English dropdown-ico

Manual Desa VV36PB(1)

40 pages 4.91 mb
Download

Go to site of 40

Summary
  • Desa VV36PB(1) - page 1

    FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch • Do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. • If you cannot reach your gas supplier, call the fire department. WARNING: ...

  • Desa VV36PB(1) - page 2

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 2 SAFETY INFORMA TION WARNING: This product contains and/or generates chemicals known to the State of California to cause cancer or birth defects, or other reproductive harm. IMPORTANT: Read this owner’s manual carefully and completely before tryi ...

  • Desa VV36PB(1) - page 3

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 3 3 SAFETY INFORMA TION Continued PRODUCT IDENTIFICA TION Figure 1 - Direct-Vent Fireplace with Millivolt Ignition SAFETY INFORMATION LOCAL CODES PRODUCT IDENTIFICATION Glass Door Assembly Blower Switch (BKT Standard with CHDV Models) Piezo Ignitor ...

  • Desa VV36PB(1) - page 4

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 4 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent fireplace: • The venting system may be routed to the outside of your home in several ways. It may vent through the roof (vertical) or it may vent to ...

  • Desa VV36PB(1) - page 5

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 5 5 A B E F G H D C Nailing T abs CLEARANCES Minimum clearances to combustibles for the fireplace are as follows: Back, and sides 0"/mm Perpendicular walls 6" (152mm) Floor 0"/mm Ceiling to louver opening 42" (1067mm) Front 36&qu ...

  • Desa VV36PB(1) - page 6

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 6 Fixed Closed Openable Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porc ...

  • Desa VV36PB(1) - page 7

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 7 7 VENTING INST ALLA TION INSTRUCTIONS NOTICE: Read these instructions completely be- fore attempting installation. These models are tested and approved for use with DESA (direct- vent) pipe components and terminations. The venting system must term ...

  • Desa VV36PB(1) - page 8

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 8 INSTALLATION PLANNING There are two basic types of direct-vent installation: • Horizontal T ermination • V er tical T ermination Horizontal Termination Installation IMPORTANT: Horizontal square terminations require only inner portion of wall f ...

  • Desa VV36PB(1) - page 9

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 9 9 WARNING: Do not recess vent termination into any wall. This will cause a fire hazard. 6. Noncombustible Exterior Wall: Position the horizontal vent cap in the center of the 8 1 / 2 " round hole and attach to the exte- rior wall with four wo ...

  • Desa VV36PB(1) - page 10

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 10 Horizontal High Wind Square Termination Wall Firestop 45° Elbow Figure 14 - Horizontal Termination Configuration for Square or Round Terminations 45° Elbow Wall Firestop Horizontal Round Termination Exterior Portion of Wall Firestop (Round Term ...

  • Desa VV36PB(1) - page 11

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 11 11 Figure 15 - Horizontal Termination Configuration for Corner Installation Using One 90° Elbow Square Termination Wall Firestop Not to Exceed (H) Limits As Required for (V) See Chart for Pipe Section Required 45° Elbow 90° Elbow 90° Elbow Sq ...

  • Desa VV36PB(1) - page 12

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 12 V enting with T wo 90° Elbows V er tical (V) Horizontal (H 1 ) + Horizontal (H 2 ) 5' min. 6' max. 6' min. 12' max. 7' min. 18' max. 8' min. 20' max. 20' max. 20' max. Figure 18 - Horizontal Term ...

  • Desa VV36PB(1) - page 13

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 13 13 INSTALLATION FOR VERTICAL TERMINATION Note: Vertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters, or other framing will obstruct the ventin ...

  • Desa VV36PB(1) - page 14

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 14 VENTING INST ALLA TION INSTRUCTIONS Continued Vertical Termination Configurations Figures 21 through 24 show four different configurations for verti- cal termination. V enting with T wo 90° Elbo ws V er tical (V) Horizontal (H 1 ) + Horizontal ( ...

  • Desa VV36PB(1) - page 15

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 15 15 VENTING INST ALLA TION INSTRUCTIONS Continued V ertical V enting V = 40' max. Figure 24 - Vertical Venting Configuration With No Horizontal Run (Vertical Round High Wind Termination Shown) Note: Install restrictor into inner collar of fir ...

  • Desa VV36PB(1) - page 16

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 16 FIREPLACE INST ALLA TION CHECK GAS TYPE Use proper gas type for the fireplace unit you are installing. If you have conflicting gas types, do not install fireplace. See retailer where you purchased the fireplace for proper fireplace according to y ...

  • Desa VV36PB(1) - page 17

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 17 17 . FIREPLACE INSTALLATION Installing Optional Blower Accessories (Cont.) V a r ia bl e F a n S w it c h W h it e W h i te B la c k G re e n O n 1 1 0 /1 1 5 V . A .C . B lo w e r M ot o r B la c k B la c k B la c k O ff Figure 27 - Location of ...

  • Desa VV36PB(1) - page 18

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 18 INSTALLING GAS PIPING TO FIREPLACE LOCATION Installation Items Needed Before installing fireplace, make sure you have the items listed below. • external regulator (supplied by installer) • piping (check local codes) • sealant (resistant to ...

  • Desa VV36PB(1) - page 19

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 19 19 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Installing Gas Piping to Fireplace Location (Cont.) Connecting Fireplace To Gas Supply Checking Gas Connections We recommend that you install a sediment trap/drip leg in supply line as ...

  • Desa VV36PB(1) - page 20

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 20 Figure 33 - Equipment Shutoff Valve Open Closed Equipment Shutoff Valve Figure 35 - Checking Gas Joints for Natural Gas Fireplace Figure 34 - Checking Gas Joints for Propane/LP Gas Fireplace Propane/LP Supply Tank Gas Valve Equipment Shutoff Valv ...

  • Desa VV36PB(1) - page 21

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 21 21 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Installing Optional Wireless Hand-Held Remote Control - (C)GHRCB and (C)GHRCTB Series Installing Remote Receiver 1. Open bottom louver and locate the switch bracket on the left. 2. Unsc ...

  • Desa VV36PB(1) - page 22

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 22 Lock Unlock REMOVING/REPLACING GLASS DOOR CAUTION: Do not operate this fireplace with a broken glass door panel or without the glass door panel securely in place. For replacement part infor- mation see Replacement Parts , page 36. Removing Louver ...

  • Desa VV36PB(1) - page 23

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 23 23 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Installing Optional Brick Liner Models BL36D(S) and BL36DH(S) INSTALLING OPTIONAL BRICK LINER MODELS BL36DA(SA) AND BL36DHA(SA) WARNING: If fireplace has been running, turn off and unpl ...

  • Desa VV36PB(1) - page 24

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 24 WARNING: The glass door must be securely in place before running this fireplace. Do not run this fireplace if glass is missing or broken. NOTICE: Do not put lava rock on burner or under burner. Placing lava rock on burner will cause perfor- mance ...

  • Desa VV36PB(1) - page 25

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 25 25 OPERA TING FIREPLACE LIGHTING INSTRUCTIONS 1 . ST OP! Read the safety information above. 2. Open lower louver panel. 3. T urn off all electric power to the fir eplace. 4. Push in gas control knob slightly and turn clockwise to “OFF”. 5. W ...

  • Desa VV36PB(1) - page 26

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 26 OPERA TING FIREPLACE Continued OPERATING FIREPLACE Optional Hand-Held Remote Operation O F F P I L O T O N L O I H ON OFF REMOTE ON OFF Blower Control Knob (Optional Accessory) Variable Control Knob Selector Switch in Remote Position Gas Control ...

  • Desa VV36PB(1) - page 27

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 27 27 OPERATING FIREPLACE Optional Hand-Held Remote Operation (Cont.) Operating Optional GWMT1 Wall Mounted Thermostat Operating Optional Blower Accessory INSPECTING BURNERS Pilot Assembly Burner Flame Pattern OPERA TING FIREPLACE Continued OPERATIN ...

  • Desa VV36PB(1) - page 28

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 28 INSPECTING BURNERS Burner Flame Pattern CLEANING AND MAINTENANCE Glass Door Pilot and Burners Logs Venting System PILOT AND BURNERS • Remove ember material before cleaning burners and replace when cleaning is complete. • Burner and controls s ...

  • Desa VV36PB(1) - page 29

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 29 29 TROUBLESHOOTING TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off heater and let cool before servicing. Only a quali- fied service person should service and repair heater. CAUTION: Never use a ...

  • Desa VV36PB(1) - page 30

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 30 OBSERVED PROBLEM Burner does not light after pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial operation Heater produces a whistling noise when burner is lit Glass soots Fireplace produce ...

  • Desa VV36PB(1) - page 31

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 31 31 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a ne ...

  • Desa VV36PB(1) - page 32

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 32 ILLUSTRATED PARTS BREAKDOWN Models V36N-A, V36P-A, VV36NB(1), VV36NSB(1), VV36NHB(1), VV36PB(1), VV36PSB(1), VV36PHB(1) and CHDV36NR-B ILLUSTRA TED P AR TS BREAKDOWN MODELS V36N-A, V36P-A, VV36NB(1), VV36NSB(1), VV36NHB(1), VV36PB(1), VV36PSB(1), ...

  • Desa VV36PB(1) - page 33

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 33 33 PARTS LIST Models V36N-A, V36P-A, VV36NB(1), VV36NSB(1), VV36NHB(1), VV36PB(1), VV36PSB(1), VV36PHB(1) and CHDV36NR-B P ARTS LIST This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed ...

  • Desa VV36PB(1) - page 34

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 34 4 3 2 5 6 7 8 9 10 11 12 13 14 15 16 17 1 21 19 20 18 ILLUSTRA TED P AR TS BREAKDOWN BURNER ASSEMBLY FOR MODELS V36N-A, V36P-A, VV36NSB(1), VV36NHB(1), VV36PB(1), VV36PSB(1), VV36PHB(1), CHDV36NR-B ILLUSTRATED PARTS BREAKDOWN Models V36N-A, V36P- ...

  • Desa VV36PB(1) - page 35

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 35 35 KEY PART NO. NUMBER DESCRIPTION QTY. 1 ** Burner Assembly Base 1 2 108759-01 Pan Burner Assembly 1 3 11165 Screw #10 x 5/8 MD TR BLK 12 4 108763-01 Tube Burner 1 5 104506-26 Pan Burner Orifice (Natural Gas #50) 1 14545 Pan Burner Orifice (Prop ...

  • Desa VV36PB(1) - page 36

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 36 V36N-A V36P-A VV36N B(1) CHDV36NR-B VV36P B(1) Btu 18,000/ 18,000/ 17,500/ 26,000 Btu/hr 26,000 Btu/hr 25,000 Btu/hr Gas Type Natural Natural Propane/LP Ignition Piezo Piezo Piezo Manifold Pressure 3.5" w.c. 3.5" w.c. 10.0" w.c. Mi ...

  • Desa VV36PB(1) - page 37

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 37 37 1. Where will the product be used? ❍ Living/F amily Room ❍ Office/Warehouse ❍ Utility Shed/Outb uilding ❍ Garage ❍ Bedroom ❍ Bathroom ❍ Other 2. If you bought this product yourself , did you plan to purchase this type of product ...

  • Desa VV36PB(1) - page 38

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 38 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 Postage Required T APE T APE ...

  • Desa VV36PB(1) - page 39

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 39 39 ACCESSORIES Purchase these fireplace accessories from your local retailer. If they can not supply these accessories, call DESA’s Sales Department at 1-866-672-6040. for information. You can also write to the address listed on the back page o ...

  • Desa VV36PB(1) - page 40

    111252-01D For more information, visit www.desatech.com For more information, visit www.desatech.com 40 LIMITED WARRANTY DIRECT-VENT FIREPLACE DESA warrants this product to be free from defects in materials and components for two (2) years from the date of first purchase, provided that the product has been properly installed, operated and maintaine ...

Manufacturer Desa Category Outdoor Fireplace

Documents that we receive from a manufacturer of a Desa VV36PB(1) can be divided into several groups. They are, among others:
- Desa technical drawings
- VV36PB(1) manuals
- Desa product data sheets
- information booklets
- or energy labels Desa VV36PB(1)
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa VV36PB(1).

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa VV36PB(1), service manual, brief instructions and user manuals Desa VV36PB(1). Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa VV36PB(1).

Similar manuals

A complete manual for the device Desa VV36PB(1), how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa VV36PB(1) by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa VV36PB(1).

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa VV36PB(1) - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa VV36PB(1), FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa VV36PB(1), that we can find in the current document
3. Tips how to use the basic functions of the device Desa VV36PB(1) - which should help us in our first steps of using Desa VV36PB(1)
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa VV36PB(1)
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa VV36PB(1) in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa VV36PB(1)?

Use the form below

If you did not solve your problem by using a manual Desa VV36PB(1), ask a question using the form below. If a user had a similar problem with Desa VV36PB(1) it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)