-
Kohler SV820 - page 1
O WNER ' S M ANUAL V ERTICAL C RANKSHAFT C OURAGE SV710-740 C OURAGE PRO SV810-840 ...
-
Kohler SV820 - page 2
2 Safety Precautions Electrical Shock! Never touch electrical wires or components while the engine is running. They can be sources of electrical shock. CAUTION Electrical Shock can cause injury . Do not touch wires while engine is running. Rotating Parts can cause severe injury . Stay away while engine is in operation. W ARNING California Propositi ...
-
Kohler SV820 - page 3
3 Accidental Starts can cause severe injury or death. Disconnect and ground spark plug leads before servicing. W ARNING Carbon Monoxide can cause severe nausea, fainting or death. W ARNING W ARNING Explosive Gas can cause fi res and severe acid burns. Charge ba ery only in a well ventilated area. Keep sources of ignition away . Accidental Star ...
-
Kohler SV820 - page 4
4 Oil Filter Air Cleaner Access Door Handle Recti fi er-Regulator Fuel Pump Identi fi cation Plate Oil Recommendations Using the proper type and weight of oil in the crankcase is extremely important. So is checking oil daily and changing oil regularly . Failure to use the correct oil, or using dirty oil, causes premature engine wear and failure. ...
-
Kohler SV820 - page 5
5 General Recommendations Purchase gasoline in small quantities and store in clean, approved containers. A container with a capacity of 2 gallons or less with a pouring spout is recommended. Such a container is easier to handle and helps eliminate spillage during refueling. Do not use gasoline le over from the previous season, to minimize gum d ...
-
Kohler SV820 - page 6
6 Operating Instructions Also read the operating instructions of the equipment this engine powers. Pre-Start Checklist • Check oil level. Add oil if low . Do not over fi ll. • Check fuel level. Add fuel if low . • Check cooling air intake areas and external surfaces of engine. Make sure they are clean and unobstructed. • Check that the air ...
-
Kohler SV820 - page 7
7 Maintenance Instructions Maintenance, repair , or replacement of the emission control devices and systems, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual. W arranty repairs must be performed by an authorized Kohler service outlet. W ARNING: Accidental Starts! Disabling eng ...
-
Kohler SV820 - page 8
8 Figure 5. Dipstick Styles. Figure 8. Oil Drain Plug. 3. Remove the oil fi ll cap/dipstick; wipe oil o ff . For engines with a press-on style dipstick: Reinsert the dipstick into the tube and press all the w ay down. See Figure 5. For engines with a thread-on style dipstick: Reinsert the dipstick into the oil fi ll tube and thread the dipstick ...
-
Kohler SV820 - page 9
9 Change the oil and oil fi lter as follows. 1. The drain plug is located on the starter side of the oil pan. See Figure 8. Clean the area around the oil drain plug and the oil fi ll cap/dipstick. 2. Remove the drain plug and the oil fi ll cap/ dipstick. 3. Allow the oil to drain and then reinstall the drain plug. Tighten 13.6 N·m (10 . lb. ...
-
Kohler SV820 - page 10
10 Service Paper Element Check the paper element every 50 hours of operation, (more o en under extremely dusty or dirty conditions). Clean or replace the element as necessary . Replace the air cleaner element annually , or every 100 hours . 1. Open the door on the blower housing to access the air cleaner element. See Figures 9 and 10. 2. Unhook ...
-
Kohler SV820 - page 11
11 NOTE: Operating the engine with a blocked grass screen, dirty or plugged cooling fi ns, and/or cooling shrouds removed, will cause engine damage due to overheating. Ignition System These engines use an electronic Capacitive Discharge (CD) ignition system. Other than periodically checking/replacing the spark plugs, no maintenance, timing, or adj ...
-
Kohler SV820 - page 12
12 Low Idle Mixture Screw Idle Speed (RPM) Adjustment Screw Fuel Solenoid If, a er checking the items listed above, the engine is hard to start, runs roughly , or stalls at low idle speed, it may be necessary to adjust or service the carburetor . Adjust Carburetor NOTE: Some engines may have a fi xed (capped) idle fuel adjusting screw or limit ...
-
Kohler SV820 - page 13
13 The system requires an additional procedure for se ing the idle speed. If speed adjustments are required proceed as follows. 1. Make any necessary speed or control adjustments following the appropriate instructions covered in this section. 2. Move the thro le control to the idle position. Hold the governor lev er away from the carburetor ...
-
Kohler SV820 - page 14
14 Courage ® SV710-740 Speci fi cations Model: ...................................................................................SV710 ............................... ..SV715 ...........................SV720 Bore: ................................................ mm (in.)......................83 (3.27) .............................83 ( 3.27) .... ...
-
Kohler SV820 - page 15
15 COURAGE ® SV710-740 ENGINE LIMITED W ARRANTY Kohler Co. warrants to the original retail consumer that each new COURAGE ® engine sold by Kohler Co. will be free from manufacturing defects in materials or workmanship in normal residential homeowner service for a period of tw o (2) years from date of purchase , provided it is operated and maintai ...
-
Kohler SV820 - page 16
16 Courage PRO ™ SV810-840 Speci fi cations Model: ...................................................................................SV810 .......................................................................SV820 Bore: ................................................ mm (in.)......................83 (3.27) ................................... ...
-
Kohler SV820 - page 17
17 COURAGE PRO TM SV810-840 ENGINE LIMITED W ARRANTY Kohler Co. warrants to the original retail consumer that each new COURAGE PRO ™ engine sold by Kohler Co. will be free from manufacturing defects in materials or workmanship in normal residential homeowner service for a period of tw o (2) years from date of purchase, provided it is operated and ...
-
Kohler SV820 - page 18
18 Continued on next page. KOHLER CO. FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS LIMITED W ARRANTY SMALL OFF-ROAD ENGINES The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), and Kohler Co. are pleased to explain the Federal and California Emission Control Systems Warranty on your small o ff -road equipme ...
-
Kohler SV820 - page 19
19 • Fuel lines, fuel line fi ings and clamps (if equipped) • Air fi lter, fuel fi lter , and spark plugs (only • Spark advance module (if equipped) to fi rst scheduled replacement point) • Crankcase breather • Evaporativ e System (if equipped) • Air Injection System (if equipped) - Canister (if equipped) - Air pump or pulse val ...
-
Kohler SV820 - page 20
REVISED: 6/09 LITHO IN U.S.A. FORM NO.: 32 590 01-B ISSUED: 9/05 ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044 FOR SALES AND SER VICE INFORMA TION IN U.S. AND CANADA, CALL 1-800-544-2444 KohlerEngines.com ...
У вас вопрос, касающийся Kohler SV820?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Kohler SV820, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Kohler SV820 со всей вероятностью он захочет поделиться методом ее решения.