-
Pride Mobility Jazzy 600 XL - page 1
Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pridemobility .com Owner’ s Manual ...
-
Pride Mobility Jazzy 600 XL - page 2
4 4 www .pridemobility .com Jazzy 600 XL SAFETY GUIDELINES Copyright © 2005 Pride Mobility Products Corp. INFMANU3091/RevA/November 05 The symbols below are used throughout this owner's manual and on the power chair to identify warnings and important information. It is very important for you to read them and understand them completely . WARNI ...
-
Pride Mobility Jazzy 600 XL - page 3
Jazzy 600 XL www .pridemobility .com 3 I. INTRODUCTION ................................................................................................................................. 4 I I . SAFETY ................................................................................................................................................. 6 II ...
-
Pride Mobility Jazzy 600 XL - page 4
4 www .pridemobility .com Jazzy 600 XL I. INTRODUCTION SAFETY WELCOME to Pride Mobility Products Corporation (Pride). The power chair you have purchased combines state-of- the-art components with safety , comfort, and styling in mind. W e are confident that these design features will provide you with the conveniences you expect during your daily ac ...
-
Pride Mobility Jazzy 600 XL - page 5
Jazzy 600 XL www .pridemobility .com 5 I. INTRODUCTION PRIDE OWNERS CLUB As an owner of a Pride product, you are invited to register your product’ s warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed product registration card or by visiting Pride's web site at www .pridemobility .com. As a ...
-
Pride Mobility Jazzy 600 XL - page 6
6 www .pridemobility .com Jazzy 600 XL II. SAFETY Cor r osiv e chemicals contained in batter y . Use onl y AGM or Gel-Cell ba tteries to reduce the risk of leakage or explosive conditions. EMI-RFI - This product has been tested and passed at an immunity level of 20 V/m. Read and f ollo w the infor mation in the owner’ s manual. Maximum seating we ...
-
Pride Mobility Jazzy 600 XL - page 7
Jazzy 600 XL www .pridemobility .com 7 II. SAFETY Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Av oid exposure to rain, snow , ice, salt, or standing wa ter w hene ver possible. Maintain and store in a clean and dr y condition. Remo val of gr ounding prong can cr ea te electrical hazard. If necessar y ...
-
Pride Mobility Jazzy 600 XL - page 8
8 www .pridemobility .com Jazzy 600 XL II. SAFETY SAFETY MAND A T OR Y! Do not operate y our new power c hair for the first time without completel y reading and understanding this owner’s manual. Y our power chair is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an extensive variety of products to best ...
-
Pride Mobility Jazzy 600 XL - page 9
Jazzy 600 XL www .pridemobility .com 9 II. SAFETY Weight Limitations Y our power chair is rated for a maximum weight capacity . Please refer to the specifications table for this limit. WARNING! Exceeding the weight capacity v oids your warr anty and may r esult in personal injur y and/or damage to your power c hair . Pride will not be held responsi ...
-
Pride Mobility Jazzy 600 XL - page 10
1 0 www .pridemobility .com Jazzy 600 XL II. SAFETY Figure 1. Maximum Safe Slope (Ascending and Descending) WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications presented in this manual. Doing so coul ...
-
Pride Mobility Jazzy 600 XL - page 11
Jazzy 600 XL www .pridemobility .com 1 1 II. SAFETY Freewheel Mode Y our power chair is equipped with two manual freewheel levers to allow for manual maneuverability by a trained attendant. For more information about how to place your power chair into and out of freewheel mode, see III. “Y our Power Chair .” WARNING! Do not use your power chair ...
-
Pride Mobility Jazzy 600 XL - page 12
1 2 www .pridemobility .com Jazzy 600 XL II. SAFETY T ransfers T ransferring onto and off of your power chair requires a good sense of balance. Always have an attendant or health- care professional present while learning to properly trans- fer yourself. T o eliminate the possibility of injury , Pride recommends that you or a trained attendant perfo ...
-
Pride Mobility Jazzy 600 XL - page 13
Jazzy 600 XL www .pridemobility .com 1 3 II. SAFETY Inclement Weather Precautions Exposure of your power chair to inclement weather conditions should be avoided whenever possible. If suddenly caught up in rain, snow , severe cold or heat while operating your power chair proceed to shelter at the earliest opportunity . Thoroughly dry your power chai ...
-
Pride Mobility Jazzy 600 XL - page 14
1 4 www .pridemobility .com Jazzy 600 XL II. SAFETY Removable Parts WARNING! Do not attempt to lift or mo ve a po wer chair by any of its removable par ts. Personal injur y and/or dama ge to the po wer chair may result. Preventing Unintended Movement WARNING! If you anticipate being sea ted in a stationar y position for an e xtended period of time, ...
-
Pride Mobility Jazzy 600 XL - page 15
Jazzy 600 XL www .pridemobility .com 1 5 III. YOUR POWER CHAIR THE JAZZY 600 XL The Jazzy 600 XL has two main assemblies: the seat assembly and the power base assembly . See figure 5. T ypically , the seat assembly includes the armrests, seatback, and seat base. The power base assembly includes two motor/brake assem- blies, two drive wheels, four c ...
-
Pride Mobility Jazzy 600 XL - page 16
1 6 www .pridemobility .com Jazzy 600 XL J J J J J AZZY 600 XL S AZZY 600 XL S AZZY 600 XL S AZZY 600 XL S AZZY 600 XL S PECIFICA PECIFICA PECIFICA PECIFICA PECIFICA TIONS TIONS TIONS TIONS TIONS Suspension: Active-Trac Extreme Drive Wheels: 14 in., solid Front Caster Wheels: 5 in., solid Rear Caster Wheels: 6 in., solid Maximum S peed: Up t o 4 mp ...
-
Pride Mobility Jazzy 600 XL - page 17
Jazzy 600 XL www .pridemobility .com 1 7 III. YOUR POWER CHAIR ELECTRICAL COMPONENTS The electrical components are located inside the power base. The ammeter and the charger power cord receptacle are located on the right side of the power base. The main circuit breaker is located on the front of the battery tray . The controller connector(s) are lo ...
-
Pride Mobility Jazzy 600 XL - page 18
1 8 www .pridemobility .com Jazzy 600 XL III. YOUR POWER CHAIR Battery Connector: This is where the controller connects to the batteries. Controller Connector (FLIGHT Only): This is where the controller connects to the power module. Main Cir cuit Breaker: The main circuit breaker is a safety feature built into your power chair . When the batteries ...
-
Pride Mobility Jazzy 600 XL - page 19
Jazzy 600 XL www .pridemobility .com 1 9 MANU AL FREEWHEEL LEVERS The Jazzy 600 XL has a manual freewheel lever on each motor . Manual freewheel levers enable you to disengage the drive motors from the gearboxes and maneuver the chair manually . WARNING! Do not use the power chair while the drive motors are disengaged! Do not disengage the drive mo ...
-
Pride Mobility Jazzy 600 XL - page 20
2 0 www .pridemobility .com Jazzy 600 XL INITIAL ASSEMBL Y Y our power chair may require some assembly either before initial use or after transportation. It may also require disassembly to make some comfort adjustments. Figure 10 details those parts of the power chair that are designed to be disassembled and assembled by an end user or by a qualifi ...
-
Pride Mobility Jazzy 600 XL - page 21
Jazzy 600 XL www .pridemobility .com 2 1 IV . ASSEMBL Y SEA T INST ALLA TION It may be necessary to install the seat either prior to initial operation or after transporting your power chair . Most seats are attached to the power base with the Universal Mount- ing System (UMS). The UMS consists of universal parts that may be attached to any medium-b ...
-
Pride Mobility Jazzy 600 XL - page 22
2 2 www .pridemobility .com Jazzy 600 XL V . COMFOR T ADJUSTMENTS COMFORT ADJUSTMENTS After becoming familiar with your power chair ’ s operation, you may find the need to make some adjustments to increase your comfort, such as seat height and angle, armrest angle, foot platform height and angle, and controller position. If your power chair is eq ...
-
Pride Mobility Jazzy 600 XL - page 23
Jazzy 600 XL www .pridemobility .com 2 3 ARMREST KNOB JAM NUTS ARMREST ANGLE ADJUSTING SCREW Figure 16. Seatback Angle Adjustment Figure 15. Seat Position Adjustment V . COMFOR T ADJUSTMENTS 12 . Reinstall each screw into the trapeze bars and tighten. 1 3. Reinstall the seat. 14 . Reconnect the controller to the power base. 15. Reinstall the rear s ...
-
Pride Mobility Jazzy 600 XL - page 24
2 4 www .pridemobility .com Jazzy 600 XL Armrest Wid th Adjustment Y ou can change each armrest’ s width independently of the other . NOTE: Changing the armrest width may increase the overall width of your power chair . T o change the armr est width: 1 . Locate the two armrest knobs on each side of the armrest receiver bracket. See figure 16. 2. ...
-
Pride Mobility Jazzy 600 XL - page 25
Jazzy 600 XL www .pridemobility .com 2 5 V . COMFOR T ADJUSTMENTS two states: clamped and unclamped. When the lever is open, the quick release fastener is unclamped. When the lever is closed, the quick release fastener is clamped. T o clamp the quick release fastener: 1. Make sure the lever is in the open position. 2 . T urn the nut clockwise until ...
-
Pride Mobility Jazzy 600 XL - page 26
2 6 www .pridemobility .com Jazzy 600 XL V . COMFOR T ADJUSTMENTS Swing-away Footrests Swing-away Footrests (SFRs) enable you to rotate the foot- rests to the side before you transfer onto or off or your power chair . See figure 20. T o rotate the SFRs: 1. Push in the release lever . 2. Rotate the SFRs. T o adjust the SFR length: 1. Remove the two ...
-
Pride Mobility Jazzy 600 XL - page 27
Jazzy 600 XL www .pridemobility .com 2 7 Multi-Axis Foot Plates The multi-axis foot plate assembly can be installed on either a swing-away footrest or an elevating leg rest. The multi- axis foot plate has four adjustments: leg rest length (A), po- sition (B), tilt (C), and angle (D). See figure 23. T o change leg rest length (A): 1. Remove the hard ...
-
Pride Mobility Jazzy 600 XL - page 28
2 8 www .pridemobility .com Jazzy 600 XL VI. BA TTERIES AND CHAR GING BA TTERIES AND CHARGING The Jazzy 600 XL uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level. Deep-cycle batteries are designed to handle a longer and ...
-
Pride Mobility Jazzy 600 XL - page 29
Jazzy 600 XL www .pridemobility .com 2 9 VI. BA TTERIES AND CHARGING NOTE: If it is a Pride off-board charger , then there are two lights in it. The red light indicates that power to the off-board charger is on. The green light indicates that the batteries are fully charged. If it is not a Pride off- board charger , then follow the instructions sup ...
-
Pride Mobility Jazzy 600 XL - page 30
3 0 www .pridemobility .com Jazzy 600 XL VI. BA TTERIES AND CHAR GING NOTE: Keep your batteries fully charged and avoid deeply discharging your batteries. Do not charge the batteries for more than 24 hours at a charging cycle. How can I get maximum range or distance per charge? Rarely do you have an ideal driving situation such as smooth, flat, har ...
-
Pride Mobility Jazzy 600 XL - page 31
Jazzy 600 XL www .pridemobility .com 3 1 How should I store my power chair and its batteries? If you do not use your power chair regularly , we recommend maintaining battery vitality by charging the batteries at least once per week. If you do not plan on using your power chair for an extended period, fully charge the batteries prior to storage. Dis ...
-
Pride Mobility Jazzy 600 XL - page 32
3 2 www .pridemobility .com Jazzy 600 XL Figure 24. FLIGHT Controller 2 3 4 5 1 VII. OPERA TION FLIGHT CONTROLLER The electronic controller is what you use to operate your power chair . It takes the battery voltage and sends it to the appropriate system. The electronic controller enables you to move the power chair , as well as monitor battery char ...
-
Pride Mobility Jazzy 600 XL - page 33
Jazzy 600 XL www .pridemobility .com 3 3 Figure 25. FLIGHT Controller Keypad VII. OPERA TION On/Off Key The on/off key turns the FLIGHT on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to stop the chair . T his will cause the power chair to stop abr uptl y . WARNING! Always tur n the po wer of f when you are ...
-
Pride Mobility Jazzy 600 XL - page 34
3 4 www .pridemobility .com Jazzy 600 XL VII. OPERA TION Speed Keys There are two keys that control the speed. Press the hare key to increase the speed. Press the tortoise key to decrease the speed. The speed setting is displayed on the speed indicator . If your power chair was programmed with a drive profile, contact your authorized Pride Provider ...
-
Pride Mobility Jazzy 600 XL - page 35
Jazzy 600 XL www .pridemobility .com 3 5 VIII. CARE AND MAINTENANCE CARE AND MAINTENANCE Y our Jazzy 600 XL is a sophisticated power chair . Like any motorized vehicle, it requires routine maintenance checks. Y ou can perform some of these checks, but others require assistance from your authorized Pride Provider . Preventive mainte- nance is very i ...
-
Pride Mobility Jazzy 600 XL - page 36
3 6 www .pridemobility .com Jazzy 600 XL VIII. CARE AND MAINTENANCE ! Check all electrical connections. Make sure they are tight and are not corroded. Batteries must sit flat within the battery tray , with the battery terminals facing inward, toward each other . Refer to the battery wiring label for the correct wiring layout. ! All wheel bearings a ...
-
Pride Mobility Jazzy 600 XL - page 37
Jazzy 600 XL www .pridemobility .com 3 7 VIII. CARE AND MAINTENANCE WARNING! If you fail to store the unit pr oper ly , the frame can r ust and the electr onics can be damaged. Cleaning Instructions WARNING! Ne ver hose off your power chair or place it in direct contact with wa ter . Y our power c hair has a painted, ABS plastic body shroud that al ...
-
Pride Mobility Jazzy 600 XL - page 38
3 8 www .pridemobility .com Jazzy 600 XL VIII. CARE AND MAINTENANCE Battery Replacement A battery wiring diagram is printed on a decal located on the front battery tray . See VI. “Batteries and Char ging” for correct battery specifications. WARNING! Prevent injur y . Do not replace batter y w hen seat is occupied. WARNING! Batter y posts, ter m ...
-
Pride Mobility Jazzy 600 XL - page 39
Jazzy 600 XL www .pridemobility .com 3 9 BATTERY WIRING DIAGRAM LABEL VIII. CARE AND MAINTENANCE Figure 28. Battery Installation REAR SHROUD FASTENERS REAR SHROUD FRONT BATTERY REAR BATTERY DWR1234L804 REV 50 ...
-
Pride Mobility Jazzy 600 XL - page 40
4 0 www .pridemobility .com Jazzy 600 XL VIII. CARE AND MAINTENANCE When to See Y our Authorized Pride Provider for Service The following symptoms could indicate a serious problem with your power chair . If necessary , contact your authorized Pride Provider . When calling, have the model number , serial number , nature of the problem, and the error ...
-
Pride Mobility Jazzy 600 XL - page 41
Jazzy 600 XL www .pridemobility .com 4 1 IX. WARRANTY LIFETIME LIMITED WARRANTY For the lifetime of your power chair from the date of purchase, Pride will repair or replace at our option to the original purchaser , free of charge, any of the following parts found upon examination by an authorized representative of Pride to be defective in material ...
-
Pride Mobility Jazzy 600 XL - page 42
4 2 www .pridemobility .com Jazzy 600 XL IX. WARRANTY RECONDITIONED UNITS WARRANTY All reconditioned units are covered by a six-month warranty from Pride effective from the date of purchase. WARRANTY EX CLUSIONS This warranty does not extend to those items which may require replacement due to normal wear and tear . ! ABS Plastic shrouds ! Motor bru ...
-
Pride Mobility Jazzy 600 XL - page 43
Quality Control- Model 14 0 0 Quality Control - Jazzy 600 XL Thank you for making the Jazzy 600XL your choice in power chairs. W e have thoroughly inspected your power chair . The following checkmarks indicate that it has been test driven and inspected. Fit and Finish Performance Inclusion of all Parts Pride keeps a more detailed r eport on file at ...
Do you have a question concerning Pride Mobility Jazzy 600 XL?
Use the form below
If you did not solve your problem by using a manual Pride Mobility Jazzy 600 XL, ask a question using the form below. If a user had a similar problem with Pride Mobility Jazzy 600 XL it is likely that he will want to share the way to solve it.