English dropdown-ico

Manual EMI EMI Corp

20 pages 2.18 mb
Download

Go to site of 20

Summary
  • EMI EMI Corp - page 1

    EMI AMERICA SERIES MUL TI-ZONE LIMITED RANGE HEA T PUMP CONDENSING UNITS P/N# 240006458 Rev . 1.0 [01/07] Enviromaster International LLC 5780 Success Dr . Rome, NY 13440 www .enviromaster .com INST ALLA TION, OPERA TION AND MAINTENANCE MANUAL An ISO 9001-2000 Certified Company S2HA Multi-Zone S2HA HEA T PUMPS Nominal Circuit Capacities: 9,000 & ...

  • EMI EMI Corp - page 2

    ...

  • EMI EMI Corp - page 3

    www .enviromaster .com 3 Multi-zone Heat Pump Condensing Units INST ALLA TION, OPERA TION AND MAINTENANCE MANUAL EM I AM ER ICA S ER IE S MU L T I- ZON E HE A T P UM P CO ND EN SIN G UN IT S P/N 240006458, Rev . 1.0 [01/07] Shi pping Dam age MUST be R epor ted t o th e Ca rrier IMM EDIA TEL Y!! ! Exa mine the cart on fo r si gns of da mage if any i ...

  • EMI EMI Corp - page 4

    www .enviromaster .com 4 Multi-zone Heat Pump Condensing Units EM I AM ER ICA SE RI ES MUL TI- ZO NE H EA T PU MP CO NDE NS ING UN IT S CON TROLS AND COMP ONEN TS (F ACT ORY INST ALLED OR S UPPLI ED) • Co mp re ss or a nd F a n Mo to r Co nt ac to r • C ap ac it or • Loss of Charge Switch • Low V oltage Connections • Large Capacity Suctio ...

  • EMI EMI Corp - page 5

    www .enviromaster .com 5 Multi-zone Heat Pump Condensing Units INST ALLA TION INSTRUCTIONS 1. Loosen the screws on left and right sides of the front panel. (Do not remove these screws.) 2. Remove the screws on the front of the panel. 3. T o remove front panel: 4. Slide front panel forward to clear side screws and remove. Side discharge unit allows ...

  • EMI EMI Corp - page 6

    www .enviromaster .com 6 Multi-zone Heat Pump Condensing Units ELECTRICAL WIRING INST ALLA TION SECTION 3. Use only HACR type breakers or time delay fuses. Select the wire size accord - ing to the ampacity rating. 4. T o access electrical connections and wiring diagram: a) Remove the screws on the side panel adjacent to the back panel. b) The screw ...

  • EMI EMI Corp - page 7

    www .enviromaster .com 7 Multi-zone Heat Pump Condensing Units 8. Check wiring diagram for the re- quired number of low voltage wires to be run between indoor and out- door sections. 9. Connect the 24 V olt wiring matching color to color . Refer to the wiring diagram on the inside panel of the condenser , and also refer to the wiring diagram on the ...

  • EMI EMI Corp - page 8

    www .enviromaster .com 8 Multi-zone Heat Pump Condensing Units The system will support refrigerant runs to the inside unit of up to 100' equivalent feet with a 35' rise included. Th e un it s are furnished with sweat connections and are equipped with refrigerant valves and Schrad er fi ttings for char ging and taking pressure readings. T ...

  • EMI EMI Corp - page 9

    www .enviromaster .com 9 Multi-zone Heat Pump Condensing Units 8. Evacuate line to 500 microns or less to ensure all moisture has been removed and there are no leaks. Manifold V accum Pump Micron Gage Manifold Setup For Evacuation S1CA Shown It is il leg al t o dis ch arg e re fri ge ran t in to th e at mo sp her e. U se pr op er r ec lai mi ng m e ...

  • EMI EMI Corp - page 10

    www .enviromaster .com 10 Multi-zone Heat Pump Condensing Units 9. Once ce rt ai n o f a go od ev ac ua ti on an d l ea k fr e e j oi nt s, ba ck - se at t he v al ve s ( co un te r- cl oc kw is e ) t o op en an d al lo w f ac to ry ch ar g e t o fi ll li ne s an d in do or u ni t. Refrigerant Refer to Refrigerant Charge T able for specified line ...

  • EMI EMI Corp - page 11

    www .enviromaster .com 1 1 Multi-zone Heat Pump Condensing Units CIRCUIT CAP ACITY EV APORA TOR P AIRING LINE CHG/FT LINE LENGTH LINE ADJUST F ACTORY CHARGE SYSTEM TOT AL S2HA S2HA 9,000 Btuh WLHA09, CAHB12 WLHA12, CAHB12 .25 OZ. 10 25 50 3 OZ. 6 OZ. 13 OZ. 42 45 48 55 12,000 Btuh WLHA12 CAHB12 .25 OZ. 10 25 50 3 OZ. 6 OZ. 13 OZ. 46 49 52 59 IMPORT ...

  • EMI EMI Corp - page 12

    www .enviromaster .com 12 Multi-zone Heat Pump Condensing Units FIELD CHARGING                        ...

  • EMI EMI Corp - page 13

    www .enviromaster .com 13 Multi-zone Heat Pump Condensing Units FIELD CHARGING                        ? ...

  • EMI EMI Corp - page 14

    www .enviromaster .com 14 Multi-zone Heat Pump Condensing Units ST ARTING THE UNIT • Before starting the unit in cool weather , powe r the syst em 24 hour s b efore at- tempting to start. • Do a final system check using the super - heat/subcooling method. Record results on T est Unit Performance Data sheet (next page). - C o o l i n g m o d e ...

  • EMI EMI Corp - page 15

    www .enviromaster .com 15 Multi-zone Heat Pump Condensing Units ST ART-UP AND TROUBLESHOOTING TEST PROCEDURE The T est Unit Performance Data sheet below is provided for use by a qualified ser vice pro fess iona l. In orde r for our T ech ni - cal Service Departme nt to better serve you, please complete and have this information ready when calling. ...

  • EMI EMI Corp - page 16

    www .enviromaster .com 16 Multi-zone Heat Pump Condensing Units MUL TI-ZONE CONDENSER SEQUENCE OF OPERA TION EMI Amer ica Series mult i-zo ne he at p ump con dense rs are desig ned to opera te with EMI Amer ica Ser ies indoor ai r ha ndle rs. Bot h t he con dense r (out door un it) and eva porat or (ind oor uni t) have a hig h V olt ser vice con ne ...

  • EMI EMI Corp - page 17

    www .enviromaster .com 17 Multi-zone Heat Pump Condensing Units MUL TI-ZONE CONDENSER SEQUENCE OF OPERA TION When the outdoor temperature falls below 35°F , compressor operation will cease. At that point the unit will switch on the indoor units electric heater to assume the heating demand, (second stage of heat) . Note: For full operation the indo ...

  • EMI EMI Corp - page 18

    www .enviromaster .com 18 Multi-zone Heat Pump Condensing Units S2HA DIMENSIONS AND SPECIFICA TIONS NOTE: All EMI products are subject to ongoing development programs so design and specifications may change without notice. S2HA ELECTRICAL SPECIFICA TIONS MODEL (1) VOL TS/HZ/PHASE F AN COMPRESSOR 1 COMPRESSOR 2 TOT AL AMPS MIN. CIR. AMPS (2) HACR B ...

  • EMI EMI Corp - page 19

    www .enviromaster .com 19 Multi-zone Heat Pump Condensing Units S2HA SYSTEM PERFORMANCE S2HA / WLHA SYSTEM PERFORMANCE MODEL COOLING HEA TING S2HA (Outdoor) Indoor Units Btuh SEER SHR EER Btuh C.O.P . 9900 WLHA09 + WLHA09 18,600 13.0 .80 12.2 16,000 3.3 2200 WLHA12 + WLHA12 22,600 13.0 .72 1 1.9 20,400 3.3 9200 WLHA09 + WLHA12 20,600 13.0 .76 12.0 ...

  • EMI EMI Corp - page 20

    Phone: 1-800-228-9364 Fax: 1-800-232-9364 5780 Success Drive, Rome, NY 13440 ...

Manufacturer EMI Category Heat Pump

Documents that we receive from a manufacturer of a EMI EMI Corp can be divided into several groups. They are, among others:
- EMI technical drawings
- Corp manuals
- EMI product data sheets
- information booklets
- or energy labels EMI EMI Corp
All of them are important, but the most important information from the point of view of use of the device are in the user manual EMI EMI Corp.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals EMI EMI Corp, service manual, brief instructions and user manuals EMI EMI Corp. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product EMI EMI Corp.

Similar manuals

A complete manual for the device EMI EMI Corp, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use EMI EMI Corp by users. Manuals are usually written by a technical writer, but in a language understandable to all users of EMI EMI Corp.

A complete EMI manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual EMI EMI Corp - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the EMI EMI Corp, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the EMI EMI Corp, that we can find in the current document
3. Tips how to use the basic functions of the device EMI EMI Corp - which should help us in our first steps of using EMI EMI Corp
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with EMI EMI Corp
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of EMI EMI Corp in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning EMI EMI Corp?

Use the form below

If you did not solve your problem by using a manual EMI EMI Corp, ask a question using the form below. If a user had a similar problem with EMI EMI Corp it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)