English dropdown-ico

Manual Century 5130

34 pages 1.03 mb
Download

Go to site of 34

Summary
  • Century 5130 - page 1

    CENTURY ® L E G E N D A R Y L E A D E R S H I P OWNER'S MANUAL 5130 / 5230 INSTALLATION, OPERATION, MAINTENANCE & PARTS NOTE: MANUAL including SPECIFICATIONS, subject to change without notice All ratings specified are based on structural factors only, not vehicle capacities or capabilities. CENTURY ® Miller Industries Towing Equipment In ...

  • Century 5130 - page 2

    LIMITED WARRANTY MILLER INDUSTRIES TOWING EQUIPMENT INC., hereinafter referred to as MILLER, warrants to the original purchaser that each new MILLER wrecker or other MILLER products will be free from defects in material and workmanship for a period of twelve (12) months from date placed in service, but in no event shall such warranty period exceed ...

  • Century 5130 - page 3

    Section VI - P ARTS This Section is provided by the manufacturer for the purpose of ordering any component part of the CENTUR Y 5130 or 5230 that may be required when part replacement is necessary . Be certain to use only original equipment replacement part s for warranty purposes as well as for keeping your CENTUR Y 5130 or 5230 in its original st ...

  • Century 5130 - page 4

    VI-2 Section VI - P ARTS (cont'd) SUBFRAME ASSEMBL Y ...

  • Century 5130 - page 5

    VI-3 REF . NO. P AR T NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) SUBFRAME ASSEMBL Y 1 6 03001 13 GREASE FITTING 2 2 0301861 QUICK PIN 3 2 0302538 BUSHING , 3-1/2" X 2-1/2" INTERNAL 4 8 0302540 CENTER BONDED MOUNT 5 12 0302541 SPECIAL WASHER 6 2 0303140 RAMP P AD 7 2 0303445 SAFETY CHAIN, SYSTEM 10 8 REF . 0306647 ...

  • Century 5130 - page 6

    VI-4 Section VI - P ARTS (cont'd) ST ANDARD BODY ASSEMBL Y - 5130 ...

  • Century 5130 - page 7

    VI-5 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) ST ANDARD BODY ASSEMBL Y - 5130 1 14 FT . 0300345 RUBBER FENDER 2 2 0301223 MUDFLAP 3 6 0301912 DOOR CHECK, 1 1" 4 7 FT . 0303056 "D" GASKET (NOT SHOWN) 5 1 0303061 BACKUP ALARM (NOT SHOWN) 6 1 03 ...

  • Century 5130 - page 8

    VI-6 Section VI - P ARTS (cont'd) ST ANDARD BODY ASSEMBL Y - 5230 ...

  • Century 5130 - page 9

    VI-7 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) ST ANDARD BODY ASSEMBL Y - 5230 1 28 FT . 0300345 RUBBER FENDER 2 2 0301223 MUDFLAP 3 6 0301912 DOOR CHECK, 1 1" 4 7 FT . 0303056 "D" GASKET (NOT SHOWN) 5 1 0303061 BACKUP ALARM (NOT SHOWN) 6 1 13 ...

  • Century 5130 - page 10

    VI-8 Section VI - P ARTS (cont'd) RECOVER Y BOOM ASSEMBL Y ...

  • Century 5130 - page 11

    VI-9 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) RECOVER Y BOOM ASSEMBL Y 1 4 03001 13 GREASE FITTING 2 2 0300626 SHEA VE, 8" 3 3 0301895 GREASE FITTING , STR 1/8" 4 14 FT . 0301949 SYNFLEX HOSE, 3/8" 5 2 0301959 SNAP RING , 1-1/2" INTERNAL 6 2 0303490 WEAR P AD 7 8 0306585 PIPE PLUG , 4 A ...

  • Century 5130 - page 12

    VI-10 Section VI - P ARTS (cont'd) UNDERLIFT & TOWER ASSEMBL Y ...

  • Century 5130 - page 13

    VI-11 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) UNDERLIFT & TOWER ASSEMBL Y 1 2 03001 10 SNAP RING 1" 2 14 03001 13 GREASE FITTING 3 1 0301 197 COMPRESSION SPRING , CROSS BAR 4 1 0301398 DETENT BALL, 1-3/16" 5 1 0301822 "O" RING , PIV ...

  • Century 5130 - page 14

    VI-12 Section VI - P ARTS (cont'd) UNDERLIFT HYDRAULICS ...

  • Century 5130 - page 15

    VI-13 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) UNDERLIFT HYDRAULICS 1 7 0300044 CONNECTOR, 6MJ-8MB 2 1 0300142 ELBOW , 6MJ-4MP90 3 1 0300206 BRANCH TEE, 6MJ-6MJ-4MP 4 1 0301425 CONNECTOR, 6MJ-6MP 5 4 0301470 ELBOW , 6MJ-8MP90 6 2 0301473 HOSE ASSEMBL Y , 18" 7 3 0301522 CONNECTOR, 6MJ-6MB 8 4 0301601 ...

  • Century 5130 - page 16

    VI-14 Section VI - P ARTS (cont'd) RECOVER Y BOOM HYDRAULICS ...

  • Century 5130 - page 17

    VI-15 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) RECOVER Y BOOM HYDRAULICS 1 2 0300044 CONNECTOR, 6MJ-8MB 2 4 03001 13 GREASE FITTING 3 2 0301207 HOSE ASSEMBL Y , 72" 4 4 0301470 ELBOW , 6MJ-8MB90 5 2 0301522 CONNECTOR, 6MJ-6MB 6 2 0302575 BULKHEAD RUN TEE W/NUT 7 2 0302585 HOSE ASSEMBL Y , 54" 8 2 ...

  • Century 5130 - page 18

    VI-16 Section VI - P ARTS (cont'd) PUMP , V AL VE & FIL TER HYDRAULICS ...

  • Century 5130 - page 19

    VI-17 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) PUMP , V AL VE & FIL TER HYDRAULICS 1 2 0301696 ELBOW , 6MJ-6FJX90 2 2 0301965 HOSE ASSEMBL Y , 131" 3 2 0302205 GAUGE, FLUSH MOUNT 6000 PSI 4 2 0302577 CONNECTOR, 6MJ-4FP 5 2 0303392 HOSE ASSEMBL Y , ...

  • Century 5130 - page 20

    VI-18 Section VI - P ARTS (cont'd) WINCH HYDRAULICS & AIR FREE SPOOL ...

  • Century 5130 - page 21

    VI-19 VI-19 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) WINCH HYDRAULICS & AIR FREE SPOOL 1 4 0300041 CONNECTOR, 8MJ-8MB 2 2 0301388 ELBOW , 8MJ-8MB90 3 40 FT . 0301577 AIR HOSE, 1/4" O.D. 4 2 0301893 HOSE ASSEMBL Y , 84" 5 35 0302434 CABLE TIE, 4" (NOT SHOWN) 6 40 FT . 0302495 CONVOLUTED L ...

  • Century 5130 - page 22

    VI-20 Section VI - P ARTS (cont'd) LEFT CONTROL ASSEMBL Y ...

  • Century 5130 - page 23

    VI-21 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) LEFT CONTROL ASSEMBL Y REMOTE CONTROL ASSEMBL Y -- -- -- REMOTE CONTROL ASSEMBL Y 34 10 / 16 0300166 WIRE CONNECTOR, SP ADE 35 1 0301574 ELBOW , 4TB-4MP90 36 15 / 25 0301577 AIR HOSE, 1/4" O.D. (FT .) 37 2 ...

  • Century 5130 - page 24

    VI-22 Section VI - P ARTS (cont'd) RIGHT CONTROL ASSEMBL Y ...

  • Century 5130 - page 25

    VI-23 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) RIGHT CONTROL ASSEMBL Y 1 2 0300834 CONTROL KNOB, (IN/OUT) 2 1 0300835 CONTROL KNOB, BOOM (UP/DOWN) 3 2 0300836 CONTROL KNOB, JACK (UP/DOWN) 4 1 0300837 CONTROL KNOB, BOOM (IN/OUT) 5 2 0302457 CONTROL CABLE, 104" 6 6 0302726 GREASE FITTING , 1/4"-28 ...

  • Century 5130 - page 26

    VI-24 Section VI - P ARTS (cont'd) REAR SP ADE HYDRAULICS 1 2 0300044 CONNECTOR, 6MJ-8MB 2 4 0300134 HOSE CLAMP , 1" INSULA TED 3 2 0301522 CONNECTOR, 6MJ-6MB 4 2 0301819 NIPPLE, BLACK PIPE, 1/2" X 4-1/2" 5 2 0303017 CONNECTOR, 8MB-6FB 6 REF . 0303093 CONTROL V AL VE, VDP1 1DDDC1 10 7 REF . 0303094 CONTROL V AL VE, VDP1 1CDDDC53 ...

  • Century 5130 - page 27

    VI-25 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) HYDRAULIC CYLINDERS 1 2 0306747 BOOM LIFT CYLINDER (COMPLETE) -- SEAL KIT , BOOM LIFT CYLINDER 2 1 0306743 BOOM EXTEND CYLINDER (COMPLETE) -- SEAL KIT , BOOM EXTEND CYLINDER 3 2 0306745 UNDERLIFT TIL T CYLINDER (COMPLETE) -- SEAL KIT , UNDERLIFT TIL T CYLINDER ...

  • Century 5130 - page 28

    VI-26 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) GLAD HAND KIT 1 1 0301909 RECEPT ACLE BOOT 2 2 0301944 GLAD HAND COUPLING 3 2 0301945 GLAD HAND PLUG 4 2 0301946 BULKHEAD CONNECT OR 5 2 0301947 ADAPTER, 1/4" NPM X 3/8" SYN. HOSE 6 1 0301948 HD 7-W A Y TRAILER CONNECTOR 7 2 0400070 SCREW , 1/4" ...

  • Century 5130 - page 29

    VI-27 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) LIFT ADAPTERS 1 2 0200018 FORK, SHORT (3" OPENING) 2 2 0200019 FORK, SHORT (4-1/2" OPENING) 3 2 0200020 FORK, MEDIUM (3" OPENING) 4 2 0200021 FORK, MEDIUM (4-1/2" OPENING) 5 2 0200022 FORK, LONG (3" OPENING) 6 2 0200023 FORK, LONG (4-1 ...

  • Century 5130 - page 30

    VI-28 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) KING PIN ADAPTER 1 1 0803605 KING PIN ADAPTER WELDMENT -- 0902782 FIFTH WHEEL ADAPTER (COMPLETE) 2 1 0400555 ROLL PIN, 3/8" X 1-1/2" 3 2 HD1259 SNAPPER PIN 4 1 V A0660 FIFTH WHEEL PIVOT PLA TE WELDMENT 5 1 V A0661 PULL PIN WELDMENT 6 1 V A0662 PIVOT ...

  • Century 5130 - page 31

    VI-29 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) MODULAR WIRING KIT 1 50 0300153 CONNECTOR,WIRE (BLUE 7520) 2 12 0300154 CONNECTOR,WIRE (YELL 7530) 3 35 0301503 10 RING CONN. 4 1 0301812 HEA T SHRINK TUBE-IN.MEL T (BLACK) 5 75 0302433 CABLE TIE, 7-50 LB 6 50 0302664 ADHESIVE BACK TIE MOUNT 7 1 0302853 WIRING ...

  • Century 5130 - page 32

    VI-30 REF . NO. P ART NO. REQ'D NUMBER DESCRIPTION Section VI - P ARTS (cont'd) MODULAR LIGHT KIT 1 1 0300076 BRACKET , LICENSE PLA TE 2 10 03001 17 RUBBER GROMMET 3 1 0300273 LICENSE PLA TE ILLUMINA TOR 4 1 0300442 3-LIGHT BAR ASSEMBL Y 5 16 FT . 0300844 CLOSED CELL SPONGE, 3/4" X 1/8" 6 24 0301503 10 RING CONN. 7 1-1/2 0301812 ...

  • Century 5130 - page 33

    NOTES ...

  • Century 5130 - page 34

    CENTURY ® Miller Industries Towing Equipment Inc. 8503 Hilltop Drive • Ooltewah, Tennessee 37363 • (423) 238-4171 www.millerind.com ...

Manufacturer Century Category Automobile Accessories

Documents that we receive from a manufacturer of a Century 5130 can be divided into several groups. They are, among others:
- Century technical drawings
- 5130 manuals
- Century product data sheets
- information booklets
- or energy labels Century 5130
All of them are important, but the most important information from the point of view of use of the device are in the user manual Century 5130.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Century 5130, service manual, brief instructions and user manuals Century 5130. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Century 5130.

Similar manuals

A complete manual for the device Century 5130, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Century 5130 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Century 5130.

A complete Century manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Century 5130 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Century 5130, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Century 5130, that we can find in the current document
3. Tips how to use the basic functions of the device Century 5130 - which should help us in our first steps of using Century 5130
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Century 5130
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Century 5130 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Century 5130?

Use the form below

If you did not solve your problem by using a manual Century 5130, ask a question using the form below. If a user had a similar problem with Century 5130 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (1)

Александр

Добрый день! Помогите решить проблему с отправкой скана по эл. почте. Дело в том что скан документы послеобработки становятся в режим по расисанию в активные задания, сброс на заводские настройки не помогает. После перезагрузки устройства все задания выплняются а новые так же становятся в статус по расписанию