-
Culligan Iron-Cleer - page 1
Culligan ® Iron-Cleer ® Automatic Water Filter Owners Guide ...
-
Culligan Iron-Cleer - page 2
...
-
Culligan Iron-Cleer - page 3
THANK YOU AND WELCOME TO YOUR NEW WORLD OF BETTER LIVING WITH CULLIGAN WATER. The Culligan ® Iron Cleer ® water filters have been tested and certified by WQA against WQA-200 for the effective reduction of iron up to 1,400 gallons for 10” units and 2,000 gallons for 12” units. Do not use with water that is microbiologically unsafe or of unknow ...
-
Culligan Iron-Cleer - page 4
Table of Contents 4 S p e c i f i c a t i o n s ...................................................... 1 I n t r o d u c t i o n ....................................................... 2 O p e r a t i n g C o n d i t i o n s ................................................ 4 F a m i l i a r i z a t i o n ............................................ ...
-
Culligan Iron-Cleer - page 5
Specifications Culligan ® Iron Cleer ® Filters 1 Capacity based on 4 gpm and 10 mg/L of dissolved iron. 2 Measured from top of media bed to top of inlet fitting. 3 Max flow rates & pressure drop characteristics have not been validated by the Water Quality Association. The max specified flow rate at which the system will deliver treated water ...
-
Culligan Iron-Cleer - page 6
Introduction Operation Step 1. Aeration Operation Service Cycle In the service cycle, raw water enters the inlet port of the aeration tank and is directed through the inlet diffuser. The oxidation process begins when the water passes through the inlet diffuser and cascades through a head of air. This air/ water contact oxidizes the iron, manganese, ...
-
Culligan Iron-Cleer - page 7
Shuttle Valve Operation In the service position, water pressure holds the shuttle valve piston in the closed position, trapping the airhead in the aeration tank and closes the air recharge inlet port and drain port. During air recharge cycle, air pressure is greater than the water pressure and forces the shuttle valve piston in the open piston. The ...
-
Culligan Iron-Cleer - page 8
The concentration limits listed below reflect the maximum individual limit that each contaminant was tested for separately without any interference of other contaminants in the influent water. In reality, however, we know that these contaminants may be present in combination which may limit the filter’s ability to remove these contaminants in hig ...
-
Culligan Iron-Cleer - page 9
Fam ilia riza tio n Power Loss The AccuSoft ® circuit board is equipped with a Hi-Cap Capacitor and EEPROM memory chip. The capacitor is capable of maintaining the time, for at least two days, in the event of a power outage. The EEPROM ensures that the individual programming parameters of your filter are not lost. If the power outage lasts long en ...
-
Culligan Iron-Cleer - page 10
Programming 6 Make sure either inlet water supply is turned off, then supply power to the timer. The display will power up ashing “12:00 PM” and the motor will energize and cycle the control, without stopping, the home position. This is required to ensure that the control is in the home position. The timer uses four buttons: Button Descripti ...
-
Culligan Iron-Cleer - page 11
7 Pressing the “Status” key will save the setting and move to the next programming step. Settline Time This setting is used to set the time in minutes for cycle 2. This cycle is usually brine draw / slow rinse for softeners and a settling time for lters. The display will show “br” in the left most digits and the cycle time in the right m ...
-
Culligan Iron-Cleer - page 12
Normally , all water except outside lines passes through the water lter . There are times when the water lter should be bypassed, using the Cul-Flo-V alv ® Bypass, or a 3-way bypass valve. Y ou should bypass: 1. If lines to outside faucets do not bypass the water lter , and you do not want to waste soft water on lawn sprinkling or other o ...
-
Culligan Iron-Cleer - page 13
9 Aeration T ank – Bypass V alve Operation Normal Operation Bypass Operation “T reated” Water Exits Supply W ater Enters Supply W ater Exits Supply W ater Enters Shut-Off Mode No W ater Exits Supply W ater is Shut Off From The House and The V alve Diagnostic Mode Supply W ater Exits Supply W ater Enters Aeration Tank Bypass Valve ...
-
Culligan Iron-Cleer - page 14
Things to Check Before You Call for Service If you unexpectedly experience problem water, make these simple checks before calling your Culligan dealer. One of the following conditions may be the reason for your interruption of service. Important If any of the following conditions is found, the water filter should be manually recharged according to ...
-
Culligan Iron-Cleer - page 15
Care and Cleaning of Your Water Conditioner 11 Following these simple precautions will help assure continued trouble-free service and keep your Culligan W ater Conditioner looking like new for years. 1 Use only mild soap and warm water when cleaning the exterior of the conditioner . Never use harsh, abrasive cleaning compounds or those which contai ...
-
Culligan Iron-Cleer - page 16
Preventative Maintenance Recommended Preventative Maintenance The Culligan Iron Cleer water filter has been designed to provide a good, consistent service life. Because of the nature of problem water, we recommend that the local Culligan dealer provide regular maintenance/service contracts for the proper operation of your systems. The water filter ...
-
Culligan Iron-Cleer - page 17
T r ou bl e sh oo t i n g Guide 13 Complaint Problem Cause Solution Iron bleed- through or staining. A. Inadequate backwash of filter 1. Plugged drain line flow control 1. Call your Culligan dealer for service. 2. Insufficient water supply from well. 2. Check for minimum specified flow and pressure requirements of filter system. 3. Plugged aeration ...
-
Culligan Iron-Cleer - page 18
Complaint Problem Cause Solution Water leaking from relief valve. A. Dirt lodged under seat of valve. 1. Pressure has exceeded rating on relief valve and caused valve to open 1. Call your Culligan dealer for service. B. Faulty or defective relief valve 1. Call your Culligan dealer for service. Water is effervescent A. This can be expected when wate ...
-
Culligan Iron-Cleer - page 19
15 Complaint Problem Cause Solution Excessive noise during regeneration. A. Howling or whistling noise during regeneration cycle. 1. Inadequate drain line size. 1. Call your Culligan dealer for service. 2. Drain line is vibrating against other pipes, conduits, pipe hangers, heat ducts, floor joists,etc. 2. Call your Culligan dealer for service. Wat ...
-
Culligan Iron-Cleer - page 20
Performance Data Sheet Culligan ® 10” and 12” Iron-Cleer ® Water Filters Important Notice — Read this data sheet and compare the capabilities of the unit to your actual water treatment needs. Culligan recommends that you have your water supply tested to determine these needs before purchasing a water treatment unit. Culligan knows the more ...
-
Culligan Iron-Cleer - page 21
17 Records and Data Important Data on Your Water Filter It is advisable to have the salesperson or installer fill in the information below for your future reference. If this has not been done, please ask for it, as it is necessary if you contact your dealer. IDENTIFICATION Model Name Catalog No. Control Model No. Control Serial No. Date of Installa ...
-
Culligan Iron-Cleer - page 22
Culligan Limited Warranty Culligan ® Iron-Cleer ® Automatic Water Filters You have just purchased one of the finest water filters made. As an expression of our confidence in Culligan International Company products, your water filter is warranted to the original end-user, when installed in accordance with Culligan specifications, against defects i ...
-
Culligan Iron-Cleer - page 23
With Culligan You Get More Than A Quality Product You Get Your Water Expert, The Culligan Man We’re here to provide you with fast, dependable service, making sure any problems you have are taken care of. The Culligan Man has been around for over sixty years, delivering dependable service all along. That’s why people say “Hey, Culligan Man! ® ...
У вас вопрос, касающийся Culligan Iron-Cleer?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Culligan Iron-Cleer, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Culligan Iron-Cleer со всей вероятностью он захочет поделиться методом ее решения.