English dropdown-ico

Manual Hatco GRAHL

28 pages 0.56 mb
Download

Go to site of 28

Summary
  • Hatco GRAHL - page 1

    GLO-RA Y ® Infrared S trip Heaters GR, GRH, GRA, GRAH, GRAL, GRAHL, GRN & GRNH Series Inst allation & Operating Manual I&W #07.05.183.00 This manual contains import ant safety information concerning the maintenance, use and operation of this product. Failure to follow the instructions contained in this manual may result in serious inju ...

  • Hatco GRAHL - page 2

    Form No. GRM-0707 i CONTENTS INTRODUCTION Hatco Glo-Ray ® S trip Heaters ensure maximum food holding and minimize the risk of food-borne illness. Optimum safety and quality is the result of food held at the proper serving temperatures, using Glo-Ray’s pre-focused heat p atterns. The pre- focused heat pattern prevent s foods from being over-cooke ...

  • Hatco GRAHL - page 3

    Form No. GRM-0707 1 IMPORT ANT SAFETY INFORMA TION W ARNINGS Only light bulbs which meet or exceed NSF st andards, specifically designed for food holding areas may be used. Breakage of light bulbs not specially coated could result in personal injury and/or food cont amination. Unit s equipped with a cord and plug supplied by Hatco must be plugged i ...

  • Hatco GRAHL - page 4

    Form No. GRM-0707 2 IMPORT ANT SAFETY INFORMA TION MODEL DESIGNA TION CAUTIONS St andard and approved manufacturing oils will smoke up to 30 minutes during initial st art-up. This is a temporary condition. T o assure safe operation, operate unit without food product until smoke dissip ates. Some exterior surfaces on the unit will get hot. Use cauti ...

  • Hatco GRAHL - page 5

    Hatco Glo-Ray ® Infrared S trip Heater keep hot foods at optimum serving temperatures longer . Foods do not dry out or become discolored; even the most delicate dishes hold that “just-prepared” look. The Glo-Ray pre-focused heat pattern direct s heat from a tubular element to bathe the entire holding surface. Hatco Glo-Ray ® S trip Heater can ...

  • Hatco GRAHL - page 6

    Form No. GRM-0707 4 SPECIFICA TIONS GR MODELS-ELECTRICAL RA TING CHART GRH MODELS-ELECTRICAL RA TING CHART The electrical information in the shaded area pertains to Export Models only . * Not available in 100 or 120 volts.  CE approved units for 220-230 volt utilize a 220 volt heating system; 230-240 CE units utilize a 240 volt heating system. ? ...

  • Hatco GRAHL - page 7

    Form No. GRM-0707 5 SPECIFICA TIONS GRA MODELS-ELECTRICAL RA TING CHART GRAH MODELS-ELECTRICAL RA TING CHART The electrical information in the shaded area pertains to Export Models only . • 100 and 120 volt models with infinite switch require tandem (end-to-end) elements, consult factory for applications. † Glo-Ray models 108" through 144& ...

  • Hatco GRAHL - page 8

    Form No. GRM-0707 6 SPECIFICA TIONS GRAL MODELS-ELECTRICAL RA TING CHART GRAHL MODELS-ELECTRICAL RA TING CHART                                                       The electrical informat ...

  • Hatco GRAHL - page 9

    Form No. GRM-0707 7 SPECIFICA TIONS GRA-XXD MODELS- ELECTRICAL RA TING CHART GRAH-XXD MODELS- ELECTRICAL RA TING CHART The electrical information in the shaded area pertains to Export Models only . • 100 and 120 volt models with infinite switch may require tandem (end-to-end) elements, consult factory for applications. † Glo-Ray models 108" ...

  • Hatco GRAHL - page 10

    Form No. GRM-0707 8 SPECIFICA TIONS GRAL-XXD MODELS- ELECTRICAL RA TING CHART GRAHL-XXD MODELS- ELECTRICAL RA TING CHART                                     The electrical information in the shaded area pertains to Export Models only . • 10 ...

  • Hatco GRAHL - page 11

    Form No. GRM-0707 9 SPECIFICA TIONS * 120 volt models not available for use with remote infinite switches. The electrical information in the shaded area pertains to Export Models only . GRN MODELS-ELECTRICAL RA TING CHART GRNH MODELS-ELECTRICAL RA TING CHART                        ...

  • Hatco GRAHL - page 12

    Form No. GRM-0707 10 SPECIFICA TIONS DIMENSIONS Figure 6. Dimensions–GR, GRH, GRA & GRAH Models Figure 7. Dimensions–GRAL & GRAHL Models Wid th Depth Depth Height Models (A) (B) (C) (D) GRAL & 18" - 144" 9" 26" 2-1/2" GRAHL (457 - 3658 mm) (229 mm) (660 mm) (64 mm) Wid th Depth Depth Height Models (A) (B) (C ...

  • Hatco GRAHL - page 13

    Form No. GRM-0707 11 INST ALLA TION UNP ACKING 1. Remove the unit from the carton and remove all packing materials. 2. Remove information packet. T o prevent delay in obt aining warranty coverage, fill out and mail in warranty card . NOTE: If unit is equipped with optional equipment, see ACCESSORIES section at back of this manual. LOCA TION W ARNIN ...

  • Hatco GRAHL - page 14

    Form No. GRM-0707 12 INST ALLA TION Figure 10. Recommended Element Height for the GR, GRA, GRH, GRN, GRAH, GRAL, GRNH, and GRAHL in all lengths (excluding dual models). 1 1"-14" (279-356 mm) 15" (381 mm) Under Shelf Mounting When mounting unit under a shelf, use adjustable angle brackets to assure proper sp acing. Remote control encl ...

  • Hatco GRAHL - page 15

    Form No. GRM-0707 13 INST ALLA TION ASSEMBL Y Glo-Ray ® S trip Heaters are shipped with most components pre-assembled. Dual unit s are available with a required 3" (76 mm) or 6" (152 mm) spacer pre-assembled at the factory . Optional breath protectors, mounting equipment and remote control enclosures must be installed on location. PORT A ...

  • Hatco GRAHL - page 16

    Form No. GRM-0707 14 INST ALLA TION PERMANENT SURF ACE MOUNT T ubular St and Mounting T ubular stand mounting permanently attaches the unit to a countertop or serving table. All wiring may be concealed within the tubular stand. T ubular stands are available in non-adjustable heights from 10"-16" (254-406 mm) or in adjust able heights from ...

  • Hatco GRAHL - page 17

    Form No. GRM-0707 15 INST ALLA TION Figure 16. Adjustable Angle Bracket Mounting UNDERSHELF MOUNTING Pass Thru NOTE: When mounting the unit under a shelf, it is recommended to use a remote switch enclosure. If the shelf has a rolled or flanged edge, use the optional adjustable angle bracket s to mount the unit below the lowest part of the rolled or ...

  • Hatco GRAHL - page 18

    Form No. GRM-0707 16 INST ALLA TION Figure 18. Combustible S pacing Requirements Models (A) (B) (C) GRA & 10" 3" 1" GRAL (254 mm) (76 mm) (25 mm) GRAH & 13-1/2" 3" 1" GRAHL (343 mm) (76 mm) (25 mm) A B C Figure 19. Non-Combustible S pacing Requirements A B C Pass Through Shelf Back W all Counter Pass Through Sh ...

  • Hatco GRAHL - page 19

    Form No. GRM-0707 17 INST ALLA TION Figure 20. Mounting with Chains CEILING MOUNTING Chain Mounting W ARNING T o avoid any injury or damage to the unit when using chains for inst allation, the chains must have sufficient strength and be securely fastened, or the unit could become loose or fall. Do not place anything on top of warmers supported by c ...

  • Hatco GRAHL - page 20

    Form No. GRM-0707 18 INST ALLA TION ELECTRICAL WIRING HOOK-UP Refer to the ELECTRICAL RA TING CHARTS for specific information. NOTE: If the unit being installed is not shown or listed in this manual refer to the wiring diagram supplied and installation information on the unit for further instruction. W ARNING T o avoid any injury or damage all elec ...

  • Hatco GRAHL - page 21

    Form No. GRM-0707 19 INST ALLA TION OPERA TION Figure 23. Remote Control Box (RMB) (RMB-7 Series Shown) CAUTION Some exterior surfaces on the unit will get hot. Use caution when touching these areas to avoid injury . W ARNING The unit is not waterproof. DO NOT submerge in water . Do not operate if it has been submerged in water . CAUTION St andard ...

  • Hatco GRAHL - page 22

    Form No. GRM-0707 20 MAINTENANCE CLEANING Hatco Glo-Ray ® S trip Heater units are designed for maximum durability and performance, with minimum maintenance. W ARNING T o avoid any injury or damage to the strip heater turn the power OFF at the disconnect switch/circuit breaker and allow to cool before performing any maintenance. T o preserve the fi ...

  • Hatco GRAHL - page 23

    Wid th Depth Height Width Models (A) (B) (C) (D) RMB-3 Series 5-1/2" 3" 2-1/2" 7" (140 mm) (76 mm) (64 mm) (178 mm) RMB-7 Series 9" 3" 2-1/2" 10-1/2" (229 mm) (76 mm) (64 mm) (267 mm) RMB-14 Series 14" 3" 2-1/2" 15-1/2" (356 mm) (76 mm) (64 mm) (394 mm) RMB-16 Series 16" 3" 2-1/2 ...

  • Hatco GRAHL - page 24

    Form No. GRM-0707 22 TROUBLESHOOTING GUIDE W ARNING T o avoid any injury or damage the strip heater must only be serviced by qualified personnel. W ARNING T o avoid any injury or damage to the strip heater turn the power OFF at the disconnect switch/circuit breaker and allow to cool before performing any maintenance. SYMPTOM PROBABLE CAUSE CORRECTI ...

  • Hatco GRAHL - page 25

    Form No. GRM-0707 23 TROUBLESHOOTING GUIDE SYMPTOM PROBABLE CAUSE CORRECTIVE ACTION Heat is excessive. Control switches burn-out rapidly . Unit mounted too close to target area. Check to see that installation is within specifications for type/model. Increase mounting height if too close. V oltage supply too high. Check power supply to unit, making ...

  • Hatco GRAHL - page 26

    Form No. GRM-0707 24 HA TCO LIMITED W ARRANTY 1. PRODUCT W ARRANTY Hatco warrants the product s that it manufactures (the “Products”) to be free from defect s in materials and workmanship, under normal use and service, for a period of one (1) year from the date of purchase when installed and maintained in accordance with Hatco’ s written inst ...

  • Hatco GRAHL - page 27

    Form No. GRM-0707 25 NOTES ...

  • Hatco GRAHL - page 28

    HA TCO CORPORA TION P .O. Box 340500, Milwaukee, WI 53234-0500 U.S.A. (800) 558-0607 (414) 671-6350 Parts & Service Fax (800) 690-2966 Int’l. Fax (414) 671-3976 www .hatcocorp.com HA TCO AUTHORIZED P ARTS DISTRIBUTORS Printed in U.S.A. July 2007 ALABAMA Jones McLeod Appl. Svc. Birmingham 205-251-0159 ARIZONA Auth. Comm. Food Equip. Phoenix 60 ...

Manufacturer Hatco Category Printer Accessories

Documents that we receive from a manufacturer of a Hatco GRAHL can be divided into several groups. They are, among others:
- Hatco technical drawings
- GRAHL manuals
- Hatco product data sheets
- information booklets
- or energy labels Hatco GRAHL
All of them are important, but the most important information from the point of view of use of the device are in the user manual Hatco GRAHL.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Hatco GRAHL, service manual, brief instructions and user manuals Hatco GRAHL. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Hatco GRAHL.

Similar manuals

A complete manual for the device Hatco GRAHL, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Hatco GRAHL by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Hatco GRAHL.

A complete Hatco manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Hatco GRAHL - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Hatco GRAHL, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Hatco GRAHL, that we can find in the current document
3. Tips how to use the basic functions of the device Hatco GRAHL - which should help us in our first steps of using Hatco GRAHL
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Hatco GRAHL
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Hatco GRAHL in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Hatco GRAHL?

Use the form below

If you did not solve your problem by using a manual Hatco GRAHL, ask a question using the form below. If a user had a similar problem with Hatco GRAHL it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)