English dropdown-ico

Manual Toastmaster MBT208

16 pages 1 mb
Download

Go to site of 16

Summary
  • Toastmaster MBT208 - page 1

    1 BATCH TOASTER Models MBT208/MBT240 Place this chapter in the Toaster Section of your Equipment Manual . MANUFACTURED EXCLUSIVELY FOR M C DONALDS ® BY TOASTMASTER ® A Middleby Company 1400 Toastmaster Drive Elgin, IL 60120 PHONE: 1 (847) 741-3300 FAX: 1 (847) 741-4406 24-hour Service Hotline: 1 (800) 238-8444 TABLE OF CONTENTS WARRANTY STATEM ...

  • Toastmaster MBT208 - page 2

    2 INTRODUCTION Batch Toaster Information The Model MBT208/MBT240 Batch Toaster is a com- mercial batch toaster designed to uniformly toast En- glish muffins, bagels, and other bakery products in large quantities. Up to six individual program settings can be selected and programmed to toast a wide vari- ety of bakery products. About This Manual Reta ...

  • Toastmaster MBT208 - page 3

    3 SPECIFICATIONS Overall Dimensions Width 17-1/2 (445mm) Depth (inc. rear cord clearance, peel removed) 28 (711mm) Depth (inc. rear cord clearance, peel in toaster) 32 (813mm) Height (inc. legs) 10-1/2 (267mm) Toasting Area Dimensions Width, Loading Area of Peel 11-1/4 (286mm) Length, Loading Area of Peel 16-1/2 (419mm) Vertical C ...

  • Toastmaster MBT208 - page 4

    4 IMPORTANT It is the customers responsibility to report any con- cealed or non-concealed damage to the freight com- pany. IMPORTANT The Batch Toaster may only be installed in a single- unit, countertop configuration. Assembly 1. Pull the door handle up and forward to open the door. Then, remove all components from inside the toaster. 2. Remove ...

  • Toastmaster MBT208 - page 5

    5 2. Check that the appropriate receptacle is available for the power cord plug. 3. Insert the power cord plug into its receptacle. 4. If required by national or local codes, connect an equipotential ground wire to the lug next to the symbol (shown in Figure 3). The equipotential ground connection must meet all applicable na- tional and local code ...

  • Toastmaster MBT208 - page 6

    6 CAUTION - HOT SURFACES DURING OPERATION, THE PEEL AND TOASTER ARE HOT. USE CAUTION AS YOU HANDLE THE PEEL AND OPERATE THE TOASTER TO AVOID INJURY. Setup 1. Replace the lower deck inside the toaster. 2. Switch the circuit breaker/fused disconnect to the ON (I) position. 3. Switch the switch to the ON (I) position. The display will flas ...

  • Toastmaster MBT208 - page 7

    7 Programming The Batch Toaster is pre-programmed with standard menu programs at the factory. Perform the following steps ONLY if you wish to change a programs settings. IMPORTANT Programming a new menu program will OVERWRITE an existing program. Do not overwrite a program that you wish to keep! Refer to Figure 5 for an illustration of the contr ...

  • Toastmaster MBT208 - page 8

    8 Close 1. Switch the switch to the OFF (O) position. The fan will remain in operation to allow the toaster to cool. 2. After the fan stops, switch the circuit breaker/fused disconnect to the OFF (O) position. 3. Cleaning the Peel and Lower Deck CAUTION - HOT SURFACES DO NOT TOUCH HOT SURFACES ON THE TOASTER. DO NOT REACH INTO THE TOAST ...

  • Toastmaster MBT208 - page 9

    9 TROUBLESHOOTING PROBLEM Product is toasted too dark or too light. PROBABLE CAUSE Toaster was not adequately preheated. Preset toasting time is incor- rect. Using refrigerated or frozen bakery products. CORRECTIVE ACTION Allow toaster to preheat until (ready) ap- pears in the display. This should occur about 15 minutes after electrical power is re ...

  • Toastmaster MBT208 - page 10

    10 PARTS IDENTIFICATION AND FUNCTION 37 38 5 7 6 9 29 28 10 8 28 25 28 22 24 16 17 36 36 20 19 35 36 36 32 12 13 21 31 2 30 28 24 23 41 11 27 40 39 30 14 1 26 15 18 3 34 33 4 28 28 42 ...

  • Toastmaster MBT208 - page 11

    11 Parts List 1 41706 1 PANEL, LEFT SIDE 2 39806 1 PANEL, RIGHT SIDE 3 32458 1 PANEL, REAR 4 41902 1 PANEL, SSR MOUNTING 5 39804 1 LOWER DECK 6 42482 1 CONTROL PANEL 7 41837 1 DECAL, CONTROL PANEL 8 41733 1 TIMER BOARD 9 35824 1 SWITCH, POWER ON/OFF 2-POLE 10 43161 4 LEG, 1-1/2 (38mm) 11 41805 1 HINGE, DOOR 12 41806 1 DOOR 13 41807 1 HANDLE, DOO ...

  • Toastmaster MBT208 - page 12

    12 ORDERING AND SERVICE INFORMATION Ordering Parts Use only genuine Toastmaster (manufacturer) replacement parts in your toaster. Use of parts other than those supplied or approved by Toastmaster will void the toasters warranty and agency approval. If your toaster requires a replacement part, locate the part in the drawing in the Parts Identific ...

  • Toastmaster MBT208 - page 13

    13 NOTES ...

  • Toastmaster MBT208 - page 14

    14 ELECTRICAL WIRING DIAGRAM TERMINAL BLOCK TSTAT NC HI LIMIT TSTAT NO COOL DN FAN CONTACTOR POWER ON/OFF (I/O) SWITCH HEATING ELEMENTS TRANSFORMER 230Vp : 24Vs TIMER BOARD AC IN R 3 R 2 R 1 12V+ + - + - + - RELAY 1 RELAY 2 RELAY 3 12 34 56 78 9 1 0 1 1 1 2 Wiring Diagram Notes:  Capacitor and resistor inside dashed box are used ONLY on Eu ...

  • Toastmaster MBT208 - page 15

    15 L1 (X) L2 (Y) FAN C TSTAT NO COOL DOWN TSTAT NC HIGH LIMIT POWER ON/OFF (I/O) SWITCH 2 POLE TFRMR 230Vp:24Vs C2 C1 +12V R1 R2 R3 TIMER BOARD SSR 1 SSR 2 SSR 3 HEATING ELEMENTS HEATING ELEMENTS HEATING ELEMENTS GND (E) Schematic Notes:  Capacitor and resistor inside dashed box are used ONLY on European MBT240 SEE NOTE BELOW ELECTRICAL SC ...

  • Toastmaster MBT208 - page 16

    16 Toastmaster  1400 Toastmaster Drive  Elgin, IL 60120  USA  (847)741-3300  FAX (847)741-4406 Middleby Corp 24-Hour Service Hotline 1-800-238-8444 www.middleby.com A Middleby Company ...

Manufacturer Toastmaster Category Toaster

Documents that we receive from a manufacturer of a Toastmaster MBT208 can be divided into several groups. They are, among others:
- Toastmaster technical drawings
- MBT208 manuals
- Toastmaster product data sheets
- information booklets
- or energy labels Toastmaster MBT208
All of them are important, but the most important information from the point of view of use of the device are in the user manual Toastmaster MBT208.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Toastmaster MBT208, service manual, brief instructions and user manuals Toastmaster MBT208. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Toastmaster MBT208.

Similar manuals

A complete manual for the device Toastmaster MBT208, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Toastmaster MBT208 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Toastmaster MBT208.

A complete Toastmaster manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Toastmaster MBT208 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Toastmaster MBT208, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Toastmaster MBT208, that we can find in the current document
3. Tips how to use the basic functions of the device Toastmaster MBT208 - which should help us in our first steps of using Toastmaster MBT208
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Toastmaster MBT208
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Toastmaster MBT208 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Toastmaster MBT208?

Use the form below

If you did not solve your problem by using a manual Toastmaster MBT208, ask a question using the form below. If a user had a similar problem with Toastmaster MBT208 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)