English dropdown-ico

Manual Nilfisk-ALTO R 580 B

24 pages 2.57 mb
Download

Go to site of 24

Summary
  • Nilfisk-ALTO R 580 B - page 1

    FLOORTEC R 580 B  DEUTSCH BETRIEBSANLEITUNG FRANÇAIS MANUEL D’UTILISA TION ENGLISH USER MANUAL NEDERLANDS GEBRUIKSAANWIJZING www .nilfisk-alto.com ...

  • Nilfisk-ALTO R 580 B - page 2

    S310208 S310209 S310027 S310114 S310181 S310117 S310119 S310133 S310210 S310211 B D E F G J I K L H 6 5 7 8 9 1 2 3 4 13 14 15 16 12 S310180 C ...

  • Nilfisk-ALTO R 580 B - page 3

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 1 INTRODUCTION .................................................. ................................................................ ................. 2 MANUAL PURPOSE AND CONTEN TS ................ .................... ................... ................ ................... ......... .. ...

  • Nilfisk-ALTO R 580 B - page 4

    ENGLISH USER MANUAL 2 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A INTRODUCTION MANUAL PURPOSE AND CONTENTS The purpose of this Manual is to provide the operator with all necessary information to use the machine properly in a safe and autonomous way. It contains information about technical characteristics, operation, machine storage, maintenance, spa ...

  • Nilfisk-ALTO R 580 B - page 5

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 3 SYMBOLS GENERAL INSTRUCTIONS Specific warnings and cautions to inform about potential damages to people and machine are shown below. DANGER! – To perform maintenance/repair procedures turn the machine ignition key to OFF position and disconnect the battery. – This machine must be ...

  • Nilfisk-ALTO R 580 B - page 6

    ENGLISH USER MANUAL 4 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A – In case of machine malfunctions, ensure that these are not due to lack of maintenance. Otherwise, request assistance from the authorised personnel or from an authorised Service Center. – In case of part replacement, order ORIGINAL spare parts from an authorised Dealer or Retaile ...

  • Nilfisk-ALTO R 580 B - page 7

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 5 22. Left broom lifting/lowering lever (optional) 23. Seat longitudinal position adjusting lever 24. Main broom lifting/lowering lever 25. Front skirt lifting pedal 26. Service brake pedal (parking brake when combined with lever, position 19) 27. Driver seat with safety microswitch 28. ...

  • Nilfisk-ALTO R 580 B - page 8

    ENGLISH USER MANUAL 6 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A Wiring diagram (See Fig. AF) BE1: Pivoting light (optional) BZ1: Reverse gear buzzer C1: Battery connector EB1: Drive electronic board EB2: Display board ES1: Line electromagnetic switch ES2: Main broom electromagnetic switch ES3: Pump relay ES4: Pump relay F0: Main fuse F1: Key fuse ...

  • Nilfisk-ALTO R 580 B - page 9

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 7 USE While reading this Manual, the Operator must pay particular attention to these symbols. Do not cover these plates for any reason and immediately replace them if they are damaged. BATTERY CHECK/SETTING ON A NEW MACHINE The machine requires one 24V battery, or four 6V batteries in s ...

  • Nilfisk-ALTO R 580 B - page 10

    ENGLISH USER MANUAL 8 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A BATTERY INSTALLATION AND BATTERY TYPE SETTING (WET OR GEL) Battery insta l lation 1. Install the batteries on the machine according to the diagram (15, Fig. V). According to the battery dimensions, check if it is possible to put them inside the related plastic container, supplied with ...

  • Nilfisk-ALTO R 580 B - page 11

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 9 Stopping the machine 1. To stop the machine, release the pedal (20, Fig. B). To stop the machine quickly, also push the service brake pedal (26, Fig. B). In case of emergency, press the emergency push-button (12, Fig. B) to immediately stop the machine. To disengage the safety switch ...

  • Nilfisk-ALTO R 580 B - page 12

    ENGLISH USER MANUAL 10 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A 7. Press both the enabling switch (1, Fig. B) and the hopper lowering switch (15) to lower the hopper down to the desired position. 8. The machine is ready to start working again. AFTER USING THE MACHINE After working, before leaving the machine: – Lift the main broom with the leve ...

  • Nilfisk-ALTO R 580 B - page 13

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 11 SCHEDULED MAINTENANCE TABLE (*): For the related procedure, see the Service Manual (1): or before each start-up (2): And after the first 8 running-in hours (3): replace hydraulic oil for the first time after 500 hours, then after 2,000 hours or every year. Maintenance operation On de ...

  • Nilfisk-ALTO R 580 B - page 14

    ENGLISH USER MANUAL 12 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A MAIN BROOM HEIGHT CHECK AND ADJUSTMENT 1. Check the main broom for proper ground clearance, proceeding as follows: – Drive the machine on a level ground; – Keep the machine stationary and rotate the main broom for a few seconds; – Stop and lift the main broom, then move the mac ...

  • Nilfisk-ALTO R 580 B - page 15

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 13 SIDE BROOM HEIGHT CHECK AND ADJUSTMENT 1. Check the side brooms for proper ground clearance, proceeding as follows: – Drive the machine on a level ground; – Keep the machine stationary, lower the side brooms and rotate them for a few seconds; – Stop and lift the side brooms, th ...

  • Nilfisk-ALTO R 580 B - page 16

    ENGLISH USER MANUAL 14 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A FRAME DUST FILTER CLEANING AND INTEGRITY CHECK 1. Drive the machine on a level ground and activate the parking brake using the pedal and the lever (26 and 19, Fig. B). 2. Turn the ignition switch (18, Fig. B) to “0” position. 3. Lift the hood (13, Fig. C) and secure it with the r ...

  • Nilfisk-ALTO R 580 B - page 17

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 15 14. Reassemble all the filter components in the reverse order of disassembly. 15. If necessary, clean the filter compartment rubber seal (3, Fig. AB) along its perimeter and check its integrity. If necessary, replace it. 16. Reassemble all the components in the reverse order of disas ...

  • Nilfisk-ALTO R 580 B - page 18

    ENGLISH USER MANUAL 16 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A CHARGING THE BATTERIES 1. Drive the machine on a level ground and activate the parking brake using the pedal and the lever (26 and 19, Fig. B). 2. Turn the ignition switch (18, Fig. B) to “0” position. 3. Lift the hood (13, Fig. C) and secure it with the rod (16, Fig. V). 4. Chec ...

  • Nilfisk-ALTO R 580 B - page 19

    USER MANUAL ENGLISH 146 2601 0 00(1)2005-03 A FLOORTEC R 580 B 17 TROUBLESHOOTING For further information, refer to th e Service Manual, available at any Nilfisk-Alto Service Center. SCRAPPING Have the machine scrapped by a qualified scrapper. Before scrapping the machine, remove the following components: –B a t t e r y – Polyester dust filter ...

  • Nilfisk-ALTO R 580 B - page 20

    ENGLISH USER MANUAL 18 FLOORTEC R 580 B 146 2601 000(1)2 005-03 A EC CERTIFICATE OF CONFORMITY $ OWR'HXWVFKODQG * PE+ * XLGR 2 EHUGRUIHU 6 WUDH  '   %HOOHQEHUJ ' LSO,Q J :ROI J DQ J 1LHXZNDPS 7 HVWVDQ G D SS URYD O V 3 UR G XFW 6 ZHH S HU 0 R G H O  )/2257(&am ...

  • Nilfisk-ALTO R 580 B - page 21

    S310215 AF SW0 F0 K1 0V 0V M2 BE1 M4 SW9 M5 0V CL1 0V ES1 ES2 24V BA TTERIES F7 M7 F8 M8 SW10 L1 0V chiude apre SW11 SW12 F1 F6 SW13 SW15 SW14 0V EB2 SW2 SW7 SW8 SW3 SW4 SW5 C1 F2 F3 F4 F5 0V BZ1 SW17 EB1 M1 R1 SW1 F9 0V 0V ES3 ES4 M3 0V BN RD WH BU OG BN VT PK OG BK RD RD RD RD RD RD OG RD OG OG YE BK YE OGBK RD BK WHBK GYBK GY BN BNBK RD RD WH VT ...

  • Nilfisk-ALTO R 580 B - page 22

    S310132 AG 4 3 1 2 5 6 70 BAR 110 BAR 200 BAR 200 BAR 750cc / HYDRAULIC OIL 32 cSt ...

  • Nilfisk-ALTO R 580 B - page 23

    S310121 S310122 S310124 S310037 S310125 S310192 S310039 S310126 M N O P R Q T U V S310128 S W X S310038 S310212 S310127 ...

  • Nilfisk-ALTO R 580 B - page 24

    2 1 1 1 1 2 1 5 6 4 3 8 7 Y S310214 Nilfi sk-AL TO HEADQUARTER HEADQUARTER DENMARK Nilfi sk-Advance Group Sognevej 25 2605 Brøndby Denmark T el: (+45) 43 23 81 00 SUBSIDIARIES AUSTRALIA Nilfi sk - AL TO 48 Egerton St. PO box 6046 Silverwater NSW 2128 Australia T el: (+61) 2 8748 5966 Fax: (+61) 2 8748 5960 AUSTRIA AL TO Österreich GmbH Nilfi ...

Manufacturer Nilfisk-ALTO Category Vacuum Cleaner

Documents that we receive from a manufacturer of a Nilfisk-ALTO R 580 B can be divided into several groups. They are, among others:
- Nilfisk-ALTO technical drawings
- R 580 B manuals
- Nilfisk-ALTO product data sheets
- information booklets
- or energy labels Nilfisk-ALTO R 580 B
All of them are important, but the most important information from the point of view of use of the device are in the user manual Nilfisk-ALTO R 580 B.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Nilfisk-ALTO R 580 B, service manual, brief instructions and user manuals Nilfisk-ALTO R 580 B. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Nilfisk-ALTO R 580 B.

Similar manuals

A complete manual for the device Nilfisk-ALTO R 580 B, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Nilfisk-ALTO R 580 B by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Nilfisk-ALTO R 580 B.

A complete Nilfisk-ALTO manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Nilfisk-ALTO R 580 B - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Nilfisk-ALTO R 580 B, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Nilfisk-ALTO R 580 B, that we can find in the current document
3. Tips how to use the basic functions of the device Nilfisk-ALTO R 580 B - which should help us in our first steps of using Nilfisk-ALTO R 580 B
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Nilfisk-ALTO R 580 B
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Nilfisk-ALTO R 580 B in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Nilfisk-ALTO R 580 B?

Use the form below

If you did not solve your problem by using a manual Nilfisk-ALTO R 580 B, ask a question using the form below. If a user had a similar problem with Nilfisk-ALTO R 580 B it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)