English dropdown-ico

Manual Napoleon EPA 1100

16 pages 2.65 mb
Download

Go to site of 16

Summary
  • Napoleon EPA 1100 - page 1

    1 W415-0360 / 11.05.02 INSTALLATION AND OPERATION INSTRUCTIONS FOR HI-TECH LISTED SOLID FUEL BURNING STOVES AND INSERTS FREE ST ANDING MODELS EP A 1 100, 1 100L, 1 100C, 1400, 1400L & 1900 INSERT MODELS EPI 1 101, 1401 INSTALLER: THESE INSTRUCTIONS MUST BE CONVEYED TO AND REMAIN WITH THE HOMEOWNER. CERTIFIED UNDER U.S. ENVIRONMENTAL PROTECTION ...

  • Napoleon EPA 1100 - page 2

    2 W415-0360 / 1 1.05.02 NAPOLEON wood fireplaces are manufactured under the strict Standard of the World Recognized ISO 9001 : 2000 Quality Assurance Certificate. NAPOLEON products are designed with superior components and materials, assembled by trained craftsmen who take great pride in their work. The complete fireplace is thoroughly inspected by ...

  • Napoleon EPA 1100 - page 3

    3 W415-0360 / 11.05.02 PG 2-4 INTRODUCTION Warranty General Information Care of Plated & Enamelled Parts Care of Glass 5-6 INST ALLA TION Installing the Legs Alcove Installation Stove Installation Chimney Connection Adding Chimney Sections Outside Air 6-7 MOBILE HOME INST ALLA TION Venting Outside Air 7-8 FIREPLA CE INSER T INST ALLA TION Prior ...

  • Napoleon EPA 1100 - page 4

    4 W415-0360 / 11.05.02 INTRODUCTION GENERAL INFORMATION Except for their different depths, models 1100, 1400, 1900 and the fireplace inserts 1101 and 1401 are iden- tical and use the same burning principles. They were specifically designed over many months of research to meet the 1990 U.S.A. EPA particulate emission stand- ards and have been extens ...

  • Napoleon EPA 1100 - page 5

    5 W415-0360 / 11.05.02 STOVE INSTALLATION If the stove is to be installed on a combustible floor, it must be placed on a approved non-com- bustible hearth pad, that extends 8" (200mm) beyond the stove sides and back, and 18" (455mm) to the front. SINGLE WALL CHIMNEY CONNECTOR* DOUBLE WALL CHIMNEY CONNECTOR CHIMNEY CONNECTION Vent the stov ...

  • Napoleon EPA 1100 - page 6

    6 W415-0360 / 11.05.02 DO NOT USE ANY MAKESHIFT MATERIALS DURING INSTALLATION. 1. Move the stove into position with the flue centered, midpoint between two joists to prevent having to cut them. Use a plumb bob to line up the centre. 2. Cut and frame an opening in the roof to provide a 2" clearance between the outside of the chimney and any com ...

  • Napoleon EPA 1100 - page 7

    7 W415-0360 / 11.05.02 OUTSIDE AIR Connection from the stove's air intake to the outside is mandatory in mobile homes only, either through a hole in the wall to line up with the knockout in the pedestal back, or through a hole in the floor to line up with the hole in the pedestal base. Use a fresh air kit. Secure the 4 inch diameter aluminum l ...

  • Napoleon EPA 1100 - page 8

    8 W415-0360 / 11.05.02 In the United States, continued: If a continuous liner is not installed, a "direct flue con- nection" must be made. The direct flue connection re- quires a non-combustible connector that extends from the insert into the chimney flue liner and also that the installed flue cover be sealed below the entry point of the ...

  • Napoleon EPA 1100 - page 9

    9 W415-0360 / 11.05.02 1101 FAN SERVICE OR REPLACEMENT 1. Turn off all electrical power to the insert. Remove the glass door and set aside in a safe place. 2. Remove the top right side bricks from inside the firebox, 4-#7's and 2- #2's. Then remove the rest of the side and back bricks from the right side of the 1101 insert. It is not nece ...

  • Napoleon EPA 1100 - page 10

    10 W415-0360 / 11.05.02 MODEL 1401/1400L - FIGURE 20 MODEL 1101/1100L - FIGURE 18 12 12 10 10 10 10 11 11 11 11 MODEL 1400 - FIGURE 19 MODEL 1100/1100C - FIGURE 17 BRICK RETAINER DETAIL - TYPICAL MODEL 1900 - FIGURE 21 AREA CIRCLED ON EACH FIGURE INDICATES THE BRICK RETAINER DETAIL SIZES #1. 1-1/4" x 4"-1/2 x 9" #2. 1-1/4" x 3&q ...

  • Napoleon EPA 1100 - page 11

    11 W415-0360 / 11.05.02 BRICK and BAFFLE INSTALLATION With stove and chimney installation completed, move the bricks into place by working as illustrated for your unit on page 10. 1. Install two or three courses of brick on both sides of the unit. Install two courses on the back wall. Install the final course of bricks on the back wall. These brick ...

  • Napoleon EPA 1100 - page 12

    12 W415-0360 / 11.05.02 You can now add larger pieces of wood and operate the stove normally. Once the stove/insert is entirely hot, it will burn very efficiently with little smoke from the chim- ney. There will be a bed of orange coals in the firebox and secondary flames flickering just below the top fire- brick. You can safely fill the firebox wi ...

  • Napoleon EPA 1100 - page 13

    13 W415-0360 / 11.05.02 DO NOT OVERFIRE THE STOVE! Overfiring can occur by: a) burning large amounts of smaller wood pieces such as furniture scraps, skids or treated wood; b) vigorously burning large loads of wood with the draft control on "HIGH" (fully open) for long periods of time (one or two hours). SMOKING A properly installed Napol ...

  • Napoleon EPA 1100 - page 14

    14 W415-0360 / 11.05.02 WOOD PILE MAINTENANCE Burn only dry, clean unpainted wood that has been seasoned. It produces more heat and less soot or creosote. Freshly cut wood contains about 50% moisture while after proper seasoning only about 20% of the water remains. As wood is burned, this water boils off consuming energy that should be used in heat ...

  • Napoleon EPA 1100 - page 15

    15 W415-0360 / 11.05.02 ORDERING PROCEDURES Contact your dealer or the factory for questions concerning prices and policies on replacement parts. Normally all parts can be ordered through your Napoleon dealer or distributor. When ordering replacement parts always give the following information: 1. Model & Serial Number of fireplace 2. Installat ...

  • Napoleon EPA 1100 - page 16

    16 W415-0360 / 11.05.02 58 57 40 53 50 51 52 48 24 29 49 1 43 33 31 28 32 15 17 19 35 34 35 37 36 38 44 55 1 39 ...

Manufacturer Napoleon Category Stove

Documents that we receive from a manufacturer of a Napoleon EPA 1100 can be divided into several groups. They are, among others:
- Napoleon technical drawings
- EPA 1100 manuals
- Napoleon product data sheets
- information booklets
- or energy labels Napoleon EPA 1100
All of them are important, but the most important information from the point of view of use of the device are in the user manual Napoleon EPA 1100.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Napoleon EPA 1100, service manual, brief instructions and user manuals Napoleon EPA 1100. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Napoleon EPA 1100.

Similar manuals

A complete manual for the device Napoleon EPA 1100, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Napoleon EPA 1100 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Napoleon EPA 1100.

A complete Napoleon manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Napoleon EPA 1100 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Napoleon EPA 1100, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Napoleon EPA 1100, that we can find in the current document
3. Tips how to use the basic functions of the device Napoleon EPA 1100 - which should help us in our first steps of using Napoleon EPA 1100
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Napoleon EPA 1100
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Napoleon EPA 1100 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Napoleon EPA 1100?

Use the form below

If you did not solve your problem by using a manual Napoleon EPA 1100, ask a question using the form below. If a user had a similar problem with Napoleon EPA 1100 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)