English dropdown-ico

Manual Friedrich CP05A10

24 pages 0.78 mb
Download

Go to site of 24

Summary
  • Friedrich CP05A10 - page 1

    Room Air Conditioner Ser vice and P ar ts Man ual C P05 / C P06 (0 6 /0 5 ) CP05A10 CP06A10 ...

  • Friedrich CP05A10 - page 2

    —2— CONTENTS 1. PREF A CE ...................................................................................................................................................3 1.1 FEA TURES................................................................................................................... ..................................3 1.2 SP ...

  • Friedrich CP05A10 - page 3

    —3— 1. PREF A CE This ser vice manual provides v arious ser vice inf or mation, including the mechanical and electr ical par ts, etc. This room air conditioner was manuf actured and assembled under a strict quality control system. The refrigerant is charged at the f actory . Be sure to read the safety precautions prior to ser vicing the unit. 1 ...

  • Friedrich CP05A10 - page 4

    —4— 1.3 LOCA TIONS OF CONTROLS 1.4 SAFETY PRECA UTIONS 1. When se r vicing, turn the unit Off and unplug the p o w er cord. 2. Obser ve the original lead dress. If a shor t circuit is found, replace all parts which have been ov erheated or damaged by the shor t circuit. 3. After ser vicing, make an insulation resistance test to pre v ent the cu ...

  • Friedrich CP05A10 - page 5

    — 5 — 2. DISASSEMBL Y INSTR UCTIONS 2.1 MECHANICAL P AR TS 2.1.1 FRONT GRILLE 1. Pull the inlet grille f orw ard. 2. Remov e the screw securing the F ront Gr ille. (Fig. 3) 3. Push the grille up from the bottom and pull the top of the grille aw a y from the case to lift the top tabs out of their slots. (Fig. 4) 4. Carefully position the grille, ...

  • Friedrich CP05A10 - page 6

    — 6 — 2.2 AIR HANDLING P AR TS 2.2.1 AIR GUIDE UPPER 1. Disconnect the unit from the power source . 2. Remov e the front grille. (Refer to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Remov e the control board. (Ref er to Section 2.1.3) 5. Remov e 2 screws that secure the air guide upper to air guide lower . (See Figure 6) ...

  • Friedrich CP05A10 - page 7

    — 7 — 2.2.3 MO T OR 1. Disconnect the unit from the power source . 2. Remov e the front grille. (Refer to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Remov e the control board. (Ref er to Section 2.1.3) 5. Remov e the air guide upper . (Ref er to Section 2.2.1) 6. Remov e the compressor , turbo fan, f an and shroud. (Ref ...

  • Friedrich CP05A10 - page 8

    — 8 — 2.3.2 COMPRESSOR 1. Remov e the front grille and cabinet. (Ref er to Section 2.1) 2. Discharge the refrigerant by using a refrigerant recov er y system. 3. Remov e the overload protector . (Ref er to Section 2.3.1) 4. After discharging the unit completel y , unb r aze the suction and discharge pipes at the compressor connections. 5. Remov ...

  • Friedrich CP05A10 - page 9

    — 9 — 2.3.6 PO WER CORD 1. Disconnect the unit from source of power . 2. Remov e the front grille. (Refer to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Remov e a screw that secures control board to base pan. (Ref er to Section 2.1.3) 5. Pulls the control board tow ard you. 6. Disconnect the 2 receptacles and remov e the ...

  • Friedrich CP05A10 - page 10

    2.4.2 E V APOR A T OR /CONDENSER 1. Remov e the cabinet. 2. Discharge the refrigerant by using a refrigerant recov er y system. 3. Remov e the air guide upper . (Refer to Section 2.2.1) 4. After discharging the refrigerant completely , unb r a z e the interconnecting tube at the proper coil connection s . 5. Remov e the ev aporator . 6. Re-install ...

  • Friedrich CP05A10 - page 11

    — 11 — Equipment needed: V acuum pump , charging cylinder , manifold gauge , brazing equipment, pinch-off tool capable of making a v apor proof seal, leak detector , tubing cutter , hand tools to remove components and service valv e. B A B A B A COMPOUND GAUGE SEE INSETS BELOW CAPILLARY TUBE EVAPORATOR (LOW PRESSURE SIDE) COMPRESSOR CONDENSER ( ...

  • Friedrich CP05A10 - page 12

    — 12 — 3 . T R OUBLESHO O TING GUIDE 3 .1 OUTSIDE DIMENSIONS (unit: mm [in]) 370 (14 9 / 16 ") 312 (12 1/4 ") 370 (14 9 / 16 ") 312 (12 1/4 ") 29 (1 5 / 32 ") 120 (4 3 / 4 ") 27.5 (1 3 / 32 ") 346 (13 5 / 8 ") 472 (18 9/16 ") 42 (1 21 / 32 ") 42 (1 21 / 32 ") 155(6 3/32 ") 12 (0.4 1/16 ...

  • Friedrich CP05A10 - page 13

    — 13 — 3 .2 PIPING SYSTEM F ollowing is a brief description of the impor tant components and their function in what is called the refr igeration system. Re f erence should be made to Figure 22 to f oll o w the ref r ige r ation cycle and the fl o w of the ref r ige r ant in the cooling cycle. COOLED AIR HOT DISCHARGED AIR MOTOR COMPRESSOR ROOM ...

  • Friedrich CP05A10 - page 14

    — 14 — 3 .3 T R OUBLESHO O TING GUIDE In gene r al, possi b le trou b le is classified in t w o categories. The one is called Starting Failure which is caused b y an electrical defect. The other is Ineff ective Air Con- ditioning caused b y a de f ect in the ref r ige r ation circuit and/or improper application. Unit is running but cooling is i ...

  • Friedrich CP05A10 - page 15

    — 15 — Fails to Start Improper thermostat setting Loose ter minal connection Improper wiring Che c k p o w er sourc e . Drop of pow er voltage . Capacitor check. Replacement. Che c k control s witch setting. Compressor f ails to star t. Def ect of compressor capacitor . Replacement of compressor (Motor damaged). Irregular motor insulation ( Ω ...

  • Friedrich CP05A10 - page 16

    COMPLAINT CA USE REMED Y F an motor will not run. No power Check v oltage at outlet. Correct if none. P ower supply cord Check v oltage to rotar y switch. If none , check power supply cord. Replace cord if circuit is open. Wire disconnected or Connect wire. Ref er to wir ing diagram f or connection loose terminal identification. Repair or replace l ...

  • Friedrich CP05A10 - page 17

    — 17 — COMPLAINT CA USE REMED Y F an motor noise. F an If crac ked, out of balance , or par tially missing, replace it. Blow er If crac ked, out of balance , or par tially missing, replace it. Loose set screw Tighten it. W orn bear ings If knocking sounds contin ue when running or loose, replace the motor . If the motor hums or noise appears to ...

  • Friedrich CP05A10 - page 18

    — 18 — COMPLAINT CA USE REMED Y Compressor cycles on F an motor If not running, deter mine the cause. Replace if ov er load. required. Condenser air flow Remo ve the cabinet, inspect the interior surf ace restriction of the condenser . If restricted, clean carefully with a v acuum cleaner (do not damage fins) or brush. Clean the inter ior base ...

  • Friedrich CP05A10 - page 19

    — 19 — 4 . CIRCUIT DI A GRAM WH(BL) POWER INPUT BK(BR) (Ribbed) (Plain) GN/YL (GN) GN/YL(GN) THERMIST OR BK BK BL RD BL RD CN-TH1 YL YL OR(BR) OR(BR) OR SYNC M OTOR R Y -LO R Y -HI CN-WORK CN-SYNC CN-DISP DISPLA Y P .W.B ASM R Y -SYNC 250V/T2A (115V/T2A) TRANS FORMER ZNR 43 R Y -COMP MAIN P .W.B ASM BK BK WH BK RD BL BL OLP RD MO TOR CAP ACIT O ...

  • Friedrich CP05A10 - page 20

    — 20 — 5 . EXPLODED VIEW 352390 130410 359012 W48602 354210 349480 352380 149980 559011 346811 554030 W48602 130910 550140 554160 567502 352115 352111 352113 35211A 135313 152302 135312 132111-2 132111-1 264110 238310 W0CZZ 249950 268714 263230 137215 268712 267110 147582-1 147582-2 147581 ...

  • Friedrich CP05A10 - page 21

    — 21 — 6 . SE R VICE P A R TS LIST • C P05A10 C P06A10 R: Service Parts N: Non Service Parts • Loc No FRIEDRICH Description 130410 67302921 BASE ASSEMBLY,WELD[SINGLE] 130910 67303709 CABINET ASSEMBLY,SINGLE 135312 67306008 GRILLE ASSEMBLY,FRONT(SINGLE) 135313 67306107 GRILLE,INLET 137215 67305507 PANEL,CONTROL 147581 67304600 LINK 147582-1 ...

  • Friedrich CP05A10 - page 22

    Loc No FRIEDRICH Description 130410 67302921 BASE ASSEMBLY,WELD[SINGLE] 130910 67303709 CABINET ASSEMBLY,SINGLE 135312 67306008 GRILLE ASSEMBLY,FRONT(SINGLE) 135313 67306107 GRILLE,INLET 137215 67305507 PANEL,CONTROL 147581 67304600 LINK 147582-1 67304500 VANE,VERTICAL 147582-2 67304501 VANE,VERTICAL 149980 67303100 SHROUD 152302 67304300 FILTER(ME ...

  • Friedrich CP05A10 - page 23

    — 23 — MEMO ...

  • Friedrich CP05A10 - page 24

    Post Office Box 1540 • 4200 N. Pan Am Expressway • San Antonio, Texas 78295-1540 • (210) 357-4400 • FAX (210) 357-4490 FRIEDRICH AIR CONDITIONING CO. Visit our web site at www.friedrich.com Use F actor y Cer tified P ar ts... ...

Manufacturer Friedrich Category Air Conditioner

Documents that we receive from a manufacturer of a Friedrich CP05A10 can be divided into several groups. They are, among others:
- Friedrich technical drawings
- CP05A10 manuals
- Friedrich product data sheets
- information booklets
- or energy labels Friedrich CP05A10
All of them are important, but the most important information from the point of view of use of the device are in the user manual Friedrich CP05A10.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Friedrich CP05A10, service manual, brief instructions and user manuals Friedrich CP05A10. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Friedrich CP05A10.

Similar manuals

A complete manual for the device Friedrich CP05A10, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Friedrich CP05A10 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Friedrich CP05A10.

A complete Friedrich manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Friedrich CP05A10 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Friedrich CP05A10, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Friedrich CP05A10, that we can find in the current document
3. Tips how to use the basic functions of the device Friedrich CP05A10 - which should help us in our first steps of using Friedrich CP05A10
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Friedrich CP05A10
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Friedrich CP05A10 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Friedrich CP05A10?

Use the form below

If you did not solve your problem by using a manual Friedrich CP05A10, ask a question using the form below. If a user had a similar problem with Friedrich CP05A10 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)