English dropdown-ico

Manual Harman Stove Company DVC-500

36 pages 3.11 mb
Download

Go to site of 36

Summary
  • Harman Stove Company DVC-500 - page 1

    R1                   ? ...

  • Harman Stove Company DVC-500 - page 2

    This appliance is also approved for installation into a shop.      5.5” X 7.5” adhesive backed metal label. LISTED SOLID FUEL BURNING ROOM HEA TER - MODEL: “DVC 500” BARCODE LABEL  Serial No. N o de s? ...

  • Harman Stove Company DVC-500 - page 3

    3  W arnings 4 Introduction 5 Assembly 6 Installation 7 Direct V ent Pipe 14 DVC500 Microprocessor Control 15 Operation 17 Maintenance 19 Fuel 23 Wiring Diagram 25 Control and Safety Sensors 26 Parts 27 Specications 30 T roubleshooting 31 Please read this entire manual before you install and use your new room heater . Failure to f ...

  • Harman Stove Company DVC-500 - page 4

    4                      ...

  • Harman Stove Company DVC-500 - page 5

    5 This remarkable design by Harman features the V erti-ow Direct V ent Stoker System. This unique, high efciency unit uses only outside air for combustion. Micro-processor controls provide for an automatic wid e ra nge of he at o utp ut f rom 7,0 00 t o 75, 000 BTU . With a big 93 pound hopper capacity , this unit can burn on high approximate ...

  • Harman Stove Company DVC-500 - page 6

    6 1. Install the hopper latch as shown at left. 2. Install 3 rebricks on the cast iron angle be- hind the grate as shown. 3. Cement in grates as shown below . This may already be done at the factory . 3 Bricks Grate Inserts g. 3  ...

  • Harman Stove Company DVC-500 - page 7

    7 4 GLASS RET AINER CLIPS 4 GLASS RET AINER BOL TS GLASS GLASS GASKET DOOR HINGE PINS P A W BOL T   The glass in your Harman stove is a special ceramic glass. • Do not abuse the glass by striking or slamming the door . • Never burn the appliance if the door glass is cracked or broken. • Replace only with ...

  • Harman Stove Company DVC-500 - page 8

    8 T ips On Installation Before the positioning of the unit can be decided a few questions should be considered? 1. Can the unit be vented properly and installed safely? 2. W ill exhaust be vented where fumes can build up or be drawn into lower levels of the structure 3. W ill fumes and y ash affect the exterior of the structure or surrounding st ...

  • Harman Stove Company DVC-500 - page 9

    9 8. Complete any other exterior ue piping necessary , using 4" pellet venting. 9. Back inside, place the 2 halves of the interior wall trim plate over ue pipe. Using the black pop rivets, fas te n toge the r , the n slid e it agai ns t the wal l and f ast en it to the wall. 10. Replace the side door / rear cover assembly with 6 black sc ...

  • Harman Stove Company DVC-500 - page 10

    10  ...

  • Harman Stove Company DVC-500 - page 11

    1 1  T o install a DVC 500 in a basement you will need additional DVC vent sections. These sections are made with a 316-grade stainless steel liner and a 20 gauge galvaneeled outer shell. Each joint is sealed with a gasket and is bolted together with 4 bolts. In order to maintain the ...

  • Harman Stove Company DVC-500 - page 12

    12  ...

  • Harman Stove Company DVC-500 - page 13

    13  ...

  • Harman Stove Company DVC-500 - page 14

    14 Exterior T ermination for wall thickness up to 8 inches 1-10-08310 Exterior T ermination for wall thickness up to 16 inches Exterior T ermination for wall thickness up to 12 inches 3-44-06256 1-10-08313 1-10-08314 1-10-08321 1-10-08317 1-10-08315 1-10-08316 1-10-08320 1-10-08319 1-10-08318 1-10-08322 1-10-08323 1-10-08324 1-10-08326 1-10-0831 1 ...

  • Harman Stove Company DVC-500 - page 15

    15 Feed Adjuster Sets the maximum feed rate, 1 to 5 T est Runs all motors at full speed for two minutes to check operation. After two minutes the feeder stops and the distribution blower alternates from high to low every four seconds to remind you that you are still in "T est Mode". Distribution Blower speed adjustment range. T emp Dial A ...

  • Harman Stove Company DVC-500 - page 16

    ESP Control Hopper Lid Latch Ash Door Latch Handle Glass Door Latch Handle Side Panel Latch ...

  • Harman Stove Company DVC-500 - page 17

    17   T urn the Feed Adjuster to "T est" mode, (g. 13.) This will cause all motors to run 100% for 2 minutes. The lights on the control panel will be lit for each motor . If you leave it on "test" the blowers will cycle as an audible reminder . ? ...

  • Harman Stove Company DVC-500 - page 18

    18 This setting will produce medium heat with the Distribution Blower on "low". Fig. 16   In "Stove T emp Mode" the control will regulate the re to match a constant exhaust temperature, based on the #1 thru 7 settings on the inner portion o ...

  • Harman Stove Company DVC-500 - page 19

    19                       ? ...

  • Harman Stove Company DVC-500 - page 20

    20     The small Fines T ray in the side of the stoker should be removed and emptied T o remove the Fines T ray , rst open the door on the left rear of the stove. Next, loosen the thumb screws holding the Fines T ray Cover , g# 20. Next, turn ...

  • Harman Stove Company DVC-500 - page 21

    21                      ? ...

  • Harman Stove Company DVC-500 - page 22

    22  1. Allow the stove to run out of coal in order to extinguish the re. This saves having to remove the coal from the hopper manually and most importantly , drives the moisture out of the stove that may be present in the coal. 2. Per for m al l th ...

  • Harman Stove Company DVC-500 - page 23

    23  Fuel The DVC500 is designed to burn Anthracite Rice Coal, which is approximately 3/8" long and wide by 3/16 thick. Anthracite coal is considered either White Ash or Red Ash. White Ash Coal will have 13 to 14,000 btu's per lb. White ash coal usually has less ash and will burn longer . Red Ash coal is usually about ...

  • Harman Stove Company DVC-500 - page 24

    24 The DVC500 grate system is composed of four pieces: the grate holder , (2)-63 hole grate inserts, and grate angle. The grate angle is bolted to the grate holder with (2) 3/8 x 1 1/4 bolts. Before installing the grate holder , 3/8" round gasket must be checked in the groove on the bottom side of the grate holder , as shown in Fig 31. Check t ...

  • Harman Stove Company DVC-500 - page 25

    25  It is recommended that End of Season Cleaning and the Annual Service are coordinated to happen at the same time for best results. BLACK BLACK -- 2.5 A. -- 300 W A T TS P ART NO. 3-89-08193 Rev A 120 VOL TS A.C. 60 HZ. HARMAN DIRECT VENT CO AL STOKER( DVC 500 C ) WIRING DIAGRAM BLACK 18 ...

  • Harman Stove Company DVC-500 - page 26

    26   Th e ES P (E xha us t Sens ing P rob e) is a tem pe rat ure sensing probe located in the exhaust outlet. The ESP works with the Control to perform all burn rate functions as well as high and low limit control.  The Room Senso ...

  • Harman Stove Company DVC-500 - page 27

     07/12   ? ...

  • Harman Stove Company DVC-500 - page 28

     07/12      IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacem ...

  • Harman Stove Company DVC-500 - page 29

     07/12 IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .     ...

  • Harman Stove Company DVC-500 - page 30

    30  Weight 500 Pounds BTU Output Range 7000 to 75,000 Heating Capacity 2200 Square Feet Fuel Anthracite Rice Coal Hopper Capacity 93 Pounds Distribution Blower Size 135 cfm Flue 4" Harman DVC V ent W attage 295 W atts Control ESP with Micro-processor Width 25 3 / 4 " Height 40 3 / 4 " Depth 29&q ...

  • Harman Stove Company DVC-500 - page 31

    31     The DVC-500 operates with a negative pressure rebox as a safety feature. The control continuou sly adjusts the draft motor speed t ...

  • Harman Stove Company DVC-500 - page 32

    32                      The DVC-500 operates with a negative pressure rebox as a safety feature. Any loss of this negative pressure will start the safety protocol, ( A two blink status warning ) The following lis ...

  • Harman Stove Company DVC-500 - page 33

    4021-645C 12-29-10 Page 1 of 2 Hearth & Home T echnologies Inc. LIMITED LIFETIME W ARRANTY Hearth & Home T echnologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer . W ARRANTY COVERAGE: HHT warr ...

  • Harman Stove Company DVC-500 - page 34

    4021-645C 12-29-10 Page 2 of 2 W ARRANTY CONDITIONS: • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor . A list of HHT authorized dealers is available on the HHT branded websites. • This warranty is only valid while the HHT appliance remains at the site of original installation. • Co ...

  • Harman Stove Company DVC-500 - page 35

    35  Date Of Service Performed By Description Of Service ...

  • Harman Stove Company DVC-500 - page 36

    Proudly P rinted On 100% Recycled P aper At Harman, we build each pr oduct to a standard, not a price. (Signatur e of Box er) Y our premium quality hearth pr oduct designed and assembled by the experienced and skilled members at Harman in Halifax, P A, USA. ...

Manufacturer Harman Stove Company Category Outdoor Fireplace

Documents that we receive from a manufacturer of a Harman Stove Company DVC-500 can be divided into several groups. They are, among others:
- Harman Stove Company technical drawings
- DVC-500 manuals
- Harman Stove Company product data sheets
- information booklets
- or energy labels Harman Stove Company DVC-500
All of them are important, but the most important information from the point of view of use of the device are in the user manual Harman Stove Company DVC-500.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Harman Stove Company DVC-500, service manual, brief instructions and user manuals Harman Stove Company DVC-500. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Harman Stove Company DVC-500.

Similar manuals

A complete manual for the device Harman Stove Company DVC-500, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Harman Stove Company DVC-500 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Harman Stove Company DVC-500.

A complete Harman Stove Company manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Harman Stove Company DVC-500 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Harman Stove Company DVC-500, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Harman Stove Company DVC-500, that we can find in the current document
3. Tips how to use the basic functions of the device Harman Stove Company DVC-500 - which should help us in our first steps of using Harman Stove Company DVC-500
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Harman Stove Company DVC-500
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Harman Stove Company DVC-500 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Harman Stove Company DVC-500?

Use the form below

If you did not solve your problem by using a manual Harman Stove Company DVC-500, ask a question using the form below. If a user had a similar problem with Harman Stove Company DVC-500 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)