-
Nortec Industries NH Series - page 1
2531550-B NH Series Outdoor ELECTRODE STEAM HUMIDIFIER Out door Model Inst allation Manual TM ...
-
Nortec Industries NH Series - page 2
2008-10-01 PROPRIETARY NOTICE This document and the info rmation disclosed herein ar e propriet ary data of W alter Meier . Neithe r this document nor the information cont ained herein shal l be reproduced used, or disclosed to others without the written authorization o f W alter Meier , except to the extent required f or installation or maintenanc ...
-
Nortec Industries NH Series - page 3
2008-10-01 TABLE OF CONTENTS Subject Page 10-00 INT RODUCTI ON 1. PREINSTALLATIO N . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 A. ABOUT THIS GUIDE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...
-
Nortec Industries NH Series - page 4
2008-10-01 LIST OF FIGURES Figure Page 10-00 I NTRODUCT ION Figure 1. Humidifier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Figure 2. Distributor Box Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...
-
Nortec Industries NH Series - page 5
2008-10-01 THIS PAGE INTENTIONALLY LEFT BLANK ...
-
Nortec Industries NH Series - page 6
10-00 Page 1 2008-10-01 10-00 INTRODUCTION ...
-
Nortec Industries NH Series - page 7
10-00 Page 2 2008-10-01 1. PRE-INSTALLATION A. ABOUT THIS GUIDE (1) This guide is intended as a supplement for the NH Series Installation Gui de. The NH Series Installation guide is included with all NH Series humidifier s and contains information on installation, operation, and maintenance that applies to both indoor and outdoor models. This guide ...
-
Nortec Industries NH Series - page 8
10-00 Page 3 2008-10-01 (a) For equipment received if an ASD, BSD, CSD distributor(s) is ordered refer to Figure 2. (b) For equipment received if a SAM-e distributor is ordered refer to Figure 3. (c) For equipment received if a RMBP is ordered refer to Figure 4. D. ACCESSORIES BOX (1) Additional accessories such as drain water coolers and filter s ...
-
Nortec Industries NH Series - page 9
10-00 Page 4 2008-10-01 Figure 1. Humidifier Figure 2. Distributor Box Contents Figure 3. SAM-e Distributor Box Figure 4. Blower Pack Box Contents ...
-
Nortec Industries NH Series - page 10
10-00 Page 5 2008-10-01 3. PRE-INSTALLATION A. EQUIPMENT VERIFICATION (1) Ensure that available voltage and phase corresponds with humidifier voltage and phase as indicated on humidifier’s specification label. (2) Ensure that the dedicated external fuse disconnect is of sufficient size to handle the rated amps as indicated on the specification la ...
-
Nortec Industries NH Series - page 11
10-00 Page 6 2008-10-01 THIS PAGE ITENTIONALLY LEFT BLANK ...
-
Nortec Industries NH Series - page 12
10-10 Page 7 2008-10-01 10-10 INSTALLATION PROCEDURES ...
-
Nortec Industries NH Series - page 13
10-10 Page 8 2008-10-01 1. HUMIDIFIER INSTALLATION A. LOCATION AND MOUNTING (1) NH Outdoor Series humidifiers are UL listed for outdoor installation and come complete with internal cooling for the electronics. An internal heater is sta ndard and ensures the enclosure remains at proper operating temperatures. Additionally, a freeze protection system ...
-
Nortec Industries NH Series - page 14
10-10 Page 9 2008-10-01 C. CURB MOUNTING (1) The integral base of the NH Outdoor models is designed to mount on a curb. The curb must be built to structurally support the entire weight of the humidifier when in operation. Required curb dimensions are given in Figure 1. Typical curb mounting installations are shown in Figure 3. Additionally, observe ...
-
Nortec Industries NH Series - page 15
10-10 Page 10 2008-10-01 (c) Wall mounting bracket provided should be securely attached horizontally with open edge upwards, using 5/16” x 3” (minimum) flat head screws. (See Figure 4). (d) Using proper lifting techniques, lift the humidifier onto the brackets to m ount it. Several people may be required to lift the unit. (e) Ensure that both t ...
-
Nortec Industries NH Series - page 16
10-10 Page 11 2008-10-01 RIG H T FRON T LEFT TO P FR O N T V IEW BOT T OM V I E W KNOC KOUT FOR PO WER L IN E AN D HOL E S F OR CONT R O L WIRI N G KNO CKOUT FOR OP T IONA L WATE R I N L E T BAC K V I EW ST EAM L IN E CON NECT ION 1.750inc h OD R O OF CUR B BY O TH ERS FILL W A T ER LINE, S ING L E OR DOUBLE , 1/2" NP T B Y OT H E R S SE CO ND ...
-
Nortec Industries NH Series - page 17
10-10 Page 12 2008-10-01 DRAIN L INES PUNCHOUT S PROVIDED FOR POWER WIRING TO AND FRO M BREAKER INSULATED AND HE AT-TRACED WATER SUPPLY ( BY OTHERS) CAN ALSO BE ROUTED THROUGH PIPE-CHASE A ND PROVIDED PUNCHOUTS MANUAL SH UT-OFF NH OUTDOOR TYPICAL AIR HANDLING UNIT INSTALLATION FUNNEL WITH AIR GAP 3-WAY VA LVE OR NO-NC VALVE ARRANGEMENT (BY OTHERS) ...
-
Nortec Industries NH Series - page 18
10-10 Page 13 2008-10-01 Figure 4. Typical Wall Mount Installation ...
-
Nortec Industries NH Series - page 19
10-10 Page 14 2008-10-01 E. ELECTRICAL INSTALLATION (1) Only qualified personnel should install electrical wiring. All wir ing must be in accordance with national and local codes. (2) Power and control wiring is to be routed into the humidifier through the pipe chase in the base of the unit. (3) A field supplied NEMA rated weatherproof disconnect s ...
-
Nortec Industries NH Series - page 20
10-10 Page 15 2008-10-01 (5) Additionally the following points should be considered: (a) Each unit is supplied with a ½” NPT male connection to the fill valve. Refer to the NH series indoor installation guide for allowa ble pressures and fill rates. (b) ALL OUTDOOR LINES MUST BE PROPERLY HEAT TR A CED AND INSULATED TO PREVENT FREEZING (c) It is ...
-
Nortec Industries NH Series - page 21
10-10 Page 16 2008-10-01 Figure 5. Normally Open / Normally Closed Valve Arran geme nt ...
-
Nortec Industries NH Series - page 22
10-10 Page 17 2008-10-01 Figure 6. 3-Way Valve Arrangement ...
-
Nortec Industries NH Series - page 23
10-10 Page 18 2008-10-01 G. DRAIN LINE (1) NH Series Outdoor units require and external drain line to provide for draining from the unit. (2) ALL OUTDOOR PIPING SHOUL D BE PROPERLY INSUL ATED AND HEAT TRACED TO PREVENT FREEZIN G. (3) Route the drain hose to a drain funnel inside the building to provide an air gap before entering the main building d ...
-
Nortec Industries NH Series - page 24
10-10 Page 19 2008-10-01 guide (Steam Distributor Installation Guide Form #XX-231 and SAM-e Short Absorption Manifold Form #XX-249). 2. IMPORTANT INFORMATION A. GENERAL CAUTION Y OUR HUMIDIFIER OPERATES ON HIGH VOLTAGE AND CURRENTS, W HICH CAN CAUSE SERIOUS IN JURY OR DEATH. ENSURE T HAT T HE POWER TO THE UNIT IS OF F BEFORE PERFORMING A NY SERVICE ...
-
Nortec Industries NH Series - page 25
10-10 Page 20 2008-10-01 WARNING IT IS ESSENTIAL THAT THE FANS AND HEA TERS BE INSPECTED PERIODICALLY TO ENSURE THA T THEY CAN SPIN FR EELY AND HAVE NOT BECOME CLOGGED W ITH DIRT, POLLEN, OR BY A NIMALS. THIS IS ESPECIALLY TRUE OF THE EXTE RNAL CASE FAN A ND FAN SHROUD. WARNING IN COLD CLIMATES THE FRE EZE PROTECTION SY STEMS MUST BE CORRECTLY INST ...
-
Nortec Industries NH Series - page 26
10-10 Page 21 2008-10-01 available to signal remotely that he humidifier requires service. If the NORTEC OnLine option was ordered, cylinder change not ices will be delivered via email. (2) Please refer to the NH Series Indoor Installation guide for further details on replacing cylinders. E. SERVICING NHRS WITH SCALE MANA GEMENT SYSTEM (1) As with ...
-
Nortec Industries NH Series - page 27
10-10 Page 22 2008-10-01 (c) Once the unit has reached an appropriate temperature it will resume normal operation. 3. OPERATION AND ADDITIONAL MAINTENANCE A. OPERATION (1) NH Outdoor series humidifiers are operated in the same manner as their indoor counterparts. Please refer to the NH Series Installation guide for more details. B. ADDITIONAL MAINT ...
-
Nortec Industries NH Series - page 28
10-10 Page 23 2008-10-01 Table 1. Weather Design Data JA NUA RY Temperature JA NUA RY Relative Humidity (% RH) JULY Temperature JULY Relative Humidity (% RH) State/Province City Dry Bulb °F Dry Bulb °C 7:30 A.M . 1:30 P.M. 7:30 P.M. Dry Bulb °F Dry Bulb °C 7:30 A.M . 1:30 P.M. 7:30 P.M. A labama Birmingham 10 -12 81 61 66 95 35 84 56 68 Mobile ...
-
Nortec Industries NH Series - page 29
10-10 Page 24 2008-10-01 Missouri Kansas City -10 -23 78 64 66 100 38 76 48 47 St. Louis 0 -10 77 65 68 95 35 73 50 55 Montana Billings -25 -32 67 73 60 90 32 65 40 33 Butte -20 -29 76 70 71 95 35 82 36 33 Nebraska North Platte -20 -29 80 62 66 85 29 84 50 46 Omaha -10 -23 82 68 73 95 35 80 51 51 Nevada Reno -5 -21 82 67 54 95 35 72 25 20 New Hamps ...
-
Nortec Industries NH Series - page 30
10-10 Page 25 2008-10-01 Wyoming Cheyenne -15 -26 59 48 55 95 35 73 36 40 A lberta Calgary -29 -34 71 87 31 34 Edmonton -29 -34 75 86 30 42 Grande Prairie -43 -42 80 84 29 38 Lethbridge -32 -36 66 91 33 30 Medicine Hat -30 -34 73 96 36 31 British Columbia Estevan Point 17 -8 84 87 31 32 Fort Nelson -40 -40 79 94 34 32 Penticton 0 -18 81 85 29 44 Pr ...
-
Nortec Industries NH Series - page 31
10-10 Page 26 2008-10-01 Sherbrooke -18 -28 87 31 58 Trois Rivieres -18 -28 88 31 58 Saskatchewan Prince Albert -41 -41 77 88 31 Regina -34 -37 81 92 33 Saskatoon -34 -37 76 90 32 Swift Current -29 -34 79 93 34 Yukon Territory Dawson -56 -49 76 57 14 60 Whitehorse -45 -43 82 78 26 40 Table Source: ASHRAE ...
-
Nortec Industries NH Series - page 32
10-20 Page 27 2008-10-01 10-20 TECHNICAL ...
-
Nortec Industries NH Series - page 33
10-20 Page 28 2008-10-01 Figure 1. NHRS Outdoor Exploded Vi e w ...
-
Nortec Industries NH Series - page 34
10-20 Page 29 2008-10-01 Figure 2. NHTC Outdoor Exploded Vie w ...
-
Nortec Industries NH Series - page 35
10-20 Page 30 2008-10-01 THIS PAGE INTENTIONALLY LEFT BLANK ...
-
Nortec Industries NH Series - page 36
10-30 Page 31 2008-10-01 10-30 WIRING DIAGRAMS ...
-
Nortec Industries NH Series - page 37
10-30 Page 32 2008-10-01 Figure 1. Wiring Diagram NHTC Outdoor ...
-
Nortec Industries NH Series - page 38
10-30 Page 33 2008-10-01 Figure 2. Wiring Diagram NHRS Outdoor (Single) ...
-
Nortec Industries NH Series - page 39
10-30 Page 34 2008-10-01 Figure 3. Wiring diagram NHRS Outdoor (Double) ...
-
Nortec Industries NH Series - page 40
THIS PAGE INTENTIONALLY LEFT BLANK ...
-
Nortec Industries NH Series - page 41
WARRANTY (1) Walter Meier Inc. and/or Walter Meier Ltd. (herein after collectively referred to as THE COMPANY), warrant for a period of two years afte r installation or 30 months from manufacturer’s ship date, whichever da te is earlier, that THE COMPANY’s manufactured and assembled products, not ot herwise expressly warranted (with the excepti ...
-
Nortec Industries NH Series - page 42
Cylinder Replacement Da te (MM/DD/YYYY) INST ALLA TION DA TE (MM/DD/YYYY) MODEL # SERIAL # CYLINDER # U.S.A. W alter Meier (Climate USA) Inc. 826 Proctor Avenue Ogdensburg, NY 13669 TEL: 1-866-NORTEC-1 EMAIL: northamerica.climate@waltermeier .com WEBSITE: www .humidity .com CANADA W alter Meier (Climate Can ada) Ltd. 2740 Fenton Road Ottawa, ON K1 ...
Do you have a question concerning Nortec Industries NH Series?
Use the form below
If you did not solve your problem by using a manual Nortec Industries NH Series, ask a question using the form below. If a user had a similar problem with Nortec Industries NH Series it is likely that he will want to share the way to solve it.