English dropdown-ico

Manual Empire Comfort Systems DV-55T-1

20 pages 0.92 mb
Download

Go to site of 20

Summary
  • Empire Comfort Systems DV-55T-1 - page 1

    Page 1 INST ALLA TION INSTRUCTIONS AND OWNER'S MANUAL F AN TYPE DIRECT VENT W ALL FURNACE MODEL DV -55T -1 Th i s ap p l i an c e ma y b e i n s ta l l ed i n an a f te r m ar k e t, pe rm a ne nt ly lo ca t ed , m an uf ac t ur e d ho me (U SA only) or mobile home, where not pr ohibited by state or local codes. Thi s appl ian ce is only for u ...

  • Empire Comfort Systems DV-55T-1 - page 2

    131 18-7-0408 Page 2 SECTION P AGE Important Safety Information ......................................................................................................................3 V ent Kit Information .................................................................................................................................... 3 Safety In ...

  • Empire Comfort Systems DV-55T-1 - page 3

    131 18-7-0408 Page 3 THIS IS A HEA TING APPLIANCE DO NOT OPERA TE THIS APPLIANCE WITHOUT FRONT P ANEL INST ALLED. • Due to high temperatur es the appliance should be located out of traffic and away from furnitur e and draperies. • Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid bu ...

  • Empire Comfort Systems DV-55T-1 - page 4

    131 18-7-0408 Page 4 Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. Y ou must find out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detect that odor . Sometimes other odors in the are ...

  • Empire Comfort Systems DV-55T-1 - page 5

    131 18-7-0408 Page 5 REQUIREMENTS FOR MASSACHUSETTS For all side wall horizontally vented gas fueled equipment installed in every dwelling, building or structure used in whole or in part for residential purposes, including those owned or operated by the Commonwealth and where the side wall exhaust vent termination is less than seven (7) feet above ...

  • Empire Comfort Systems DV-55T-1 - page 6

    131 18-7-0408 Page 6 Introduction Always consult your local Building Department regarding regulations, codes or ordinances which apply to the installation of a direct vent wall furnace. Instructions to Installer 1. Installer must leave instruction manual with owner after installa - tion. 2. Installer must have owner fill out and mail warranty card ...

  • Empire Comfort Systems DV-55T-1 - page 7

    131 18-7-0408 Page 7 Locating Gas Supply The gas line can enter the unit either through the floor or outside wall. The gas line opening should be made at this time. Location of the opening will be determined by the position of floor joists and the valve and union used for servicing. Note: Never use plastic pipe. Check to confirm whether your loc ...

  • Empire Comfort Systems DV-55T-1 - page 8

    131 18-7-0408 Page 8 Clearances 1. In selecting a location for installation, it is necessary to provide adequate accessibility clearances for servicing and proper installation. 2. The DV4T -59-1, 5" to 9" wall depth is the standard vent kit provided with the DV -55T . See Accessories Page 6 to order vent kits for wall depths of 8" to ...

  • Empire Comfort Systems DV-55T-1 - page 9

    131 18-7-0408 Page 9 Locating W all Opening The furnace is to be located on an outside wall. Locate wall studs so that wall opening will be located between wall studs. The furnace is 16 inches in width and normal 16 inches on center studs will not allow the furnace to be recessed into the wall unless a stud is repositioned. The wall opening require ...

  • Empire Comfort Systems DV-55T-1 - page 10

    131 18-7-0408 Page 10 Using Plastic Expansion Anchors 1. After locating mounting holes, drill two (2) 5/16" diameter holes into the wall. 2. Insert two (2) plastic expansion anchors provided into the holes. 3. T ighten two (2) 10 x 1" screws provided into the plastic expansion anchors. (See Figure 9) Figure 9 Attention! The screw holes on ...

  • Empire Comfort Systems DV-55T-1 - page 11

    131 18-7-0408 Page 1 1 1. Remove old caulking beneath the collar of the outside mounting plate. Apply new caulking beneath the collar of the outside mounting plate. Use additional caulking to correct uneven wall surface, such as clapboard. 2. Insert six inch air tube on outside mounting plate INTO six inch air tube attached to air drop. Position th ...

  • Empire Comfort Systems DV-55T-1 - page 12

    131 18-7-0408 Page 12 1. STOP! Read the safety information above. 2. Set the thermostat to lowest setting. 3. T urn off all electric power to the appliance. 4. Remove control access panel (lower front panel). 5. T urn gas control knob clockwise to "OFF ." 6. W ait ten (10) minutes to clear out any gas. Then smell for gas, including near t ...

  • Empire Comfort Systems DV-55T-1 - page 13

    131 18-7-0408 Page 13 The correct flame will be a short blue inner flame with a much larger light blue outer flame. The main burner (Figure 13) shows the approximate height of each part of the flame for each gas. The burner does not have a primary air adjustment. The flame will be correct if the factory-set pressure and orifice opening are us ...

  • Empire Comfort Systems DV-55T-1 - page 14

    131 18-7-0408 Page 14 Figure 14 The appliance, when installed, must be electrically grounded in ac- cordance with local codes or , in the absence of local codes, with the National Electrical Code, ANSI/NFP A 70 or Canadian Electrical Code, CSA C22.1, if an external electrical source is utilized. This appliance is equipped with a thr ee-prong [groun ...

  • Empire Comfort Systems DV-55T-1 - page 15

    131 18-7-0408 Page 15 Replacing Fan and Oiling the Motor The fan motor sho uld be cleaned and oil ed once each heatin g season. T o reach the motor, withdraw the metal shroud surrounding the fan blade by removing the screws on each side. Oil holes are located on the top at each end of the motor . Use a few drops of #10 motor oil. T o clean the moto ...

  • Empire Comfort Systems DV-55T-1 - page 16

    131 18-7-0408 Page 16 PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide. I n de x P a rt N o . Number Description USE ONL Y MANUF ACTURER'S REPLACEMENT P AR TS. USE OF ANY OTHER P AR TS COULD CAUSE INJURY OR DEA TH. 1 1 17 62 O U T E R C A S I N G T O P 2 R -6 18 M O T O R M O U N T - 4 R ...

  • Empire Comfort Systems DV-55T-1 - page 17

    131 18-7-0408 Page 17 P AR TS VIEW ...

  • Empire Comfort Systems DV-55T-1 - page 18

    131 18-7-0408 Page 18 SER VICE NOTES ...

  • Empire Comfort Systems DV-55T-1 - page 19

    131 18-7-0408 Page 19 SER VICE NOTES ...

  • Empire Comfort Systems DV-55T-1 - page 20

    131 18-7-0408 Page 20 EMPIRE EMPIRE Comfo r t Systems Empire Comfort Systems Inc. 918 Freeburg A ve. Belleville, IL 62220 If you have a general question about our products, please e-mail us at info@empirecomfort.com. If you have a service or repair question, please contact your dealer . www .empirecomfort.com ...

Manufacturer Empire Comfort Systems Category Furnace

Documents that we receive from a manufacturer of a Empire Comfort Systems DV-55T-1 can be divided into several groups. They are, among others:
- Empire Comfort Systems technical drawings
- DV-55T-1 manuals
- Empire Comfort Systems product data sheets
- information booklets
- or energy labels Empire Comfort Systems DV-55T-1
All of them are important, but the most important information from the point of view of use of the device are in the user manual Empire Comfort Systems DV-55T-1.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Empire Comfort Systems DV-55T-1, service manual, brief instructions and user manuals Empire Comfort Systems DV-55T-1. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Empire Comfort Systems DV-55T-1.

Similar manuals

A complete manual for the device Empire Comfort Systems DV-55T-1, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Empire Comfort Systems DV-55T-1 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Empire Comfort Systems DV-55T-1.

A complete Empire Comfort Systems manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Empire Comfort Systems DV-55T-1 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Empire Comfort Systems DV-55T-1, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Empire Comfort Systems DV-55T-1, that we can find in the current document
3. Tips how to use the basic functions of the device Empire Comfort Systems DV-55T-1 - which should help us in our first steps of using Empire Comfort Systems DV-55T-1
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Empire Comfort Systems DV-55T-1
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Empire Comfort Systems DV-55T-1 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Empire Comfort Systems DV-55T-1?

Use the form below

If you did not solve your problem by using a manual Empire Comfort Systems DV-55T-1, ask a question using the form below. If a user had a similar problem with Empire Comfort Systems DV-55T-1 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)