English dropdown-ico

Manual Ariens 985119

24 pages 0.77 mb
Download

Go to site of 24

Summary
  • Ariens 985119 - page 1

    Owner/Oper ator Man ual Models 985114 - 16 HP 985115 - 8.5 HP 985117 - 13.5 HP 985119 - 12 HP 08499300 1/03 Printed in USA Pr of essional 2-Wheel T ractor ...

  • Ariens 985119 - page 2

    2 ENGLISH 1. Operator Presence Control 2. Steering Brake Handlebar 3. Throttle Control 4. Ignition Switch 5. Hourmeter 6. Range Shift Handle (T wo Speed Axle) 7. Direction Control Le ver 8. P arking Brake Handle (Optional on 8.5HP) 9. Brak e Handle Cross Bar 10. Choke Le v er (Robin & K ohler) 11. Choke Control Knob (Briggs & Stratton) 12. ...

  • Ariens 985119 - page 3

    GB - 3 Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Service and Adjustments . . . . . . . . . ...

  • Ariens 985119 - page 4

    GB - 4 2. Check the saf ety inter lock system to mak e sure that it is functioning properly . Unit must not start unless direction control le v er is in neutral (N) and P ower T ak eoff (PT O) is disengaged (Off). Engine must stop if operator releases the handlebar with the direction control le v er or PT O engaged (On). See Saf ety Interlock Syste ...

  • Ariens 985119 - page 5

    GB - 5 SAFETY DECALS AND LOCATIONS AL W A YS replace missing or damaged Saf ety Decals. Ref er to Figure 3 below f or Safety Decal locations. 1. D ANGER! T o Av oid Injur y or Death ! SAFETY FIRST READ THE OPERATOR'S MANUAL BEFORE USING TRACTOR • DISENGAGE ALL CLUTCHES AND SHIFT INTO NEUTRAL BEFORE STARTING ENGINE • HANDLE GASOLINE WITH CA ...

  • Ariens 985119 - page 6

    GB - 6 2. SAF ETY FIRST 3. SAF ETY FIRST 4. CAUTION! Do not park on a slope unless wheels are chocked. SAFETY RULES Read, understand and f ollow all saf ety practices in Owner/Operator Manual bef ore beginning assembly . F ailure to follow instructions could result in personal injur y and/or damage to unit. AL W A YS remov e k e y (if equipped) and ...

  • Ariens 985119 - page 7

    GB - 7 DO NO T touch unit par ts which might be hot from operation. Allow par ts to cool bef ore attempting to maintain, adjust or ser vice. NEVER place your hands or an y par t of your body or clothing inside or near any mo ving par t while unit is running. DO NO T wear loose clothing or je w elr y . Tie bac k hair that ma y get caught in rotating ...

  • Ariens 985119 - page 8

    GB - 8 K eep the nozzle in contact with the rim of the fuel tank or container opening at all times until fueling is complete. Do not use a nozzle lock-open de vice. If fuel is spilled on clothing, change clothing immediately . Batter y posts, terminals and related accessories contain lead and lead compounds, chemicals kno wn to the State of Calif o ...

  • Ariens 985119 - page 9

    GB - 9 ASSEMBL Y Install Hubs and Wheels F or Semi-Pneumatic Wheels: install bushings and wheel/hub assemblies onto tr actor axles. F or all other wheels: install hubs to axles and secure wheels to hubs with hardware pro vided. Install Kick Stand Slide kick stand into the righthand side of the low er brac ket on the rear hitch. Secure it in positio ...

  • Ariens 985119 - page 10

    GB - 10 2. Connect the f orward end to the piv ot plate on the unit with a .375 x .75 cle vis pin, two .406 x .812 x .065 fl at washers and a .09 x .75 cotter pin. Inser t cle vis pin with cotter pin to the outside of adjustment brac ket (Figure 8). Right Hand Rod: 1. Hook the rear of the right hand brake rod into the right outside end of the brak ...

  • Ariens 985119 - page 11

    GB - 11 CONTROLS AND FEATURES NO TE: Read the attachment(s) and unit manuals bef ore operating the equipment. Operate the unit only from the operator ’ s position, behind the handlebars. Ser vice the unit and attachment bef ore operating. Ref er to Controls and F eatures f or the f ollo wing. Safety Interloc k System NO TE: One of the operator pr ...

  • Ariens 985119 - page 12

    GB - 12 Throttle Le ver The throttle le v er is used to control the engine speed. T o increase the engine speed, mov e the le v er up to the “ F AST ” position. T o decrease the engine speed, mov e the le v er down to the “ SLO W ” position. Choke Control The choke control is used to chok e a cold engine f or star ting. The chok e control i ...

  • Ariens 985119 - page 13

    GB - 13 3. Ensure the PT O control is in the “ OFF ” position and the gear shift le v er is in the “ NEUTRAL ” position. 4. If the engine is cold, apply the choke . See Engine Manual f or detailed instructions. 5. Set the throttle to the proper position. After the engine star ts, adjust the chok e as needed. 6. Put the ke y in the ignition ...

  • Ariens 985119 - page 14

    GB - 14 TIPS FOR OPERATION Use slow gears when oper ating the tractor on rough ground, slopes, small areas , near b uildings or other obstacles. Use a slow gear and a f ast engine speed when oper ating a snowb low er , rotar y cultivator , or a mower in hea vy grass . W alk behind, ne v er betw een the handlebars. CHECK SAF ETY INTERLOC K SYSTEM T ...

  • Ariens 985119 - page 15

    GB - 15 3. Clean the dipstick tube and the dipstic k (Figure 11). 4. Remov e the dipstic k, wipe it with a clean cloth or tow el and put it back in the tube . 5. Pull the dipstick out again and look at the oil. 6. If the oil le v el is below the lo w mark on the dipstick, add oil. 7. Clean the area around the fi ller plug. 8. Remov e the fi ller ...

  • Ariens 985119 - page 16

    GB - 16 4. Place batter y on bench or other well-v entilated area. 5. Connect positiv e (+) lead of charger to positive (+) terminal, and negative ( – ) lead to negativ e ( – ) terminal. 6. Charge batter y according to charger and batter y manuf acturers ’ instr uctions. 7. Reinstall batter y on unit and connect positiv e (+) cable fi rst, t ...

  • Ariens 985119 - page 17

    GB - 17 T o adjust the rev erse clutch (Figure 13) : 1. Loosen the two nuts on the end of the fwd-re v control e xtension rod. 2. T ur n the adjusting nut so that the direction control le v er stops 15 degrees past v er tical to the rear . 3. Hold the adjusting nut and tighten the jam nut against it. T o adjust the forw ard clutch (Figure 13) : 1. ...

  • Ariens 985119 - page 18

    GB - 18 IMPORT ANT : Tighten and loosen the bolts in a cross sequence as shown in Figure 16. 4. Tighten all PT O brak e bolts until the springs are solid. Back all bolts up 1/2 turn (Figure 17). NO TE: Mak e sure the trunnion bloc k is on the shipper shaft and held in place by the dog. The dog should rest on the spiral teeth of the clutch dog plate ...

  • Ariens 985119 - page 19

    GB - 19 IMPORT ANT : Tighten and loosen the bolts in a cross sequence as shown in Figure 16. 11. T ur n all of the jam nuts counterclockwise to loosen. 12. T orque bolts to 70 lbf-in in two stages. First tighten bolts to 20 lbf-in in patter n shown (Figure 16). Then tighten to 70 lbf-in in same patter n. 13. Slide the clutch assembly bac k onto the ...

  • Ariens 985119 - page 20

    GB - 20 T R OUBLESHOOTING PROBLEM PROB ABLE CA USE CORRECTION Starter will not operate when ignition key is turned to “ S ” position. 1. Fwd-Re v le v er in “ FOR W ARD ” position. 2. PT O engaged. 3. Loose batter y cable(s). 4. Blown fuse . 5. Discharged batter y . 6. Def ectiv e solenoid s witch. 7. Def ectiv e star ter . 1. Place Fwd-Re ...

  • Ariens 985119 - page 21

    GB - 21 Attachment will not operate. 1. Gear shift le v er in “ NEUTRAL ” position. 2. Attachment jammed or damaged. 3. Attachment slip clutch out of adjustment or damaged. 4. Shipper shaft and clutch dog loose and out of adjustment. 1. Place gear shift le v er in Hi or Low position. 2. Clear debris from attachment. Repair bef ore restar ting e ...

  • Ariens 985119 - page 22

    GB - 22 SERVICE P AR TS Be sure to alwa ys use gen uine Gra v ely par ts to keep your unit running like ne w . P ar t no . Qty Description 01554800 1 Batter y (Robin and K ohler Models) 04202200 1 Batter y (Briggs Model) 21527200 1 Air Cleaner (Robin EH25) 21527300 1 Assembly-Air Cleaner Element (Robin EH41) 21527100 1 Air-Cleaner Element (Robin EH ...

  • Ariens 985119 - page 23

    GB - 23 2-Y ear Limited W arranty Gra vely Division of Ariens Company (Gr av ely) hereby warrants to the original consumer purchaser that all Gra vely T wo-Wheel, Prof essional G, Pro , and ProMaster products will be free from defects in material and workmanship for a period of two (2) years from the date of purchase or 1000 hours, whiche v er come ...

  • Ariens 985119 - page 24

    GRA VEL Y A Division of Ariens Company 655 West Ryan Str eet P .O. Box 157 Brillion, WI 54110-0157 920-756-2141 Fax 920-756-2407 www .gravely .com ...

Manufacturer Ariens Category Lawn Mower

Documents that we receive from a manufacturer of a Ariens 985119 can be divided into several groups. They are, among others:
- Ariens technical drawings
- 985119 manuals
- Ariens product data sheets
- information booklets
- or energy labels Ariens 985119
All of them are important, but the most important information from the point of view of use of the device are in the user manual Ariens 985119.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Ariens 985119, service manual, brief instructions and user manuals Ariens 985119. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Ariens 985119.

Similar manuals

A complete manual for the device Ariens 985119, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Ariens 985119 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Ariens 985119.

A complete Ariens manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Ariens 985119 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Ariens 985119, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Ariens 985119, that we can find in the current document
3. Tips how to use the basic functions of the device Ariens 985119 - which should help us in our first steps of using Ariens 985119
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Ariens 985119
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Ariens 985119 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Ariens 985119?

Use the form below

If you did not solve your problem by using a manual Ariens 985119, ask a question using the form below. If a user had a similar problem with Ariens 985119 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)