-
Quadra-Fire CB1200-B - page 1
R www .quadrare.com 7014-082D September 1, 2008 CLASSIC BA Y 1200 PELLET ST OVE O-T L T ested and Listed by Portland Oregon USA OMNI-T est Laboratories, Inc. C US Owner ’ s Manual Installation and Operation CB1200-B Model: DO NOT DISCARD THIS MANUAL NOTICE • Impo rtant oper ating and maintenance instruc - tions included. • Leave this manua ...
-
Quadra-Fire CB1200-B - page 2
Page 2 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradi - tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durabil - ity , and performance. This commitment begins with our research of the ...
-
Quadra-Fire CB1200-B - page 3
R R R September 1, 2008 7014-082D Page CB 1200 Pellet Stove Section 1: Listing and Code Approvals A. Appliance Certications ...................... 4 B. Mobile Home Approved ...................... 4 C. Glass Specications ............................ 4 D. Electrical Rating .................................. 4 E. BTU & Efciency Speci? ...
-
Quadra-Fire CB1200-B - page 4
Page 4 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 1 Listing and Code Approvals A. Appliance Certication C. Glass Specications E. BTU & Efciency Specications This appliance is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contact your dealer for replacement glass. This appliance is app ...
-
Quadra-Fire CB1200-B - page 5
R R R September 1, 2008 7014-082D Page 5 CB 1200 Pellet Stove 2 Getting Started A . Design, Installation & Location Considerations B. Fire Safety Maintain the designated clearances to combustibles. Insu - lation must not touch the chimney . Y ou must maintain the designated air space clearance around the chimney . This space around a chimney is ...
-
Quadra-Fire CB1200-B - page 6
Page 6 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R D. Inspect Appliance & Components and Pre-Use Check List Reciprocating Saw Channel Locks Hammer Phillips Screwdriver T ape Measure Plumb Line Level Framing Material Hi-temp Caulking Material Gloves Safety Glasses Framing Square Electric Drill & Bits (1/4”) 1/4” Self-T apping ...
-
Quadra-Fire CB1200-B - page 7
R R R September 1, 2008 7014-082D Page 7 CB 1200 Pellet Stove 3 Dimensions and Clearances A. Appliance Dimensions 5.0 in (127mm) 4-5/8 in ( 1 18mm) 12-/8 in (14mm) 14-1/4 in (62mm) 2-1/2 in (64mm) C L 8-1/6 in. (205 mm) 20 - 7/1 6 in . (519 mm) 28 -1/2 in. (72 4mm) 27 -5/8 in. (692 mm) 25 -/4 in. (654 mm) C L 10- /4 in. (27 mm) 24 ...
-
Quadra-Fire CB1200-B - page 8
Page 8 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Straight Back Against W all Inches Millimeters A Back W all to Appliance 2 51 B Side W all to Appliance 6 152 Corner Installation Inches Millimeters C W alls to Appliance 2 51 V ertical Installation Inches Millimeters D Back W all to Flue Pipe 76 E Side W all to T op 6 152 F Back W a ...
-
Quadra-Fire CB1200-B - page 9
R R R September 1, 2008 7014-082D Page 9 CB 1200 Pellet Stove *L Exception for Horizontal Installations: USA INSTALLATIONS : A non-combustible oor protec - tion is recommended extending beneath the ue pipe when installed with horizontal venting or under the top vent adapter with vertical installation. CANADA INSTALLATIONS : A non-combustible ...
-
Quadra-Fire CB1200-B - page 10
Page 10 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Do not terminate vent in any enclosed or semi-enclosed area such as a carport, garage, attic, crawl space, under a sun deck or porch, narrow walkway or closely fenced area, or any location that can build up a concentration of fumes such as a stairwell, covered breezeway , etc. CAUTION V ...
-
Quadra-Fire CB1200-B - page 11
R R R September 1, 2008 7014-082D Page 1 1 CB 1200 Pellet Stove Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner ’s information manual provided with this ap pli - anc e. For as sis tan ce or add iti ona l i nfo rma tio n c ons ult a qualied installer , service agency ...
-
Quadra-Fire CB1200-B - page 12
Page 12 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 5 V enting Systems NOTE: • Illustrations reect typical installations and are FOR DESIGN PURPOSES ONL Y . • Illustrations/diagrams are not drawn to scale. • Actual installation may vary due to individual design preference. A. Alcove Figure 12.1 All minimums listed are to a combu ...
-
Quadra-Fire CB1200-B - page 13
R R R September 1, 2008 7014-082D Page 1 CB 1200 Pellet Stove 12 in . (05 mm ) Min im u m Non-combustible Hearth Pad W all Thimble Horizontal T ermination Cap 2 in. (51mm) Minimum 6 in. (152mm) Minimum From Glass Straight Out B. Through The W all Horizontal termination cap must be a minimum of 12 inches. (05mm) from the wall. Approved for ...
-
Quadra-Fire CB1200-B - page 14
Page 14 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R We recommend a minimum of 60 in. (1524mm) vertical, however above the eave is preferred. Bo th ins ta l la ti on s a re app ro v ed f o r mob i le home installations. Must use or 4 inch (76 to 102mm) “L” or “PL” Listed pellet venting or listed double wall pipe and Quadra-Fir ...
-
Quadra-Fire CB1200-B - page 15
R R R September 1, 2008 7014-082D Page 15 CB 1200 Pellet Stove Fire Hazard Inspection of Chimney: • Masonry chimney must be in good condition. • Meets minimum standard of NFP A 21 1 • Factory-built chimney must be 6 in. (152mm) UL10 HT . W ARNING E. Masonry F . Alternate Masonry Non-Combust ible Hearth Pad Airtight Clean-ou t Door Cleano u ...
-
Quadra-Fire CB1200-B - page 16
Page 16 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 6 Mobile Home 1. An ou tsi de ai r inl et mus t be pro vided for the com busti on air and must remain clear of leaves, debris, ice and/or snow . It must be unrestricted while the appliance is in use to prevent room air starvation which causes smoke spillag e. Sm oke spill age can also s ...
-
Quadra-Fire CB1200-B - page 17
R R R September 1, 2008 7014-082D Page 17 CB 1200 Pellet Stove 7 Appliance Set-Up A. Outside Air Kit Instructions Flex Hose Hose Clamp Collar Assembly T rim Ring T erminatio n Cap Assembly Hose Clamp Included in Kit: 1 piece of 2 inch x foot ex hose, 2 hose clamps, 1 collar assembly , termination cap assembly , 1 trim ring, 12 screws. a. Mea ...
-
Quadra-Fire CB1200-B - page 18
Page 18 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 3 to 3 inch T op V ent Adapter 3 to 6 inch T op V ent Offset Adapter 1. Put a layer of high temperature silicone on the inch (76mm) exhaust outlet. 2. Slide the top vent adapter onto the rear exhaust outlet and adjust the assembly to a vertical position. . Drill 4 holes with #26 ...
-
Quadra-Fire CB1200-B - page 19
R R R September 1, 2008 7014-082D Page 19 CB 1200 Pellet Stove D. Optional Brick Set Installation 1. Remove the bafe rst, follow instructions on page 33 . 2. Slide bottom of left rear brick in rst; rotate top edge toward rear of appliance and then rotate outer edge toward rear of appliance, until brick slides into place. Figure 19.1. . ...
-
Quadra-Fire CB1200-B - page 20
Page 20 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R G. Optional Gold or Nickel Grille Assembly 1. Plac e the fr ont lo g in rst as sh own in Fi gure 20.1 . Pl ace log between repot and face of appliance with charred area surrounding repot. 2. Set the left and right logs onto the front log, placing the holes in the base of the le ...
-
Quadra-Fire CB1200-B - page 21
R R R September 1, 2008 7014-082D Page 21 CB 1200 Pellet Stove 1 . A 12 volt AC thermostat is required to operate this pellet appl iance. Y ou may use the inclu ded wal l moun t ther mo - stat or purchase an optional programmable thermostat or remote control. It is equipped with an adjustable heat anticipator . The current rating is .05 amps. The a ...
-
Quadra-Fire CB1200-B - page 22
Page 22 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 8 Operating Instructions A. Fuel Size And Material 1. Wood Pellets Fuel pellets are made from sawdust or wood by-products. If the sour ce materi al is har dwo od, they c an h ave a h igh er m ine ral content, creating more ash. Fuels containing bark will also have higher ash content. Mi ...
-
Quadra-Fire CB1200-B - page 23
R R R September 1, 2008 7014-082D Page 2 CB 1200 Pellet Stove E. Fire Characteristics A properly adjusted re with the heat output control switch set on “high” has a short active ame pattern that extends out of the repot approximately 4 to 6 inches (102 to 152mm). If the re has tall ames with black tails and seems somewhat lazy ...
-
Quadra-Fire CB1200-B - page 24
Page 24 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R G. Ignition Cycles 1. During each ignition cycle, it is normal to see some smoke in the rebox. The smoke will stop once the re starts. 2. The convection blower will automatically turn on after your appliance has reached the set temperature on the “high” setting. This blower tr ...
-
Quadra-Fire CB1200-B - page 25
R R R September 1, 2008 7014-082D Page 25 CB 1200 Pellet Stove 9 T roubleshooting With proper installation, operation, and maintenance your appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualied service person in the diagnosis of a problem and the corrective action t ...
-
Quadra-Fire CB1200-B - page 26
Page 26 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Symptom Possible Cause Corrective Action Slow or smoky start-up (Cont’d ) Dirty exhaust and/or venting system. Check for ash build up in unit, includ - ing behind rear panels, rebox, heat exchanger , exhaust blower and venting. Feed system fails to start. Out of fuel. #2 snap disc ...
-
Quadra-Fire CB1200-B - page 27
R R R September 1, 2008 7014-082D Page 27 CB 1200 Pellet Stove Symptoms Possible Cause Corrective Action Convection blower fails to start. #1 snap disc defective. Blower not plugged in. Blower is defective. Control box is defective. Replace snap disc. Check that blower is plugged into wire har - ness. Replace blower . Replace control box. Exhaust b ...
-
Quadra-Fire CB1200-B - page 28
Page 28 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 10 Maintaining & Servicing Y our Appliance C. General Maintenance 1. T ypes of Fuel Depending on the type of fuel you are burning will dictate how often you have to clean your repot. If the fuel you are burning has a high dirt or ash content or you are burning shelled eld corn ...
-
Quadra-Fire CB1200-B - page 29
R R R September 1, 2008 7014-082D Page 29 CB 1200 Pellet Stove 5. Disposal of Ashes • Frequency: As needed • By: Homeowner Ashes should be placed in a metal container with a tight-tting lid. The closed container of ashes should be placed on a non-combustible oor or on the ground, well away from all combustible materials, pending nal di ...
-
Quadra-Fire CB1200-B - page 30
Page 0 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 7. Cleaning Beneath Heat Exchanger • Frequency: Monthly or after burning 1 ton of fuel • By: Homeowner a. Be sure the appliance is allowed to cool, has been unplugged and the exhaust blower is off . b. A more thorough cleaning is needed to remove the excess ash that is left behind ...
-
Quadra-Fire CB1200-B - page 31
R R R September 1, 2008 7014-082D Page 1 CB 1200 Pellet Stove 15. Soot and Fly Ash: Formation & Need for Removal in Exhaust V enting System. • Frequency: Y early or more frequently depending on ash build-up. • By: Qualied Service T echnician/Homeowner Be sure the appliance is allowed to cool, has been unplugged and the exhaust blower ...
-
Quadra-Fire CB1200-B - page 32
Page 2 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Correct Flame Size, Y ellow/White in Colo r Correct Figure 32.3 Ash Build Up in Firebox Pellets Back Up In Feed T ube Firepot Overfills T all, Lazy Flame, Orange in Colo r Incorrect Figure 32.1 Figure 32.2 D. High Ash Fuel Content Maintenance • Frequency: When the ash build-up excee ...
-
Quadra-Fire CB1200-B - page 33
R R R September 1, 2008 7014-082D Page CB 1200 Pellet Stove 2. Exhaust Blower Replacement G. Igniter Replacement F . Bafe Removal 1. Use proper shut down procedures to shut down the appliance and let it completely cool down and then unplug it and remove the ash drawer . 2. Follow instructions to remove the ash drawer found on page 29 . Re ...
-
Quadra-Fire CB1200-B - page 34
Page 4 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R H. Glass Replacement • Glass is 5mm thick high temperature heat- resistant ceramic glass. • DO NOT REPLACE with any other material. • Alternate material may shatter and cause injury . W ARNING Figure 34.1 T op & Bottom Frame Door Latch Side Frame Center Posts Glass Remove Do ...
-
Quadra-Fire CB1200-B - page 35
R R R September 1, 2008 7014-082D Page 5 CB 1200 Pellet Stove 1 1 Reference Materials 7. Heat Exchangers The heat exchan gers trans fer hot air from the exhaust syst em into convection air . Lift the stove top to access the heat exchangers. There are 2 clean out rods located under the heat exchangers. 8 . Heat Output Switch The he at ou tpu t sw ...
-
Quadra-Fire CB1200-B - page 36
Page 6 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 16. Snap Disc #1 (Convection Blower) 145°F Snap disc #1 is located on the right side of the appliance on the top of the heat exchanger box. There are 2 purple wires connected to it. This snap disc turns the convection blower on and of f as needed. Power is always present at snap disc ...
-
Quadra-Fire CB1200-B - page 37
R R R September 1, 2008 7014-082D Page 7 CB 1200 Pellet Stove B. Component Locations Heat Output Fan Speed Reset Button Call Light HIGH HIGH MED LOW LOW Power Outlet T erminal Block. Center 2 screws for Thermostat Wires Outside Air Flex Hose Convection Blower Cleaning Rods Heat Exchanger T ubes Figure 37.1 Figure 37.3 Figure 37.4 Figure 37.2 ...
-
Quadra-Fire CB1200-B - page 38
Page 8 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Figure 38.1 - Door , Face, Glass & Door Latch Assembly Figure 38.2 - Firepot, Igniter & Thermocouple C. Exploded Views 1 2 4 5 6 7 8 9 Glass Size Center: 13-7/8” wide x 1 1” high Glass Size Sides: 5-1/8” wide x 1 1” high Nbr Description Part Number 1 Door Frame not ...
-
Quadra-Fire CB1200-B - page 39
R R R September 1, 2008 7014-082D Page 9 CB 1200 Pellet Stove Figure 38.1 2 24 25 26 27 28 29 0 1 2 4 5 6 7 8 9 40 41 42 4 44 45 46 47 48 Nbr Description 2 Door Assembly 24 Ash Pan 25 Panel Access, Front (Firepot) 26 Latch, Draw 27 Director , Air , Large 28 Director , Air , Small 29 Grille, Louvers 0 ...
-
Quadra-Fire CB1200-B - page 40
Page 40 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 51 52 5 54 55 56 70 71 72 7 62 74 57 58 59 60 61 6 64 65 66 67 68 69 75 76 77 Figure 39.1 Nbr Description 51 Exhaust Plenum Clean-Out Plate 52 Snap Disc, #1, 145-40 degree 5 Blower , Convection 54 Convection Air Plenum, not sellable 55 Snap Disc, #2, 200 degree 56 Curtain Mo ...
-
Quadra-Fire CB1200-B - page 41
R R R September 1, 2008 7014-082D Page 41 CB 1200 Pellet Stove IMPORT ANT : THI S IS DA TED INF ORMA TI ON. The most curr ent inf ormati on is loca ted on th e Quadra - Fire web site at www .quadrare.com . When ordering, supply serial and model numbers to ensure correct service parts. D. Service Parts and Accessories Item # Parts (Alphabetical O ...
-
Quadra-Fire CB1200-B - page 42
Page 42 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Grille, Bar , Bottom 410-80 72 Handle, Hopper Lid 200-01 10 Heat Output Control Switch, (Rocker Switch), position 812-500 75 Heat Shield Extension, T op 410-522 Hinge, Female, Door 450-2910 Hinge, Male, Door 450-2810 71 Hopper Lid 410-4901 45 Igniter , Loop (Heating Elem ...
-
Quadra-Fire CB1200-B - page 43
R R R September 1, 2008 7014-082D Page 4 CB 1200 Pellet Stove Appliance Part No. Classic Bay 1200 Freestanding Pellet Stove CB1200-B Accessories Part No. Brick, Set, 4 pc 81 1-0601 Log Set, pc 81 1-0592 Door Assembly , Black DR-CB12-BK Door Assembly , Gold DR-CB12-GD Door Assembly , Nickel DR-CB12-NL Grille Assembly , Black L VGRL-CB12-NL Gr ...
-
Quadra-Fire CB1200-B - page 44
Page 44 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Date of Service Performed By Description of Service E. Service And Maintenance Log ...
-
Quadra-Fire CB1200-B - page 45
R R R September 1, 2008 7014-082D Page 45 CB 1200 Pellet Stove F . Homeowner ’s Notes ...
-
Quadra-Fire CB1200-B - page 46
Page 46 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R G. W arranty Policy Hearth & Home T echnologies LIMITED W ARRANTY Hearth & Home T echnologies (“HHT”) and its respective brands extends the following warranty for HHT gas, wood, pellet and electric appliances purchased from an authorized HHT dealer and installed in the Unite ...
-
Quadra-Fire CB1200-B - page 47
R R R September 1, 2008 7014-082D Page 47 CB 1200 Pellet Stove this noise are not covered by this warranty . HHT’s obligation under this warranty does not extend to damages resulting from: (1) installation, operation or main - tenance of the appliance not in accordance with the installation instructions; operating instructions and the list ...
-
Quadra-Fire CB1200-B - page 48
R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI INDUSTRIES www .quadrare.com 7014-082D Septemer 1, 2008 Page 48 CONT ACT INFORMA TION : This product may be covered by one or more of the following patents: (United States) 459510, 4686807, 4766876, 47922, 481 154, 5000162, 5016609, 5076254, 51 ...
У вас вопрос, касающийся Quadra-Fire CB1200-B?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Quadra-Fire CB1200-B, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Quadra-Fire CB1200-B со всей вероятностью он захочет поделиться методом ее решения.