-
Stow PSH - page 1
POR TO-SCREED MODEL PSH © COPYRIGHT 2004, MUL TIQUIP INC . OPERA TION AND P AR TS MANUAL Re vision #1 (03/17/04) MODEL # SERIAL # P/N 36505 ST O W CONSTRUCTION EQ UIPMENT A DIVISION OF MUL TIQUIP HANO VER MILL FITZRO Y STREET ASHTON-UNDER-L YNE LANCASHIRE, OL7 OTL UNITED KINGDOM PH. 0161-339-2223 F AX. 0161-339-3226 E-MAIL: stow@stowmfg.com www .s ...
-
Stow PSH - page 2
...
-
Stow PSH - page 3
FOR HELP AND TECHNICAL ASSIST FOR HELP AND TECHNICAL ASSIST FOR HELP AND TECHNICAL ASSIST FOR HELP AND TECHNICAL ASSIST FOR HELP AND TECHNICAL ASSIST ANCE ANCE ANCE ANCE ANCE (UNITED KINGDOM AND EUROPE) PLEASE HA VE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING P P P P P AR AR AR AR AR TS/SER TS/SER TS/SER TS/SER TS/SER VICE/ W VICE/ W VICE/ W V ...
-
Stow PSH - page 4
P A GE 4 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) POR T O-SCREED PSH— T ABLE OF CONTENTS Help and T echnical Assistance .................................. 3 T able of Contents/Introduction .................................. 4 P ar ts Order ing Procedures U .K. & Europe ................ 5 P ar ts Ord ...
-
Stow PSH - page 5
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 5 PORT O-SCREED PSH— SPECIFICA TIONS (PSH) NOTE: 1 . Sound pressure is a weighted measure. It is measured at the operator's ear position while the walk-behind PSH is operating at full throttle on concrete in a manner most often experienced in “ normal ” ci ...
-
Stow PSH - page 6
P A GE 6 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) PORT O-SCREED PSH— SPECIFICA TIONS (ENGINE) s n o i t a c i f i c e p S e n i g n E . 2 e l b a T e n i g n E l e d o M 2 X Q 1 K 0 2 1 X G A D N O H e p y T r e d n i l y C e l g n i S , e v l a v d a e h r e v O , e k o r t s - 4 e k o r t S X e r o B ...
-
Stow PSH - page 7
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 7 POR T O-SCREED PSH— SAFETY MESSA GE ALER T SYMBOLS Safety precautions should be followed at all times when operating this equipment. F ailure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others. FOR ...
-
Stow PSH - page 8
P A GE 8 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) Respiratory Hazard AL W A YS wear approv ed respirator y protection. AL W A YS wear approv ed eye and hearing protection. Sight and Hearing hazard Equipment Damage Messages Other important messages are provided throughout this manual to help pre vent damag ...
-
Stow PSH - page 9
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 9 F ailure to follo w instructions in this manual ma y lead to ser ious injury or e ven death! This equipment is to be operated by tr ained and qualified personnel only! This equipment is f or industrial use only . ■ AL W A Y S use e xtreme caution when working wit ...
-
Stow PSH - page 10
P A GE 10 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) ■ NEVER Run engine without air filter . Sev ere engine damage ma y occur . Ser vice air filter frequently to pre vent carburetor malfunction. ■ A V OID wearing jewelry or loose fitting clothing that may snag on the controls or moving parts as this can ...
-
Stow PSH - page 11
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 11 POR T O-SCREED PSH— OPERA TION AND SAFETY DECALS OPERA TION AND SAFETY DECALS The POR T O-SCREED w alk-behind PSH is equipped with a number of operation and saf ety decals . These decals are provided f or operator safety and maintenance information. Should an y ...
-
Stow PSH - page 12
P A GE 12 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) The ST O W MODEL PSH PORT O-SCREED is designed f or vibration screeding concrete . Vibration screeding with the ST O W P or to-screed is the ideal wa y to str ik e-off and vibrate concrete sidewalks, floors, patios, and even bridge decks. The PSH P or to- ...
-
Stow PSH - page 13
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 13 Figure 5. Controls and Components Figures 5 shows the location of the basic controls or components, f or the POR T O-SCREED PSH . Listed belo w is a brief explanation of each control or component 1. Throttle Control Lever – Controls the speed of the engine. Move ...
-
Stow PSH - page 14
P A GE 14 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) Figure 6. Engine Controls and Components INITIAL SER VICING The engine (Figure 6) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturer's engine manual f or instr uctions & details of operation ...
-
Stow PSH - page 15
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 15 Fuel Check Motor fuels are highly flammable and can be dangerous if mishandled. DO NOT smoke while refueling. DO NOT attempt to refuel the PSH if the engine is hot! or running . D ANGER 1 . Remove the gasoline cap located on top of fuel tank. 2 . Visually inspect ...
-
Stow PSH - page 16
P A GE 16 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) 3 . Place the choke lever (Figure 11) in the " CLOSED " position if starting a cold engine. POR T O-SCREED PSH — INITIAL ST ART -UP This section is intended to assist the operator with the initial start-up of the PSH. It is extremely important ...
-
Stow PSH - page 17
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 17 Figure 15. Throttle Le ver (Run Position) POR T O-SCREED PSH — INITIAL ST ART -UP Figure 14. Starter Grip 2 . After the engine cools , turn the engine start/stop switch to the “ OFF ” position (Figure 16). Figure 16. Engine ON/OFF Switch (OFF Position) 3 . C ...
-
Stow PSH - page 18
P A GE 18 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) OPERA TION POR T O-SCREED PSH — OPERA TION DO NO T alter .this setting since damage to the eccentric bearings can result and both the engine and machine warranty will be automatically V OIDED . 4. Start the engine as previously described. Refer to the E ...
-
Stow PSH - page 19
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 19 See the engine manual supplied with your machine for appropriate engine maintenance schedule and troubleshooting guide for problems. MAINTENANCE SCHEDULE Daily (8-10 Hours) 1. Check the oil le v el in the engine crankcase; fill as necessar y . 2 . Check V -belt. W ...
-
Stow PSH - page 20
P A GE 20 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) PORT O-SCREED PSH — TROUBLESHOO TING (ENGINE) ) E N I G N E ( G N I T O O H S E L B U O R T . 4 E L B A T M O T P M Y SE S U A C E L B I S S O PN O I T U L O S o n t u b , e l b a l i a v a s i l e u f " , t r a t s o t t l u c i f f i D . " g ...
-
Stow PSH - page 21
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 21 SUGGESTED SP ARE P AR TS POR T O-SCREED PSH 1 T O 3 UNITS WITH HOND A GX120K1QX2 ENGINE 1 to 3 Units Qt y . ..... P/N ........................ Description 1 ........... 30033-401 ............ CABLE, THRO TTLE ASM 4 ........... 22094-006 ............ O-RING (F ASTE ...
-
Stow PSH - page 22
P A GE 22 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) POR T O-SCREED PSH — NAMEPLA TE AND DECALS NAMEPLA TE AND DECALS D DECAL SHEET INTL STDS ISO P/N 1 1246 C B A P/N 36099 (ISO Blue) P/N 25263-001 P/N 20109-001 P/N 131 18 CONT ACT SERVICE DEP ARTMENT P O W D E R C O T E D A 4 LUBRICATION C D B A “HOT? ...
-
Stow PSH - page 23
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 23 POR T O-SCREED PSH — NAMEPLA TE AND DECALS NAMEPLA TE AND DECALS NO . P AR T NO . P AR T NAME QTY . REMARKS 1 21302 DECAL: GU ARD W ARNING .................................. 1 ....... SAFETY ITEM 2 20525 SMALL DECAL: W ARNING, CA PROP 65 ........................ ...
-
Stow PSH - page 24
P A GE 24 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) POR T O-SCREED PSH — ASSEMBL Y ASSEMBL Y 2 3 31 36 37 1 4 5 5 5 25 26 6 6 32 8 8 9 27 28 7 7 10 13 11 16 17 18 19 29 24 20 33 19 19 20 34 30 22 21 14 15 35 15 23 12 ...
-
Stow PSH - page 25
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 25 ASSEMBL Y NO . P AR T NO . P AR T NAME QTY . REMARKS 1 21387 ENGINE, 4 HP . HOND A GX120K1QX2 1 2 12704-304 CLUTCH 1 3 18241-301 B EL T G UAR D ...................................................... 1 ......... SAFETY ITEM 4 0655 SCREW , HHC 5/16 - 18 X 3/4" ...
-
Stow PSH - page 26
P A GE 26 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (03/17/04) Effective: July 15, 2003 TERMS AND CONDITIONS OF SALE — P AR TS Effective: July 1, 2000 TERMS AND C ON DITI ON S OF SALE — P AR TS P A YMENT TERMS T er ms of pa yment for unit sales are 2% 15 days net 30 days from date of invoice unless otherwise spec ...
-
Stow PSH - page 27
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (03/17/04) — PAGE 27 NO TE P A GE ...
-
Stow PSH - page 28
OPERA TION AND P AR TS MANUAL ST O W CONSTRUCTION EQ UIPMENT A DIVISION OF MUL TIQUIP HANO VER MILL FITZRO Y STREET ASHTON-UNDER-L YNE LANCASHIRE, OL7 OTL UNITED KINGDOM PH. 0161-339-2223 F AX. 0161-339-3226 E-MAIL: stow@stowmfg.com www .stowmfg.com Atlanta • Boise • Newark • Quebec, Canada Manchester, UK • Rio de Janeiro, BR • Puebla, MX ...
Do you have a question concerning Stow PSH?
Use the form below
If you did not solve your problem by using a manual Stow PSH, ask a question using the form below. If a user had a similar problem with Stow PSH it is likely that he will want to share the way to solve it.