Русский dropdown-ico

Инструкция обслуживания Stow SMC3PE

42 страниц 1.99 mb
Скачать

Перейти на страницу of 42

Summary
  • Stow SMC3PE - page 1

    © COPYRIGHT 2003, MUL TIQUIP INC . P AR TS AND OPERA TION MANUAL POR TO MIX MINI CONCRETE MIXER PLASTIC DRUM MODELS SMC3PE AND SMC3PB Re vision #0 (08/08/03) P ARTS DEP A RTMENT : 800-427-1244 F AX: 800-672-7877 SERVICE DEP AR TMENT/TECHNICAL ASSIST ANCE: 800-478-1244 F AX: 310-631-5032 STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW ...

  • Stow SMC3PE - page 2

    ...

  • Stow SMC3PE - page 3

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/09/02) — PAGE 3 HERE'S HOW TO GET HELP PLEASE HA VE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING P AR TS DEP AR TMENT 800-427-1244 or 310-537-3700 F AX: 800-672-7877 or 310-637-3284 SER VICE DEP AR TMENT 800-478-1244 F AX: 310- 537-4259 TECHNICAL ASSIST ANCE 800-478-1244 F ...

  • Stow SMC3PE - page 4

    P A GE 4 —ST O W POR T O MIXER — P ARTS & OPERA TION MANUAL — REV . #0 (08/08/03) T ABLE OF CONTENTS Here's How T o Get Help ............................................ 3 T able Of Contents ..................................................... 4 P ar ts Order ing Procedures ....................................... 5 STOW PORTO MIXER ...

  • Stow SMC3PE - page 5

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 5 P ARTS ORDERING PR OCEDURES When ordering parts, please supply the following information: ❒ ❒ ❒ ❒ ❒ Dealer account number ❒ ❒ ❒ ❒ ❒ Dealer name and address ❒ ❒ ❒ ❒ ❒ Shipping address (if different than billing address) ❒ ❒ ❒ ❒ ? ...

  • Stow SMC3PE - page 6

    P A GE 6 —ST O W POR T O MIXER — P ARTS & OPERA TION MANUAL — REV . #0 (08/08/03) Accidental Starting AL W A YS place the circuit breaker or power ON/OFF switch in the OFF position when the pump is not in use. Respiratory Hazard AL W A YS wear approved respir ator y protection. Equipment Damage Messages Other important messages are provid ...

  • Stow SMC3PE - page 7

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 7 ST O W PORT O MIXER— SAFETY MESSA GE ALER T SYMBOLS Accidental Starting AL W A YS place the engine ON/OFF switch in the OFF position, and remove the ignition key when the machine is not in use. Respiratory Hazard AL W A YS wear approv ed respirator y protection. E ...

  • Stow SMC3PE - page 8

    P A GE 8 —ST O W POR T O MIXER — P ARTS & OPERA TION MANUAL — REV . #0 (08/08/03) RULES FOR SAFE OPERA TION ■ AL W A YS refuel in a well-ventilated area, a wa y from spar k s and open flames. ■ AL W A YS use extreme caution when working with flammable liquids. When refueling, stop the engine and allow it to cool. DO NOT smoke around o ...

  • Stow SMC3PE - page 9

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 9 ■ High T emperatures – Alwa ys stop engine and allow the engine to cool before adding fuel, oil or performing service and maintenance functions. Contact with hot components can cause serious burns. ■ NEVER disconnect any "emergency or safety devices" ...

  • Stow SMC3PE - page 10

    P A GE 10 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) Emergencies ■ AL W A YS know the location of the nearest fire extinguisher . ■ AL W A YS know the location of the nearest first aid kit . ■ In emergencies always know the location of the nearest phone or keep a phone on the job site . Also know the ph ...

  • Stow SMC3PE - page 11

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 11 OPERA TION AND SAFETY DECALS Machine Safety Decals The ST O W POR T O MIXER is equipped with a number of saf ety decals. These decals are provided for oper ator saf ety and maintenance inf or mation. The illustration below and on the ne xt page shows these decals a ...

  • Stow SMC3PE - page 12

    P A GE 12 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) OPERA TION AND SAFETY DECALS 6. check V-belt before starting mixer . AL WA YS 1. Read owner’s manual before operating mixer. ELECTRIC MOTOR Make sure power cord has been disconnected from power source before cleaning mixer . use an extension cord of prope ...

  • Stow SMC3PE - page 13

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 13 ST O W PORT O MIXER— SPECIFICA TIONS ) r o t o M c i r t c e l E & e n i g n E ( s n o i t a c i f i c e p S . 1 e l b a T r o t o M c i r t c e l E / e n i g n E l e d o M0 0 2 1 9 N O T T A R T S & S G G I R B4 0 3 E Y L 7 1 R O D L A B e p y T e l g n ...

  • Stow SMC3PE - page 14

    P A GE 14 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) ST O W PORT O MIXER— DIMENSIONS (MIXER) Figure 1. Mix N' Go Mixer Dimensions ...

  • Stow SMC3PE - page 15

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 15 ST O W POR T O MIXER— DIMENSIONS (ELECTRIC MO T OR) Figure 2. Electric Motor ...

  • Stow SMC3PE - page 16

    P A GE 16 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) ST O W PORT O MIXER— GENERAL INFORMA TION APPLICA TION This mixer is only intended for the production of concrete and mor tar . The mixer m ust be used f or its intended purposes and is not suitable for the mixing of flammable or explosive substances. The ...

  • Stow SMC3PE - page 17

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 17 ST O W POR T O MIXER— MIXER COMPONENTS Figure 4. Mixer Components S T N I H G N I X I M . 3 e l b a T S N O I T A C I L P P A X I M S O I T A R S E I T I T N A U Q H C T A B H C T A B . X O R P P A T U P T U O . s b l 2 1 1 T N E M E C ) . s g K 0 5 ( g a B D N A ...

  • Stow SMC3PE - page 18

    P A GE 18 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) Figure 5. Engine Controls and Components INITIAL SER VICING The engine (Figure 5) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturers engine manual f or instructions and details of operation and ser vic ...

  • Stow SMC3PE - page 19

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 19 ST O W PORT O MIXER— ASSEMBL Y INSTRUCTIONS Assembly 1 . Remove the mixer drum and associated components from the packing container (Figure 6). Match the components against the parts list to make sure that they are all accounted fo r. Figure 6. Packing Container ...

  • Stow SMC3PE - page 20

    P A GE 20 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) 6 . Tip mixer onto mouth as shown in Figure 10, and insert support stand into frame swivel point. 9 . Bef ore attempting to lift mix er , locate the fr ame locking clip . Attach the locking clip as sho wn in Figure 12. This will pre vent the mixing drum fro ...

  • Stow SMC3PE - page 21

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 21 ST O W PORT O MIXER— PRE-INSPECTION (GASOLINE ENGINE) Figure 15. Engine Oil Dipstick (Removal) 3 . Insert and remove the dipstick without screwing it into the filler neck. Check the oil level shown on the dipstick. 4 . If the oil level is low (Figure 16), fill to ...

  • Stow SMC3PE - page 22

    P A GE 22 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) ST O W PORT O MIXER— INITIAL ST ART -UP (ELECTRIC MO T OR) CAUTION: CAUTION: CAUTION: CAUTION: CAUTION: DO NOT attempt to operate the mixer until the Saf ety , General Inf or mation and Inspection sections have been read and understood. Initial Start-up I ...

  • Stow SMC3PE - page 23

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 23 ST O W PORT O MIXER— INITIAL ST ART -UP (GASOLINE ENGINE) Star ting the Engine ( BRIGGS & STRA TT ON ) 1 . Place the choke lever (Figure 21) in the CHOKE (CLOSED) position if star ting a cold engine. DO NOT attempt to operate the mixer until the Saf ety , Gen ...

  • Stow SMC3PE - page 24

    P A GE 24 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) ST O W PORT O MIXER— INITIAL ST ART -UP (GASOLINE ENGINE) Figure 26. Throttle Lever (Idle P osition) 2 . After the engine cools , mov e the throttle le v er to the ST OP position (Figure 27). Figure 27. Throttle Le ver (Stop P osition) Stopping The Engine ...

  • Stow SMC3PE - page 25

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 25 ST O W PORT O MIXER— MAINTENANCE Maintenance Gearbox Oil Check 1. P osition the mix er on a le vel surf ace and place a suppor t bloc k under the front of the mix er frame as shown in Figure 29. This will le v el the mixer . 2. NEVER! check the gearbox oil level ...

  • Stow SMC3PE - page 26

    P A GE 26 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) ST O W PORT O MIXER— MAINTENANCE (GASOLINE ENGINE) Reference manufacturer engine manual for specific servicing instructions. NOTE e l u d e h c S e c n a n e t n i a M e n i g n E . 6 e l b a T ) 3 ( N O I T P I R C S E DN O I T A R E P OE R O F E B T S R ...

  • Stow SMC3PE - page 27

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 27 Maintenance P erf orm the scheduled maintenance procedures as definded by T able 6 and below: D AIL Y ■ Thoroughly remove dirt and oil from the engine and control area. Clean or replace the air cleaner elements as necessar y . Check and retighten all f asteners a ...

  • Stow SMC3PE - page 28

    P A GE 28 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) ST O W PORT O MIXER— PREP ARA TION FOR LONG -TERM ST ORA GE Mixer Storage For storage of the mixer for over 30 days, the following is recommended: z Drain the fuel tank completely , or add ST A-BIL to the fuel. z Run the engine until the fuel is completel ...

  • Stow SMC3PE - page 29

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 29 NO TE P A GE ...

  • Stow SMC3PE - page 30

    P A GE 30 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) ST O W PORT O MIXER— TR OUBLESHOO TING (ENGINE) G N I T O O H S E L B U O R T E N I G N E . 7 E L B A T M O T P M Y S M E L B O R P E L B I S S O P N O I T U L O S t r a t s o t t l u c i f f i D g u l p k r a p s t u b e l b a l i a v a s i l e u F e l b ...

  • Stow SMC3PE - page 31

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 31 ST O W PORT O MIXER— TROUBLESHOO TING (ENGINE/MIXER) G N I T O O H S E L B U O R T R E X I M . 8 E L B A T M O T P M Y S M E L B O R P E L B I S S O P N O I T U L O S . h g u o r s e t a t o r m u r D ? x o b r a e g e v i t c e f e D s a e c a l p e R . n r o w ...

  • Stow SMC3PE - page 32

    P A GE 32 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) How to read the marks and remarks used in this parts book. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serial number range (inclusiv e) where a par ticular par t is used. Model Number-Where indicated, this shows ...

  • Stow SMC3PE - page 33

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 33 ST O W PORT O MIXER — SUGGESTED SP ARE P ARTS ST O W PORT O MIXER 1 TO 3 UNITS 1 to 3 Units Qt y . P/ N Description 2 ............ DM1840 ................ V -BEL T , A23 (ELECTRIC MO T OR) 2 ............ MS-01 ................... V -BEL T , A24 (GASOLINE) ...

  • Stow SMC3PE - page 34

    P A GE 34 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) ST O W PORT O MIXER — NAME PLA TE AND DECALS NAME PLA TE AND DECALS ...

  • Stow SMC3PE - page 35

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 35 ST O W PORT O MIXER — NAME PLA TE AND DECALS NAME PLA TE AND DECALS NAMEPLA TE AND DECALS. NO P AR T NO P AR T NAME QTY . REMARKS 1 DCL300 DECAL: W ARNING ST O W 1 2 DECAL: ST O W POR T O MIX ..................... 1 ............ INCLUDED WITH TUB 3 DECAL: NAMEPLA ...

  • Stow SMC3PE - page 36

    P A GE 36 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) MIXER ASSY . (PLASTIC DR UM) ST O W PORT O MIXER — MIXER ASSY . (PLASTIC DR UM) ...

  • Stow SMC3PE - page 37

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 37 ST O W PORT O MIXER — MIXER ASSY . (PLASTIC DR UM) MIXER ASSY . (PLASTIC DR UM) NO . P AR T NO . P AR T NAME QTY . REMARKS 1 # DM3150 HEX HEAD BOL T M12 x 70 1 2 # DM1356 OIL FILLER PLUG M14 x 2 x 15L 1 3 # DM1912 HEX NUT M10 2 4 # DM355 HEX HEAD BOL T M8 x P1.25 ...

  • Stow SMC3PE - page 38

    P A GE 38 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) MIXER ASSY . (PLASTIC DR UM) ST O W PORT O MIXER — MIXER ASSY . (PLASTIC DR UM) ...

  • Stow SMC3PE - page 39

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 39 MIXER ASSY . (PLASTIC DR UM) NO . P AR T NO . P AR T NAME QTY . REMARKS 3 1 DM1527 HEX NUT M10 1 2 3 2 DM1524 B O L T 1 2 3 3 DM1510 PLASTIC BARREL 1 3 4 DM1531 BLADE, BARREL 2 3 5 DM1613 HANDLE GRIP , RUBBER 2 3 6 DM1630 TOP C O VER CLAMP 2 3 7 DM1631 SCREW 5.5 x ...

  • Stow SMC3PE - page 40

    P A GE 40 —ST O W PORT O MIXER — P ARTS & OPERA TION MANU AL — REV . #0 (08/08/03) TERMS AND CONDITIONS OF SALE — P AR TS Effective: July 15, 2003 T erms and Conditions of Sale STOW Construction Equipment ST O W CONSTR UCTION EQUIPMENT POST OFFICE BO X 6254 CARSON, CALIFORNIA 90749 310-661-4242 • 877-BUY -STO W F AX: 310-604-9237 E-MA ...

  • Stow SMC3PE - page 41

    STOW PORTO MIXER — PARTS & OPERATION MANUAL — REV. #0 (08/08/03) — PAGE 41 NO TE P A GE ...

  • Stow SMC3PE - page 42

    P AR TS AND OPERA TION MANUAL HERE'S HOW TO GET HELP PLEASE HA VE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING P AR TS DEP AR TMENT 800-427-1244 or 310-537-3700 F AX: 800-672-7877 or 310-637-3284 SER VICE DEP ARTMENT 800-478-1244 F AX: 310- 537-4259 TECHNICAL ASSIST ANCE 800-478-1244 F AX: 310- 631-5032 W ARRANTY DEP ARTMENT 888-661-4279, ...

Производитель Stow Категория Webcam

Документы, которые мы получаем от производителя устройства Stow SMC3PE мы можем разделить на несколько групп. Это в частности:
- технические чертежи Stow
- инструкции обслуживания SMC3PE
- паспорта изделия Stow
- информационные брошюры
- энергетические этикетки Stow SMC3PE
Все из них важны, однако самую важную информацию с точки зрения пользователя мы найдем в инструкции обслуживания Stow SMC3PE.

Группа документов, определяемая как инструкции обслуживания, делится также на более подробные типы, такие как: Инструкции монтажа Stow SMC3PE, инструкции обслуживания, короткие инструкции или инструкции пользователя Stow SMC3PE. В зависимости от потребностей, Вам необходимо поискать требуемый документ. На нашем сайте Вы можете просмотреть самую популярную инструкцию использования изделия Stow SMC3PE.

Похожие инструкции обслуживания

Полная инструкция обслуживания устройства Stow SMC3PE, как должна выглядеть?
Инструкция обслуживания, определяемая также как пособие пользователя, или просто "руководство" - это технический документ, цель которого заключается в использовании Stow SMC3PE пользователями. Инструкции пишет, как правило технический писатель, языком, доступным для всех пользователей Stow SMC3PE.

Полная инструкция обслуживания Stow, должна заключать несколько основных элементов. Часть из них менее важная, как например: обложка / титульный лист или авторские страницы. Однако остальная часть, должна дать нам важную с точки зрения пользователя информацию.

1. Вступление и рекомендации, как пользоваться инструкцией Stow SMC3PE - В начале каждой инструкции, необходимо найти указания, как пользоваться данным пособием. Здесь должна находится информация, касающаяся местонахождения содержания Stow SMC3PE, FAQ и самых распространенных проблем - то есть мест, которые чаще всего ищут пользователи в каждой инструкции обслуживания
2. Содержание - индекс всех советов, касающихся Stow SMC3PE, которое найдем в данном документе
3. Советы по использованию основных функций устройства Stow SMC3PE - которые должны облегчить нам первые шаги во время использования Stow SMC3PE
4. Troubleshooting - систематизированный ряд действия, который поможет нам диагностировать а в дальнейшем очередность решения важнейших проблем Stow SMC3PE
5. FAQ - чаще всего задаваемые вопросы
6. Контактные данные Информация о том, где искать контактные данные производителя / сервисного центра Stow SMC3PE в данной стране, если самостоятельно не получится решить проблему.

У вас вопрос, касающийся Stow SMC3PE?

Воспользуйтесь формуляром, находящимся ниже

Если с помощью найденной инструкции Вы не решили свою проблему с Stow SMC3PE, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Stow SMC3PE со всей вероятностью он захочет поделиться методом ее решения.

Перепишите текст с картинки

Captcha
Новая картинка

Комментарии (0)