Manual Weil-McLain SERIES 7 PFG

16 pages 3 mb
Download

Go to site of 16

Summary
  • Weil-McLain SERIES 7 PFG - page 1

    Part No. 550-110-643/0605 T o complete boiler installation, follow: • General Information 2 • Boiler Wiring 3-5 • V ent Damper Installation 6 • Check-out Procedur e 7 • Operating Instructions 8-10 For additional help, see: • T roubleshooting 11-15 • Parts List 16 Contr ols must onl y be installed by and Contr ol Supplement used by a q ...

  • Weil-McLain SERIES 7 PFG - page 2

    2 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 GENERAL INFORMA TION: PLEASE GIVE THE MODEL listed on the boiler rating label AND THE CP NUMBER found next to the rating label. The following dened terms are used throughout this manual. They bring attention to the presence of hazards of v ...

  • Weil-McLain SERIES 7 PFG - page 3

    3 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 Section A: Installation 1. Bring supply wiring to boiler. Must be 14 ga. or heavier. See pages listed below each Figure for appropriate wiring diagram. 2. Proceed to page 6. PFG 5 Boiler Figure 1, see page 4 PFG 6 thru 8 Boilers Figure 2, see ...

  • Weil-McLain SERIES 7 PFG - page 4

    4 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG-5 ...

  • Weil-McLain SERIES 7 PFG - page 5

    5 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG 6 thru 8 ...

  • Weil-McLain SERIES 7 PFG - page 6

    6 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 These boiler s mus t have vent damper s: • PFG 5 (U.S . onl y) These boiler s may have vent d ampers : • PFG 6-8 (U .S. o nly) • PFG 5-7 (C anadi an) These boiler s mus t not have v ent da mper: • PFG 8 (Can adian ) If not insta lling ...

  • Weil-McLain SERIES 7 PFG - page 7

    7 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 1. See Figure 5 for operating instructions page numbers. Raise room thermostat to call for heat. Damper actuator will slowly open damper (if provided). 2. When damper (if provided) is fully open, ignition control powers spark generator and op ...

  • Weil-McLain SERIES 7 PFG - page 8

    8 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG-5 WITH HONEYWELL VR8204/VR8304 GAS V AL VE ...

  • Weil-McLain SERIES 7 PFG - page 9

    9 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG-5 WITH WHITE-RODGERS 36C GAS V AL VE ...

  • Weil-McLain SERIES 7 PFG - page 10

    10 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 PFG 6-8 WITH ROBER TSHAW 7000 DERHC GAS V AL VE ...

  • Weil-McLain SERIES 7 PFG - page 11

    11 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 VERIFY PROPER OPERA TION AFTER SERVICING Nev er jumpe r (by pas s) any devi ce excep t for momentary testing as outlined in Troubleshooting Charts. Substantial property damage and/or severe personal injury could occur. Label all wires prior ...

  • Weil-McLain SERIES 7 PFG - page 12

    12 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 Check for open thermostat or circ. relay (where used) or check for loose wire connections, defective spill switch or rollout thermal fuse element, or open LWCO or limit c ontacts. If LWCO, spill sw itch or rollout thermal fuse element contac ...

  • Weil-McLain SERIES 7 PFG - page 13

    13 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 Check for open thermostat or circ. relay (where used) or check for loose wire connections, defective spill switch or rollout thermal fuse element, or open LWCO or hight limit contacts. If LWCO, spill switch or rollout thermal fuse element co ...

  • Weil-McLain SERIES 7 PFG - page 14

    14 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 T ABLE III: Pilot Lights, Main V alve Will Not Come On With or Without V ent Damper Correct wiring. Make sure sense wire is not wrapped around any pipe or accessories. Is sense wire securely attached to sense terminal and pilot assembly? No ...

  • Weil-McLain SERIES 7 PFG - page 15

    15 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 T ABLE IV: Spark is Present, Pilot Will Not Light With or Without V ent Damper Connect securely to T er minals PV and MV/PV on ignition control. Are pilot valve connections CORRECT and securely fastened? No Y es Open manual hand valve. Is ma ...

  • Weil-McLain SERIES 7 PFG - page 16

    16 PFG S erieS 7 G aS - Fired W a ter B oiler – U niverSal C ontrol S y StemS Part Number 550-110-643/0605 Section E: Parts **Not for use on Canadian PFG-8 boilers. Only dampers listed above are approved for use on and PFG Series 6 & 7 boilers. Any other damper installed can cause severe personal injury or death. Part Description V endor Part ...

Manufacturer Weil-McLain Category Boiler

Documents that we receive from a manufacturer of a Weil-McLain SERIES 7 PFG can be divided into several groups. They are, among others:
- Weil-McLain technical drawings
- SERIES 7 PFG manuals
- Weil-McLain product data sheets
- information booklets
- or energy labels Weil-McLain SERIES 7 PFG
All of them are important, but the most important information from the point of view of use of the device are in the user manual Weil-McLain SERIES 7 PFG.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Weil-McLain SERIES 7 PFG, service manual, brief instructions and user manuals Weil-McLain SERIES 7 PFG. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Weil-McLain SERIES 7 PFG.

A complete manual for the device Weil-McLain SERIES 7 PFG, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Weil-McLain SERIES 7 PFG by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Weil-McLain SERIES 7 PFG.

A complete Weil-McLain manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Weil-McLain SERIES 7 PFG - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Weil-McLain SERIES 7 PFG, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Weil-McLain SERIES 7 PFG, that we can find in the current document
3. Tips how to use the basic functions of the device Weil-McLain SERIES 7 PFG - which should help us in our first steps of using Weil-McLain SERIES 7 PFG
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Weil-McLain SERIES 7 PFG
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Weil-McLain SERIES 7 PFG in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Weil-McLain SERIES 7 PFG?

Use the form below

If you did not solve your problem by using a manual Weil-McLain SERIES 7 PFG, ask a question using the form below. If a user had a similar problem with Weil-McLain SERIES 7 PFG it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)