English dropdown-ico

Manual Desa CGDV32NR

38 pages 1.88 mb
Download

Go to site of 38

Summary
  • Desa CGDV32NR - page 1

    FOR YOUR SAFETY WHA T TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch • Do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier ’ s instructions. • If you cannot reach your gas supplier , call the fire de - partment ...

  • Desa CGDV32NR - page 2

    www .desatec h.com 1 16646-01A 2 SAFETY INFORMA TION WAR NI NG : Thi s pr odu ct c on ta in s and /o r gen er at es ch em ic als kn own to the Sta te of Cal if or nia to c au se ca nc er or b ir th de fe ct s or o th er r epr od uc tiv e ha rm . IMPORT ANT : Read this owner’s manual carefully and completely before trying to assemble, operate or s ...

  • Desa CGDV32NR - page 3

    3 3 www .desatec h.com 1 16646-01A SAFETY INFORMA TION Continued PR ODUCT IDENTIFICA TION Figure 1 - Direct-V ent Fireplace with Millivolt Ignition L OCAL CODES Install and use fireplace with care. Follow all local codes. In the absence to local codes, use the current National Fuel Gas Code ANSI Z223.1/NFP A 54* (USA) or the current CSA-B149.1 Ins ...

  • Desa CGDV32NR - page 4

    www .desatec h.com 1 16646-01A 4 PR ODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent fireplace: • The venting system may be routed to the outside of your home in several ways. It may vent through the roof (vertical) or it may vent to an outsid e/exter ior wall (horiz ontal). The vent pipe instal - lat ...

  • Desa CGDV32NR - page 5

    5 5 www .desatec h.com 1 16646-01A A B E F G H D C Nailing T abs CLEARANCES Mi ni mu m cle ar an ces t o co mb ust ib le s for t he fi re pla ce a re as f ol lo ws: *Back and sides 0"/mm Perpendicular walls 6" (152mm) Floor 0"/mm Ceiling to louver opening 42" (1067mm) Front 36" (914mm) T op of Standoffs 0"/mm V ent (S ...

  • Desa CGDV32NR - page 6

    www .desatec h.com 1 16646-01A 6 Fixed Closed O pe n a bl e Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12 inches (30.5mc) minimum] B = clearance t ...

  • Desa CGDV32NR - page 7

    7 7 www .desatec h.com 1 16646-01A These models are tested and approved for use with DESA (direct- vent) pipe components and terminations. The vent ing syst em must term inate on the outsi de of the stru cture and can not be atta ched to a chimn ey or flue sys tem servi ng a sep arat e sol id fuel or gas burni ng appli ance . A direc t-ve nt appli ...

  • Desa CGDV32NR - page 8

    www .desatec h.com 1 16646-01A 8 INST ALLA TION PLANNING There are two basic types of direct-vent installation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMP ORTAN T : Horizontal square terminations require only inner portion of wall firestop. Horizontal installations using round ter- mination requ ...

  • Desa CGDV32NR - page 9

    9 9 www .desatec h.com 1 16646-01A W ARNING: Do not recess vent termination into any wall. This will cause a fire hazard. 6. Noncombustible Exterior Wall: Position the horizontal vent cap in the center of the 8 1 / 2 " round hole and attach to the exterior wall with four wood screws provided. Before attach- ing the vent cap to exterior wall, ...

  • Desa CGDV32NR - page 10

    www .desatec h.com 1 16646-01A 10 Horizontal High Wind Square T ermination W all Firestop 45° Elbow Fig ure 14 - Hori zonta l Ter minat ion Co nfigur ation for Square or Round T erminations 45° Elbow W all Firestop Horizontal Round T ermination Exterior Portion of W all Firestop (Round T ermination Only) GROUND FLOOR INST ALLA TION Recommended A ...

  • Desa CGDV32NR - page 11

    1 1 1 1 www .desatec h.com 1 16646-01A Figure 15 - Horizontal T ermination Configuration for Corner Installation Using One 90° Elbow Square T ermination W all Firestop Not to Exceed (H) Limits As Required for (V) See Chart for Pipe Section Required 45° Elbow 90° Elbow 90° Elbow Square T ermination W all Firestop 45° Elbow 12" Minimum COR ...

  • Desa CGDV32NR - page 12

    www .desatec h.com 1 16646-01A 12 V enting with T wo 90° Elbows V ertical (V) Horizontal (H 1 ) + Horizontal (H 2 ) 5' min. 6' max. 6' min. 12' max. 7' min. 18' max. 8' min. 20' max. 20' max. 20' max. Figure 18 - Horizontal T ermination Configuration for V enting Using T wo 90° Elbows with T ermi ...

  • Desa CGDV32NR - page 13

    13 13 www .desatec h.com 1 16646-01A INS TAL LATI ON F OR V ERTI CAL TER MINA TION Not e : V ertical restrictor must be installed in all vertical installa- tions. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters or other framing will obstruct the venting system, consider an offset (see Figure 19) to avoid cutt ...

  • Desa CGDV32NR - page 14

    www .desatec h.com 1 16646-01A 14 VENTING INST ALLA TION INSTR UCTIONS Continued V ertical T ermination Configurations Figures 21 through 24 show four different configurations for verti- cal termination. V enting with T wo 90° Elbows V ertical (V) Horizontal (H 1 ) + Horizontal (H 2 ) 5' min. 2' max. 6' min. 4' max. 7' m ...

  • Desa CGDV32NR - page 15

    15 15 www .desatec h.com 1 16646-01A VENTING INST ALLA TION INSTR UCTIONS Continued V ertical V enting V = 40' max. Figure 24 - V ertical V enting Configuration With No Horizontal Run (V ertical Round High Wind T ermination Shown) Note : Install restrictor into inner collar of fireplace as shown. 45° Elbow HIGH AL TITUDE INST ALLA TION Y ou ...

  • Desa CGDV32NR - page 16

    www .desatec h.com 1 16646-01A 16 CHECK GAS TYPE Us e pro pe r gas ty pe fo r th e fire pl ac e uni t you ar e ins ta ll ing . If you ha ve co nfl ic tin g gas ty pe s, do not in sta ll fire pl ac e. See re tai le r wh er e you pu rc ha sed t he fir ep lac e fo r pro pe r fire pl ace a cc ord in g to yo ur ga s typ e or to purchase gas convers ...

  • Desa CGDV32NR - page 17

    17 17 www .desatec h.com 1 16646-01A Figure 26 - Attaching Speed Control to Firebox Speed Control Control Shaft Locknut Control Knob Switch Bracket Blower Plug-In FIREPLACE INST ALLA TION Installing Optional Blower Accessories (Cont.) Duplex Outlet (Located underneath firebox floor against lower right outside wall) 5. Mo unt spee d cont rol box t ...

  • Desa CGDV32NR - page 18

    www .desatec h.com 1 16646-01A 18 Figure 29 - Blower Wiring Diagram for Thermostat-Controlled Models Blower Wiring Diagram CAUTION: Label all wires prior to disconnection when servicing controls. W iring errors can cause improper and dangerous operation. V erify proper operation after servicing. Blue V a riable Fan Switch Fan Switch (N.O.) Green Wh ...

  • Desa CGDV32NR - page 19

    19 19 www .desatec h.com 1 16646-01A FIREPLA CE INST ALLA TION Continued FIREPLACE INST ALLA TION Installing Gas Piping to Fireplace Location (Cont.) Connecting Fireplace to Gas Supply Checking Gas Connections CA UTION : Us e o nly new, bla ck i ron or s teel pip e. Int ernal ly-t inned copp er tubin g may be used in cer tain ar ea s. C hec k yo ur ...

  • Desa CGDV32NR - page 20

    www .desatec h.com 1 16646-01A 20 Figure 33 - Equipment Shutoff V alve Open Closed Equipment Shutoff V alve Figure 35 - Checking Gas Joints for Natural Gas Fireplace Figure 34 - Checking Gas Joints for Propane/LP Gas Fireplace Propane/LP Supply T ank Gas V alve Equipment Shutoff V alve Gas Meter Gas V alve Equipment Shutoff V alve FIREPLA CE INST A ...

  • Desa CGDV32NR - page 21

    21 21 www .desatec h.com 1 16646-01A FIREPLA CE INST ALLA TION Continued FIREPLACE INST ALLA TION Installing Optional Wireless Hand-Held Remote Control - GHRCB and GHRCTB Series Removing/Replacing Glass Door INST ALLING OPTIONAL WIRELESS HAND- HELD REMOTE CONTROL - GHRCB AND GHRCTB SERIES NOTICE: Use only alkaline batteries (not included). Installi ...

  • Desa CGDV32NR - page 22

    www .desatec h.com 1 16646-01A 22 Lock Unlock Glass Frame Assembly Screw Fi gu re 42 - Removing/Replacing Glass Door Hinge Removing Glass Door If replacement of glass is necessary , the entire assembly , glass and frame, must be replaced. If glass is broken, wear gloves and tape the remaining fragments onto the frame. 1. Remove screen assembly by p ...

  • Desa CGDV32NR - page 23

    23 23 www .desatec h.com 1 16646-01A FIREPLA CE INST ALLA TION Continued FIREPLACE INST ALLA TION Installing Optional Brick Liner Model BL32D (Cont.) Installing Logs, Lava Rock and Glowing Embers Figure 44 - Installing Side Brick Panels Left Side Brick Panel INST ALLING LOGS, LA V A ROCK AND GLOWING EMBERS Each log is marked with a number . These n ...

  • Desa CGDV32NR - page 24

    www .desatec h.com 1 16646-01A 24 OPERA TING FIREPLACE Installing Logs, Lava Rock and Glowing Embers (Cont.) For Y our Safety Read Before Lighting Lighting Instructions OPERA TING FIREPLACE FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exa ctly , a fire or expl osion may resu lt causi ng prope rty damage, p ...

  • Desa CGDV32NR - page 25

    25 25 www .desatec h.com 1 16646-01A OPERA TING FIREPLACE Lighting Instructions (Cont.) T o Turn Off Gas T o Appliance Manual Lighting Procedure Optional Hand-Held Remote Operation O F F P I L O T L O I H O N Figure 51 - Control V alve Piezo Ignitor Gas Control Knob V ariable Control Knob OPERA TING FIREPLACE Continued O F F P I L O T L O I H ON OF ...

  • Desa CGDV32NR - page 26

    www .desatec h.com 1 16646-01A 26 Fi gu re 54 - Thermostat Hand-Held Remote Control Unit GHRCTB T urns Hand-Held Remote On or Off and Allows Y ou to Choose the Manual Setting Selects Auto Setting Increases Room T emperature in AUTO Mode Locks System to Prevent Accidental Ignition Digital Display Shows T emperature and Settings T urns Burners On or ...

  • Desa CGDV32NR - page 27

    27 27 www .desatec h.com 1 16646-01A OPERA TING FIREPLACE Continued OPERA TING OPTIONAL BLOWER ACCESSOR Y Locate the blower controls by opening the lower louver panel on the fireplace. Blower controls are located on the right side of the switch bracket to the left just inside the louver panel. The BK manua l blower and the BKT therm ostati cally- ...

  • Desa CGDV32NR - page 28

    www .desatec h.com 1 16646-01A 28 CLEANING AND MAINTENANCE Glass Door Pilot and Burners Logs V enting System C L E A N I N G A N D M A I N T E N A N C E W ARNING: T urn off fireplace and let cool before cleaning. C AU T IO N : Yo u m us t k e ep c o nt r ol ar e as , b ur n er s and c ir c ul a t in g ai r pa s sa g e wa y s of fi re p la c e cl ...

  • Desa CGDV32NR - page 29

    29 29 www .desatec h.com 1 16646-01A TR OUBLESHOOTING Note: All troubleshooting items are listed in order of operation. W ARNING: T urn off heater and let cool before servicing. Only a qualified service person should service and repair heater . CAUTION: Never use a wire, needle or similar object to clean pilot. This can damage pilot unit. POSSIBLE ...

  • Desa CGDV32NR - page 30

    www .desatec h.com 1 16646-01A 30 TROUBLESHOOTING OBSERVED PROBLEM Burner does not light after pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial opera - tion Heater produces a whistling noise when burner is lit Glass soots Fireplace produces a clicking/ticking noise just after burners are ...

  • Desa CGDV32NR - page 31

    31 31 www .desatec h.com 1 16646-01A TR OUBLESHOOTING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier ’ s instructions. • ...

  • Desa CGDV32NR - page 32

    www .desatec h.com 1 16646-01A 32 6 7 21 18 19 10 13 2 11 20 8 22-2 22-6 22-4 22-5 22-3 22-1 1 14 9 12 17 3 15 4 16 5 16 9-3 9-2 9-1 9-13 9-14 9-18 9-15 9-16 9-19 9-4 9-5 9-9 9-7 9-8 9-6 9-12 9-10 9-11 9-17 ILLUSTRA TED P ARTS BREAKDOWN (V)T32N-A, (V)T32NB-A, (V)T32NR-A, (V)T32NRB-A (V)T32P-A, (V)T32PB-A, (V)T32PR-A, (V)T32PRB-A, CGDV32NR ILL USTRA ...

  • Desa CGDV32NR - page 33

    33 33 www .desatec h.com 1 16646-01A P ARTS LIST (V)T32N-A, (V)T32NB-A, (V)T32NR-A, (V)T32NRB-A (V)T32P-A, (V)T32PB-A, (V)T32PR-A, (V)T32PRB-A, CGDV32NR P ARTS LIST (V)T32N-A, (V)T32NB-A, (V)T32NR-A, (V)T32NRB-A, (V)T32P-A, (V)T32PB-A, (V)T32PR-A, (V)T32PRB-A, CGDV32NR This list contains replaceable parts used in your fireplace. When ordering part ...

  • Desa CGDV32NR - page 34

    www .desatec h.com 1 16646-01A 34 CGDV32NR (V)T32N(R)-A (V)T32P(R)-A Btu 12,000/18,000 Btu/hr 1 1,000/17,000 Btu/hr Gas T ype Natural Propane/LP Ignition Piezo Piezo Manifold Pressure 3.5" w .c. 10.0" w .c. Minimum Inlet Supply Pressure 5.5" w .c. 1 1.0" w .c. D im e ns i on ( H x W x D) Fireplace (Actual size of firebox. 32 1 ...

  • Desa CGDV32NR - page 35

    35 35 www .desatec h.com 1 16646-01A 1. Where will the product be used? � Living/Family Room � Office/W arehouse � Utility Shed/Outbuilding � Garage � Bedroom � Bathroom � Other 2. If you bought this product yourself, did you plan to purchase this type of product before going into the store? � Y es � No 3. Who selected the product ...

  • Desa CGDV32NR - page 36

    www .desatec h.com 1 16646-01A 36 2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 Postage Required T APE T APE ...

  • Desa CGDV32NR - page 37

    37 37 www .desatec h.com 1 16646-01A T APE ACCESSORIES Purchase these fireplace accessories from your local retailer . If they can not supply these accessories, call DESA ʼ s Sales Department at 1-866-672-6040. for information. Y ou can also write to the address listed on the back page of this manual. BRICK LINER (Not Shown) BL32D - Refractory Br ...

  • Desa CGDV32NR - page 38

    LIMITED WARRANTY DIRECT -VENT FIREPLACE DESA warrants this product to be free from defects in materials and components for two (2) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. T o make a claim under this warranty the Bill of Sal ...

Manufacturer Desa Category Outdoor Fireplace

Documents that we receive from a manufacturer of a Desa CGDV32NR can be divided into several groups. They are, among others:
- Desa technical drawings
- CGDV32NR manuals
- Desa product data sheets
- information booklets
- or energy labels Desa CGDV32NR
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa CGDV32NR.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa CGDV32NR, service manual, brief instructions and user manuals Desa CGDV32NR. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa CGDV32NR.

Similar manuals

A complete manual for the device Desa CGDV32NR, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa CGDV32NR by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa CGDV32NR.

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa CGDV32NR - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa CGDV32NR, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa CGDV32NR, that we can find in the current document
3. Tips how to use the basic functions of the device Desa CGDV32NR - which should help us in our first steps of using Desa CGDV32NR
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa CGDV32NR
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa CGDV32NR in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa CGDV32NR?

Use the form below

If you did not solve your problem by using a manual Desa CGDV32NR, ask a question using the form below. If a user had a similar problem with Desa CGDV32NR it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)