English dropdown-ico

Manual Johnson Controls AV*(C) Series

18 pages 0.83 mb
Download

Go to site of 18

Summary
  • Johnson Controls AV*(C) Series - page 1

    536636-UIM-D-1211 SINGLE PIECE V ARIABLE SPEED AIR HANDLERS MODELS: A V*(C) SERIES INSTALLATION MANUAL ISO 9001 Certified Quality Management System LIST OF SECTIONS GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Johnson Controls AV*(C) Series - page 2

    536636-UIM-D-1211 2 Johnson Controls Unitary Products 1. Install this air handler only in a location and position as specified in SECTION III of these instructions. 2. Always install the air handler to operate within the air handler’s intended maximum outlet air t emperature. Only connect the air handler to a duct system which has an external sta ...

  • Johnson Controls AV*(C) Series - page 3

    536636-UIM-D-1211 Johnson Controls Unitary Produ cts 3 DOWNFL OW AND HORIZONT AL CONVERSION (A V ONL Y) These air handler units are supplied ready to be installed in a upflow and right hand horizontal position. If unit requires left hand positioning, the unit must have the coil assembly repositioned. 1. Remove blower , coil, and filter access panel ...

  • Johnson Controls AV*(C) Series - page 4

    536636-UIM-D-1211 4 Johnson Controls Unitary Products CLADDING CONFIGURA TION FOR DOWNF LO W INST ALLA TION (IF USED) T o reconfigure the cladding parts, remove the grille by pulling gently at the top. Once the grille is removed, the circuit breaker cover can also be removed. Remove the gray , non-brande d grille and circuit breaker cover from the ...

  • Johnson Controls AV*(C) Series - page 5

    536636-UIM-D-1211 Johnson Controls Unitary Produ cts 5 DUCT CONNECTIONS Air supply and return may be handled in one of several ways best suited to the installation. See Figure 3 for dimensions for duct inlet and outlet connections. The vast majority o f problems encountered with combin ation heating and cooling systems can be linked to improperly d ...

  • Johnson Controls AV*(C) Series - page 6

    536636-UIM-D-1211 6 Johnson Controls Unitary Products TXV METERING D EVICES If the model (C) numb er is of the following format: 4F , 4G , 4H, 4J, and 4K will have the coil with R410A TXV metering device installed at the factory . If the model (C) number is of the 3X model series: The coil will require an or ifice or R 410A TXV to be installed in t ...

  • Johnson Controls AV*(C) Series - page 7

    536636-UIM-D-1211 Johnson Controls Unitary Produ cts 7 DRAIN CONNECTIONS All drain lines should be trapped a minimum of three inches, should be pitched away from unit drain pan and should be no smaller than the coil drain connection. Route the drain line so that it does not interfere with accessibility to the coil, air handling system or filter and ...

  • Johnson Controls AV*(C) Series - page 8

    536636-UIM-D-1211 8 Johnson Controls Unitary Products CONVENTIONAL L OW V OL T AGE CONTROL WIRING (24 V AC) The 24 volt power supply is provi ded by an int ernally wired low voltage transformer which is standard on all model s, However, if the unit is con- nected to a 208 volt power supply , the low voltage transformer must be rewired to the 208 vo ...

  • Johnson Controls AV*(C) Series - page 9

    536636-UIM-D-1211 Johnson Controls Unitary Produ cts 9 . * Optional dehumidificat ion hu midistat switch cont acts open on humidit y rise. NOTES : 1. “Y/Y2” T erminal on air handler control board must be con nected for full CFM and appli cations requiring 60 second blower of f delay for SEER enhancement. 2. Remove humidistat jump er on air hand ...

  • Johnson Controls AV*(C) Series - page 10

    536636-UIM-D-1211 10 Johnson Controls Unitary Products The low voltage connections may be connected to the screw terminals or the quick connect terminals. T he screw terminals and t he quick con- nect terminals are phy sically connected o n the control board. SECTION VI: REQUIRED CONTROL SET -UP 1. Consult system wiring diagram to de termine proper ...

  • Johnson Controls AV*(C) Series - page 11

    536636-UIM-D-1211 Johnson Controls Unitary Produ cts 11 The control energizes the fir st stage of electric heat immediately , the second stage 10 seconds after the call for second st age heat, and the third stage 20 seconds after the call for third stage heat. Depending on the heat kit installed in the air handler , the control pro- vides the flexi ...

  • Johnson Controls AV*(C) Series - page 12

    536636-UIM-D-1211 12 Johnson Controls Unitary Products SECTION VIII: AIRFLO W AND COMFORT SETTING SELECTION AIRFLOW SELECTION The airflow and comfort setting se lection jumpers must be set properly at the time of installation for proper system operation. Place jumpers in the proper locations based on the information show n in T able 16 and Figure 1 ...

  • Johnson Controls AV*(C) Series - page 13

    536636-UIM-D-1211 Johnson Controls Unitary Produ cts 13 * May be 0 (no breaker) or 1 (with breaker). TA B L E 8 : Elect rical Data - Cool ing Only (60 Hz) Models T otal Motor Amp s Minimum Circuit Ampacity Max. O.C.P . Amps/T ype 1 Minimum Wire Size A.W .G . 60 Hertz 60 Hertz 208V 230V 208V 230V 24B 3.2 2.8 4.0 3.5 15 14 36C 4.7 4.3 5.9 5.4 15 14 4 ...

  • Johnson Controls AV*(C) Series - page 14

    536636-UIM-D-1211 14 Johnson Controls Unitary Products * May be 0 (no breaker) or 1 (with breaker). TA B L E 11 : Electrical Data - (For Single Source Power Supply) - Copper W ire - 208/23 0-1-60 Models Heater Models* Heater Amps 240V Field Wiring Min. Circuit Ampacity Max. O.C.P . Amps/T ype 1 75 ° C Wire Size - A WG 208V 230V 208V 230V 208V 230V ...

  • Johnson Controls AV*(C) Series - page 15

    536636-UIM-D-1211 Johnson Controls Unitary Produ cts 15 T ABLE 13: Electrical Data - 208/230-3 -60 Models Heat Kit - Three Phase Max. Stat ic Min. Spe ed Ta p To t a l H e a t 1 kW S taging kW MBH W1 Only W2 Only W1 + W2 208V 230V 208V 230V 208V 230V 208V 230V 208V 230V 24B 4HK06501025 0.5 Heat-B 7.2 9.6 24.6 32.8 7.2 9.6 7.2 9.6 7.2 9.6 36C 4HK065 ...

  • Johnson Controls AV*(C) Series - page 16

    536636-UIM-D-1211 16 Johnson Controls Unitary Products T ABLE 16: Air Handler Air Flow Data HIGH/LOW SPEED COOLING AND HEA T PUMP AIRFLOW CFM m 3 /min JUMPER SETTINGS 24B 36C 24B 36C High Low High Low High Low High Low COOL T ap ADJ T ap 1088 707 1387 905 30.8 20.0 39.3 25.6 A B 830 542 1 151 753 23. 5 15.3 32.6 21.3 B B 948 617 1201 783 26.8 17.5 ...

  • Johnson Controls AV*(C) Series - page 17

    536636-UIM-D-1211 Johnson Controls Unitary Produ cts 17 SECTION X: MAINTENANCE Filters must be cleaned or replaced when they become dirty . Inspect at least once per month. Th e frequency of cleaning depends upon the hours of operation and the local atmospheric conditions. Clean filters keep unit efficiency high. COIL CLEANING If the coil needs to ...

  • Johnson Controls AV*(C) Series - page 18

    Subject to change without not ice. Published in U.S.A. 536636-UIM-D-1211 Copyright © 201 1 by Johnson Controls, In c. All ri ghts reserved. Supersedes: 536636-UIM-C-1010 Johnson Contro ls Unit a r y Prod uct s 5005 Y ork Drive Norman, OK 73069 SECTION XI: WIRING DIA GRAM FIGURE 16: Wiring Diagram ...

Manufacturer Johnson Controls Category Humidifier

Documents that we receive from a manufacturer of a Johnson Controls AV*(C) Series can be divided into several groups. They are, among others:
- Johnson Controls technical drawings
- AV*(C) Series manuals
- Johnson Controls product data sheets
- information booklets
- or energy labels Johnson Controls AV*(C) Series
All of them are important, but the most important information from the point of view of use of the device are in the user manual Johnson Controls AV*(C) Series.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Johnson Controls AV*(C) Series, service manual, brief instructions and user manuals Johnson Controls AV*(C) Series. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Johnson Controls AV*(C) Series.

Similar manuals

A complete manual for the device Johnson Controls AV*(C) Series, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Johnson Controls AV*(C) Series by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Johnson Controls AV*(C) Series.

A complete Johnson Controls manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Johnson Controls AV*(C) Series - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Johnson Controls AV*(C) Series, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Johnson Controls AV*(C) Series, that we can find in the current document
3. Tips how to use the basic functions of the device Johnson Controls AV*(C) Series - which should help us in our first steps of using Johnson Controls AV*(C) Series
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Johnson Controls AV*(C) Series
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Johnson Controls AV*(C) Series in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Johnson Controls AV*(C) Series?

Use the form below

If you did not solve your problem by using a manual Johnson Controls AV*(C) Series, ask a question using the form below. If a user had a similar problem with Johnson Controls AV*(C) Series it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)