English dropdown-ico

Manual Vulcan-Hart VGL60E

12 pages 0.19 mb
Download

Go to site of 12

Summary
  • Vulcan-Hart VGL60E - page 1

    VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201-0696, TEL. (502) 778-2791 FORM 30909 (1-95) VGL SERIES GAS STEAM KETTLES MODEL VGL20 VGL40 VGL60 VGL20E VGL40E VGL60E INST ALLA TION & OPERA TION MANUAL MODEL VGL40 ...

  • Vulcan-Hart VGL60E - page 2

    – 2 – IMPORT ANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GAS EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. POST IN A PROMINENT LOCATION THE INSTRUCTIONS TO BE FOLLOWED IN THE EVENT THE SMELL OF GAS IS DETECTED. THIS INFORMATION CAN BE OB ...

  • Vulcan-Hart VGL60E - page 3

    – 3 – Installation, Operation, and Care of VGL SERIES GAS STEAM KETTLES SA VE THESE INSTRUCTIONS FOR FUTURE USE GENERAL The VGL Series Gas Steam Kettles use efficient gas heat and thermostat controls to provide superior cooking performance. The VGL Kettles are intended for commercial use only; not for household use. If the VGL kettle's mod ...

  • Vulcan-Hart VGL60E - page 4

    – 4 – LEVELING THE APPLIANCE To level the kettle, use a spirit level in all directions on the top of the kettle with the lid up. Units with legs — adjust the bottom foot in each leg to overcome an uneven floor. INSTALLATION CODES AND STANDARDS The steam kettle must be installed in the United States in accordance with: 1) State and local codes ...

  • Vulcan-Hart VGL60E - page 5

    – 5 – GAS CONNECTION The data plate on the lower right side of the kettle indicates the type of gas your unit is equipped to burn. DO NOT connect to any other gas type. A 1" NPT line is provided at the rear for the connection. Each kettle is equipped with an internal pressure regulator which is set for 4" W.C. manifold pressure for na ...

  • Vulcan-Hart VGL60E - page 6

    – 6 – ELECTRICAL CONNECTION Refer to the electrical diagram attached to the inside of the front panel and to ELECTRICAL DATA. ELECTRICAL DATA MODEL Volts / Hz / Ph Standard / Optional Amps Circuit Requirement VGL Series 115 / 60 / 1 Standard 2.0 15 Amp Cord/Plug 208 / 60 / 1 or 3 Optional 1.0 Hard wire 236 / 60 / 1 or 3 Optional 1.0 Hard wire C ...

  • Vulcan-Hart VGL60E - page 7

    – 7 – USING THE GAS CONTROL (Kettles with Pilot Lights) A. Lighting 1. Turn thermostat to lowest position and turn the power switch OFF. 2. Open control panel access door. 3. Turn dial on combination control to pilot position. NOTE : Any gas service valves exterior to the unit should be open. 4. Remove shield which fits over the burners for acc ...

  • Vulcan-Hart VGL60E - page 8

    – 8 – USING THE GAS CONTROL (Kettles with Electronic Ignition) Units equipped with electronic ignition do not require "lighting" the pilot with a match. A. Lighting 1. Turn thermostat to lowest position and turn the power switch OFF. 2. Open control panel access door. 3. Turn dial on combination control to ON position by rotating the ...

  • Vulcan-Hart VGL60E - page 9

    – 9 – ON OFF POWER COOKING LOW WATER COOK TEMP. ▼ OFF PRESSURE WATER LEVEL OPERA TION WARNING : THE STEAM KETTLE AND ITS PARTS ARE HOT. USE CARE WHEN OPERATING, CLEANING, AND SERVICING THE STEAM KETTLE. CONTROLS (Figs. 1, 2) Main Power Switch — Turns main power ON or OFF. Switch must be turned ON to heat the kettle. Turn the switch OFF when ...

  • Vulcan-Hart VGL60E - page 10

    – 10 – DAILY OPERATION Daily operation should consist of turning on the power switch and setting the thermostat for the desired temperature. It is recommenced the kettle be preheated empty prior to use. Milk or egg based products should be placed in the kettle before heating, however, to prevent sticking. The kettle is preheated when the cookin ...

  • Vulcan-Hart VGL60E - page 11

    – 11 – CLEANING WARNING : DISCONNECT ELECTRICAL POWER BEFORE CLEANING. Clean inside the kettle daily by wiping with a clean damp cloth. Clean the exterior daily with soap and detergent and water. Rinse thoroughly and wipe dry with a soft clean cloth. Monthly — Clean around burner air mixers, louvered panels and pilots if grease or lint have a ...

  • Vulcan-Hart VGL60E - page 12

    – 12 – FORM 30909 (1-95) PRINTED IN U.S.A. ...

Manufacturer Vulcan-Hart Category Hot Beverage Maker

Documents that we receive from a manufacturer of a Vulcan-Hart VGL60E can be divided into several groups. They are, among others:
- Vulcan-Hart technical drawings
- VGL60E manuals
- Vulcan-Hart product data sheets
- information booklets
- or energy labels Vulcan-Hart VGL60E
All of them are important, but the most important information from the point of view of use of the device are in the user manual Vulcan-Hart VGL60E.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Vulcan-Hart VGL60E, service manual, brief instructions and user manuals Vulcan-Hart VGL60E. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Vulcan-Hart VGL60E.

Similar manuals

A complete manual for the device Vulcan-Hart VGL60E, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Vulcan-Hart VGL60E by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Vulcan-Hart VGL60E.

A complete Vulcan-Hart manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Vulcan-Hart VGL60E - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Vulcan-Hart VGL60E, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Vulcan-Hart VGL60E, that we can find in the current document
3. Tips how to use the basic functions of the device Vulcan-Hart VGL60E - which should help us in our first steps of using Vulcan-Hart VGL60E
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Vulcan-Hart VGL60E
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Vulcan-Hart VGL60E in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Vulcan-Hart VGL60E?

Use the form below

If you did not solve your problem by using a manual Vulcan-Hart VGL60E, ask a question using the form below. If a user had a similar problem with Vulcan-Hart VGL60E it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)