English dropdown-ico

Manual Empire Comfort Systems VFDR30LB

24 pages 2.31 mb
Download

Go to site of 24

Summary
  • Empire Comfort Systems VFDR30LB - page 1

    Page 1 21565-3-0906 INST ALLA TION INSTRUCTIONS AND OWNER'S MANUAL UNVENTED GAS LOG HEA TER OR VENTED DECORA TIVE APPLIANCE MODELS VFDR18LB(N,P)-1 VFDR24LB(N,P)-1 VFDR30LB(N,P)-1 EFFECTIVE DA TE SEPTEMBER 2006 V ented/V ent-Fr ee Burner and Logs This is an unvented gas-fired heater . It uses air (oxygen) fr om the r oom in which it is install ...

  • Empire Comfort Systems VFDR30LB - page 2

    Page 2 21565-3-0906 SECTION P AGE IMPOR T ANT SAFETY INFORMA TION ........................................................................................ 3 SAFETY INFORMA TION FOR USERS OF LP-GAS ..................................................................... 4 INTRODUCTION .................................................................... ...

  • Empire Comfort Systems VFDR30LB - page 3

    Page 3 21565-3-0906 W ARNING When used without adequate combustion and ventilation air , heater may give off CARBON MONOXIDE, an odorless, poisonous gas. Do not install heater until all necessary provisions are made for combustion and ventilation air . Consult the written instructions provided with the heater for information concerning combustion a ...

  • Empire Comfort Systems VFDR30LB - page 4

    Page 4 21565-3-0906 Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. Y ou must find out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detect that odor . Sometimes other odors in the area ...

  • Empire Comfort Systems VFDR30LB - page 5

    Page 5 21565-3-0906 Notice: During initial firing of this unit, its paint will bake out, and smoke will occur . T o prevent triggering of smoke alarms, ventilate the room in which the unit is installed. W ARNING: This appliance is for installation only in a solid- fuel burning masonry or UL 127 factory-built fireplace or in a list ed vent less ? ...

  • Empire Comfort Systems VFDR30LB - page 6

    Page 6 21565-3-0906 This is an unvented gas-fired heater . It uses air (oxygen) from the room in which it is installed. Provisions for adequate combustion and ventilation air must be provided. Keep room area clear and free from combus tib le materi als, gaso line and other flammable vapors and liquids. Unvented gas heaters are a supplemental zone ...

  • Empire Comfort Systems VFDR30LB - page 7

    Page 7 21565-3-0906 ventilation air by one of the methods described in the National Fuel Gas Code, ANSI Z223.1, Section 5.3. or applicable local codes. Example of Large Room with 1/2 W all divider . Figure 1 The following formula can be used to determine the maximum heater rating per the definition of unconfined space: Btu/Hr = (L 1 + L 2 )FT x ( ...

  • Empire Comfort Systems VFDR30LB - page 8

    Page 8 21565-3-0906 Mantel Clearances with Hood (Figur e 5) Y ou must have non-combustible materials above the fireplace opening. Non-combustible material must extend at least 8" above fir epl ac e ope ni ng. W ith she et met al , you must ha ve non -c om bu st ibl e material behind it. Heat resistant materials such as slate and marble must ...

  • Empire Comfort Systems VFDR30LB - page 9

    Page 9 21565-3-0906 FOR MASONR Y BUIL T FIREPLACES FREE OPEN ING A REA OF CHI MNEY DAMPER FOR VENTING COMBUSTION PRODUCTS FROM DECORA- TIVE APPLIANCES FOR INST ALLA TION IN SOLID FUEL BURNING FIREPLACES * Height is from hearth to top of chimney and the minimum height is 6 feet. ** Chart shows minimum opening (sq. in.) for given height and input rat ...

  • Empire Comfort Systems VFDR30LB - page 10

    Page 10 21565-3-0906 Notice (Damper Clamp Installation) When installing your log set as a vented installation the damper clamp must be used. When installing your log set as a vent-free installation the damper clam p can be used to elimi nate the potenti al for odors when burnin g the logs for the first time. Installing Damper Clamp (Figur e 9) Rem ...

  • Empire Comfort Systems VFDR30LB - page 11

    Page 1 1 21565-3-0906 Check all local codes for requirements, especially for the size and type of gas supply line required. Note: Never use plastic pipe. Check to confirm whether your local codes allow copper tubing or galvanized. Note: Since some municipalities have additional local codes, it is always best to consult your local authority and ins ...

  • Empire Comfort Systems VFDR30LB - page 12

    Page 12 21565-3-0906 Before you begin: if you are installing logs onto the VFDR18 or VFDR24 models, this burner assemb ly is supplied with a set of five ceramic fiber logs. Do not handle these logs with your bare hands! Always wear gloves to prevent skin irritation from ceramic fibers. After handling logs, wash your hands gently with soap and wa ...

  • Empire Comfort Systems VFDR30LB - page 13

    Page 13 21565-3-0906 Before you begin: If you are installing logs onto the VFDR30 model, this burner assembly place is supplied with a set of seven ceramic fiber logs. Do not handle these logs with your bare hands. Always wear gloves to prevent skin irritation from ceramic fibers. After handling logs, wash your hands gently with soap and water to ...

  • Empire Comfort Systems VFDR30LB - page 14

    Page 14 21565-3-0906 Flames from the pilot (rear right back side of the pan burner) as well as the main flame should be visually checked as the log set is installed. In norma l operati on at full rate, the flame appeara nce should be sets of yellow flames above the rear burner section, and shorter blue flames with glowing embers on the front bu ...

  • Empire Comfort Systems VFDR30LB - page 15

    Page 15 21565-3-0906 Th e rm o st a t s a re no t ap p ro v ed on v en t ed de c or a t iv e a p pl i a nc e s. Label all wires prior to disconnection when servicing controls. W iring errors can cause improper and dangerous operation. V erify proper operation after servicing. 18", 24" and 30" Gas Logs (Millivolt) thermopile is self p ...

  • Empire Comfort Systems VFDR30LB - page 16

    Page 16 21565-3-0906 W ARNING: If you do not follow these instructions exactly , a fire or explosion may r esult causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these instructions exactly . B. BEFORE LIGHTING, smell all arou nd the applianc e are ...

  • Empire Comfort Systems VFDR30LB - page 17

    Page 17 21565-3-0906 Figure 18 shows a correct pilot flame pattern. The correct flame will be blue and will extend beyond the thermocouple. The flame will surround the thermocouple just below the tip. A slight yellow flame may occur where the pilot flame and main burner flame meet. Figure 19 shows an incorrect pilot flame pattern. The incorr ...

  • Empire Comfort Systems VFDR30LB - page 18

    Page 18 21565-3-0906 Annual inspection and cleaning by your dealer or qualified service technician is recommended to prevent malfunction and/or sooting. TURN OFF HEA TER AND ALLOW TO COOL BEFORE CLEANING. Remove logs, handling carefully by holding gently at each end. Gloves are recommended to prevent skin irritation from ceramic fibers. If skin b ...

  • Empire Comfort Systems VFDR30LB - page 19

    Page 19 21565-3-0906 If the gas quality is bad, your pilot may not stay lit, the burners may pr oduce soot and the heater may backfire when lit. If the gas quality or pressur e is low , contact your local gas supplier immediately . 1. When ignitor button is pressed, there is no spark at ODS/ pilot. a. Ignitor electrode positioned wrong - Replace p ...

  • Empire Comfort Systems VFDR30LB - page 20

    Page 20 21565-3-0906 Attention: When ordering parts, it is very important that part number and description of part coincide. USE ONL Y MANUF ACTURER'S REPLACEMENT P AR TS. USE OF ANY OTHER P AR TS COULD CAUSE INJUR Y OR DEA TH. P AR TS LIST INDEX NO. P AR T NUMBERS DESCRIPTION VFDR18LB VFDR24LB VFDR30LB 1 21588 21588 21588 PILOT SHIELD (NA T O ...

  • Empire Comfort Systems VFDR30LB - page 21

    Page 21 21565-3-0906 P AR TS VIEW Parts can be ordered only through your service person or dealer . For best results, the service person or dealer should order parts through the distributor . Parts can be shipped directly to the service person/dealer . All parts listed in the Parts List have a Part Number . When ordering parts, first obtain the Mo ...

  • Empire Comfort Systems VFDR30LB - page 22

    Page 22 21565-3-0906 SER VICE NOTES ...

  • Empire Comfort Systems VFDR30LB - page 23

    Page 23 21565-3-0906 SER VICE NOTES ...

  • Empire Comfort Systems VFDR30LB - page 24

    Page 24 21565-3-0906 Empire Comfort Systems, Inc. 918 Freeburg A ve. Belleville, IL 62220 PH: 618-233-7420 or 800-851-3153 F AX: 618-233-7097 or 800-443-8648 info@empirecomfort.com www .empirecomfort.com ...

Manufacturer Empire Comfort Systems Category Gas Heater

Documents that we receive from a manufacturer of a Empire Comfort Systems VFDR30LB can be divided into several groups. They are, among others:
- Empire Comfort Systems technical drawings
- VFDR30LB manuals
- Empire Comfort Systems product data sheets
- information booklets
- or energy labels Empire Comfort Systems VFDR30LB
All of them are important, but the most important information from the point of view of use of the device are in the user manual Empire Comfort Systems VFDR30LB.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Empire Comfort Systems VFDR30LB, service manual, brief instructions and user manuals Empire Comfort Systems VFDR30LB. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Empire Comfort Systems VFDR30LB.

Similar manuals

A complete manual for the device Empire Comfort Systems VFDR30LB, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Empire Comfort Systems VFDR30LB by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Empire Comfort Systems VFDR30LB.

A complete Empire Comfort Systems manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Empire Comfort Systems VFDR30LB - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Empire Comfort Systems VFDR30LB, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Empire Comfort Systems VFDR30LB, that we can find in the current document
3. Tips how to use the basic functions of the device Empire Comfort Systems VFDR30LB - which should help us in our first steps of using Empire Comfort Systems VFDR30LB
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Empire Comfort Systems VFDR30LB
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Empire Comfort Systems VFDR30LB in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Empire Comfort Systems VFDR30LB?

Use the form below

If you did not solve your problem by using a manual Empire Comfort Systems VFDR30LB, ask a question using the form below. If a user had a similar problem with Empire Comfort Systems VFDR30LB it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)