English dropdown-ico

Manual Desa (V)KC36PE SERIES, (V)KC36NE SERIES

40 pages 2.33 mb
Download

Go to site of 40

Summary
  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 1

    For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol-           ? ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 2

    www .desatech.com 1 16238-01E 2 SAFETY INFORMA TION T ABLE OF CONTENTS Safety Information ............................................... 2 Product Identication ........................................... 4 Local Codes......................................................... 4 Product Features ................................................. 5 ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 3

    www .desatech.com 1 16238-01E 3 This replace must be installed by a qualied (cer - tied or licensed) service person. It has a sealed gas combustion chamber that uses a coaxial pipe (pipe within a pipe and having the same center) venting system. It brings in fresh air for combus - tion through the outer pipe and combustion gases are exhaust ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 4

    www .desatech.com 1 16238-01E 4 2. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrica l switch; do not use any phone in your building • immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier's instructions • if you cannot reach you gas supplier , ca ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 5

    www .desatech.com 1 16238-01E 5 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent replace: • The venting system may be routed to the out - side of your home in several ways. It may vent through the roof (vertical) or it may vent to an outside/exterior wall (horizontal). The vent pipe installation i ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 6

    www .desatech.com 1 16238-01E 6 • Y our replace is designed to be used in zero clea ranc e install atio ns. W all or fram ing mater ial can be placed directly against any exterior sur - face on the back, sides or top of your replace, except where standoff spacers are integrally atta ched . If stand of f spac ers are attach ed to your rep ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 7

    www .desatech.com 1 16238-01E 7 A B E F G H D C Nailing T abs Figure 4 - Framing Clearances for Installation Against an Exterior Wall 36 1 / 8 " 41 1 / 4 " 21" Horizontal V ent 24 1 / 2 " V ertical V ent C B A D E F G T op of Louver Opening 3 2 1 4 5 6 7 W all Figure 5 - Framing Clearances for Corner Installation  Ma ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 8

    www .desatech.com 1 16238-01E 8 Figure 7 - Minimum Clearances for T ermination Cap LOCA TION OF TERMINA TION CAP Fixed Closed Op en ab le Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 9

    www .desatech.com 1 16238-01E 9 VENT ING INST ALLA TION INSTRUCTIONS NOTICE: Read these instruc-                           -  Thes e mod els a re te sted and app roved f or us e with DESA (direct-vent) pipe ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 10

    www .desatech.com 1 16238-01E 10 INST ALLA TION pLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop. Hori - zon tal inst all atio ns using rou nd termi nat ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 11

    www .desatech.com 1 16238-01E 1 1 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess       6.  ? ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 12

    www .desatech.com 1 16238-01E 12 VENTING INST ALLA TION INSTRUCTIONS Continued Figure 13 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screws High Wind T ermination Apply Mastic to Outside Edge of Standoff Exterior W all with Vinyl Siding 10 3 / 4 " x 10 3 / 4 " Framed Opening Ma ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 13

    www .desatech.com 1 16238-01E 13 CORNER INST ALLA TION Recommended Applications: • Corner ground oor installation • G ro un d  o or in st a ll at io n w he re pi p e ve nt s ho ri zo n - ta lly th rou gh wal l ( ove r 12" horizontal pipe) • Basement installation where one foot clearance from ground to termination is possible VENTIN ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 14

    www .desatech.com 1 16238-01E 14 VENTING INST ALLA TION INSTRUCTIONS Continued      Horizontal (H   Horizontal (H   Horizontal (H   5' min. 2' max. 6' max. 6' min. 4' max. 12' ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 15

    www .desatech.com 1 16238-01E 15    TERMINA TION Note: V ertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters or other framing will obstruct the venting system, consi de ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 16

    www .desatech.com 1 16238-01E 16 5. Pla ce th e as hing ov er th e pip e sec tion( s) extendin g through the roof. Secure the base of the ashing to the roof and framing with roof - ing nails. Be sure roo ng materia l over laps the top edge of the ashing as shown in Figure 19, page 15. There must be a 1" clearance from the vent pipe ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 17

    www .desatech.com 1 16238-01E 17 VENTING INST ALLA TION INSTRUCTIONS Continued Note : Install restrictor into inner collar of replace as shown.         5' min. 6' max. 6' ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 18

    www .desatech.com 1 16238-01E 18   AND COMpONENTS                 P58-6 6" Section Double W all Pipe, Galvanized P58-12 12& ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 19

    www .desatech.com 1 16238-01E 19 FIREPLACE INST ALLA TION  Us e pro per ga s typ e for the r ep la ce un it yo u are in st al li ng . If you hav e co n ic ti ng gas typ es , do not in st al l re plac e. See reta ile r whe re yo u pur chas ed th e re plac e f or p ro pe r re plac e a cc or di ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 20

    www .desatech.com 1 16238-01E 20 CA UTI ON: Nev er to uc h th e            9. Ch ec k to mak e sure th at the pow er cor d is com - pl et el y cl ea r of t he b lo we r wh ee l an d t hat t he re ar e no oth er for ei gn obj ect s in bl ow er whe el. Tu ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 21

    www .desatech.com 1 16238-01E 21 7. Che ck to ma ke su re t ha t th e po we r co rd is c om - pl ete ly c lea r of th e b low er w he el a nd t ha t th ere a re no ot he r f or ei gn o bj ec ts i n b lo we r wh ee l . A ls o do ubl e c he ck al l w ir e l ea ds an d m ak e s ur e w ir e ro uti ng is no t pi nc he d or in a p re car iou s pos it io ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 22

    www .desatech.com 1 16238-01E 22 Figure 30 - External Regulator with V ent Pointing Down (Propane/LP Only) Propane/LP Supply T ank External Regulator V ent Pointing Down CAUTION: Use only new ,       - ? ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 23

    www .desatech.com 1 16238-01E 23 FIREPLACE INST ALLA TION Continued             and connections , internal and external to unit, for leaks after   ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 24

    www .desatech.com 1 16238-01E 24 pRESSURE TESTING FIREpLACE GAS CONNECTIONS 1. Open equipment shutof f valve (see Figure 33, page 23). 2. O pe n p ro p a ne / L P s u p pl y t an k v al v e f o r propane/LP fireplace or main gas valve located on or near gas meter for natural gas replace. 3. Make sure control knob of replace is in the OFF posi ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 25

    www .desatech.com 1 16238-01E 25 4. Remount the new frame at the hinge with ve new s crew s bef ore c losin g do or . Th is wi ll ensure seating of the gasket. 5. Cl os e gla ss doo r fra me. Lo ck la tc he s by pl ac in g the bar unde r the tab on doo r and pus hin g down and b ack on latch (see Figur e 37, page 2 4). 6. Replace screen/rod asse ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 26

    www .desatech.com 1 16238-01E 26 7. Remove three screws from deector shield on the inside top of rebox. Set shield and screws aside. 8. Install rear brick panel rst. Rest bottom edge of panel on back edge of burner assembly (see Figure 39). 9. Install left side brick panel by sliding it be - tween the burner assembly and the side of the ? ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 27

    www .desatech.com 1 16238-01E 27 EV2 EV1 ORANGE IGNITOR LEAD GREEN PILOT TRANSFORMER IS1070B SYNETEK CONTROLS INC 24V AC E4 E2 E3 E6 RED E8 E12 BLUE 120V AC GROUND BLACK WHITE WIRING DIAGRAM ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 28

    www .desatech.com 1 16238-01E 28 6. W ait ve (5)minutes toclear outany gas. Then smell for gas, including near the oor . Ifyousmell gas,STOP!Follow“B”inthe safet y inform ation in column  1. If you don't smellgas,gotot ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 29

    www .desatech.com 1 16238-01E 29 Figure 45 - T ypical Flame Pattern OpTIONAL REMOTE OpERA TION Note:  The WRC receiver and hand-held re - motecontr olkitmust bepurchased separately (see Accessories , page 35). Follow installation instructionsonpage26. 1. T urn equi pmentshut ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 30

    www .desatech.com 1 16238-01E 30 C L E A N IN G AN D M A I N T EN AN C E                           ? ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 31

    www .desatech.com 1 16238-01E 31  Conduct annual inspection of the venting system following these guidelines: 1. Check areas of venting system that are ex - posed to the weather for corrosion (rust spots or streaks and, in extreme cases, holes). Have these items replaced immediately by a quali - ed servi ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 32

    www .desatech.com 1 16238-01E 32  Pilot will not stay lit No gas to burner , although wall switch and valve are set to the ON position Frequent pilot outage Fir epla ce produ ces a clicki ng/t ick - ing noise just after burner is lit or shut off Slight smoke or odor during initial operation REMEDY 1 . ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 33

    www .desatech.com 1 16238-01E 33 TROUBLESHOO TING Continued          ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 34

    www .desatech.com 1 16238-01E 34 REPLACEMENT P ARTS Note : Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . p ARTS UNDER W ARRANTY Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA ’ s Customer Serv ice Department at 1-866-6 ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 35

    www .desatech.com 1 16238-01E 35    - Black  - Brushed Brass  - Platinum  - Polished Brass  Ma nu al va ri abl e c ont ro l blo we r acce ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 36

    www .desatech.com 1 16238-01E 36 ILL USTRA TED P ARTS BREAKDOWN   6 7 20 17 18 13 2 12 19 8 1 4 1 1 9 14 3 16 5 15 10 24 21 23 22 ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 37

    www .desatech.com 1 16238-01E 37 P ARTS LIST   This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 38

    www .desatech.com 1 16238-01E 38 7 15 10 12 1 12 2 3 13 9 1 1 6 12 14 18 17 17 18 19 20 16 14 8 4 5 22 23 24 21 31 33 32 30 29 28 25 27 26 ILL USTRA TED P ARTS BREAKDOWN     ? ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 39

    www .desatech.com 1 16238-01E 39 P ARTS LIST      This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed ...

  • Desa (V)KC36PE SERIES, (V)KC36NE SERIES - page 40

    2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 16238-01 Rev . E 03/06 WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notice ...

Manufacturer Desa Category Outdoor Fireplace

Documents that we receive from a manufacturer of a Desa (V)KC36PE SERIES, (V)KC36NE SERIES can be divided into several groups. They are, among others:
- Desa technical drawings
- (V)KC36PE SERIES, (V)KC36NE SERIES manuals
- Desa product data sheets
- information booklets
- or energy labels Desa (V)KC36PE SERIES, (V)KC36NE SERIES
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa (V)KC36PE SERIES, (V)KC36NE SERIES.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa (V)KC36PE SERIES, (V)KC36NE SERIES, service manual, brief instructions and user manuals Desa (V)KC36PE SERIES, (V)KC36NE SERIES. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa (V)KC36PE SERIES, (V)KC36NE SERIES.

Similar manuals

A complete manual for the device Desa (V)KC36PE SERIES, (V)KC36NE SERIES, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa (V)KC36PE SERIES, (V)KC36NE SERIES by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa (V)KC36PE SERIES, (V)KC36NE SERIES.

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa (V)KC36PE SERIES, (V)KC36NE SERIES - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa (V)KC36PE SERIES, (V)KC36NE SERIES, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa (V)KC36PE SERIES, (V)KC36NE SERIES, that we can find in the current document
3. Tips how to use the basic functions of the device Desa (V)KC36PE SERIES, (V)KC36NE SERIES - which should help us in our first steps of using Desa (V)KC36PE SERIES, (V)KC36NE SERIES
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa (V)KC36PE SERIES, (V)KC36NE SERIES
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa (V)KC36PE SERIES, (V)KC36NE SERIES in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa (V)KC36PE SERIES, (V)KC36NE SERIES?

Use the form below

If you did not solve your problem by using a manual Desa (V)KC36PE SERIES, (V)KC36NE SERIES, ask a question using the form below. If a user had a similar problem with Desa (V)KC36PE SERIES, (V)KC36NE SERIES it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)