English dropdown-ico

Manual United States Stove 6039I

32 pages 3.02 mb
Download

Go to site of 32

Summary
  • United States Stove 6039I - page 1

    USSC 1 851621E MUL TIFUEL ST OVE 6039, 6039I, 6039T OWNER’S MANUAL Installation - Operation - Maintenance Instructions - Repair Parts READ THIS ENTIRE MANUAL , THOROUGHL Y , BEFORE A T TEMPTING T O INST ALL AND/OR BURN YOUR NEW AMERICAN HARVEST CORN AND PELLET MUL TI-FUEL ST OVE. F AILURE T O FOLLOW THESE INSTRUCTIONS MA Y RESUL T IN PROPERTY DAM ...

  • United States Stove 6039I - page 2

    2 USSC Heat Input, Maximum 52,200 BTU/HR Heat Output, Maximum , , , , , 48,280 BTU/HR Heating Capacity 1,200 Sq. Ft 0 Fuel Storage Capacity 60 Lbs. Width 29 in./737mm Height 31 in./787mm 24 in./610mm Depth 28 in./711mm SPECIFICATIONS United States Stove Company ( manufacturer of the American Harvest Multifuel Stove ) reserves the right to alter pro ...

  • United States Stove 6039I - page 3

    USSC 3 ASSEMBLY Assembly 1. Unpack unit and make sure all components are included; (4) Legs, and all hardware for installation. 2. Fold the corner padding from the carton and lay it on the floor behind the unit. This is used to hold the heater up off the floor to install the legs. Gently tilt the heater on its back, door opening up. 3. Assemble the ...

  • United States Stove 6039I - page 4

    4 USSC 6039I ASSEMBLY For the following assemblies, we suggest locating the unit near it’s desired location. Depending on installation, you may want to connect the exhaust venting before installing the facade parts. Assembly - Facade (Surround) Remove contents from packaging and make sure you have all components: (2) T op F acade (a) (1) Left Sid ...

  • United States Stove 6039I - page 5

    USSC 5 COMPONENT LOCATION ...

  • United States Stove 6039I - page 6

    6 USSC Ashes will have to be removed from the stove for proper operation. See cleaning procedure. Y our American Harvest sto v e, due to the natur e of sol id f uels, wi l l r equir e brief periodic at tention. Please do not expect to light your stove and walk away from it. A few moments of adjustment and cleaning is an important part of burning so ...

  • United States Stove 6039I - page 7

    USSC 7 FLOOR PROTECTION The American Harvest Multifuel Stove may be installed on a combustible floor , with proper floor protection, or on a masonry hearth. The hearth or noncombustible floor protector must extend a minimum of (6) inches (152mm)in front and (6) inches (152mm) from each side of the unit. INSTALLATION REQUIREMENTS SHELLED CORN (Dry , ...

  • United States Stove 6039I - page 8

    8 USSC CLEARANCES TO COMBUSTIBLES 6039(T) The stove must be installed with the following minimum clearances to side and back wall combustible materials. NOTE: These are minimum clearances to combustible walls established by the testing lab. PARALLEL - A - Sidewall to T op Edge of Unit 8 in./203mm B - Sidewall to Flue 13 in./330mm C - Backwall to Fl ...

  • United States Stove 6039I - page 9

    USSC 9 CLEARANCES TO COMBUSTIBLES 6039I ...

  • United States Stove 6039I - page 10

    10 USSC GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN • • • • • • • • A UL listed 3” or 4” type “PL ” pellet vent exhaust system must be used for installation and attached to the pipe connector provided on the back of the stove. Use a 3” to 4” adapter for 4” pipe. A cap must be used at the termination of t ype “L ” ...

  • United States Stove 6039I - page 11

    USSC 11 For installations with horizontal through-the-wall exhaust, it is strongly recommended that the stove combustion air be connected to the outside. If the home is newer or has been tightly insulated, it is required to install outside combustion air . Connection to outside the house is REQUIRED for mobile home installations. W e strongly urge ...

  • United States Stove 6039I - page 12

    12 USSC Note: Where passage through a wall, or partition of combustible construction is desired, the installation shall conform to CAN/CSA -B365 The American Harvest Multifuel Stove Model 6039/6039T may be installed as follows: 1) A freestanding unit The American Harvest Multifuel Stove Model 6039I insert may be installed as follows: 1) In a pr e-f ...

  • United States Stove 6039I - page 13

    USSC 13 3" PL Vent (12" Long) Inner Wall Thimble Outer Wall Thim ble 3" PL Vent (12" Long) 3" PL Tee w/ Cleanou t 3" PL Vent (12" Long) 3" PL Ve nt 90° Elbow 3" PL Vent Termination Cap Note: Always check dimensions on unit before cutting hole in wall 3’ Minimum V ertical Pipe Dimensional tolerance ±1 ...

  • United States Stove 6039I - page 14

    14 USSC THROUGH THE WALL, VERTICAL PIPE INSTALLATION WITH TERMINATION CAP The Hearth Pad is not required under the unit if the floor is noncombustible but is required 6 inches (152mm) beyond the front of the unit and 6 inches (152mm) bey ond each side of the door if the floor is a combustble floor . wood flooring, carpet, linoleum, etc. ...

  • United States Stove 6039I - page 15

    USSC 15 DESIGN GUIDELINES FOR 6039I INSERT INSTALLATION INSTALLATION AS A BUILT-IN FIREPLACE A continuous sheet of non-combustible floor protection must be installed underneath the unit to prevent the possibility of embers falling through to the combustible floor . If the floor beneath the unit is of non-combustible material, the protector i s not ...

  • United States Stove 6039I - page 16

    16 USSC DESIGN GUIDELINES FOR 6039I INSERT INSTALLATION INSTALLATION INTO A MASONRY FIREPLACE When installing into a masonry fireplace, DO NOT remove an y bricks or masonry , with the following exception: masonry or steel, including the damper plate, may be removed from the smoke shelf and adjacent damper fr ame, if necessary , to accom- modate a c ...

  • United States Stove 6039I - page 17

    USSC 17 Y our American Harvest Multifuel Stove comes to you wi th the glass door instal led in place, ready f or use. The glass is surrounded on the edges with a gasket and seated in a glass channel. It is held in place with two (2) clips. REMOVAL OF BROKEN OR DAMAGED CERAMIC GLASS Open the door and lift off of hinges. If the door is tight, tap gen ...

  • United States Stove 6039I - page 18

    18 USSC UNDERSTANDING THE CONTROL BOARD CONTROL PANEL T urning the heater OFF/ON, as well as adjustments for the fuel feed rate and room fan speed are performed by pressing the appropriate button(s) on the control panel which is located on the lower left-hand side of your American Harvest heater. The insert model 6039I is located on the left facade ...

  • United States Stove 6039I - page 19

    USSC 19 LIGHTING INSTRUCTIONS CAUTION: DO NOT USE CHEMICALS OR FLUIDS T O ST ART THE FIRE HOT WHILE IN OPERA TION. KEEP CHILDREN, CLO THING AND FURNITURE AW AY . CONT ACT MA Y CAUSE SKIN BURNS. Before lighting your heater for the first time, make sure that all items are out of the hopper, ash pan and firebox area. Press the “On” button and allo ...

  • United States Stove 6039I - page 20

    20 USSC SPECIAL CLEANING/OPERATIONAL INSTRUCTIONS: After cleaning or when operating the stove, you need to make sure that “both” clean-outs are in their proper position. If left out or placed incor- rectly , the combustion air is eff ected greatly and the stove will not burn properly . Also, make sure that the ash dumps on each side of the damp ...

  • United States Stove 6039I - page 21

    USSC 21 FUEL ADDITIVE Chicken Scratch for my Corn Burner? Y es - Crazy as it may sound, ground Oyster Shells, (calcium carbonate) same as fed to chickens, is the ideal additiv e to promote clean burning, especially when the Corn Fuel is extra high in starch. And it’s available at your local Feed and Seed. The “aver age” mixture is 1/2 pound o ...

  • United States Stove 6039I - page 22

    22 USSC CIRCUIT BOARD FUNCTIONS Draft Fan Agitator Auger Room Fan Automatic Shutdown Normal Operation COMPONENT OPERA TION ST ART OPERA TION END ST ART -UP SEQUENCE OF EVENTS Once the control panel is turned to on, a timer begins that will start, stop and continue operation of the American Harvest as a preset temperature is achieved. S tarts Immedi ...

  • United States Stove 6039I - page 23

    USSC 23 ERROR CODES and DISPLAY INDICATORS CAUTION: When performing any internal electrical maintenance • Moving parts inside of the cabinet may cause injury . Do not oper ate unit with panels remov ed or open. • HOT parts. Do not operate the unit with panel open. • Risk of electric shock. Disconnect power before servicing unit. • In the ev ...

  • United States Stove 6039I - page 24

    24 USSC TROUBLE SHOOTING NOTE: Negative pressure in a home is a serious issue. All American Harvest appliances should be installed with the optional fresh air kit (69F AK). Unplug stove before performing any maintenance PROBLEM CAUSE: T oo rich air/fuel mixture ? Fire burns with a lazy , orange flame and/or fuel builds up in the firepot. Glass may ...

  • United States Stove 6039I - page 25

    USSC 25 WIRING DIAGRAM ...

  • United States Stove 6039I - page 26

    26 USSC REPAIR PARTS DIAGRAM-6039 ...

  • United States Stove 6039I - page 27

    USSC 27 K EY PAR T # DESCRIPTION QTY. 1 69516 Feed Door Assembly 1 2 25080MB Latch, Door 1 3 25409MB Pedestal (6039) 1 4 69508MB Pedestal Bottom Weldment (6039) 1 5 25451MB Pedestal Back (6039) 1 6 69478MB Ash Pan Weldment (6039) 1 7 891138 Handle, Brass 1 8 25493 Corner , T rim (6039) 2 9 25468MB P edestal T rim, Front (6039) 1 10 25471MB P edesta ...

  • United States Stove 6039I - page 28

    28 USSC 22 23 20 21 24 25 26 27 18 17 7 6 3 4 6 5 11 10 2 9 8 10 15 14 16 12 13 19 23 1 28 29 REPAIR PARTS-6039I ...

  • United States Stove 6039I - page 29

    USSC 29 K EY PA RT # DESCRIPTION QTY. 1 891373 Pad, Door Hinge(Threaded) 2 2 69547MB Weldment, Sub-Base 1 3 25569 Bracket, Caster 2 4 891424 Caster , Plastic 2 5 83412 1/4-20 x 1-1/2 Hex Bolt 2 6 83136 Washer 4 7 83261 1/4-20 Lock Nut 2 8 69548MB Weldment, Ash Pan 1 9 891137 Handle, Brushed Nickel 1 10 25570MB F acade, B ottom 2 11 83479 Leveler 2 ...

  • United States Stove 6039I - page 30

    30 USSC K e y Part No. Descritption Qty. 1 25523 Leg, Cast Iron 4 1 a 891216 Leg, Steel (alternate to item 1) - 2 25425 Guide Rail, Ash Pan 2 3 69483B Ash Pan Weldment 1 4 891138 Handle, Brass 1 1 3 2 4 5 6 7 9 10 8 11 2 3 1 6 4 5 K e y Part No. Descritption Qty. 7 83278 #10 Flat Washer 4 8 25465 R etainer , Bottom Glass 1 9 25464 R etainer , T op ...

  • United States Stove 6039I - page 31

    USSC 31 Notes ...

  • United States Stove 6039I - page 32

    32 USSC THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPEND- ABLE SERVICE FROM YOUR AMERICAN HARVEST, AND EN- ABLE YOU TO ORDER REPAIR PARTS CORRECTLY. KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFER- ENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE ...

Manufacturer United States Stove Category Stove

Documents that we receive from a manufacturer of a United States Stove 6039I can be divided into several groups. They are, among others:
- United States Stove technical drawings
- 6039I manuals
- United States Stove product data sheets
- information booklets
- or energy labels United States Stove 6039I
All of them are important, but the most important information from the point of view of use of the device are in the user manual United States Stove 6039I.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals United States Stove 6039I, service manual, brief instructions and user manuals United States Stove 6039I. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product United States Stove 6039I.

Similar manuals

A complete manual for the device United States Stove 6039I, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use United States Stove 6039I by users. Manuals are usually written by a technical writer, but in a language understandable to all users of United States Stove 6039I.

A complete United States Stove manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual United States Stove 6039I - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the United States Stove 6039I, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the United States Stove 6039I, that we can find in the current document
3. Tips how to use the basic functions of the device United States Stove 6039I - which should help us in our first steps of using United States Stove 6039I
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with United States Stove 6039I
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of United States Stove 6039I in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning United States Stove 6039I?

Use the form below

If you did not solve your problem by using a manual United States Stove 6039I, ask a question using the form below. If a user had a similar problem with United States Stove 6039I it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)