English dropdown-ico

Manual Tecumseh LH195SA/LH195SP (HSSK40-55)

32 pages 1.87 mb
Download

Go to site of 32

Summary
  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 1

    LH195SA/LH195SP (HSSK40-55) LH318SA/LH358SA (HMSK80-1 10) OH195SA/OH195SP (OHSK50-75) OH318SA/OH358SA (OHSK80-130) 181-1275-14 (English) 6/01/08 ENGINE MODEL: SPEC: DOM: 4-Cycle Engine OPERA T OR’S MANUAL For your convenience, enter your engine model, spec and DOM numbers here. Visit our website at www.TecumsehPower.com Maint ain Y our ENGINE Wit ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 2

    Page ii 4-Cycle • Snow King Engine 181-1275- 14 IMPORT ANT NOTICE! Safety Definitions Statements in this manual preceded by the following wor ds and graphics are o f special significance: Or WARNING indicat es a potent ially hazardous situation which if NOT avoided, could result in death or ser ious injury. Indicates a potent ially hazard ous sit ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 3

    181-1275-14 4-Cycle • Snow King Engine Page 1 I. General Safety Precautions ! W ARNING A. A void Carbon Monoxide Poisoning All engine exhaust contain s carbon monoxide, a dead ly gas. Breathing carbon monoxide can cause headaches, dizziness, drowsiness, nausea, co nfusion and eventually death. Carbon monoxide is a colorless, odor less, taste less ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 4

    Page 2 4-Cycle • Snow King Engin e 181-1275-14 E. DO NOT Modify Engine To avoid serio us in jury or de ath, DO NOT mo dify engine in any way. Tampering with the governor setting can lead to a runaway engine and cause it to operate at unsa fe speeds. NEVER tamper with factory se tting of engi ne governor. ! W ARNING F . A void Burns and Fi re from ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 5

    181-1275-14 4-Cycle • Snow King Engine Page 3 II. How to Get Service For engine adjustme nts, r epairs or warranty service NOT covere d in this manu al, contact y our neares t Authorized Te cumseh Power Servicing Dealer. Find them on our website at www.Te cumsehPower. com or call TecumsehPower Company at 1-80 0-558-5402 for additional information ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 6

    Page 4 4-Cycle • Snow King Engin e 181-1275-14 III. Oil and Fuel S pecifications A. Oil To operate your engin e you need to use a clean, high quality, detergent oil. For re commended engine oil, see Table 1. In addition, you need to be sure the oil sump contains the correct amou nt of oil to operate properly. For recommended oil sum p capacity, s ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 7

    181-1275-14 4-Cycle • Snow King Engine Page 5 B. Filling Oil Sump I. Oil Fill Cap/Dip stick If your engine has an oil fill cap/ dipstic k go to step 1. If your engine does NOT have an oil f ill cap/dipstick, see "II. Oil Fill Cap/Plug" instru ctions below. 1. Be sure engine is upright and level. 2. Unscrew oil fill cap/ dipstick from oi ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 8

    Page 6 4-Cycle • Snow King Engin e 181-1275-14 C. Check the Following Items NOTE Be sure equipment is in neutral before attempting to st art (see equipment manufacturer’s instructions). 1. Be sure ig nition switch o n engine or equipment is in “ON”, “RUN” o r “ST AR T” positio n. See Figure s 10, 11 and 12. Or Insert ignition key, i ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 9

    181-1275-14 4-Cycle • Snow King Engine Page 7 Figure 14. 4-Cycle Sn ow Engine Component s 2 3 7 12 8 6 13 9 10 4 5 2 4 3 7 12 8 6 13 10 1 5 1 3 4 7 12 8 6 13 9 10 2 5 1 9 11 11 OH318SA/OH358SA 1 3 4 8 12 7 6 13 9 10 2 5 OH195SA/OH195SP LH195SA/LH195SP LH318SA/LH358SA ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 10

    Page 8 4-Cycle • Snow King Engin e 181-1275-14 E. Filling Fuel T ank An adult should fuel this engine. NEVER allow children to refuel this engine. Gasoline (fuel) vapors are hig hly flammable and can explode . Fuel vapo rs can spre ad and be ig nited by a spark or flame many feet away from engine. To preven t injury or death from fuel fires, foll ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 11

    181-1275-14 4-Cycle • Snow King Engine Page 9 V . S t arting Y our Engine To avoid serious injury or death, an adult should start this engine. Only allow children to start engine if an adult has determined they are e xperienced and capabl e of such ope ration. If you are unable to star t this eng in e after following instru ctions in this manual, ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 12

    Page 10 4-Cycle • Snow King Engine 181-1275- 14 A. Engines with El ectric St arters If you have a recoil starte r, see “B. Engin es with Recoil Starters” instructions on page 1 3. Some electric starters are equipped with a 120V AC Three-Wire Power Cord and Plug designed to opera te on a 120V AC household current. It must be properly grounded ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 13

    181-1275-14 4-Cycle • Snow King Engine Page 11 5. Move engine speed control to “FAST” position. See Figures 21 and 22. 6. Set choke control to “FULL CHOKE” position (see equipment manu facturer’s inst ructions). See Figure 24 on page 12. Af terward, continue reading instructions below . 7. Hold the primer bulb in fo r one full second ea ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 14

    Page 12 4-Cycle • Snow King Engine 181-1275- 14 Figure 24. Choke Contr ol Positions S T O P STOP S T O P STOP S T O P STOP STOP STOP STOP ST O P STOP ST O P STOP ST OP STOP LH195SA/LH195SP OH195SA/OH195SP OH318SA/OH358SA LH318SA/LH358SA 1. “NO CHOKE” Position 2. “1/2 CHOKE” Position 3. “FULL CHOKE” Position 1 2 3 3 1 2 3 1 2 1 2 3 ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 15

    181-1275-14 4-Cycle • Snow King Engine Page 13 B. Engines with Recoil St arters If you have an ele ctric starter, s ee “A. Engines with Electr ic Starters” instructions on page 1 0. DO NOT pull starter rope with engine running. Doing so may VOID YOUR WARRANTY. 1. T o avoid carbon monoxide poisoning, be sure engine is outdoors in a well-ventil ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 16

    Page 14 4-Cycle • Snow King Engine 181-1275- 14 When pulling starter rope, th e rope can unexpe ctedly jerk bac k toward engine causin g ser iou s inju ry . To avoid this ris k, carefully follow these instructions: 7. Grasp starter cord han d le. Se e Fig ur e 29. a. Pull rop e out slowly u ntil you feel dr ag. b. Without allowing the rope to ret ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 17

    181-1275-14 4-Cycle • Snow King Engine Page 15 VI. S topping Y our Engine and Short-T erm S torage Stop engine according to equipment manufa cturer’s instructions. To avoid unsupervised op er ation of an engine, especially by children, NEVER leave it unattended when it is running. Always turn off the engine after use an d remove ignition key, i ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 18

    Page 16 4-Cycle • Snow King Engine 181-1275- 14 B. Af ter Engine is Stopped To prevent po ssib le fr ee ze -u p of engine controls, follow instru ctions with engine STOPPED, listed below. 1. Wipe all snow a nd moisture from engine control lever and choke areas. 2. Move equipment control, if pr esent (see manufacturer ’s instructions), engin e c ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 19

    181-1275-14 4-Cycle • Snow King Engine Page 17 VII. Maintenance To avoid serious injury or death, an adult should perform mainten ance on this engine. Only allow childre n to perform maintenance if an adult has determined they are exp erienced and capable of such operation. To prevent acc idental start ing whe n working on equipment, always: • ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 20

    Page 18 4-Cycle • Snow King Engine 181-1275- 14 I. Oil Fill Cap/Dip stick If your engine has an oil fill cap/dipstick go to step 1. If your engine does NOT have an oil fill cap/dipstick , see "II. Oil Fill Ca p/Plug" instructions on page 20. 1. Carefully disconnect spark plug wir e and keep it away from spar k plug. See Figu res 38 a nd ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 21

    181-1275-14 4-Cycle • Snow King Engine Page 19 5. Place approved recyclable oil container under oil drain plug, if present. See Figure 41 on page 18. Afterward, continue readin g in structions below . 6. Remove oil drain plug, if present. 7. T ip engine to position the oil flow , so it will drain from the lowest point on the engine (see equipme n ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 22

    Page 20 4-Cycle • Snow King Engine 181-1275- 14 II. Oil Fill Cap/Plug If your engine does NOT have an oil fill cap/dipstick , go to step 1. If your engi ne has an oil fill cap/dipstick , see "I. Oil Fill Cap/Dipstick" instructions on p age 18. 1. Carefully disconnect spark plug wir e and keep it away from spar k plug. See Figures 44 and ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 23

    181-1275-14 4-Cycle • Snow King Engine Page 21 5. Place approved recyclable oil container under oil drain plug. See Figures 47 and 48 st arting on page 20. Af ter - ward, continue reading instructions below . 6. T ip engine to position the oil drain plug a t the lowest point on the engine (see equipme nt manufacturer ’s instructions). 7. Remove ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 24

    Page 22 4-Cycle • Snow King Engine 181-1275- 14 D. Carburetor If you think your carburetor needs adjusting, see your nearest Authorized TecumsehPower Ser vicing Dealer. Engine performance shou ld not be affected at altitudes up to 7,000 feet (2,134 meters) . For operation at higher elevations, contact an Authorized TecumsehPo wer Servicing Dealer ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 25

    181-1275-14 4-Cycle • Snow King Engine Page 23 Figure 52. Snow and Debris Removal Locations 4 1 5 4 1 5 3 2 LH195SA/LH195SP 4 1 2 OH195SA/OH195SP OH318SA/OH358SA LH318SA/LH358SA 1. Oil Fill Cap/D ip stick 2. Fuel Fill Ca p Area s 3. Recoil Starter/Flywheel Gu a rd Area s 4. Linkag e Area s 5. Sp ark Plug Connect ion 4 3 2 3 2 3 1 5 5 ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 26

    Page 24 4-Cycle • Snow King Engine 181-1275- 14 IX. S toring Y our Engine A. Short-T erm/Seasonal Storage I. Clean Engine Before servicing the en gine remove the carburetor cover and/or blower housing. Remove dirt and debris from the following areas: • Cooling Fins • Air Intake Screen or Recoil S t arter/ Flywheel Guard Areas • Oil Fill Cap ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 27

    181-1275-14 4-Cycle • Snow King Engine Page 25 II. Oil Cylinder Bore When lubricatin g cylinder bor e, fuel may spray from spark plug hole. To prevent se rious injury fro m fuel fires, follow these instructions: 1. Carefully disconnect spark plug wir e and keep it away from spa rk plug. See Figures 53 and 54. • Keep the discon nected spark plug ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 28

    Page 26 4-Cycle • Snow King Engine 181-1275- 14 X. Preventing Forest, Brush and Grass Fires Local, state and federal laws may require use of a spark arrester to prevent fires. For examp le, it is a violation of California Public Resource s Code (section 4442) to use or operate engine on any forest-cover ed , brush-covered or unimproved grass-cove ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 29

    181-1275-14 4-Cycle • Snow King Engine Page 27 Every 5 Hours or Before Each Use 1. Check Oil Level 2. Clean Cooling Fins Date____________ ___Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dea ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 30

    Page 28 4-Cycle • Snow King Engine 181-1275- 14 CALIFORNIA & US EP A EMISSION CONTROL W ARR ANTY S TATEMENT The U. S. Environmental Pr otection Agency (“EP A”), the California Air Resources Board (“CARB”) and T ecumseh- Power Company are pleased to explain the Federal and California Emission Control Systems W arranty on your new small ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 31

    181-1275-14 4-Cycle • Snow King Engine Page 29 EMISSION CONTROL SYSTEM W ARRANTY Emission Control System Warranty (“ECS Warranty”) for 1995 and later model year Ca lifornia small off-road engines (for other states, 1997 and later model year engin es): A . APPLICABILITY : This warranty shall apply to 1995 and later model year California small ...

  • Tecumseh LH195SA/LH195SP (HSSK40-55) - page 32

    XII. W arranty Information LIMITED WARRANTY FOR NE W TECUMSEHPOWE R ENGINES AND ELECTRONIC IGNITION MODULES For the time period sh own below from the d ate of pu rchase and su bject to the exception s and limit ations descr ibed herein , T ecum sehPower Company will, at it s option as the exclusive remedy , eit her rep air or replace for the origin ...

Manufacturer Tecumseh Category Automobile Parts

Documents that we receive from a manufacturer of a Tecumseh LH195SA/LH195SP (HSSK40-55) can be divided into several groups. They are, among others:
- Tecumseh technical drawings
- LH195SA/LH195SP (HSSK40-55) manuals
- Tecumseh product data sheets
- information booklets
- or energy labels Tecumseh LH195SA/LH195SP (HSSK40-55)
All of them are important, but the most important information from the point of view of use of the device are in the user manual Tecumseh LH195SA/LH195SP (HSSK40-55).

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Tecumseh LH195SA/LH195SP (HSSK40-55), service manual, brief instructions and user manuals Tecumseh LH195SA/LH195SP (HSSK40-55). Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Tecumseh LH195SA/LH195SP (HSSK40-55).

Similar manuals

A complete manual for the device Tecumseh LH195SA/LH195SP (HSSK40-55), how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Tecumseh LH195SA/LH195SP (HSSK40-55) by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Tecumseh LH195SA/LH195SP (HSSK40-55).

A complete Tecumseh manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Tecumseh LH195SA/LH195SP (HSSK40-55) - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Tecumseh LH195SA/LH195SP (HSSK40-55), FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Tecumseh LH195SA/LH195SP (HSSK40-55), that we can find in the current document
3. Tips how to use the basic functions of the device Tecumseh LH195SA/LH195SP (HSSK40-55) - which should help us in our first steps of using Tecumseh LH195SA/LH195SP (HSSK40-55)
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Tecumseh LH195SA/LH195SP (HSSK40-55)
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Tecumseh LH195SA/LH195SP (HSSK40-55) in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Tecumseh LH195SA/LH195SP (HSSK40-55)?

Use the form below

If you did not solve your problem by using a manual Tecumseh LH195SA/LH195SP (HSSK40-55), ask a question using the form below. If a user had a similar problem with Tecumseh LH195SA/LH195SP (HSSK40-55) it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)