English dropdown-ico

Manual Powerex SBS1307

20 pages 0.52 mb
Download

Go to site of 20

Summary
  • Powerex SBS1307 - page 1

    Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or prop- erty damage! Retain instructions for future reference. Powerex ? ...

  • Powerex SBS1307 - page 2

    2 Scroll Air Compr essors T ankmount/Basemount Installation RECEIVING THE UNIT Immediately upon receipt of the scroll compressor, the unit should be inspect- ed for any damage which may have occurred in shipment. Any shipping damage must be immediately filed with the freight carrier. The compressor nameplate should be checked to see if the unit is ...

  • Powerex SBS1307 - page 3

    3 Scroll Air Compr essors T ankmount/Basemount RESET RESET Figure 1 - SBS Scroll Basemount Simplex Figure 2 - STS Scroll Tankmount Figure 3 - STD Scroll Tankmount Duplex Aftercooler Scroll Air End Pressure Switch Starter ASME Receiver 30/60 Gallon Auto Drain (optional) ASME Receiver 30/60 Gallon Beltguard Pulley Belt 3/4” NPT Outlet Aftercooler S ...

  • Powerex SBS1307 - page 4

    RESET 4 Scroll Air Compr essors T ankmount/Basemount SCFM Full Load Gallon Dimension Ship Model HP Phase @100 PSIG Voltage Amperage Tank LxWxH Weight (Lbs.) SBS0307 3 3 8.6 208/230/460 8.7/8.0/4.0 Basemount 29x19x19 160 SBS1307 3 1 8.6 230 17 Basemount 29x19x19 175 SBS0507 5 3 14.7 208/230/460 13.7/13.2/6.6 Basemount 29x19x19 180 SBS1517 5 1 14.7 2 ...

  • Powerex SBS1307 - page 5

    5 Maintenance Schedule Operating Hours Item Action needed 500 2500 5000 10,000 15,000 20,000 Remarks Tank Drain moisture Daily Inlet air filter Replace  (Every 2,500 hrs or less) Part #91348550 Blower fan Clean  Fan Duct Clean  Compressor Fins Clean  (Every 2,500 hrs or less) Bearings Grease  Service Center On ...

  • Powerex SBS1307 - page 6

    6 Scroll Air Compr essors T ankmount/Basemount Electrical Wiring Diagram - Simplex Figure 4 - 3-5 HP Basemount/Simplex Single-Phase 208/230 Volts Field furnished power supply  Disconnect Red Black Motor Red Red Pressure electric switch L1 L2 T1 T2 Open Red Black Red Red Red Red Black Red Blank  Main disconnect and branch circuit protection to ...

  • Powerex SBS1307 - page 7

    7 Scroll Air Compr essors T ankmount/Basemount Electrical Wiring Diagram - Simplex Figure 5 - 3-5 HP Basemount/Simplex Three-Phase 208-230/460 Volts Disconnect Black Motor Red Pressure electric switch L1 L2 T1 T2 L3 T3 Blue Red Red Red Black Blue Field furnished power supply   Main disconnect and branch circuit protection to be installed by a ...

  • Powerex SBS1307 - page 8

    8 Scroll Air Compr essors T ankmount/Basemount PANEL DATA - 3 PHASE, 60 Hz OVERLOAD SETTINGS TOTAL PANEL F.L.A. F.L.A. TOTAL UNIT 208 230 460 PANEL 208 230 460 HP VOLT VOLT VOLT HP VOLT VOLT VOLT 3 10.29 9.2 4.6 6 21.1 18.9 9.7 5 15.56 14.0 7.0 10 31.6 28.5 14.5 Figure 6 - 3-5 HP Duplex Three-Phase 208-230/460 Volts ...

  • Powerex SBS1307 - page 9

    9 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for SBS Models RESET RESET RESET Ref. SBS Model No. Description Part Number Qty. 1 Motor 3 HP 3 Phase MC022374AV 1 Motor 3 HP 1 Phase MC301519AV 1 Motor 5HP 3 Phase MC022307AV 1 Motor 5HP 1 Phase MC301520AV 1 2 Base BA000301AV 1 3 Angle bracket ST185500AV 4 4 Beltguard back BG303 ...

  • Powerex SBS1307 - page 10

    10 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for STS Models Ref. STS Model No. Description Part Number Quantity 1 Motor: 3 HP 3 Phase MC022374AV 1 3 HP 1 Phase MC301519AV 1 5 HP 3 Phase MC022307AV 1 5 HP 1 Phase MC301520AV 1 2 Starter: 3 HP 230V 1 Phase JP001045AV 1 5 HP 230V 1 Phase JP001046AV 1 3 HP 230V 3 Phase JP001047 ...

  • Powerex SBS1307 - page 11

    11 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for STD Models Ref. STD Model No. Description Part Number Quantity 1 Motor: 3 HP 3 Phase MC022374AV 1 3 HP 1 Phase MC301519AV 1 5 HP 3 Phase MC022307AV 1 5 HP 1 Phase MC301520AV 1 2 Starter alternator panel: 3 HP 230V 1 Phase ZZ000435AJ 1 5 HP 230V 1 Phase ZZ000436AJ 1 3 HP 230V ...

  • Powerex SBS1307 - page 12

    Scroll Air Compr essors T ankmount/Basemount Powerex • 150 Production Drive • Harrison, OH 45030 • USA Powerex Limited W arranty Powerex 3 Year / 10,000 Hour Extended Parts Limited Warranty - Powerex warrants each Compressor Pump or Scroll Air-End against defects in material or workmanship from the date of purchase for a period of Three years ...

  • Powerex SBS1307 - page 13

    The Powerex Oilless Rotary Scroll Air Compressor has advanced scroll com- pressor technology through the devel- opment of a completely oilless unit. The Powerex Scroll Compressor offers a dynamically balanced air end which insures vibration-free operation. The rotary design permits a continuous 100% duty cycle. No oil separation, oil filtration, or ...

  • Powerex SBS1307 - page 14

    2 Scroll Air Compr essors GREASE DELIVERY SLAE03 SLAE05 Bearing 1st Time 2nd Time 1st Time 2nd Time Orbit Scroll Bearing 5 Times 3 Times 6 Times 4 Times Pin Crank Bearing Orbit Scroll Side 5 Times 3 Times 6 Times 4 Times Pin Crank Bearing Housing Side 5 Times 3 Times 6 Times 4 Times NOTE: Each pump of the grease gun equals 0.65 grams of grease. Fig ...

  • Powerex SBS1307 - page 15

    3 Scroll Air Compr essors Figure 4 Figure 5 Extension Adaptor Needle Adaptor Orbit Scroll Bearings Grease Fitting Housing Side Bearings Maintenance Schedule Operating Hours Item Action needed 500 2500 5000 10,000 15,000 20,000 Remarks Tank Drain moisture Daily Inlet air filter Replace  (Every 2,500 hrs or less) Part #IP032901AV Blower fan Cle ...

  • Powerex SBS1307 - page 16

    expensive filtration. The tip seal should be replaced every 10,000 hours of oper- ation. 1. Confirm if the tip seal you pur- chased is correct for the air end you are repairing (See Parts Listing below). 2. Confirm if the following parts are included (See Figure 6). 1. Remove six nuts with T-type wrench and then FS set from air end (See Figure 7). ...

  • Powerex SBS1307 - page 17

    5 Scroll Air Compr essors Figure 9 Lip Direction Lip Surface (Inside) Enter Side Lip Side (Grooved Bottom) Machined To Avoid Movement During Installation Figure 10 Dust Seal 3 o’clock Position 6 o’clock Position Back-up Tube Figure 8 Figure 11 NOTE: Tips seals for Fixed Scroll and Orbit Scroll have opposing seal cut angels (See NOTE and explana ...

  • Powerex SBS1307 - page 18

    6 Scroll Air Compr essors Figure 12 - Compressor Parts 19 1 2 4 3 6 5 8 7 10 9 12 11 14 15 16 17 18 15 17 A A B B 13 ...

  • Powerex SBS1307 - page 19

    7 Scroll Air Compr essors Ref. Part No. For Models No. Description SLAE03 SLAE05 SLAE03HP SLAE05HP Quantity 1 Airend Pulley 92805020 IP600400AV 92805020 IP600400AV 1 2 Key IP600600AV IP600600AV IP600600AV IP600600AV 1 3 Centrifugal Fan IP601300AV IP601300AV IP601300AV IP601300AV 1 4 Fan Duct (1) IP601400AV IP601400AV IP601400AV IP601400AV 1 5 Fan D ...

  • Powerex SBS1307 - page 20

    Scroll Air Compr essors Powerex • 150 Production Drive • Harrison, OH 45030 • USA Powerex Limited W arranty POWEREX 3 YEAR / 10,000 HOUR EXTENDED PARTS LIMITED WARRANTY - Powerex warrants each Compressor Pump or Scroll Air-End against defects in material or workmanship from the date of purchase for a period of Three years or 10,000 hours , wh ...

Manufacturer Powerex Category Air Compressor

Documents that we receive from a manufacturer of a Powerex SBS1307 can be divided into several groups. They are, among others:
- Powerex technical drawings
- SBS1307 manuals
- Powerex product data sheets
- information booklets
- or energy labels Powerex SBS1307
All of them are important, but the most important information from the point of view of use of the device are in the user manual Powerex SBS1307.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Powerex SBS1307, service manual, brief instructions and user manuals Powerex SBS1307. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Powerex SBS1307.

Similar manuals

A complete manual for the device Powerex SBS1307, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Powerex SBS1307 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Powerex SBS1307.

A complete Powerex manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Powerex SBS1307 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Powerex SBS1307, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Powerex SBS1307, that we can find in the current document
3. Tips how to use the basic functions of the device Powerex SBS1307 - which should help us in our first steps of using Powerex SBS1307
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Powerex SBS1307
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Powerex SBS1307 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Powerex SBS1307?

Use the form below

If you did not solve your problem by using a manual Powerex SBS1307, ask a question using the form below. If a user had a similar problem with Powerex SBS1307 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)