODE To remove grill from cooler for tabletop u s e... Begin with grill in the lowered position. Grasp the plinth on each side (see arrows) and lift grill from cooler. Beneath the plinth, unfold the wire legs. Legs will lock into position when fully extended. If grease bottle has been removed, attach to left side of p ...

  • Thermos 465630003 - page 18

    18 • Fire & Ice NO TE: MUST Regulator and gas cylinder be removed from grill before placing grill onto cooler. Align posts beneath plinth with holes on top of cooler and slide grill downward onto cooler. To close legs and return grill to coole r... Press legs inward to release from locked position, then fold legs under plinth. ...

  • Thermos 465630003 - page 19

    Fire & Ice • 19 USE AND CARE Propane Cylinder Use (1 lb. Disposable) • • • • Use only cylinder marked “Propane Fuel”. Size should be 4” diameter , 8” height, or 3” diameter , 10” height. Save cylinder cap and reinstall when not in use. Cylinder supply system must be arranged for vapor withdrawal. Gas cylinder must be uprig ...

  • Thermos 465630003 - page 20

    20 • Fire & Ice Propane Cylinder Use (20 lb. Refillable) The 20 lb. LP tank used with your grill must meet the following requirements: • • • Use only tanks equipped with this type of valve. Tank must be upright in use. LP Tank Filling • • must be purged • NEVER • LP Tank Exchange Exchange for OPD safety feature equipped tank as ...

  • Thermos 465630003 - page 21

    Fire & Ice • 21 Leak Testing (20 lb. Refillable) IMPORT ANT! For your safety • • • • Use mild soap and water. Do not use household cleaning agents. (A) Leak test must be repeated each time LP tank is exchanged or refilled. Do not smoke during leak test. Do not use an open flame to check for gas leaks. Grill must be leak checked outdoo ...

  • Thermos 465630003 - page 22

    22 • Fire & Ice Connecting The Adapter Hose To The LP Tank (continued) 5. Hold hose end, insert nipple (A) into LP tank valve. Hand tighten coupling nut, (B) so as not to cross thread the connection. holding connector in a straight line with LP tank valve Position coupling nut and hose-end as shown for proper connection to LP tank valve. Nipp ...

  • Thermos 465630003 - page 23

    Fire & Ice • 23 WARNING • Do not use grill until leak checked. • If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, close LP tank valve and call LP gas supplier or your fire department! immediately Leak Testing Valves, Hoses and Regulator Turn grill control knob to off. Correct before pr ...

  • Thermos 465630003 - page 24

    24 • Fire & Ice For Safe Use Of Your Grill: • • • • • • • Operate grill with 1 lb. cylinder in correct position as shown in . • Always remove 1 lb. cylinder from grill when transporting. • Operate grill with 20 lb. cylinder in correct position as show in . • Always remove 20 lb. cylinder from grill when transporting. Do no ...

  • Thermos 465630003 - page 25

    Fire & Ice • 25 Safety Tips Ignitor Check Regulator/Valve must be in “Off” position. Ignitor Lighting s s s s s s s s The use of alcohol, prescription or nonprescription drugs may impair the consumer ’ s ability to properly assemble or safely operate the appliance. When grill is not in use, disconnect 1 lb. cylinder or turn off 20 lb. c ...

  • Thermos 465630003 - page 26

    26 • Fire & Ice Match Lighting 1. Push Regulator/V alve in and turn counterclockwise to LIGHTING POSITION. 2. Attach match to match lighting stick, light match. 3. Insert match lighting stick into vent hole at rear of grill. WARNING If burner does not light within 5 seconds, turn knob to OFF, wait 5 minutes, try again. Burner Flame Check Befo ...

  • Thermos 465630003 - page 27

    Fire & Ice • 27 General Grill Cleaning Do not apply a caustic grill/oven cleaner to painted surfaces. Plastic Side Shelves: • Non-Stick Cooking Surface: • Grease Bottle: • Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply ...

  • Thermos 465630003 - page 28

    28 • Fire & Ice Non-Stick Cooking Surface Use and Care. Food Safety Clean: Separate: Cook: Chill: How to Tell if Meat is Grilled Thoroughly • • • • • • Use only plastic tools. • Do not cut food on surface. • Do not put pots or pans on surface. • Do not leave lid down for more than 10 minutes without food on the grill. Non-st ...

  • Thermos 465630003 - page 29

    Fire & Ice • 29 Troubleshooting Problem Burner will not light using ignitor. Burner will not match light. Flames blow out. Flashback (fire in burner tube) Possible Cause Electrode and burner are wet. Electrode cracked or broken, "sparks at crack". Wire is loose or disconnected. Wire is shorting (sparking) between ignitor and electro ...

  • Thermos 465630003 - page 30

    30 • Fire & Ice Recreational Vehicles THERMOS GRILLS has approved use of the Fire & Ice with specific recreational vehicles subject to the following provisions: • The is to be directly connected to an additional 20 lb. or 30 lb. DOT/TC LP tank mounted on the RV . The cannot be attached to any part of the gas system of the RV except dire ...

  • Thermos 465630003 - page 31

    Fire & Ice • 31 ...

  • Thermos 465630003 - page 32

    ® A Division of W.C. Bradley Company P .O. Box 1240 Columbus, GA 31902–1240 Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, Faststart®, Flare Fighter®, FlavorMaster®, Gas Grill Silouette and Design®, H2O Smoke ...

Manufacturer Thermos Category Gas Grill

Documents that we receive from a manufacturer of a Thermos 465630003 can be divided into several groups. They are, among others:
- Thermos technical drawings
- 465630003 manuals
- Thermos product data sheets
- information booklets
- or energy labels Thermos 465630003
All of them are important, but the most important information from the point of view of use of the device are in the user manual Thermos 465630003.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Thermos 465630003, service manual, brief instructions and user manuals Thermos 465630003. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Thermos 465630003.

Similar manuals

A complete manual for the device Thermos 465630003, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Thermos 465630003 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Thermos 465630003.

A complete Thermos manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Thermos 465630003 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Thermos 465630003, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Thermos 465630003, that we can find in the current document
3. Tips how to use the basic functions of the device Thermos 465630003 - which should help us in our first steps of using Thermos 465630003
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Thermos 465630003
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Thermos 465630003 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Thermos 465630003?

Use the form below

If you did not solve your problem by using a manual Thermos 465630003, ask a question using the form below. If a user had a similar problem with Thermos 465630003 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)