-
Invacare 3650 - page 1
Owner’s Operator and Maintenance Manual DEALER: This manual MUST be given to the user of the tub. USER: BEFORE using this tub, read this manual and save for future reference. For more information regarding Invacare Continuing Care Group products, parts, and services, please visi t www.invacare-ccg.com Side Entry Whirlpool Tub Model 3600 & Mod ...
-
Invacare 3650 - page 2
Side Entry Whirlpool Tub 2 Part No 1118387 WARNING DO NOT use this product or any availa ble option al equipmen t without first completely reading and understanding these instructions and any additional instructional material such as owner’s manuals, service manu als or instruction sheets supplied with this pr oduct or optional equipmen t. If ...
-
Invacare 3650 - page 3
TABLE OF CONTENTS Part No 1118387 3 Side Entry Whirlpool Tub TABLE OF CONTENTS SPECIAL NOTES ................................................................................ 5 LABEL LOCATION ............................................................................ 6 TYPICAL PRODUCT PARAMETERS .................................................... ...
-
Invacare 3650 - page 4
TABLE OF CONTENTS Side Entry Whirlpool Tub 4 Part No 1118387 TABLE OF CONTENTS Safety Inspection Checklis ts ................... ............................................. .................. .................................28 Initially ..................................................................................... .................. ..... ...
-
Invacare 3650 - page 5
SPECIAL NOTES Part No 1118387 5 Side Entry Whirlpool Tub SPECIAL NOTES Signal words are use d in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the following table f ...
-
Invacare 3650 - page 6
LABEL LOCATION Side Entry Whirlpool Tub 6 Part No 1118387 LABEL LOCATION SERIAL NO. MODEL NO. P ATENTS PENDING U.S. AND FOREIGN ...
-
Invacare 3650 - page 7
TYPICAL PRODUCT PARAMETERS Part No 1118387 7 Side Entry Whirlpool Tub TYPICAL PRODUCT PARAMETERS MODEL 3600 3600XL 3650 MINIMUM SPACE REQUIREMENTS: 7 feet x 6 feet LENGTH EXTERIOR: INTERIOR: 63 inches 46.5 inche s 72 inches 56 inches 67 inches 56 inches WIDTH EXTERIOR: INTERIOR (SEAT): 34 inches 32 inches 32 inches 26 inches HEIGHT OVERA LL: RIM: 4 ...
-
Invacare 3650 - page 8
FEATURES Side Entry Whirlpool Tub 8 Part No 1118387 FEATURES Models 3600 and 3600XL Control Panel Tub Interior Flow Water Thermometer Tub Exterior Disinfectan t Cabinet Door Door Handle Shower Massage Wand Holder Hot and Cold Water Inlets Motor Access Hole Drain Whirlpool Inlet Burp Fitting Whirlpool Jets Control Panel (See Above) Shower ON/ OFF Va ...
-
Invacare 3650 - page 9
FEATURES Part No 1118387 9 Side Entry Whirlpool Tub Model 3650 Control Panel Tub Interior Flow Water Thermometer Tub Exterior Disinfectant Cabinet Door Door Handle Shower Massage Wand Holder Hot Water Inlet Cold Water Inlet Motor Access Hole Drain Drain Plug Whirlpool Inlet Burp Fitting Whirlpool Jets Door Handle Safety Pin Control Panel (See Above ...
-
Invacare 3650 - page 10
SECTION 1—GENERAL GUIDELINES Side Entry Whirlpool Tub 10 Part No 1118387 SECTION 1—GENERAL GUIDELINES WARNING SECTION 1 - GENERAL GUIDELIN ES contai ns important inform ation for the safe operation and use of this product. Check all parts for shipping damage before using . In case of damage, D ...
-
Invacare 3650 - page 11
SECTION 1—GENERAL GUIDELINES Part No 1118387 11 Side Entry Whirlpool Tub Electrical Be certain ALL electrical wor k is performed by a qualified electrician and is in compliance with local electrical codes. ALL electrical connections are to be wa t e r ...
-
Invacare 3650 - page 12
SECTION 1—GENERAL GUIDELINES Side Entry Whirlpool Tub 12 Part No 1118387 Maintenance and Inspection DANGER ELECTRICAL SHOCK HAZARD. All disasse mbly and maintenance of the tub MUST be done by a qualif ied technician, certified electrician or plumber. Disconnect electrical supply or turn o ff circuit breaker befo re performing any maintenance ...
-
Invacare 3650 - page 13
SECTION 1—GENERAL GUIDELINES Part No 1118387 13 Side Entry Whirlpool Tub Operation DANGER Keep hair and body away from su ction guard when pump is running. The causes, symptoms, and effects of hyperthermia may be described as follows: Hyperthermia occurs when the internal temperature of the bo dy reaches a level several degrees above the no r ...
-
Invacare 3650 - page 14
SECTION 2—PARTS AND INSTALLATION Side Entry Whirlpool Tub 14 Part No 1118387 SECTION 2—PARTS AND INSTALLATION Parts Information For parts information, please contact ICCG Te c h n i c a l Service at (800) 668 ‐ 2337. About Installation WARNING Access for servicing the tub MU ST be provided. In stall ...
-
Invacare 3650 - page 15
SECTION 2—PARTS AND INSTALLATION Part No 1118387 15 Side Entry Whirlpool Tub FIGURE 2.1 Preparing the Work Area Service Access Panel Service Access Panel Models 3600 and 3600XL Model 3650 B E D H Right Side of Tub Left Side of Tub Floor Drain C I Rear of Tub A J G F Hot and Cold Water Inlets Screw Leg Leg Mounting Pad DETAIL “A” LETTER DESCRI ...
-
Invacare 3650 - page 16
SECTION 2—PARTS AND INSTALLATION Side Entry Whirlpool Tub 16 Part No 1118387 Securing Tub NOTE: For this proced ure, ref er to FIGURE 2.2. 1. Set the tub in place. 2. Ensure plumbing and electrical hook ‐ ups have be en installed. Refer to Electrical and ...
-
Invacare 3650 - page 17
SECTION 2—PARTS AND INSTALLATION Part No 1118387 17 Side Entry Whirlpool Tub Electrical and Plumbing Hook-up Locations on the Tub NOTE: For this proced ure, ref er to FIGURE 2.3 on page 17. NOTE: For installation deta ils ref e r to Electrical Installation on page 17 and ...
-
Invacare 3650 - page 18
SECTION 2—PARTS AND INSTALLATION Side Entry Whirlpool Tub 18 Part No 1118387 WARNING All electrical conduit, fittin gs and wire to unit are to be supplied and installed by a professional electrician in accordance with the Nation al electrical cod e as a minimum requirement, includi ng the supply and install ation of a Ground Fault Circuit Int ...
-
Invacare 3650 - page 19
SECTION 2—PARTS AND INSTALLATION Part No 1118387 19 Side Entry Whirlpool Tub FIGURE 2.4 Electrical Installation Wall Tub Wall Pump Motor Black White Green DETAIL “B” - ELECTRICAL SCHEMATIC Air Switch Line Motor Cover Ground (GREEN) Line (BLACK) Neutral (WHITE) Ground Line Neutral DETAIL “D” - MOTOR END PLATE DETAIL “C” - MOTOR COVER S ...
-
Invacare 3650 - page 20
SECTION 2—PARTS AND INSTALLATION Side Entry Whirlpool Tub 20 Part No 1118387 Plumbing Installation DANGER Be certain all plumbing work is perfor med by a qualified plumber and is in compliance with local codes. WARNING Some state and local pl umbing codes require the install ation of a “reduced pressure zone” (RPZ) assembly on both th ...
-
Invacare 3650 - page 21
SECTION 2—PARTS AND INSTALLATION Part No 1118387 21 Side Entry Whirlpool Tub 9. Check fo r leaks in supply or drain lines and check operation of tub. Refer to Operating Instructions on page 22. NOTE: Check local codes re g ar d i n g maximum water ...
-
Invacare 3650 - page 22
SECTION 3—OPERATING INSTRUCTIONS Side Entry Whirlpool Tub 22 Part No 1118387 SECTION 3—OPERATING INSTRUCTIONS Overview The tub is designed to improve the efficiency and environmental safety of you r facility ʹ s operation. Howev er , if the tub is not operated ...
-
Invacare 3650 - page 23
SECTION 3—OPERATING INSTRUCTIONS Part No 1118387 23 Side Entry Whirlpool Tub Disinfecting the Tub Using the Closed Loop System WARNING Disinfect the tub after EACH us e to avoid resident infection and contamination of the tub. DO NOT disinfect the tub when it is occupied otherwise injury may occur. Read and understand all information on Invac ...
-
Invacare 3650 - page 24
SECTION 3—OPERATING INSTRUCTIONS Side Entry Whirlpool Tub 24 Part No 1118387 Opening/Closing the Tub Door WARNING DO NOT open door when water is in th e tub, serious injury could result. NOTE: For this proced ure, ref er to FIGURE 3.2 on page 24. Opening the Tub Door 1. Place one hand on top ...
-
Invacare 3650 - page 25
SECTION 3—OPERATING INSTRUCTIONS Part No 1118387 25 Side Entry Whirlpool Tub Tub Operation WARNING DO NOT stand in tub. Tub surfaces are slippery wh en wet. Serious injury may occur. Before immers ing the resident or op erati ng the shower/massage wand, check that the water temperature is be tween 95° F and 105 ° F (35° C and 41° C) to av ...
-
Invacare 3650 - page 26
SECTION 3—OPERATING INSTRUCTIONS Side Entry Whirlpool Tub 26 Part No 1118387 Operating Shower/Massage Wand NOTE: For this proced ure, ref er to FIGURE 3.4. NOTE: STEPS 1 ‐ 3 are to be performed while holding the shower/massage wand over the tub. 1. T urn s ...
-
Invacare 3650 - page 27
SECTION 3—OPERATING INSTRUCTIONS Part No 1118387 27 Side Entry Whirlpool Tub FIGURE 3.5 Filling Tub Hydromassage CAUTION Before starting hy dromassage, water level MUST be completely above whirlpool jets otherwise severe damage to the motor/pump will result. NOTE: For this proced ure, ref er to FIGURE 3.6 on page ? ...
-
Invacare 3650 - page 28
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Side Entry Whirlpool Tub 28 Part No 1118387 SECTION 4—SAFETY INSPECTION/ TROUBLESHOOTING NOTE: Every six months or as necessary have a qualified technician perform a thorough inspection and servicing. Routine maintenance will ...
-
Invacare 3650 - page 29
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Part No 1118387 29 Side Entry Whirlpool Tub Cleaning Cleaning the Door Seal Gasket The rubber door seal gasket should remain clean and free of debris. Use a w orking solution of a commercially av ailable heavy duty c ...
-
Invacare 3650 - page 30
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Side Entry Whirlpool Tub 30 Part No 1118387 Heavy Duty Cleaning Procedure WARNING The disinfectant dispensing system has been fact ory tested and calibrated for use with I nvacare disinfectant. The use of any disinfectant with a dilution ratio (½ oz. per gallon) or visco sity level different than t ...
-
Invacare 3650 - page 31
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Part No 1118387 31 Side Entry Whirlpool Tub Calibrating the Disinfectant Flow Meter WARNING The disinfectant dispensing system has been factory te sted and calibrated for use with Invacare disinfectant. The use of any disinfectant wi th a dilution ratio (½ oz. per gallon) or viscosit y level differ ...
-
Invacare 3650 - page 32
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Side Entry Whirlpool Tub 32 Part No 1118387 11. Close all jets by pushing the center of each jet in or turning the center of the jet clockwise. 12. Close the whirlpool inlet by pulling the inlet plug ...
-
Invacare 3650 - page 33
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Part No 1118387 33 Side Entry Whirlpool Tub FIGURE 4.1 Calibrating the Disinfectant Flow Meter Troubleshooting NOTE: If pr oblems are not rem ed i e d by the suggested means above, contact an ICCG dealer or technical support. SYMPTOMS F ...
-
Invacare 3650 - page 34
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Side Entry Whirlpool Tub 34 Part No 1118387 Maintenance Record DATE MAINTENANCE PERSON TYPE OF MAINTENANCE PERFORMED NOTES ...
-
Invacare 3650 - page 35
NOTES Part No 1118387 35 Side Entry Whirlpool Tub NOTES ...
-
Invacare 3650 - page 36
LIMITED WARRANTY PLEASE NOTE: THE WA RRANTY BELOW HAS BE EN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MA N UFACTURED AFTER JULY 4, 1975. This warranty is extended only to the o riginal purchaser/user of our pro ducts. This warranty gives you speci fic legal rights and you may also have other legal ri ghts which vary from state to st ...
Do you have a question concerning Invacare 3650?
Use the form below
If you did not solve your problem by using a manual Invacare 3650, ask a question using the form below. If a user had a similar problem with Invacare 3650 it is likely that he will want to share the way to solve it.