English dropdown-ico

Manual Heat & Glo Dakota 42-CE

36 pages 2.4 mb
Download

Go to site of 36

Summary
  • Heat & Glo Dakota 42-CE - page 1

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 1 Installer ’ s Guide Installation and Operation Model: Dakota 42-CE Note : This fi replace is intend ed for outdoor use only . 0087 These instructions are only valid if the following country symbol is on the fi replace. If this symbol is not present on the fi r ...

  • Heat & Glo Dakota 42-CE - page 2

    2 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Read this manual before installing or operating this fi replace. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Heat & Glo LifeStyle Collec- tion gas fi replace—an elegant and clean alternative to wood burning fi r ...

  • Heat & Glo Dakota 42-CE - page 3

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 3 T able of Contents 1 Listing and Code Approvals 4 A. Fireplace Certi fi cation . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started 4 A. Design and Installation Considerations . . . . . . . . . . . . 4 B. Inspect Fireplace and Components . . . . . ...

  • Heat & Glo Dakota 42-CE - page 4

    4 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 1 1 Listing and Code Approv als Do NOT use this fi replace if any part has been under water . Immediately call a quali fi ed service technician to inspect the fi replace and to replace any part of the control system and any gas control which has been under water . ...

  • Heat & Glo Dakota 42-CE - page 5

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 5 B A G E Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. C D F F C D G F E 1.47 M 2.08 M Note: • Illustrations re fl ect typical installations and are FOR DESIGN PURPOSES ONL Y . • Illu ...

  • Heat & Glo Dakota 42-CE - page 6

    6 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Mantel B A 2.13 m minimum ceiling height Overhang 30.5 cm max. combustible mantel depth B. Clearances Figure 3.3 Clearances to Combustible Mantels or Other Combustibles Above Fireplace 111 . 4 c m 111 . 4 c m Header height. Use only non-combustible material below the ...

  • Heat & Glo Dakota 42-CE - page 7

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 7 FP = FIREPLACE OPENING X = AIR SUPP L Y I NLE T = AREA WHERE FIREPLACE IS NOT PERMITTED O N P R Q FP (See Note 2) ___________________________________________________________________________ ___________________________________________________________________________ ...

  • Heat & Glo Dakota 42-CE - page 8

    8 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 5 5 Fireplace Preparation Sharp Edges • Wear protective gloves and safety glasses during installation. CAUTION A. Remove Logs and Shipping Cover Open the doors by sliding the handles toward the outside edges of the doors (see Figure 5.1) Remove the cartons of logs ...

  • Heat & Glo Dakota 42-CE - page 9

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 9 6 6 Gas Infor mat ion Note: Gas line MUST be run f rom right side of fi replac e. W ARNING CHECK FOR GAS LEAKS Fire Risk Explosion Risk Asphyxiation Risk • Check all fi ttings and connections. • Do not use open fl ame. • After the gas line installation is ...

  • Heat & Glo Dakota 42-CE - page 10

    10 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Batt er y p o la r it y m u s t b e c or rec t o r m odu l e d am a g e w i l l occur . CAUTION 7 7 El ect ric al Infor mation Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. V erify proper op ...

  • Heat & Glo Dakota 42-CE - page 11

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 1 1 A. Mantel Projections Figure 8.1 shows the minimum vertical dimension of fi replace mantels or other combustible projections above the top front edge of the fi replace. Mantel B A 2.13 m minimum ceiling height Overhang 30.5 cm max. combustible mantel depth Figu ...

  • Heat & Glo Dakota 42-CE - page 12

    12 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Sealant Material 0 cm. 0 cm. 0 cm. Finish wall material may be combustible, top & sides. Upper front can be covered with non-combustible material or removed and replaced with non-combustible material. Fire Risk Do NOT obstruct air inlet or outlet grilles. Do NOT ...

  • Heat & Glo Dakota 42-CE - page 13

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 13 A. Clean the Fireplace Clean/vacuum any sawdust that may have accumulated in- side the fi rebox or underneath in the control cavity . Figure 9.1 Back Legs in Grate Brackets (front view) 9 9 Fireplace Setup Figure 9.5 Left Rear Log (SRV728) (front view) Figure 9.3 ...

  • Heat & Glo Dakota 42-CE - page 14

    14 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Figure 9.9 Front Log (SRV727) (front view) Figure 9.7 Left Side Log (SRV723) (front view) Place the fork of log onto the left front bar and rest its back on right rear log. Place front log in front of the main grate with its left end resting on left rear log as show ...

  • Heat & Glo Dakota 42-CE - page 15

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 15 Place right front corner log between the right side wall and right side grate bar as shown. Place right log against the rightmost front grate bar and rest its rear on right rear log, angled towards the corner as shown. Place right center log between the 4th and 5t ...

  • Heat & Glo Dakota 42-CE - page 16

    16 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Handle glass with care. • Inspect the glass for cracks, chips or scratches. • Do NOT strike, slam or scratch glass. • Do NOT operate fi replace with glass door removed, cracked, broken or scratched. • Replace glass door assembly as a complete assembly . W A ...

  • Heat & Glo Dakota 42-CE - page 17

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 17 Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner ’s information manual provided with this fi replace. For assistance or additional information consult a quali fi ed installer , servic ...

  • Heat & Glo Dakota 42-CE - page 18

    18 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 B. Lighting the Fireplace Electronic Ignition LIGHTING INSTRUCTIONS T O TURN OFF GAS T O FIREPLACE 1. Push the ‘OFF’ button on remote. 2. Remove batteries from receiver . FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exact ...

  • Heat & Glo Dakota 42-CE - page 19

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 19 Note: This fi replace should be r un three to four hour s on the initial star t-up. T ur n it of f and let it c ool c ompletely . Clean the glass. Replace t he glass and r un the fi replac e for an a dd i t i on a l 1 2 ho u r s . T h i s w i l l h e l p c u r e ...

  • Heat & Glo Dakota 42-CE - page 20

    20 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Although the frequency of fi replace servicing and maintenance will depend on use and the type of installation, a quali fi ed service technician should perform an fi replace check-up at the beginning of each heating season. Debris from any outside source and/or s ...

  • Heat & Glo Dakota 42-CE - page 21

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 21 A. V alve Access and Service Figure 1 1.1 Lift Out Doors Figure 1 1.3 Loosen Refractory Retaining Strip Figure 1 1.4 Remove V alve Access Panel Figure 1 1.5 Remove Exterior V alve Access Panel Figure 1 1.6 Connect Manometer • The gas valve can be accessed behind ...

  • Heat & Glo Dakota 42-CE - page 22

    22 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 B. Battery Replacement • Remove switch cover plate from the control box. • Slide access panel. • Replace four AA batteries. • Replace access panel and switch cover plate. Ground Wire Control Box Switch Cover Plate Access Panel Batteries Ensure ground wire is ...

  • Heat & Glo Dakota 42-CE - page 23

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 23 C. Maintenance and Service T asks: Inspect Maintenance T asks Doors, surrounds and fronts 1. Inspect for scratches and nicks that can lead to breakage when exposed to heat. 2. Verify no obstructions to air fl ow through the louvers. 3. Verify proper clearance to ...

  • Heat & Glo Dakota 42-CE - page 24

    24 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 With proper installation, operation and maintenance your gas fi replace will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a quali fi ed service person in the diagnosis of a problem and the corrective ...

  • Heat & Glo Dakota 42-CE - page 25

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 25 A. Fireplace Dimension Diagram Dimensions are actual fi replace dimensions. Use for reference only . For framing dimensions and clearances refer to Sec- tion 3. Figure 13.1 Fireplace Dimensions 1 3 13 Referen ce Materials 121.9 cm 106.7 cm 58.7 cm 94.3 cm 17.1 cm ...

  • Heat & Glo Dakota 42-CE - page 26

    26 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 B. Service Parts List Exploded Parts Diagram 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-CE SERIES Beginning Manufacturing Date: 2/01/06 Ending Manufacturing Date: Active 25 16 17 18 22 20 21 24 24 26 27 19 28 4 7 8 10 10 15 14 8 13 8 12 11 11 8 3 2 1 1 9 9 ...

  • Heat & Glo Dakota 42-CE - page 27

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 27 Service Parts List 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-CE SERIES Beginning Manufacturing Date: 2/01/06 Ending Manufacturing Date: Active # Description of Part DAK-B-CE DAK-N-CE DAK-P-CE Qty . req. 1 Door Grille Bar 4036-177 4036-177 4036-177 4 2 T ...

  • Heat & Glo Dakota 42-CE - page 28

    28 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Exploded Parts Diagram 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-CE SERIES Beginning Manufacturing Date: 2/01/06 Ending Manufacturing Date: Active 2 1 13 14 12 4 5 7 8 10 6 9 11 3 3 21 22 23 24 19 20 17 15 16 18 25 ...

  • Heat & Glo Dakota 42-CE - page 29

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 29 Service Parts List 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-CE SERIES Beginning Manufacturing Date: 2/01/06 Ending Manufacturing Date: Active # Description of Part DAK-B-CE DAK-N-CE DAK-P-CE Qty . req. 1 ON/OFF Gas V alve 15697 15697 15697 1 2 Flex Ass ...

  • Heat & Glo Dakota 42-CE - page 30

    30 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 Service Parts List 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-CE SERIES Beginning Manufacturing Date: 2/01/06 Ending Manufacturing Date: Active  SRV720 SRV722 SRV723 SRV724 SRV728 SRV740 SRV742 SRV727  ...

  • Heat & Glo Dakota 42-CE - page 31

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 31 Service Parts List 42 in. Outdoor Gas Fireplace Service Parts DAKOT A42-CE SERIES Beginning Manufacturing Date: 2/01/06 Ending Manufacturing Date: Active # Description of Part DAK-B-CE DAK-N-CE DAK-P-CE Qty . req. Log Set - Box 1 of 3 4036-71 1 4036-71 1 4036-71 1 ...

  • Heat & Glo Dakota 42-CE - page 32

    32 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 This page intentionally left blank. ...

  • Heat & Glo Dakota 42-CE - page 33

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 33 This page intentionally left blank. ...

  • Heat & Glo Dakota 42-CE - page 34

    34 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 This page intentionally left blank. ...

  • Heat & Glo Dakota 42-CE - page 35

    Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1 1/07 35 C. W arranty HEA T & GLO LIFESTYLE COLLECTION LIMITED 10 YEAR W ARRANTY In order to presumptively establish the dates to which your HEA T & GLO Limited W arranty runs, you must mail the completed warranty card to HEA T & GLO, 20802 Kensington Boulevard ...

  • Heat & Glo Dakota 42-CE - page 36

    36 Heat & Glo Lifestyle Collection • Dakota 42-CE • 4036-915 Rev I • 1/07 D. Contact Information Please contact your Heat & Glo LifeStyle Collection dealer with any questions or concerns. For the number of your nearest Heat & Glo LifeStyle Collection dealer , please visit www .heatnglo-lifestyle.com - NOTES - This product may be c ...

Manufacturer Heat & Glo Category Outdoor Fireplace

Documents that we receive from a manufacturer of a Heat & Glo Dakota 42-CE can be divided into several groups. They are, among others:
- Heat & Glo technical drawings
- Dakota 42-CE manuals
- Heat & Glo product data sheets
- information booklets
- or energy labels Heat & Glo Dakota 42-CE
All of them are important, but the most important information from the point of view of use of the device are in the user manual Heat & Glo Dakota 42-CE.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Heat & Glo Dakota 42-CE, service manual, brief instructions and user manuals Heat & Glo Dakota 42-CE. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Heat & Glo Dakota 42-CE.

Similar manuals

A complete manual for the device Heat & Glo Dakota 42-CE, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Heat & Glo Dakota 42-CE by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Heat & Glo Dakota 42-CE.

A complete Heat & Glo manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Heat & Glo Dakota 42-CE - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Heat & Glo Dakota 42-CE, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Heat & Glo Dakota 42-CE, that we can find in the current document
3. Tips how to use the basic functions of the device Heat & Glo Dakota 42-CE - which should help us in our first steps of using Heat & Glo Dakota 42-CE
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Heat & Glo Dakota 42-CE
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Heat & Glo Dakota 42-CE in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Heat & Glo Dakota 42-CE?

Use the form below

If you did not solve your problem by using a manual Heat & Glo Dakota 42-CE, ask a question using the form below. If a user had a similar problem with Heat & Glo Dakota 42-CE it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)