English dropdown-ico

Manual Vulcan-Hart 1GR85MF ML-136787

24 pages 1.17 mb
Download

Go to site of 24

Summary
  • Vulcan-Hart 1GR85MF ML-136787 - page 1

    INSTALLATION & OPERATIONAL MANUAL GRM SERIES GAS FRYERS MODELS: 1GR35M ML-136407 1GR45M ML-136408 1GR65M ML-136409 1GR85M ML-136410 1GR45MF ML-136785 1GR65MF ML-136786 1GR85MF ML-136787 2GR45MF ML-136417 2GR65MF ML-136418 2GR85MF ML-136419 3GR45MF ML-136420 3GR65MF ML-136421 3GR85MF ML-136422 4GR45MF ML-136423 1GR45M Shown For additional inform ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 2

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -2- IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GAS EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. POST IN A PROMINENT LOCATION THE INSTRUCTIONS TO BE FOLLOWED IN THE EVE ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 3

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -3- TABLE OF CONTENTS IMPORTANT FOR YOUR SAFETY……………………………… ………. 2 INTRODUCTION…………………… …………………………………… … 4 GENERAL…………………………… ……………………………… 4 ORDERING PARTS……? ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 4

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -4- INTRODUCTION GENERAL Vulcan Fryers are produced wit h quality workmanship and mate rial. Proper installation, usage and maintenance will result in year s of satisfactory performance. Before installing the fryer, thoroughly read th is manual and carefully fo llow all instruction. ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 5

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -5- Check that the followi ng have been included:  Crumb Rack  Basket Hanger  Twin Fry Baskets (2)  Tank Brush  Adjustable Casters (4) two locking, two non- locking for freestanding fryers. Fryer Batteries with the KleenScreen PLUS® Filtration System have casters inst ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 6

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -6-  Minimum clearance from noncombustible construction: 0” from the sides of the fryer 0” from the back of the fryer  Between the fryer and any open-top flame units: 16” (41 cm)  Allow space for servicing and operation. Location  Install fryer in an area with suffi ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 7

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -7- ASSEMBLY The fryer must be restrained to prevent tipping and the splashing of ho t liquid. The means of restraint may be the manner of installa tion, such as connection to a battery of appliances, installing the fryer in an alcove, or by separate m eans such as adequate ties. FLU ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 8

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -8- Prior to lighting, check all joints in the g as supply line for lea ks. Use soap and water solution. Do not use an open flame. After piping has been checked for leaks, fully purge gas pipes to remove air. GAS PRESSURES (ALL MODELS): The gas pressure should be set at 4” W.C. (W ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 9

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -9-  The fryer must be installed with a connec tor (not supplied by Vulcan) complying with the above codes.  The fryer must be installed with restrain ing means to guard against transmission of strain to the connector. See illustration.  The fryer must be installed with the ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 10

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -10- BEFORE FIRST USE Cleaning New units are wiped down at the fa ctory to remove an y visible signs of dirt, oil, grease, etc. remaining from th e manufacturing process. Before any food preparation, thoroughly wash the protective oil from all surface parts and the tank interior with ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 11

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -11- LIGHTING THE PILOT A B A Thermostat Knob B G a s C o n t r o l H a n d l e 1. Open the door. 2. Turn the thermostat to OFF (see figure below, view A). The thermostat is located behind the door. 3. Push the gas control valve knob and turn to OFF. Wait 5 minutes for unburned gas t ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 12

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -12- TURNING ON THE FRYER  Set the temperature knob to desired temperature.  After the set temperature has been reached, the thermostat shuts off the gas flow to burners.  The pilot remains lit. The burners wil l cycle on and off, maintaining the set temperature. TURNING OFF ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 13

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -13-  When frying doughnuts and fritters, turn product only once during frying.  When cooking French fries or onion rings, shake the basket several times.  Batter-covered foods should be dropped carefully, one by one, into shortening or basket. If you use the basket, first d ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 14

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -14- 5. Slowly open the drain valve to allow oil to fl ow from the fry tank to the filter pan. Then open the drain valve all the way. 6. When fry tank is empty use the tank brush to remove any additional debris. 7. Close the drain valve. 8. Fill tank with new shortening. Fill to a mi ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 15

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -15-  Use a damp cloth with warm water and a mild soap or detergent. Do not use chlorine or sulfate/sulfide cleaners.  Rinse thoroughly, and then po lish with a soft dry cloth.  Keep the fryer exterior clean and free of accumulated grease to prevent stubborn stains from form ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 16

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -16- KleenScreen PLUS ® Filtration System Installation and Operational Manual For GRMF Models 2GR45MF Shown GAS KleenScreen PLUS® Models: 1GR45MF ML-136785 1GR65MF ML-136786 1GR85MF ML-136787 2GR45MF ML-136417 2GR65MF ML-136418 2GR85MF ML-136419 3GR45MF ML-136420 3GR65MF ML-136421 ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 17

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -17- Filtering Instructions for KleenScreen PLUS ® Fryers General The KleenScreen PLUS® filtration system filters the oil as it is pumped back into its’ respective tank(s). Only one tank can be dr ained and filtered at a time. Unde r no circumstances should both tanks be drained ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 18

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -18- Fully assembled filter screen assembly: F i g . 2 Secure Tube with Suction Tube Clip Filter Screen Lays Flat On Bottom of Filter Pan Fig. 3 Micro-Filtration Fabric Envelope Assembly: Same Suction Tube F a b r i c E n v e l o p e I n s e r t (Different from Screen Assembly) Fabri ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 19

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -19- INSTRUCTIONS TO REMOVE & REPLACE KLEENSCREEN PLUS ® FILTER ENVELOPE FOR ABSOLUTE FILTRATION & MAXIMUM FLOW RA TE WE RECOMME ND YOU CHANGE YOUR FILTER ENVELOPES AT EVERY OIL CHANGE (10-14 DAYS DEPENDING ON OIL USAGE). Step 1 Discard all oil from the filter vessel, (see p ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 20

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -20- Operation Hot oil and parts can cause burns. Use care when operating, cleaning and servicing the fryer. Spilling hot frying compound can cause severe burns. Do not move fryer without draining all frying compound from the tank. Never run water or boil out solution thr ough filter ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 21

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -21- 4. Drain the oil out of t he fry tank by turning t he red handle drain valve. The filter pan will begin to fill with oil. When the oil level fills half of the filter pan, pull the red handled filter lever towards you. The motor / pump will begin and oil will flow back into the f ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 22

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -22- FLUSH AND DISCARD: 1. Follow filtering instructions 1- 3, however do not put oil treatment media into the fryer. Drain the fryer oil into the filter pan. 2. Attach the quick disconnect hose to the discard male quick di sconnect fitting. 3. Place other end of the discard hose int ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 23

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -23- THERMAL OVERLOAD PROTECTION BUTTON: The motor/pump supplied wi th the filtering system has a thermal overload protec tion circuit that senses when excess heat occurs due to filtering for long periods of time or under heavy load prior to discarding debris buildup. If the thermal ...

  • Vulcan-Hart 1GR85MF ML-136787 - page 24

    GRM SERIES GAS FRYERS VULCAN-HART F-312 33 Rev. K (February 2011) -24- Troubleshooting Chart: Problem: Probable Cause: No Heat: Thermostat dial not turned on. P i l o t n o t l i t . Gas supply not turned on. Wire connections loose (call service) Wires connections need cleaning (call service) T h e r m o p i l e ( c a l l s e r v i c e ) Insufficie ...

Manufacturer Vulcan-Hart Category Fryer

Documents that we receive from a manufacturer of a Vulcan-Hart 1GR85MF ML-136787 can be divided into several groups. They are, among others:
- Vulcan-Hart technical drawings
- 1GR85MF ML-136787 manuals
- Vulcan-Hart product data sheets
- information booklets
- or energy labels Vulcan-Hart 1GR85MF ML-136787
All of them are important, but the most important information from the point of view of use of the device are in the user manual Vulcan-Hart 1GR85MF ML-136787.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Vulcan-Hart 1GR85MF ML-136787, service manual, brief instructions and user manuals Vulcan-Hart 1GR85MF ML-136787. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Vulcan-Hart 1GR85MF ML-136787.

Similar manuals

A complete manual for the device Vulcan-Hart 1GR85MF ML-136787, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Vulcan-Hart 1GR85MF ML-136787 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Vulcan-Hart 1GR85MF ML-136787.

A complete Vulcan-Hart manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Vulcan-Hart 1GR85MF ML-136787 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Vulcan-Hart 1GR85MF ML-136787, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Vulcan-Hart 1GR85MF ML-136787, that we can find in the current document
3. Tips how to use the basic functions of the device Vulcan-Hart 1GR85MF ML-136787 - which should help us in our first steps of using Vulcan-Hart 1GR85MF ML-136787
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Vulcan-Hart 1GR85MF ML-136787
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Vulcan-Hart 1GR85MF ML-136787 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Vulcan-Hart 1GR85MF ML-136787?

Use the form below

If you did not solve your problem by using a manual Vulcan-Hart 1GR85MF ML-136787, ask a question using the form below. If a user had a similar problem with Vulcan-Hart 1GR85MF ML-136787 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)