English dropdown-ico

Manual Desa (V)VC36P Series

44 pages 2.47 mb
Download

Go to site of 44

Summary
  • Desa (V)VC36P Series - page 1

    For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol-           ? ...

  • Desa (V)VC36P Series - page 2

    www .desatech.com 1 16200-01H 2 SAFETY INFORMA TION T ABLE OF CONTENTS Safety Information ............................................... 3 Product Identication ........................................... 4 Local Codes......................................................... 5 Product Features ................................................. 5 ...

  • Desa (V)VC36P Series - page 3

    www .desatech.com 1 16200-01H 3 This replace must be installed by a qualied (cer - tied or licensed) service person. It has a sealed gas combustion chamber that uses a coaxial pipe (pipe within a pipe and having the same center) venting system. It brings in fresh air for combus - tion through the outer pipe and combustion gases are exhaust ...

  • Desa (V)VC36P Series - page 4

    www .desatech.com 1 16200-01H 4 2. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrica l switch; do not use any phone in your building • immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier's instructions • if you cannot reach you gas supplier , ca ...

  • Desa (V)VC36P Series - page 5

    www .desatech.com 1 16200-01H 5 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent replace: • The venting system may be routed to the out - side of your home in several ways. It may vent through the roof (vertical) or it may vent to an outside/exterior wall (horizontal). The vent pipe installation i ...

  • Desa (V)VC36P Series - page 6

    www .desatech.com 1 16200-01H 6 • Y our replace is designed to be used in zero clea ranc e install atio ns. W all or fram ing mater ial can be placed directly against any exterior sur - face on the back, sides or top of your replace, except where standoff spacers are integrally atta ched . If stand of f spac ers are attach ed to your rep ...

  • Desa (V)VC36P Series - page 7

    www .desatech.com 1 16200-01H 7 A B E F G H D C Nailing T abs Figure 4 - Framing Clearances for Installation Against an Exterior Wall 36 1 / 8 " 41 1 / 4 " 21" Horizontal V ent 24 1 / 2 " V ertical V ent C B A D E F G T op of Louver Opening 3 2 1 4 5 6 7 W all Figure 5 - Framing Clearances for Corner Installation Ref. Mantel Dep ...

  • Desa (V)VC36P Series - page 8

    www .desatech.com 1 16200-01H 8 Fixed Closed Op en abl e Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12" (30.5 cm) minimum] B = clearance to window or ...

  • Desa (V)VC36P Series - page 9

    www .desatech.com 1 16200-01H 9 VENT ING INST ALLA TION INSTRUCTIONS NOTICE: Read these instruc-                           -  Thes e mo dels are tes ted a nd ap prove d fo r use with DESA (direct-vent) pipe ...

  • Desa (V)VC36P Series - page 10

    www .desatech.com 1 16200-01H 10 INST ALLA TION PLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop. Hori - zon tal inst all atio ns using rou nd termi nat ...

  • Desa (V)VC36P Series - page 11

    www .desatech.com 1 16200-01H 1 1 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess       6.  ? ...

  • Desa (V)VC36P Series - page 12

    www .desatech.com 1 16200-01H 12 VENTING INST ALLA TION INSTRUCTIONS Continued Figure 13 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screws High Wind T ermination Apply Mastic to Outside Edge of Standoff Exterior W all with Vinyl Siding 10 3 / 4 " x 10 3 / 4 " Framed Opening Ma ...

  • Desa (V)VC36P Series - page 13

    www .desatech.com 1 16200-01H 13 CORNER INST ALLA TION Recommended Applications: • Corner ground oor installation • G ro un d  o or in st a ll at io n w he re pi p e ve nt s ho ri zo n - ta lly th rou gh wal l ( ove r 12" horizontal pipe) • Basement installation where one foot clearance from ground to termination is possible VENTIN ...

  • Desa (V)VC36P Series - page 14

    www .desatech.com 1 16200-01H 14 VENTING INST ALLA TION INSTRUCTIONS Continued      Horizontal (H 1  Horizontal (H 1  Horizontal (H 2  5' min. 2' max. 6' max. 6' min. 4' max. 12' max. 7 ...

  • Desa (V)VC36P Series - page 15

    www .desatech.com 1 16200-01H 15 INST ALLA TION FOR VERTICAL TERMINA TION Note: V ertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters or other framing will obstruct the venting system, consi der an offse t (see Figure 19) to avoid cut - ting load ...

  • Desa (V)VC36P Series - page 16

    www .desatech.com 1 16200-01H 16 5. Pla ce th e a shing o ver the pip e sec tion( s) extendin g through the roof. Secure the base of the ashing to the roof and framing with roof - ing nails. Be sure roo ng materia l over laps the top edge of the ashing as shown in Figure 19, page 15. There must be a 1" clearance from the vent pipe ...

  • Desa (V)VC36P Series - page 17

    www .desatech.com 1 16200-01H 17 VENTING INST ALLA TION INSTRUCTIONS Continued Note : Install restrictor into inner collar of replace as shown.    V ertical (V 1   5' min. 6' max. 6' min. 12' max. 7&ap ...

  • Desa (V)VC36P Series - page 18

    www .desatech.com 1 16200-01H 18   AND COMPONENTS                 P58-6 6" Section Double W all Pipe, Galvanized P58-12 12& ...

  • Desa (V)VC36P Series - page 19

    www .desatech.com 1 16200-01H 19 FIREPLACE INST ALLA TION  Us e pro per ga s typ e for the r ep la ce un it yo u are in st al li ng . If you hav e co n ic ti ng gas typ es , do not in st al l re plac e. See reta ile r whe re yo u pur chas ed th e re plac e f or p ro pe r re plac e a cc or di ...

  • Desa (V)VC36P Series - page 20

    www .desatech.com 1 16200-01H 20 CA UTI ON: Ne ver tou ch th e            9. Ch ec k to mak e sure th at the pow er cor d is com - pl et el y cl ea r of t he b lo we r wh ee l an d t hat t he re ar e no oth er for ei gn obj ect s in bl ow er whe el. Tu r ...

  • Desa (V)VC36P Series - page 21

    www .desatech.com 1 16200-01H 21 7. Ch ec k to ma ke su re th at th e po we r co rd i s co m - pl ete ly c lea r of th e b low er w he el a nd t ha t th ere a re no ot he r f or ei gn o bj ec ts i n b lo we r wh ee l . A ls o do ubl e c he ck al l w ir e l ea ds an d m ak e s ur e w ir e ro uti ng is no t pi nc he d or in a p re car iou s pos it io ...

  • Desa (V)VC36P Series - page 22

    www .desatech.com 1 16200-01H 22 Figure 31 - External Regulator with V ent Pointing Down (Propane/LP Only) Propane/LP Supply T ank External Regulator V ent Pointing Down CAUTION: Use only new ,       - ? ...

  • Desa (V)VC36P Series - page 23

    www .desatech.com 1 16200-01H 23 Figure 33 - Connecting Flexible Gas Line to Millivolt V alve Flexible Gas Line Do NOT Kink Equipment Shutoff V alve T o Gas Supply (Natural) T o External Regulator (Propane/LP) Control V alve FIREPLACE INST ALLA TION Continued     ...

  • Desa (V)VC36P Series - page 24

    www .desatech.com 1 16200-01H 24 PRESSURE TESTING FIREPLACE GAS CONNECTIONS 1. Open equipment shutof f valve (see Figure 34, page 23). 2. O pe n p r op a ne / L P s up p l y t an k v al v e f o r propane/LP fireplace or main gas valve located on or near gas meter for natural gas replace. 3. Make sure control knob of replace is in the OFF posi ...

  • Desa (V)VC36P Series - page 25

    www .desatech.com 1 16200-01H 25    Held Remote Control Unit 1. Remove battery cover on back of remote control unit. 2. Attach terminal wires to a 9-volt alkaline battery (not included). Place battery into the battery hou ...

  • Desa (V)VC36P Series - page 26

    www .desatech.com 1 16200-01H 26 4. Remount the new frame at the hinge with ve new s crew s bef ore clo sing doo r . T his wil l ensure seating of the gasket. 5. Cl os e g la ss d oo r fr am e. L oc k l at che s by p la ci ng th e ba r u nd er t he ta b on do or a nd p us hi ng do wn an d bac k on la t ch ( se e Fi gu re 42, p age 25). 6. Replac ...

  • Desa (V)VC36P Series - page 27

    www .desatech.com 1 16200-01H 27 6. Install rear brick panel rst. Rest bottom edge of panel on back edge of burner assembly (see Figure 44). 7. Install left side brick panel by sliding it be - tween the burner assembly and the side of the rebox (see Figure 44). 8. Install the right brick panel using the same method described in step 6 for lef ...

  • Desa (V)VC36P Series - page 28

    www .desatech.com 1 16200-01H 28 7. Turn gas control knob counterclockwise t o “PI LO T”. (s ee F ig ur e 4 5) 8. Push in gas control knob all the way and hold. Immediately light the pilot by repeat- edly depr essing the piezo spar k igni tor unti l a ame appears . Contin ue to hold for about one (1) minute after the pilot is lit. Release ga ...

  • Desa (V)VC36P Series - page 29

    www .desatech.com 1 16200-01H 29 OPERA TING FIREPLACE Continued  Hold the control button on the hand-held remote until burner turns on. Hold the con- trol button again until burner turns off (see Figure 47).   press both buttons on hand-held remote ...

  • Desa (V)VC36P Series - page 30

    www .desatech.com 1 16200-01H 30  Th is fea tu re all ows the use r to lo ck /u nl oc k the ke ypa d on th e han d- he ld rem ote in th e MA NU or A UT O mo de to pr ev en t in ad ve rt en t o pe ra ti on ( i. e. ch il dre n ope rat in g th e han d-h el d re mo te con tr ol , et c. ). T he ...

  • Desa (V)VC36P Series - page 31

    www .desatech.com 1 16200-01H 31 INSPECTING B URNERS Continued    Burn er ames will be steady; not lifti ng or oat ing. Flame patterns will be different from unit to unit and will vary depending on installation type and weather conditions. If the vent conguration is installed inco ...

  • Desa (V)VC36P Series - page 32

    www .desatech.com 1 16200-01H 32 CAUTION: Do not vacuum if  Use only the tempered glass door replacement intende d for this replace (see Replacement Parts , page 37 for detail on ordering). No substitutions may be made. See Removing/Replacing Glass Door , p a ge 2 5 f or in s tr uc ti o ns f or r ep l ...

  • Desa (V)VC36P Series - page 33

    www .desatech.com 1 16200-01H 33 TROUBLESHOO TING      ? ...

  • Desa (V)VC36P Series - page 34

    www .desatech.com 1 16200-01H 34  Pilot lights but ame goes out when control knob is released Burner does not light after pilot is lit Delayed ignition burner Burner backring during com - bustion Slight smoke or odor during initial operation REMEDY 1 . Press in gas control knob fully 2. After pi ...

  • Desa (V)VC36P Series - page 35

    www .desatech.com 1 16200-01H 35 TROUBLESHOO TING Continued  Heater produces a whistling noise when burner is lit Glass soots Fir epla ce produ ces a clicki ng/t ick - ing noise just after burners are lit or shut off Remote does not function REMEDY 1. T urn gas control knob to LO position and let warm ...

  • Desa (V)VC36P Series - page 36

    www .desatech.com 1 16200-01H 36 TROUBLESHOO TING Continued          ...

  • Desa (V)VC36P Series - page 37

    www .desatech.com 1 16200-01H 37 REPLACEMENT P ARTS Note : Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . P ARTS UNDER W ARRANTY Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA ’ s Customer Service Department at 1-866-67 ...

  • Desa (V)VC36P Series - page 38

    www .desatech.com 1 16200-01H 38 ILL USTRA TED P ARTS BREAKDOWN     SERIES 6 7 22 19 20 15 2 14 21 8 1 4 13 9 16 3 18 5 17 23 10 1 1 12 24 ...

  • Desa (V)VC36P Series - page 39

    www .desatech.com 1 16200-01H 39 P ARTS LIST     SERIES This list contains replaceable parts used in your replace. When ordering parts, follow the instructions list ...

  • Desa (V)VC36P Series - page 40

    www .desatech.com 1 16200-01H 40 7 15 10 12 1 12 2 3 13 9 1 1 21 22 TPTH TP TH 6 12 14 18 17 17 18 19 20 16 14 8 4 5 ILL USTRA TED P ARTS BREAKDOWN      ? ...

  • Desa (V)VC36P Series - page 41

    www .desatech.com 1 16200-01H 41 P ARTS LIST        This list contains replaceable parts used in your repla ...

  • Desa (V)VC36P Series - page 42

    www .desatech.com 1 16200-01H 42  Man ual vari abl e contro l blowe r acces sory pro vide s better heat distribution. Complete installation and operation instructions included in this manual. ACCESSORIES NOTICE: All accessories may   ...

  • Desa (V)VC36P Series - page 43

    www .desatech.com 1 16200-01H 43 ACCESSORIES Continued RE CEI VE R AND H AN D-H EL D ON/ OF F         SERIES Al lo ws t he f ire pl ac e t o be t ur ne d on a nd o ff con ven ient ly . A wa ll-m ount ed do ckin g s tati on is included. W ALL MOUNTED THERMOST A T  ...

  • Desa (V)VC36P Series - page 44

    2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 16200-01 Rev . H 03/06 WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notice ...

Manufacturer Desa Category Indoor Fireplace

Documents that we receive from a manufacturer of a Desa (V)VC36P Series can be divided into several groups. They are, among others:
- Desa technical drawings
- (V)VC36P Series manuals
- Desa product data sheets
- information booklets
- or energy labels Desa (V)VC36P Series
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa (V)VC36P Series.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa (V)VC36P Series, service manual, brief instructions and user manuals Desa (V)VC36P Series. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa (V)VC36P Series.

Similar manuals

A complete manual for the device Desa (V)VC36P Series, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa (V)VC36P Series by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa (V)VC36P Series.

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa (V)VC36P Series - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa (V)VC36P Series, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa (V)VC36P Series, that we can find in the current document
3. Tips how to use the basic functions of the device Desa (V)VC36P Series - which should help us in our first steps of using Desa (V)VC36P Series
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa (V)VC36P Series
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa (V)VC36P Series in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa (V)VC36P Series?

Use the form below

If you did not solve your problem by using a manual Desa (V)VC36P Series, ask a question using the form below. If a user had a similar problem with Desa (V)VC36P Series it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)