English dropdown-ico

Manual Briggs & Stratton BARON XL

32 pages 3.94 mb
Download

Go to site of 32

Summary
  • Briggs & Stratton BARON XL - page 1

    OPERA T OR’S MANU AL 21HP Hydro Tractors Mfg. No. Description 2690762 Simplicity Baron XL, 21HP w/ 40” Mower (CE) 2690763 Snapper RD21V40, 21HP w/ 40” Mower (CE) 2690772 Massey Ferguson 2421 XL, 20HP w/ 40” Mower (CE) 2690773 Simplicity Baron XL, 21HP 4WD w/40” Mower (CE) 2690774 Snapper RD21V40, 21HP 4WD w/40” Mower (CE) Baron XL / 240 ...

  • Briggs & Stratton BARON XL - page 2

    Not for Reproduction ...

  • Briggs & Stratton BARON XL - page 3

    Regular Maint enance ........................................20 Maintenance Schedule ..........................................20 Check Tire Pressures ............................................20 Safety Interlock System Check ..............................21 Blade Brake Check................................................21 Battery Maintenance . ...

  • Briggs & Stratton BARON XL - page 4

    Opera ting Saf ety Congratulations on purchasing a superior-quality piece of lawn and garden equipment. Our products are designed and manufactured to meet or exceed all industry standards for safety. Power equipment is only as safe as the operator. If it is misused, or not properly maintained, it can be dangerous! Remember, you are responsible for ...

  • Briggs & Stratton BARON XL - page 5

    Slope Opera tion You could be seriously injured or even killed if you use this unit on too steep an incline. Using the unit on a slope that is too steep or where you don’t have adequate traction can cause you to lose control or roll over. A good rule of thumb is to not operate on any slope you cannot back up (in 2-wheel drive mode). You should no ...

  • Briggs & Stratton BARON XL - page 6

    GENERAL OPERA TION 1. Read, understand, and follow all instructions in the manual and on the unit before starting. 2. Do not put hands or feet near rotating parts or under the machine. Keep clear of the discharge opening at all times. 3. Only allow responsible adults, who are familiar with the instructions, to operate the unit (local regulations ca ...

  • Briggs & Stratton BARON XL - page 7

    CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the unit and the mowing activity. Never assume that children will remain where you last saw them. 1. Keep children out of the mowing area and under the watchful care of another responsible adult. 2. Be alert and turn unit of ...

  • Briggs & Stratton BARON XL - page 8

    SER VICE AND MAINTENANCE Safe Handling of Gasoline 1. Extinguish all cigarettes, cigars, pipes, and other sources of ignition. 2. Use only approved gasoline containers. 3. Never remove the gas cap or add fuel with the engine running. Allow the engine to cool before refueling. 4. Never fuel the machine indoors. 5. Never store the machine or fuel con ...

  • Briggs & Stratton BARON XL - page 9

    Tractor ID Tag Identifica tion Numbers When contacting your authorized dealer for replacement parts, service, or information you MUST have these numbers. Record your model name/number, manufacturer’s identification numbers, and engine serial numbers in the space provided for easy access. These numbers can be found in the locations shown. NOTE: Fo ...

  • Briggs & Stratton BARON XL - page 10

    Saf ety Decals This unit has been designed and manufactured to provide you with the safety and reliability you would expect from an industry leader in outdoor power equipment manufacturing. Although reading this manual and the safety instructions it contains will provide you with the necessary basic knowledge to operate this equipment safely and ef ...

  • Briggs & Stratton BARON XL - page 11

    Warning: Read Operator’s Manual. Read and understand the Operator’s Manual before using this machine. Danger: Thrown Objects. This machine is capable of throwing objects and debris. Keep bystanders away. Warning: Remove Key Before Servicing. Remove the key and consult technical literature before performing repairs or maintenance. Danger: Machin ...

  • Briggs & Stratton BARON XL - page 12

    12 F ea tures & Contr ols Throttle/Chok e Control (Single Lever Models) The throttle/choke lever controls engine speed and choke. Move the throttle forward to increase engine speed and back to decrease engine speed. Always operate at FULL throttle. Move the control fully forward (past the detent) to close the choke. Close the choke for cold sta ...

  • Briggs & Stratton BARON XL - page 13

    Headlight s The light switch turns the tractor headlights on and off. Brak e P edal Depressing the brake pedal applies the tractor brake. Hour Met er (Optional) The hour meter measures the number of hours the key has been in the RUN position (A). The hour meter will flash an initial oil change indicator at 5 hours, and a lubrication reminder every ...

  • Briggs & Stratton BARON XL - page 14

    Seat A djustment L e ver The seat can be adjusted forward and back. Move the lever, position the seat as desired, and release the lever to lock the seat into position. T ransmis sion Release V alv e Le ver The transmission release valve lever deactivates the transmission so that the tractor can be pushed by hand. See PUSHING THE TRACTOR BY HAND for ...

  • Briggs & Stratton BARON XL - page 15

    G eneral Oper ating S afety Be sure to read all information in the Safety and Operation sections before attempting to operate this unit. Become familiar with all of the controls and how to stop the unit. Adding F uel To add fuel: 1. Remove the fuel cap (A, Figure 2.1). 2. Fill the tank. Do not overfill. Leave room in the tank for fuel expansion. Re ...

  • Briggs & Stratton BARON XL - page 16

    16 Opera ting the T ractor If an operator chooses to mow in reverse, the RMO system can be used. To use the Reverse Mowing Option (RMO) turn the RMO key after the PTO is engaged. The L.E.D. light will illuminate, and the operator can then mow in reverse. Each time the PTO is disengaged the RMO needs to be reactivated if desired. The key should be r ...

  • Briggs & Stratton BARON XL - page 17

    17 Opera ting the T ractor Figure 3. Engaging the Parking Brake A. Ground Speed Pedals B. Brake Pedal C. Parking Brake Knob Figure 4. Emptying the Hopper A. Catcher Dump Pedal B. Catcher Lever P arking Brake F unction Applying the Parking Brake - See Figure 3. To lock the parking brake, release the ground speed pedals (A), fully depress the brake p ...

  • Briggs & Stratton BARON XL - page 18

    Ca tcher R emov al AND Installa tion 1. Move the catcher removal knob (C, Figure 6) forward to unlock the catcher from the rear support arms. 2. Depress the catcher dump lock pedal (A). 3. Use the catcher lever (B) to open the catcher slightly. 4. Lift the catcher off the rear support arms. 5. Install in reverse order of removal. To assist installi ...

  • Briggs & Stratton BARON XL - page 19

    12 V olt P ower Outle t (certain models) The 12-volt accessory plug is located in the left side pod (Figure 1). It can be used to power small electronic devices. The accessory must be rated at 14 amps or less. NOTE: Operating a 12-volt accessory, especially with the engine at idle, may cause battery discharge. When not using the accessory plug it m ...

  • Briggs & Stratton BARON XL - page 20

    Maintenance Schedule The following schedule should be followed for normal care of your tractor and mower. Check Tire Pr essur es Tire Pressure should be checked periodically, and maintained at the levels shown in the chart (Figure 7). Note that these pressures may differ slightly from the “Max Inflation” stamped on the side-wall of the tires. T ...

  • Briggs & Stratton BARON XL - page 21

    Ba ttery Maintenance Cleaning the Batt ery and Cables 1. Disconnect the cables from the battery, negative cable first (A, Figure 8). 2. Remove the battery hold-down (C) and battery. 3. Clean the battery compartment with a solution of baking soda and water. 4. Clean the battery terminals and cable ends with a wire brush and battery terminal cleaner ...

  • Briggs & Stratton BARON XL - page 22

    T roubleshooting While normal care and regular maintenance will extend the life of your equipment, prolonged or constant use may eventually require that service be performed to allow it to continue operating properly. The troubleshooting guide below lists the most common problems, their causes, and remedies. See the information on the following pag ...

  • Briggs & Stratton BARON XL - page 23

    T roubleshooting the T ractor (Continued) PROBLEM LOOK FOR REMED Y Brake will not hold. Internal brake worn. See authorized dealer. Tractor steers hard or handles poorly. Steering linkage is loose. See authorized dealer. Improper tire inflation. See Check Tire Pressure section. Front wheel spindle bearings dry. See authorized dealer. Engine exhaust ...

  • Briggs & Stratton BARON XL - page 24

    Sea t Adjustment Pitch Adjustment The pitch of the seat can be adjusted to one of three positions. See your dealer for assistance. Seat Slide A djustment The seat can also be adjusted forward and back. Move the lever (A, Figure 9), position the seat as desired, and release the lever to lock the seat into position. Seat Spring A djustment The seat s ...

  • Briggs & Stratton BARON XL - page 25

    Ba ttery Charging A dead battery or one too weak to start the engine may be the result of a defect in the charging system or other electrical component. If there is any doubt about the cause of the problem, see your dealer. If you need to replace the battery, follow the steps under Cleaning the Battery & Cables in the Regular Maintenance Sectio ...

  • Briggs & Stratton BARON XL - page 26

    26 1737660 Rev B BRIGGS & STRA TTON POWER PRODUCTS GROUP , L.L.C. OWNER W ARRANTY POLICY LIMITED W ARRANTY Briggs & Stratton Power Products Group, LLC will repair and/or replace, free of charge, any part(s) of the equipment that is defective in material or workmanship or both. Briggs & Stratton Corporation will repair and/or replace, fr ...

  • Briggs & Stratton BARON XL - page 27

    27 Specifica tions ENGINE 21 HP* Briggs & S tratton Make Briggs & Stratton Model Twin Vanguard (385777) Horsepower 21 Displacement 38.2 cu in. (627 cc) Electrical System Alternator: 12 volt, 16 amp Battery: 230 CCA Oil Capacity 48 oz (1,4 L) CHAS SIS Fuel Tank Cap Capacity: 2.5 Gallons (9.5 L) Rear Wheels Tire Size: 20 x 10.00-8 (2WD) Tire ...

  • Briggs & Stratton BARON XL - page 28

    Replacement P ar t s Replacement parts are available from your authorized dealer. Always use genuine Simplicity Service Parts. Engine Oil Touch-Up Paint Grease Gun Kit 8 oz. Grease Tube Tire Sealant Degrimer/Degreaser Gas Stabilizer Maintenance It ems Many convenient and helpful service and maintenance items are available from you authorized dealer ...

  • Briggs & Stratton BARON XL - page 29

    Not for Reproduction ...

  • Briggs & Stratton BARON XL - page 30

    Not for Reproduction ...

  • Briggs & Stratton BARON XL - page 31

    Not for Reproduction ...

  • Briggs & Stratton BARON XL - page 32

    www.MasseyLawn.com www.snapper.com Briggs & Stratton Power Products Group, L.L.C. Copyright © 2010 Briggs & Stratton Corporation Milwaukee, WI USA. All Rights Reserved www.BRIGGSandSTRATTON.com www.SimplicityMfg.com Not for Reproduction ...

Manufacturer Briggs & Stratton Category Lawn Mower

Documents that we receive from a manufacturer of a Briggs & Stratton BARON XL can be divided into several groups. They are, among others:
- Briggs & Stratton technical drawings
- BARON XL manuals
- Briggs & Stratton product data sheets
- information booklets
- or energy labels Briggs & Stratton BARON XL
All of them are important, but the most important information from the point of view of use of the device are in the user manual Briggs & Stratton BARON XL.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Briggs & Stratton BARON XL, service manual, brief instructions and user manuals Briggs & Stratton BARON XL. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Briggs & Stratton BARON XL.

Similar manuals

A complete manual for the device Briggs & Stratton BARON XL, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Briggs & Stratton BARON XL by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Briggs & Stratton BARON XL.

A complete Briggs & Stratton manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Briggs & Stratton BARON XL - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Briggs & Stratton BARON XL, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Briggs & Stratton BARON XL, that we can find in the current document
3. Tips how to use the basic functions of the device Briggs & Stratton BARON XL - which should help us in our first steps of using Briggs & Stratton BARON XL
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Briggs & Stratton BARON XL
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Briggs & Stratton BARON XL in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Briggs & Stratton BARON XL?

Use the form below

If you did not solve your problem by using a manual Briggs & Stratton BARON XL, ask a question using the form below. If a user had a similar problem with Briggs & Stratton BARON XL it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)