English dropdown-ico

Manual IBM T22

182 pages 2.77 mb
Download

Go to site of 182

Summary
  • IBM T22 - page 1

    IBM Mobile Systems ThinkPad Computer Hardware Maintenance Manual April 2002 This manual support s: ThinkPad T20, T21, T22, T23 (MT 2647/2648) ThinkPad Dock (MT 2631)  ...

  • IBM T22 - page 2

    Note Before using this information and the product it supports, be sure to read the general information under “Notices” on page 174. First Edition (April 2002) The following paragraph does not apply to the United Kingdom or any country where such provisions are inconsistent with local law: INTERNA TIONAL BUSINESS MACHINES CORPORA TION PROVIDES ...

  • IBM T22 - page 3

    About this manual This manual contains service and reference information for IBM ThinkPad T20, T21, T22, T23 (MT2647, 2648), and ThinkPad Dock (MT2631) products. Use this manual along with the advanced diagnostic tests to troubleshoot problems. The manual is divided into sections as follows: v The common sections provide general information, guidel ...

  • IBM T22 - page 4

    iv ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 5

    Contents About this manual ........... i i i Introduction ............. 1 Important service information ......... 1 Strategy for replacing FRUs ........ 1 How to use error messages ........ 2 Diskette compatibility matrix ......... 2 Safety notices: multilingual translations ...... 3 Safety information ............ 1 3 General safety ............ 1 ...

  • IBM T22 - page 6

    1030 Hard-disk drive .......... 6 3 1040 DIMM ............ 6 5 1050 Mini PCI adapter ......... 6 6 1060 Ethernet daughter card ....... 7 1 1070 Ultrabay 2000 device ........ 7 3 1080 Keyboard ........... 7 4 1090 Keyboard CRU insulator ....... 8 2 1 100 Hinge cover ........... 8 3 1 1 10 Keyboard bezel .......... 8 8 1 120 Fan assembly .......... 9 ...

  • IBM T22 - page 7

    Introduction Important service information Important BIOS and device driver fixes are customer-installable. The BIOS and device drivers are posted on the IBM support site http://www.ibm.com/pc/support Advise customers to contact the PC Company HelpCenter at 800-772-2227 if they need assistance in obtaining or installing any diskette fixes. Customer ...

  • IBM T22 - page 8

    Strategy for replacing a hard-disk drive Always try to run a low-level format before replacing a hard-disk drive. Attention: The drive startup sequence in the computer you are servicing may have been changed. Be extremely careful during write operations such as copying, saving, or formatting. If you select an incorrect drive, data or programs can b ...

  • IBM T22 - page 9

    Safety notices: multilingual translations In this manual, safety notices appear in English with a page number reference to the appropriate multilingual, translated safety notice found in this section. The following safety notices are provided in English, French, German, Italian, and Spanish. Safety notice 1 Before the computer is powered-on after F ...

  • IBM T22 - page 10

    Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery , recharge it, throw it into fire or water , or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery c ...

  • IBM T22 - page 11

    (continuation of safety notice 2) Alcune batterie di riserva contengono una piccola quantit à di nichel e cadmio. Non smontarle, ricaricarle, gettarle nel fuoco o nell ’ acqua n é cortocircuitarle. Smaltirle secondo la normativa in vigore (DPR 915/82, successive disposizioni e disposizioni locali). Quando si sostituisce la batteria dell ’ RTC ...

  • IBM T22 - page 12

    Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water , or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result ...

  • IBM T22 - page 13

    Safety notice 4 DANGER (continuation of safety notice 3) Las bater í as contienen peque ñ as cantidades de n í quel. No las desmonte, ni recargue, ni las eche al fuego o al agua ni las cortocircuite. Des é chelas tal como dispone la normativa local. Utilice s ó lo bater í as que se encuentren en la lista de piezas al sustituir la bater í a. ...

  • IBM T22 - page 14

    (continuation of safety notice 4) Die Systembatterie ist eine Lithiumbatterie. Sie kann sich entz ü nden, explodieren oder schwere V erbrennungen hervorrufen. Batterien dieses T yps d ü rfen nicht aufgeladen, zerlegt, ü ber 100 C erhitzt oder verbrannt werden. Auch darf ihr Inhalt nicht mit W asser in V erbindung gebracht oder der zur richtigen ...

  • IBM T22 - page 15

    Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing. Si le panneau d ’ affichage à cristaux liquides se brise et que vous recevez dans les yeux ou ...

  • IBM T22 - page 16

    Safety notice 6 DANGER T o avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. Afin d ’é viter tout risque de choc é lectrique, ne retirez pas le cache en plastique prot é geant la partie inf é rieure de la carte d ’ alimentation. Aus Sicherheitsgr ü nden die Kunststoffabdeckung, die den unteren ...

  • IBM T22 - page 17

    Safety notice 7 DANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. Bien que le voltage des batteries principales soit peu é lev é , le court-circuit ou la mise à la masse d ’ une batterie peut produire suffisamment de courant pour br û ler des ...

  • IBM T22 - page 18

    Safety notice 8 DANGER Before removing any FRU, power off the computer , unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. A vant de retirer une unit é rempla ç able en client è le, mettez le syst è me hors tension, d é branchez tous les cordons d ’ alimentation des socle ...

  • IBM T22 - page 19

    Safety information The following section presents the safety information that you need to be familiar with before servicing an IBM mobile computer . General safety Follow these rules to ensure general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Ensure you can stan ...

  • IBM T22 - page 20

    v After service, reinstall all safety shields, guards, labels, and ground wires. Replace any safety device that is worn or defective. v Reinstall all covers correctly before returning the machine to the customer . Electrical safety Observe the following rules when working on electrical equipment. Important Use only approved tools and test equipment ...

  • IBM T22 - page 21

    – When using testers, set the controls correctly and use the approved probe leads and accessories for that tester . – Stand on suitable rubber mats (obtained locally , if necessary) to insulate you from grounds such as metal floor strips and machine frames. Observe the special safety precautions when you work with very high voltages; these inst ...

  • IBM T22 - page 22

    If any unsafe conditions are present, you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem. Consider these conditions and the safety hazards they present: v Electrical hazards, especially primary power (primary voltage on the frame can cause serious or fatal electrical shock) ...

  • IBM T22 - page 23

    damage by equalizing the charge so that the machine, the part, the work mat, and the person handling the part are all at the same charge. Notes 1. Use product-specific ESD procedures when they exceed the requirements noted here. 2. Make sure that the ESD protective devices you use have been certified (ISO 9000) as fully effective. When handling ESD ...

  • IBM T22 - page 24

    Laser compliance statement Some IBM Personal Computer models are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. They are also sold separately as options. The drive is certified in the U.S. to conform to the requirements of the Department of Health and Human Services 21 Code of Federal Regulations ...

  • IBM T22 - page 25

    When a CD-ROM drive, DVD drive or the other laser product is installed, note the following: CAUTION: Opening the CD-ROM drive, DVD-ROM drive or the other optical storage device could result in exposure to hazardous laser radiation. There are no serviceable parts inside those drives. Do not open. Use of controls or adjustments or performance of proc ...

  • IBM T22 - page 26

    Some CD-ROM drives, DVD-ROM drives, or other optical storage devices contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radia çã o por raio laser ao ...

  • IBM T22 - page 27

    General descriptions This chapter includes descriptions for any ThinkPad model that has the PC-Doctor DOS diagnostics program. Some descriptions might not apply to your particular computer . Read this first Before you go to the checkout guide, be sure to read this section. Important notes v Only certified trained personnel should service the comput ...

  • IBM T22 - page 28

    __ 4. Date of purchase __ 5. Failure symptoms, error codes appearing on the display , and beep symptoms __ 6. Procedure index and page number in which the failing FRU was detected __ 7. Failing FRU name and part number __ 8. Machine type, model number , and serial number __ 9. Customer ’ s name and address Note for warranty: During the warranty p ...

  • IBM T22 - page 29

    Related service information This section provides information about the following: v “ Service web site ” v “ Restoring the preloaded system ” v “ Passwords ” on page 26 v “ Power management ” on page 28 Service web site When the latest maintenance diskette and the system program service diskette become available, a notice will be p ...

  • IBM T22 - page 30

    2. At the prompt, press F1 1. (The option to press F1 1 appears for only a few seconds. Y ou must press F1 1 quickly .) The Product Recovery program main menu opens. Note: If you are prompted to select the operating system, select one you want to recover . Then the Product Recovery program main menu opens. 3. Select System Utilities from the main m ...

  • IBM T22 - page 31

    Note: Network drivers are not automatically restored with Windows NT 4.0; you will need to reinstall them. Note: If you use Windows 2000 or Windows 98, restart the system by pressing Ctrl+Alt+Del or by turning the computer off and then on again. The computer will restart with the pre-installed operating system, drivers, and software. Using the reco ...

  • IBM T22 - page 32

    v T o preload the hard-disk drive without installing the service partition, press N key . 8. If you get a message asking which operating system to install, select the proper operating system and press Enter . 9. A message is displayed: “ Full Recovery: ” . Press Enter to select. 10. On each of the next three windows, press the Y key . 1 1. Foll ...

  • IBM T22 - page 33

    Attention: If the user HDP has been forgotten, check whether a master HDP has been set. If it has, it can be used for access to the hard-disk drive. If no master HDP is available, IBM does not provide any services to reset either the user or the master HDP , or to recover data from the hard-disk drive. The hard-disk drive can be replaced for a sche ...

  • IBM T22 - page 34

    8. Press F10; then, in the Setup confirmation window , select Ye s . How to remove the hard-disk password Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made available to the servicer , IBM does not provide any services to reset the user HDPs or to recover data from the hard-disk drive. The hard-disk driv ...

  • IBM T22 - page 35

    v The hard-disk drive motor stops. 3. If the time set on the “ Turn of f monitor ” timer in the operating system expires, v The LCD backlight turns off. T o end screen blank mode and resume normal operation, press any key . Standby mode When the computer enters standby mode, the following events occur in addition to what occurs in screen blank ...

  • IBM T22 - page 36

    v T urn on the power switch. Also, the computer automatically returns from standby mode and resumes operation in either of the following events: v The ring indicator (RI) is signaled by a serial device or a PC Card device (Windows 2000 does not support the ring indicator (RI) resume by PC Card device.) v The time set on the resume timer elapses. In ...

  • IBM T22 - page 37

    v If you are using the ACPI operating system and have defined one of the following actions as the event that causes the system to go into hibernation mode, perform that action. – Closing the lid. – Pressing the power button. – Pressing Fn+F4 keys. Also, the computer goes into hibernation mode automatically in either of the following condition ...

  • IBM T22 - page 38

    Checkout guide Use the following procedures as a guide in identifying and correcting problems with the ThinkPad computer . Note: The diagnostic tests are intended to test only IBM products. The use of non-IBM products, prototype cards, or modified options can lead to false indications of errors and invalid system responses. 1. Identify the failing ...

  • IBM T22 - page 39

    If an error code appears, go to “ Symptom-to-FRU index ” on page 49. On the first screen, select the model and press Enter . Follow the instructions on the screen. 2. The main panel of PC-Doctor appears. 3. Select Diagnostics with the arrow keys, and press Enter . A pull-down menu appears. (Its exact form depends on the model.) The options on t ...

  • IBM T22 - page 40

    Diagnostics Quit Interactive T ests Hardware Info Utility F1=Help Run Quick T est Run Normal T est Systemboard CPU/Coprocessor Video Adapter Serial Ports Diskette Drives Fixed Disks Parallel Ports Other Devices Use the cursor keys and ESC to move in menus. Press ENTER to select. PC-DOCTOR 2.0 Copyright 2001 PC-Doctor, Inc. All Right s Reserved. ZIP ...

  • IBM T22 - page 41

    Power system checkout T o verify a symptom, do the following: 1. Power off the computer . 2. Remove the battery pack. 3. Connect the ac adapter . 4. Check that power is supplied when you power on the computer . 5. Power off the computer . 6. Disconnect the ac adapter and install the charged battery pack. 7. Check that the battery pack supplies powe ...

  • IBM T22 - page 42

    Checking operational charging T o check whether the battery charges properly during operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer . Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery pack and let it ...

  • IBM T22 - page 43

    Note: Recharging will take at least 3 hours, even if the indicator does not turn on. If the voltage is still less than +1 1.0 V dc after recharging, replace the battery . 4. If the voltage is more than +1 1.0 V dc, measure the resistance between battery terminals 4 and 5. The resistance must be 4 to 30 K  . If the resistance is not correct, repl ...

  • IBM T22 - page 44

    Checkout guide 38 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 45

    ThinkPad T20, T21, T22 and T23 series Product overview ............ 4 1 Specifications ............ 4 3 Status indicators ........... 4 5 FRU T ests ............. 4 7 Fn key combinations .......... 4 8 Symptom-to-FRU index .......... 4 9 Numeric error codes .......... 4 9 Error messages ........... 5 2 Beep symptoms ........... 5 3 No-beep symptoms ...

  • IBM T22 - page 46

    1 160 Hard-disk bay .......... 1 0 5 1 170 Ultrabay 2000 slot ........ 1 0 7 For T20 series .......... 1 0 7 For T21 and T22 series ........ 1 0 8 For T23 series .......... 1 1 1 1 180 System board .......... 1 1 3 For T20, T21, T22 series ....... 1 1 3 For T23 series .......... 1 1 5 1 190 Secure chip .......... 1 1 7 1200 Microphone cable ....... ...

  • IBM T22 - page 47

    Product overview This section presents the following product-unique information: v “ Specifications ” v “ Status indicators ” on page 44 v “ FRU T ests ” on page 46 v “ Fn key combinations ” on page 48 Specifications The following table lists the specifications of the ThinkPad T20, T21, T22 and T23 series : Feature Description Proce ...

  • IBM T22 - page 48

    Feature Description Memory (optional) T20, T21, T22 v 64 MB, 128 MB, or 256 MB DIMM card (maximum of 512 MB) T23 v 64 MB, 128 MB, 256 MB, or 512 MB DIMM card (maximum of 1024 MB) CMOS RAM 242 bytes Display T20 v 13.3-inch, 16M colors, XGA (1024 × 768 resolution) TFT color LCD v 14.1-inch, 16M colors, XGA (1024 × 768 resolution) TFT color LCD T21, ...

  • IBM T22 - page 49

    Feature Description Internal modem 56.6 Kbps Audio v Internal microphone v Internal speaker v Software control volume Infrared transfer IrDA 1.1 802.1 1b (only for T23 series) Mini PCI T ype-IIIa IEEE 802.1 1b wireless LAN card PC Card One T ype-III or two T ype-II AC adapter 72-watt type Bay device T20 v 1.44 MB (3-mode), 3.5-inch diskette drive v ...

  • IBM T22 - page 50

    Status indicators The system status indicators show the status of the computer , as follows: 1 2 3 4 5 6 7 8 Indicator Meaning 1 Drive in use Green: Data is being read from or written to the hard-disk drive, the diskette drive, or the drive in the Ultrabay 2000. When this indicator is on, do not put the computer into standby mode or turn off ...

  • IBM T22 - page 51

    Indicator Meaning 4 Scroll lock Green: Scroll Lock mode is enabled. Arrow keys can be used as screen-scroll function keys, but not to move the cursor . T o enable or disable Scroll Lock mode, press Fn + ScrLk key . Not all application programs support this function. 5 Power on Green: This indicator stays lighted whenever the computer is ...

  • IBM T22 - page 52

    FRU T ests The following table shows the test for each FRU. FRU Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard Power Diagnostics --> Other Devices --> IBM AC Adapter , IBM Battery 1 (IBM Battery 2) LCD unit 1. Diagnostics --> Video Adapter 2. Interactive T ests --> Video Modem 1. Mak ...

  • IBM T22 - page 53

    FRU Applicable test Diskette drive 1. Diagnostics --> Diskette Drives 2. Interactive T ests --> Diskette CD-ROM, DVD, CD-RW or CD-RW/DVD combo drive 1. Diagnostics --> Other Devices --> CD-ROM/DVD 2. Interactive T ests --> CD-ROM/DVD T est Memory 1. If two DIMMs are installed, remove one of them and run Diagnostics --> Memory T es ...

  • IBM T22 - page 54

    Fn key combinations The following table shows the function of each combination of Fn with a function key . Key combination Description Fn+F1 Reserved. Fn+F2 Reserved. Fn+F3 T urn off the LCD display , leaving the screen blank. T o turn the LCD display on again, press any key or the T rackPoint stick. Note: T o use Fn+F3 for screen blank in Windows ...

  • IBM T22 - page 55

    Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “ FRU or action, in sequence. ” If replacing a FRU does not solve the problem, put th ...

  • IBM T22 - page 56

    Symptom or error FRU or action, in sequence 0193 RF antenna has been removed Enter the supervisor password . 0194 The computer has been carried through a security gate Enter the supervisor password . 0195 Security hardware tamper detected 1. Enter IBM BIOS Setup Utility by entering supervisor password, and select “ Password ” --> “ IBM Sec ...

  • IBM T22 - page 57

    Symptom or error FRU or action, in sequence 0232 Extended RAM error — Extended RAM fails at offset nnnn. 1. DIMM . 2. System board. 0250 System battery error — System battery is dead. Replace the backup battery and run IBM BIOS Setup Utility to reset the time and date . 0251 System CMOS checksum bad — Default configuration used. Replace the b ...

  • IBM T22 - page 58

    Error messages Symptom or error FRU or action, in sequence Device address conflict. 1. Load “ Setup Defaults ” in IBM BIOS Setup Utility . 2. Backup battery . 3. System board. Allocation error for device. 1. Load “ Setup Defaults ” in IBM BIOS Setup Utility . 2. Backup battery . 3. System board. Failing bits: nnnn. 1. DIMM . 2. System board ...

  • IBM T22 - page 59

    Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, unreadable, or flashing LCD. 1. Reseat the LCD connector . 2. LCD assembly . 3. External CRT . 4. System board. One long and two short beeps, and a blank or unreadable LCD. 1. System board . 2. LCD assembly . 3. DIMM. T wo short beeps with error codes. POST error . See ...

  • IBM T22 - page 60

    LCD-related symptoms Important The TFT LCD for the notebook computer contains many thin-film transistors (TFT s). A small number of dots that are missing, discolored, or always lighted is characteristic of TFT LCD technology , but excessive pixel problems can cause viewing concerns. The LCD should be replaced if the number of missing, discolored, o ...

  • IBM T22 - page 61

    Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be considered only when a problem recurs. When analyzing an intermittent problem, do the following: 1. Run the diagnos ...

  • IBM T22 - page 62

    FRU replacement notices This section contains notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In IBM ThinkPad computer , this problem is addressed with special nylon-coated screws that have the following characteristics: v They maintai ...

  • IBM T22 - page 63

    v Make sure you use the correct screw . If you have a torque screwdriver , tighten all screws firmly to the torque shown in the table. Never use a screw that you removed. Use a new one. Make sure the screws are tightened firmly . Retaining serial numbers This section includes the following descriptions: v “ Restoring the serial number of the syst ...

  • IBM T22 - page 64

    and stored in the EEPROM of your system board. The algorithm that generates the number is designed to provide unique IDs until the year A.D. 3400. No two computers in the world have the same number . When you replace the system board, you must set the UUID on the new system board as follows: 1. Install the ThinkPad hardware maintenance diskette ver ...

  • IBM T22 - page 65

    Removing and replacing a FRU This section presents directions and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before replacing any FRU, review “ FRU replace ...

  • IBM T22 - page 66

    1010 Battery pack DANGER 1 2 Use only the battery in the parts listing for your computer . Use of an incorrect battery can result in ignition or explosion of the battery . Removing and replacing a FRU 60 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 67

    1020 Backup battery DANGER For access, remove this FRU: v “ 1010 Battery pack ” on page 60 1 2 Step Screw (quantity) T orque 1 M2.5 × 3.5 mm, (1) 0.392 Nm (4 kgfcm) (continued) Use only the battery in the parts listing for your computer . Use of an incorrect battery can result in ignition or explosion of the battery . Removing and replac ...

  • IBM T22 - page 68

    Cable routing: When attaching the backup battery to the holder , route the battery cable as in the following figure. Removing and replacing a FRU 62 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 69

    1030 Hard-disk drive Attention Do not drop or apply any shock to the hard-disk drive. The hard-disk drive is sensitive to physical shock. Incorrect handling can cause damage and permanent loss of data. Before removing the drive, have the user make a backup copy of all the information on the drive if possible. Never remove the drive while the system ...

  • IBM T22 - page 70

    When removing the hard-disk drive, open the LCD a little as shown in the figure. 2 3 3 4 When installing: Make sure that the HDD connector is firmly connected. Removing and replacing a FRU 64 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 71

    1040 DIMM For access, remove this FRU: v “ 1010 Battery pack ” on page 60 Note: Loosen the screw 1 , but do not remove it. 2 1 3 3 4 When installing: With the notched end of the DIMM toward the socket, insert the DIMM into the socket, and then press it firmly . Pivot the DIMM until it snaps into place. Make sure that the card is firmly fi ...

  • IBM T22 - page 72

    1050 Mini PCI adapter For access, remove this FRU: v “ 1010 Battery pack ” on page 60 For T20, T21 and T22 series Note: Loosen the screw 1 , but do not remove it. 2 1 (continued) Removing and replacing a FRU 66 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 73

    Note: The following illustration shows the combo card. Connector (A) is for the LAN feature and (B) is for the modem feature. Disconnect either (A) or (B) in step 6 . This slot also supports a Mini PCI modem card or Mini PCI network card. 4 3 4 (A) (B) 6 5 (A) (B) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series ...

  • IBM T22 - page 74

    When installing: Make sure not to pinch the connector cable when re-installing the Mini PCI adapter . For T23 series Note: Loosen the screw 1 , but do not remove it. 2 1 (continued) Removing and replacing a FRU 68 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 75

    In step 3a and 3b , pull the tab of the each antenna cables to unplug the cables. 4 3a 4 3b When installing: Plug the gray antenna cable 3a into jack J1 (MAIN), and the black antenna cable 3b into jack J2 (AUX). 5 6 When installing: With the notched end of the card toward the socket, insert the card into the socket, and then ...

  • IBM T22 - page 76

    1060 Ethernet daughter card Note This section is only for the following models of T23 series; v All models of MT2647 excepting xQx, L4x v All models of MT2648 Other models do not have the Ethernet daughter card (EDC). For access, remove this FRU: v “ 1010 Battery pack ” on page 60 Note: Loosen the screw 1 , but do not remove it. 2 1 (cont ...

  • IBM T22 - page 77

    3 3 Step Screw (quantity) T orque 3 M2.5 × 1 1.5 mm, nylon-coated (2) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 71 ...

  • IBM T22 - page 78

    4 5 6 When installing: Make sure that both of the connectors 4 and 6 are firmly attached. Removing and replacing a FRU 72 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 79

    1070 Ultrabay 2000 device Any of several devices can be inserted into the Ultrabay 2000. The procedure for installing and removing is the same for every device. Ultrabay 2000 also supports Ultrabay Plus device, such as Ultrabay Plus carrier . Note: When you release the switch in step 1 the lever pops out. Pull the lever a little in step 2? ...

  • IBM T22 - page 80

    1080 Keyboard For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 For T20, T21 and T22 series 1 Step Screw (quantity) T orque 1 M2.5 × 14 mm, nylon-coated (2) 0.392 Nm (4 kgfcm) Note: T ...

  • IBM T22 - page 81

    For T23 series Note: Loosen the screw 2 , but do not remove it. 3 2 1 Step Screw (quantity) T orque 1 M2.5 × 14 mm, nylon-coated (2) 0.392 Nm (4 kgfcm) 4 Step Screw (quantity) T orque 4 M2.5 × 1 1.5 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 75 ...

  • IBM T22 - page 82

    Note: Step 5 to 10 are common for all models. 5 5 6 (continued) Removing and replacing a FRU 76 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 83

    9 8 7 7 8 9 10 9 (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 77 ...

  • IBM T22 - page 84

    Note: Before installing a new keyboard, attach the easy-button cover as follows: 1 1 2 3 4 (continued) Removing and replacing a FRU 78 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 85

    When installing the keyboard, do as follows: 1. Install the new keyboard, following the directions in the figure. Make sure that the keyboard edges, shown in the figure as (A) , (B) , and (C) , are under the frame. (A) (B ) (C) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 79 ...

  • IBM T22 - page 86

    2. Insert your fingers into the PC Card slot on the left of the computer and the Ultrabay 2000 slot on the right of the computer as shown in 1 . Then, with your fingers in those slots as in 2 , latch the keyboard in place by using your thumbs to press firmly on the shift keys. Press the Y key to connect the keyboard to the connector on ...

  • IBM T22 - page 87

    3. T o make sure that the front side of the keyboard is housed firmly , gently press the shift keys with your thumbs and try to slide the keyboard towards you. Do not push parts (A) and (B) on the keyboard strongly; to do so might cause distortion of the Ultrabay 2000 slot and the PC Card slot. (A) (B) 4. Replace the screws, using the new screws pr ...

  • IBM T22 - page 88

    1090 Keyboard CRU insulator For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 Note: The shape of the keyboard CRU insulator varies from model to model. In ...

  • IBM T22 - page 89

    1 100 Hinge cover For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 Note: Step 1 is common for all m ...

  • IBM T22 - page 90

    For T20 and T21 series a a 3 4 2 Step Screw (quantity) T orque 2 M2.5 × 4.8 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) When installing: 1. Install the hinge cover according to the step 3 , 4 and then tighten the screw 2 . In step 3 , take care not to damage the lens. 2. Make sure that both latches a are firmly atta ...

  • IBM T22 - page 91

    For T22 series 2 3 Step Screw (quantity) T orque 2 M2.5 × 14 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 85 ...

  • IBM T22 - page 92

    6 a a 5 4 Step Screw (quantity) T orque 4 M2.5 × 4.8 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) When installing: 1. Install the hinge cover according to the step 5 , 6 and then tighten the screw 4 . In step 5 , take care not to damage the lens. 2. Make sure that both latches a are firmly attached and snap into plac ...

  • IBM T22 - page 93

    For T23 series 4 3 2 a a Step Screw (quantity) T orque 2 M2.5 × 4.8 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) When installing: 1. Install the hinge cover according to the step 3 , 4 and then tighten the screw 2 . In step 3 , take care not to damage the lens. 2. Make sure that both latches a are firmly attached and ...

  • IBM T22 - page 94

    1 1 10 Keyboard bezel For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on pag ...

  • IBM T22 - page 95

    4 2 3 Step Screw (quantity) T orque 2 M2.5 × 14 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) 3 M2.5 × 4.8 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 89 ...

  • IBM T22 - page 96

    For T23 series Note: Loosen the screw 1 , but do not remove it. 2 1 3 Step Screw (quantity) T orque 3 M2.5 × 1 1.5 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU 90 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 97

    4 Step Screw (quantity) T orque 4 M2.5 × 3.5 mm, nylon-coated (3) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 91 ...

  • IBM T22 - page 98

    5 7 6 Step Screw (quantity) T orque 5 M2.5 × 14 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) 6 M2.5 × 4.8 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) Removing and replacing a FRU 92 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 99

    When installing, do as follows: v Make sure that the a -part is firmly attached as shown in the figure. v Make sure that all of the latches of the keyboard bezel b are firmly attached. a b b b b Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 93 ...

  • IBM T22 - page 100

    1 120 Fan assembly For T20, T21, T22 series For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 1 1 a 2 b No ...

  • IBM T22 - page 101

    When installing the fan assembly: For T20 Remove the protective sheet from the thermal rubber on the fan assembly . For T21, T22 Apply the thermal grease (05K5751) on the a -part of the fan as shown in the following figure. a Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 95 ...

  • IBM T22 - page 102

    For T23 series For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on page 83 v ...

  • IBM T22 - page 103

    4 5 6 Step Screw (quantity) T orque 4 M2.0 × 13.5 mm, nylon-coated (3) 0.245 Nm (2.5 kgfcm) When installing: Apply the thermal grease (05K5751) on the a -part of the fan as shown in the following figure. a Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 97 ...

  • IBM T22 - page 104

    1 130 CPU For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 120 Fan assembly ” on page 94 For T2 ...

  • IBM T22 - page 105

    For T23 series Note: The shape of the CPU socket vary from model to model. When removing or installing the CPU, confirm the shape of the CPU socket and do either steps 1 , 2 and a or steps 1' , 2 and a' . Rotate the head of the screw to the direction of the arrow 1 or 1' to release the ...

  • IBM T22 - page 106

    1 140 PC Card slot assembly For T20, T21, T22 series For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 1 2 ...

  • IBM T22 - page 107

    When installing the PC card slot assembly , do as shown in the figure. Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 101 ...

  • IBM T22 - page 108

    For T23 series For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on page 83 v ...

  • IBM T22 - page 109

    1 150 Speaker For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on page 83 v ? ...

  • IBM T22 - page 110

    Before installing new speaker for T22 and T23 series: Secure speaker RF bracket ( a ) to the new speaker with an adhesive tape inside of the bracket. For T22 series a For T23 series a Removing and replacing a FRU 104 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 111

    1 160 Hard-disk bay For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on page ...

  • IBM T22 - page 112

    When installing: Make sure the followings: v a -parts of the insulation do not come off. v b -part ( b' s are only for T23 series) is not turned over . v Holes in the guide rail and in the aluminium sheet are aligned, and the aluminium sheet does not protrude in the c -parts. The protruding parts of the sheet can cause ...

  • IBM T22 - page 113

    1 170 Ultrabay 2000 slot For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on ...

  • IBM T22 - page 114

    For T21 and T22 series 1 2 Note: T21 series do not have the removal procedure 3 and 4 . After step 2 , go to step 5 . When installing: Make sure that the FPC connector is firmly attached. (continued) Removing and replacing a FRU 108 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 115

    For T23 series 3 2 1 Step Screw (quantity) T orque 1 M2 × 13.5 mm, nylon-coated (1) 0.245 Nm (2.5 kgfcm) 2 M2.5 × 14 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 109 ...

  • IBM T22 - page 116

    4 Note: The models with 13.3-in. XGA LCD in T20 series and in T21 series do not have FPC bracket ( 5 ). For those models, skip step 5 . 5 a When installing: Make sure that the FPC bracket is firmly attached as shown in the figure a . (continued) Removing and replacing a FRU 11 0 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 117

    Note: Step 6 to step 9 are common for T20, T21, T22 and T23 series. 6 Step Screw (quantity) T orque 6 M2.5 × 4.8 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) 9 8 7 Step Screw (quantity) T orque 7 M2 × 13.5 mm, nylon-coated (2) 0.245 Nm (2.5 kgfcm) 8 M2.5 × 4.8 mm, nylon-coated (2) 0.392 Nm (4 kgfcm) Removing and replacin ...

  • IBM T22 - page 118

    When installing: Make sure that the guide of the slot is firmly attached 1 and if the eject lever has been poped out, push it back in the direction of arrow 2 until it snaps, and then push the upper-right corner of the slot 3 to fix it firmly . 1 2 3 Removing and replacing a FRU 11 2 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 119

    1 180 System board For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1040 DIMM ” on page 65 v “ 1050 Mini PCI adapter ” on page 66 v “ 1060 Ethernet daughter card ” on page 70 (only for T23 series) v “ 1070 Ultrabay 200 ...

  • IBM T22 - page 120

    When installing: Make sure that all of the guides are firmly attached 1 and you have fastened the connector firmly to the underside of the system board 2 . 2 1 1 1 Removing and replacing a FRU 11 4 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 121

    For T23 series 1 2 3 5 6 4 Step Screw (quantity) T orque 5 M2.5 × 4.8 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 11 5 ...

  • IBM T22 - page 122

    When installing: Make sure that all of the guides are firmly attached 1 and you have fastened the connector firmly to the underside of the system board 2 . 1 1 1 2 Removing and replacing a FRU 11 6 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 123

    1 190 Secure chip Note This section is only for the following models; v MT2647-5Lx, 9Lx, DL T , HLU v MT2647-5Dx, 5Fx, 5Hx, 5Jx, 5Nx, 5Mx, 9Dx, 9Fx, 9Hx, 9Jx, 9Nx, 9Mx, DFx, HNx, NNx v MT2647-5Rx, 5Sx, 5Ux, 9Rx, 9Sx, 9Ux, HSU Other models do not have the secure chip. For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v ...

  • IBM T22 - page 124

    1200 Microphone cable For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1040 DIMM ” on page 65 v “ 1050 Mini PCI adapter ” on page 66 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 109 ...

  • IBM T22 - page 125

    2010 LCD assembly For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1050 Mini PCI adapter ” on page 66 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on pag ...

  • IBM T22 - page 126

    For models excepting MT2647-xLx, xNx 4 2 4 3 Step Screw (quantity) T orque 2 M2.5 × 14 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) 4 M2.5 × 4.8 mm, nylon-coated (2) 0.392 Nm (4 kgfcm) Removing and replacing a FRU 120 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 127

    For MT2647-xLx, xNx 5 3 2 5 4 Step Screw (quantity) T orque 2 M2.5 × 14 mm, nylon-coated (1) 0.392 Nm (4 kgfcm) 5 M2.5 × 4.8 mm, nylon-coated (2) 0.392 Nm (4 kgfcm) Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 121 ...

  • IBM T22 - page 128

    2020 Front bezel For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on page 83 ...

  • IBM T22 - page 129

    2030 Inverter card For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on page 8 ...

  • IBM T22 - page 130

    2040 LCD panel For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboard CRU insulator ” on page 82 v “ 1 100 Hinge cover ” on page 83 v ...

  • IBM T22 - page 131

    2a 2 2a 2 2a 2a Step Screw (quantity) T orque For 13.3-in. XGA LCD LG (05K9636), 14.1-in. XGA LCD Hitachi (05K9568), 14.1-in. SXGA+ LCD Hitachi (46L2493) 2 M2 × 4 mm, nylon-coated (4) 0.245 Nm (2.5 kgfcm) For 14.1-in. XGA LCD LG (05K9567), SAMSUNG (05K9678), Hyundai (05K9940), DBU (05K9888), 14.1-in. SXGA+ LCD LG (46L2495) 2a M2 × 4 m ...

  • IBM T22 - page 132

    6 5 4 7 5 3 (continued) Removing and replacing a FRU 126 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 133

    Cable routing: When installing the LCD, route the connector cable as in the following figure: Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 127 ...

  • IBM T22 - page 134

    2050 Antenna assembly Note This section is only for MT2647-xFx, xJx, xLx, xNx, xSx. Other models do not have the antenna assembly . For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 10 ...

  • IBM T22 - page 135

    Strip off the insulation tapes 2 securing the antenna cables. 2 2 3 3 Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 129 ...

  • IBM T22 - page 136

    Cable routing: Route the antenna cables as follows; 1. Hook the black antenna cable to projection ( 1 )o nt h e right corner of the rear cover . 2. Route the black antenna cable to go through cable guides 2 and 3 . 3. Hook the gray antenna cable to projection ( 4 )o nt h e left corner of the rear cover . 4. Route the gray an ...

  • IBM T22 - page 137

    2060 Sub card For access, remove these FRUs, in order: v “ 1010 Battery pack ” on page 60 v “ 1020 Backup battery ” on page 61 v “ 1030 Hard-disk drive ” on page 63 v “ 1040 DIMM ” on page 65 v “ 1050 Mini PCI adapter ” on page 66 v “ 1070 Ultrabay 2000 device ” on page 73 v “ 1080 Keyboard ” on page 74 v “ 1090 Keyboa ...

  • IBM T22 - page 138

    4 a When installing, do the following: v Attach the I/O card spacer ( a ) onto the new sub card and make sure that the connector is firmly attached. v Make sure that the eject lever is poped out b and then install the sub card. v T ake care not to damage the switch on the sub card ( A ). v Make sure that the guide of the card is firmly ...

  • IBM T22 - page 139

    3010 ThinkPad Dock PCI cover Before replacing the PCI cover: There are two types of ThinkPad Dock, as follows: v ThinkPad Dock: FRU no. 08N1546 (PCI cover: FRU no. 05K6246) v ThinkPad Dock with extension plate: FRU no. 08N1537 (PCI cover: FRU no. 08N7317) Confirm the FRU no. of the ThinkPad Dock first and choose the proper PCI cover FRU for the Thi ...

  • IBM T22 - page 140

    Note: The following illustration shows how to remove the PCI cover of ThinkPad Dock (FRU no. 08N1546). Do the same to remove the PCI cover of ThinkPad Dock with extension plate (FRU no. 08N1537). 1 2 1 (Bottom view) Removing and replacing a FRU 134 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 141

    3020 ThinkPad Dock top cover Note This section is only for the ThinkPad Dock (FRU no. 08N1546). The top cover and screw kit for ThinkPad Dock (FRU no. 12P4143) is not available for the ThinkPad Dock with extension plate (FRU no. 08N1537) . 1 (Rear view) Step Screw (quantity) T orque 1 M2.5 × 4.8 mm (2) 0.392 Nm (4 kgfcm) (continued) Removing ...

  • IBM T22 - page 142

    2 2 2 (Bottom view) Step Screw (quantity) T orque 2 M2.5 × 4.8 mm (8) 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU 136 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 143

    Make sure that the system lock key A is set to the Unlock position. Release the front latches in step 3 , and then remove the top cover 4 . For step 5 , see the inside view , shown in the circle. 5 4 3 A Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 137 ...

  • IBM T22 - page 144

    When replacing the top cover , do the following: v Make sure that the springs are placed correctly . v Make sure that the device release lever is seated correctly . (continued) Removing and replacing a FRU 138 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 145

    v Make sure that the release button works correctly . Removing and replacing a FRU ThinkPad T20, T21, T22 and T23 series 139 ...

  • IBM T22 - page 146

    Locations Front view 1 System status indicators 2 Power switch 3 Battery , standby mode, and Ultrabay status indicators 4 Bay latch 5 Eject button 6 Ultrabay 2000 device Note: The Ultrabay 2000 accepts storage devices, such as a DVD drive or a CD-ROM drive. 7 T rackPoint pointing stick 8 T rackPoint b ...

  • IBM T22 - page 147

    Rear view 1 Security keyhole 2 TV -out connector 3 Serial connector 4 Parallel connector 5 External-monitor connector 6 Modem connector 7 Ethernet connector 8 Power jack 9 Universal serial bus (USB) connector Note: T23 series have two USB connectors. 10 External-input-device connector 1 10 ...

  • IBM T22 - page 148

    Bottom view 1 Built-in stereo speakers 2 Battery pack 3 Battery pack latches 4 Docking connector 5 Mini PCI card slot 6 DIMM 7 PC card slots 8 PC card eject button 9 Infrared port 10 Stereo headphone jack 11 Stereo line-in jack 12 Microphone jack 13 Hard-disk drive 14? ...

  • IBM T22 - page 149

    Parts list T20, T21, T22 and T23 series model matrix The T20, T21, T22 and T23 series includes several models. The following table summarizes the characteristics of each model, to help you determine which FRU in the part list meets your need. Model CPU Bay device Mini PCI adapter LCD HDD T20 (Memory: 128 MB) (*): Memory 64 MB (**): Memory 256 MB 26 ...

  • IBM T22 - page 150

    Model CPU Bay device Mini PCI adapter LCD HDD T21 (Memory: 128 MB) 2647-27x, 67x CMG 750 CD- ROM Modem 13.3-in. XGA 10 GB 2647-2Ax, 6Ax Combo (Xircom) 2647-4Bx, 8Bx Combo (3Com) 2647-47x, 49x, 87x, L7x CMG 800 DVD- ROM (8x) Modem 14.1-in. XGA 20 GB 2648-47x, 87x 2647-4Ax, 8Ax Combo (Xircom) 2648-4Ax, 8Ax Combo (Intel) 2647-4Bx, 8Bx Combo (3Com) 264 ...

  • IBM T22 - page 151

    Model CPU Bay device Mini PCI adapter LCD HDD T23 (Memory: 128 MB) (**): Memory 256 MB 2647-2Kx except 2KC 2647-6Kx except xxC 2647-AKx, BAx, BJx, EKx T ual 866 CD- ROM Modem 13.3-in. XGA 15 GB 2647-2KC, 6KC DVD- ROM (8x) 2647-2Rx, 6Rx Tual 1.0 CD- ROM 14.1-in. XGA 20 GB 2647-2Tx, 2UC, 6UC, 3RG, 7RG DVD- ROM (8x) 2648-2Tx 2647-3TK, 7TK CD- ROM 30 G ...

  • IBM T22 - page 152

    Model CPU Bay device Mini PCI adapter LCD HDD T23 (Memory: 128 MB) (**): Memory 256 MB 2647-5Mx, 9Mx T ual 1.2 CD- RW Modem 14.1-in. SXGA+ 48 GB 2647-5Nx, 9Nx, HNx, NNx *2 802.1 1/ v .90 14.1-in. SXGA+ with antenna 2647-5Fx, 9Fx, DFx *2 DVD- ROM (8x) 2647-5Dx, 9Dx *2 Modem 14.1-in. SXGA+ 2647-5Hx, 9Hx *2 DVD/ CD- RW combo 2647-5Jx, 9Jx *2 802.1 1/ ...

  • IBM T22 - page 153

    Overall For T20, T21 and T22 1 a b 2 3 4 5 7 6 9 8 10 11 12 15 14 k l 16 19 18 17 20 21 22 23 24 13 c d e f g j h i Parts list ThinkPad T20, T21, T22 and T23 series 147 ...

  • IBM T22 - page 154

    v Each FRU is available for all types or models, unless specific types or models are given. v The FRUs marked with asterisk are CRUs (customer replaceable units.) v The FRUs marked with OP are also available as optional FRUs. No. FRU P/N a-l See “ Miscellaneous parts ” on page 167. 1 LCD unit (see “ LCD FRUs ” on page 157) 2 Keyboard ...

  • IBM T22 - page 155

    No. FRU P/N 7 Base cover for T22 for 2647-3xx, 7xx, Bxx except models xxK 26P9291 for 2647-3xK, 7xK, BxK 26P9309 for 2647-4xx, 5xx, 8xx, 9xx, Mxx, Lxx except models xxK 08K7362 for 2647-4xK, 5xK, 8xK, 9xK, MxK, LxK 26P9174 for 2648-all except models xxK 26P9173 for 2648-xxK 26P9175 8 Ultrabay 2000 diskette drive (TEAC) 08K9606* Ultrabay 2000 disket ...

  • IBM T22 - page 156

    No. FRU P/N 15 Mini PCI modem card OP for T20 (models x1x except T1U, x2x, x3x, BxG) 08K3429* Mini PCI modem card (Ambit) for T20, T21 (models x1x, x2x, x3x, xxG) 08K4855* Mini PCI modem card (Hoshi CR) for T21 (models x7x except x7G) 08K3338* Mini PCI modem card (Ambit), V .92 ready for T22 (models xCx) 08K4853* Mini PCI combo card (Intel) ? ...

  • IBM T22 - page 157

    No. FRU P/N 18 Asset ID RF adapter (see “ Optional FRUs ” on page 170) 19 Hard-disk drive (6.0 GB), STD OP 05K9227* Hard-disk drive (6.0 GB), HIT ACHI OP 05K9228* Hard-disk drive (10.0 GB), STD OP 08K9508* Hard-disk drive (10.0 GB), HIT ACHI OP 08K9531* Hard-disk drive (12.0 GB), STD OP 05K9229* Hard-disk drive (12 ...

  • IBM T22 - page 158

    For T23 1 a 2 3 4 5 7 6 9 8 10 11 12 15 24 14 i j 16 19 18 k 17 20 21 22 23 13 e c h f g 25 b d Parts list 152 ThinkPad T20, T21, T22, T23 (MT 2647/2648) ...

  • IBM T22 - page 159

    v Each FRU is available for all types or models, unless specific types or models are given. v The FRUs marked with one asterisk are CRUs (customer replaceable units.) v The FRUs marked with OP are also available as optional FRUs. No. FRU P/N a-k See “ Miscellaneous parts ” on page 167. 1 LCD unit (see “ LCD FRUs ” on page 157) 2 Keybo ...

  • IBM T22 - page 160

    No. FRU P/N 7 Base cover for 2648 wireless (T23) for models xNx, xSx, except xNC, xNK, xNT , xSC, xSK, xST 46L4921 for models 4NC, 8NC, xSC 46L4935 for models 4NK, 8NK, xSK 46L4933 for models 4NT , 8NT , xST 46L4925 8 Ultrabay 2000 CD-ROM drive (LG), low power OP 27L4301* Ultrabay 2000 CD-ROM drive (TEAC), low power OP 27L3436* Ultrabay ...

  • IBM T22 - page 161

    No. FRU P/N 12 Cover, Mini PCI adapter slot 08K7416* 13 Speaker assembly 08K6089 14 128-MB SDRAM SO DIMM (PC133) OP 19K4653* 256-MB SDRAM SO DIMM (PC133) OP 19K4655* for other optional DIMMs, see “ Optional FRUs ” on page 170. 15 Mini PCI modem card (Ambit) OP for all models except 2647-xFx, xJx, xLx, xNx, xSx, 5TC, 9TC, and 2 ...

  • IBM T22 - page 162

    No. FRU P/N 24 Ethernet daughter card (Ambit) OP for all models except 2647-xQx 26P8181 25 Secure chip OP for 2647-5xx except 5Kx, 9xx except 9Kx for 2647-HNx, xLx 26P8084 — T elephone cable (SAN T AI) 27L0603 — Recovery CD (see “ Recovery CDs ” on page 161.) — AC adapter* (see “ AC adapters ” .) AC adapters FRU P/N AC ada ...

  • IBM T22 - page 163

    LCD FRUs 7 5 4 4 3 2 1 5 6 Notes: 1. The parts marked with  are only for 13.3-in. LCD cover kit. 2. 5 is for the models with 14.1-in. XGA TFT with antenna and for the models with 14.1-in. SXGA+ TFT with antenna. 3. 6 is only for 2647-52x, 92x, C2x, L1x. 13.3-in. XGA TFT No. FRU P/N 1 LCD cover kit (13.3-in.) XGA (except models xxK) 08K6685 model ...

  • IBM T22 - page 164

    14.1-in. XGA TFT No. FRU P/N 1 LCD cover kit (14.1-in.) XGA for T20, T21 (except models xxK) 26P9566 for T20, T21 (models xxK) 26P9567 for T22, T23 (except models xxK) 46L4843 for T22, T23 (models xxK) 46L4844 LCD cover antenna kit (except models xxK) 46L4910 models xxK 46L491 1 2 LCD cable assembly 14.1 XGA for T20, T21 27L0519 LCD cable assembly ...

  • IBM T22 - page 165

    14.1-in. SXGA+ TFT No. FRU P/N 1 LCD cover kit (14.1-in.) SXGA+ (except models xxK) 26P9383 models xxK 26P9385 LCD cover antenna kit (except models xxK) 46L4910 models xxK 46L491 1 2 LCD cable assembly 14.1 SXGA+ 27L0590 3 LCD panel, 14.1 SXGA+ (HIT ACHI) 46L2493 LCD panel, 14.1 SXGA+ (LG) 46L2495 4 Hinges 08K6087 Hinges for antenna 26P9196 5 Anten ...

  • IBM T22 - page 166

    Keyboard Language P/N (NMB) P/N (ALPS) Arabic 02K5750* — Belgian 02K5745* — Chinese, traditional 02K5747* 02K5718* Czech 02K5751* — Danish 02K5738* — Dutch 02K5735* — English, U.K. 02K5731* — English, U.S. 02K5729* — French, Canadian 02K5732* — French, European 02K5734* — German 02K5733* — Greek 02K5753* — Hungarian 02K5752* ? ...

  • IBM T22 - page 167

    Recovery CDs For Windows 98 (T22 series) Language P/N Arabic 14P9515* Chinese, Simplified 27P21 12* Chinese, T raditional 27P21 10* Czech 14P9516* Danish 23P9240* Dutch 23P9247* English, U.K. 23P9236* English, U.S. 23P9235* Finnish 23P9246* French, Canadian 23P9237* French, European 23P9241* German 23P9242* Greek 23P9266* Hebrew 14P9517* Hungarian ...

  • IBM T22 - page 168

    For Windows 2000 (T22 series) Language P/N Arabic 14P9525* Czech 14P9526* Greek 23P9218* Hebrew 14P9527* Hungarian 23P9219* Polish 14P9528* Russian 23P9220* Slovak 23P9222* Slovenian 23P9221* T urkish 14P9529* For Windows 2000/Windows NT (T22 series) Language P/N Chinese, Simplified 27P21 17* Chinese, T raditional 27P21 14* Danish 23P9180* Dutch 23 ...

  • IBM T22 - page 169

    For Windows 98 (T23 series) Language P/N Arabic 14P9202* Arabic (modem enabled) 14P9201* Chinese, Simplified 46P4518* Chinese, T raditional 46P4514* Chinese, T raditional (Hong Kong S.A.R.) 46P6327* Czech 14P9203* Danish 14P9192* Dutch 14P9199* English, U.K. 14P9188* English, U.S. 32P5573* Finnish 14P9198* French, Canadian 14P9189* French, European ...

  • IBM T22 - page 170

    For Windows 2000 (T23 series) Language P/N Arabic 32P6633* Chinese, Simplified 46P4520* Chinese, T raditional 46P4516* Chinese, T raditional (Hong Kong S.A.R.) 46P6329* Czech 32P6634* Danish 32P6624* Dutch 32P6631* English, U.K. 32P6620* English, U.S. 32P6619* Finnish 32P6630* French, Canadian 32P6621* French, European 32P6625* German 32P6626* Gree ...

  • IBM T22 - page 171

    For Windows 2000/Windows NT (T23 series) Language P/N Danish 14P9291* Dutch 14P9298* English, U.K. 32P5645* English, U.S. 32P5576* French, Canadian 14P9288* French, European 14P9292* Finnish 14P9297* German 14P9293* Italian 14P9296* Japanese 46P4421* Norwegian 32P5742* Portuguese 14P9290* Spanish, European 14P9294* Spanish, Latin American 14P9289* ...

  • IBM T22 - page 172

    For Windows XP (T23 series) Language P/N Arabic 32P6736* Chinese, Simplified 46L6288* Chinese, T raditional 46L6287* Chinese, T raditional (Hong Kong S.A.R.) 46P6362* Czech 32P6737* Danish 32P6727* Dutch 32P6734* English, U.K. 32P6723* English, U.S. 32P6722* Finnish 32P6733* French, Canadian 32P6724* French, European 32P6728* German 32P6729* Greek ...

  • IBM T22 - page 173

    Miscellaneous parts Italicized letters in parentheses are reference to the exploded view on page 147 and 152. FRU P/N Screw kit (including nylon-coated screws) for T20, T21, T22 and T23 series: v M2.5 x 14 mm, bind head (15) v M2.5 x 1 1.5 mm, flat head (5) v M2.5 x 4.8 mm, flat head (20) v M2.5 x 3.5 mm, flat head (10) v M2.0 x 13.5 mm, pan head ( ...

  • IBM T22 - page 174

    FRU P/N System miscellaneous parts for T20 series: v ( a ) Hinge cover assembly v (23) Easy button cover v ( i ) I/O card spacer v ( h ) Cable RJ1 1 to system board docking v ( j ) Holder , backup battery v ( g ) Ultrabay 2000 guide rail v ( l ) Hard-disk bay guide rail v ( b ) Insulator , keyboard CRU v Mini PCI guide v Screw caps v Screw caps, re ...

  • IBM T22 - page 175

    FRU P/N System miscellaneous parts for T23 series: v ( a ) Hinge cover assembly v (23) Easy button cover T23 v ( g ) I/O card spacer v ( f ) Cable RJ1 1 to system board docking v ( h ) Holder , backup battery v ( e ) Ultrabay 2000 guide rail v ( j ) Hard-disk bay guide rail v ( b ) Insulator , keyboard CRU v ( k ) ESD bracket, FPC v ( d ) ESD brack ...

  • IBM T22 - page 176

    FRU P/N System board miscellaneous parts for T23 series: v System board stud v System board stud (long) v System board stud (back) v Insulator , PC card v Insulator , battery latch v Keyboard connector guide v Shock rubber v Insulator , docking connector v Insulator , Ultrabay 2000 bay connector v Insulator , I/O connector v Insulator , hard-disk d ...

  • IBM T22 - page 177

    FRU P/N Ultrabay 2000 SuperDisk drive (LS120) 05K9235* Ultrabay 2000 SuperDisk drive (LS120 2x) 27L3450* Ultrabay 2000 SuperDisk drive (LS240) 08K9615* Ultrabay 2000 ZIP-250 drive 00N8254* Ultrabay 2000 battery 02K6645* Ultrabay 2000 2nd HDD adapter 08K6067* Hard-disk drive (6.0 GB), STD 05K9227* Hard-disk drive (6.0 GB), HIT ACHI 05K9228* Hard-dis ...

  • IBM T22 - page 178

    Common parts list T ools T riconnector wrap plug 72X8546 PC test card 35G4703 Audio wrap cable 66G5180 USB parallel test cable 05K2580 Screwdriver kit 95F3598 T orque screwdriver 05K4695 5 mm socket wrench 05K4694 Screwdriver 27L8126 ThinkPad hardware maintenance diskette version 1.62 Note: Download the file from the following Web site: http://www. ...

  • IBM T22 - page 179

    Power cords (docking station) IBM power cords for a specific country or region are usually available only in that country or region: For 3-pin power cords: Region P/N Argentina 36L8868* Australia, New Zealand 75H8988* Canada, Thailand, U.S. 75H8989* Denmark 75H8992* European countries 75H8990* India, South Africa 75H8993* Israel 75H8999* Italy 75H8 ...

  • IBM T22 - page 180

    Notices References in this publication to IBM products, programs, or services do not imply that IBM intends to make these available in all countries in which IBM operates. Any reference to an IBM product, program, or service is not intended to state or imply that only that IBM product, program, or service may be used. Any functionally equivalent pr ...

  • IBM T22 - page 181

    Notices ThinkPad T20, T21, T22 and T23 series 175 ...

  • IBM T22 - page 182

     Part Number: 62P9631 (1P) P/N: 62P9631 ...

Manufacturer IBM Category Laptop

Documents that we receive from a manufacturer of a IBM T22 can be divided into several groups. They are, among others:
- IBM technical drawings
- T22 manuals
- IBM product data sheets
- information booklets
- or energy labels IBM T22
All of them are important, but the most important information from the point of view of use of the device are in the user manual IBM T22.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals IBM T22, service manual, brief instructions and user manuals IBM T22. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product IBM T22.

Similar manuals

A complete manual for the device IBM T22, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use IBM T22 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of IBM T22.

A complete IBM manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual IBM T22 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the IBM T22, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the IBM T22, that we can find in the current document
3. Tips how to use the basic functions of the device IBM T22 - which should help us in our first steps of using IBM T22
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with IBM T22
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of IBM T22 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning IBM T22?

Use the form below

If you did not solve your problem by using a manual IBM T22, ask a question using the form below. If a user had a similar problem with IBM T22 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)