-
Kenmore 122.1643101 - page 1
Use & Care Guide ® Charcoal- Gas Combo Grill Sears Model No.: 122.16431010 Kmart Item No.: 640-01350178-8 • Safety • Parts • Use and Care • Assembly This Grill is for Outdoor Use Only • Read and follow all Safety, Assembly, and Use and Care Instructions in this Guide before assembling and cooking with this grill. • Failure to follo ...
-
Kenmore 122.1643101 - page 2
Warranty ................................................ 2 Safety Precautions 2 Packaging Content List .............................. 5 Hardware Pack ........................................ 7 Preparation 7 Assembly Instructions 7 Lighting Instructions 16 Cleaning and Maintenance for Gas Grill ...... 18 Troubleshooting ............................ ...
-
Kenmore 122.1643101 - page 3
A tank of approximately 12 inches in diameter by 18- 1/2 inches high is the maximum size LP gas tank to use. You must use an OPD gas tank which offers an Overfill Prevention Device. This safety feature prevents the tank from being overfilled which can cause malfunction of the LP gas tank, regulator and/or grill. The LP gas tank must be constructed ...
-
Kenmore 122.1643101 - page 4
WARNING A strong gas smell, or the hissing sound of gas indicates a serious problem with your gas grill or the LP gas tank. Failure to immediately follow the steps listed below could result in a fire or explosion that could cause serious bodily injury, death, or property damage. • Shut off gas supply to the gas grill. • Turn the control knobs t ...
-
Kenmore 122.1643101 - page 5
B. Cart Leg, Front Left ...... 1pc. ! A. Firebox ........ 1pc. iii C. Cart Leg, Back Left .... 1pc. D. Cart Brace, Left ...... 1pc. G. Cart Brace, Right ...... 1pc. J. Bottom Panel 1pc. M. Triangle Bracket ..... 2pcs P. Towel Rack .......... 1pc. E. Cart Leg, Front Right ..... 1pc. H. Swivel Caster with Brake K. Wheel Axle ........... 1pc. N. Trian ...
-
Kenmore 122.1643101 - page 6
S. Charcoal Bin Right Side Panel-- 1pc T. Charcoal Bin back panel--lpc. z _f W. Front Trim Panel ........ 1pc. V. Charcoal Bin Handle---lpc. Y. Charcoal Bin Slide---2pcs. ZB. Gas Tank Barrier Bar --1pc. ZE. 1.5 Volt "AA" Size Alkaline Battery .......... 1pc. ZH. Heat Diffuser ....... 3pcs. ZK. Gas grill Cooking Grid--2pcs ZN. Crank Handle ...
-
Kenmore 122.1643101 - page 7
Pack Description Required for assembly(pcs) Extra Total hardware (pcs) (pcs) AA 5/32-in. x 10-mm Round Head Screw 54 2 56 BB 5/32-in. Lock Washer 54 2 56 CC 1/4-in. x 15-mm Round Head Screw 20 2 22 DD 1/4-in. Lock Washer 28 2 30 EE Allen Key 1 -- 1 FF 1/4-in. Nut 2 1 3 GG 1/4-in. Flat Washer 2 1 3 HH 1/4-in. x 61-mm Round Head Screw 8 1 9 II 1/4-in ...
-
Kenmore 122.1643101 - page 8
UNPACKING 5. With theaidof an assistant, liftthe Firebox from the bottom of the shipping box and place on protected fiat surface. Be careful not to damage hose and regulator. 6. Remove grill bottom panel from bottom of shipping box. 7. Refer to the Parts Lists to check thatallparts are present. 8. Inspect the grill for damage as you assemble it. Do ...
-
Kenmore 122.1643101 - page 9
3. Bottom Panel Assembly a) Use 4 HH Round Head Screws, 4 DD Lock Washers and 4 GG Flat Washers to attach and securely tighten Bottom Panel (J) to Left Cart Legs (E & F). See Fig. 5. b) Repeat step 3a to attach and securely tighten Bottom Panel (J) to Right Cart Legs (B & C). Note: Use Tank Hole on bottom panel as indicator of Right Side of ...
-
Kenmore 122.1643101 - page 10
6. Charcoal Bin Assembly Fig. 10 a). Place Charcoal Bin Bottom Panel (Q) on a fiat level surface, Connect Charcoal Bin Left (R) and Right (S) Side panels to Bottom Panel by securely hooking Bottom panel tabs into Side panel slots, See Fig. 9. b). Securely hook Charcoal Bin Back Panel (T) tabs into Left and Right Side panel slots. See Fig. 10. c). U ...
-
Kenmore 122.1643101 - page 11
7. Front Trim Panel Assembly a). Place Front Trim Panel (W) against right side of Charcoal Bin Front Panel. Fit Trim Panel hinge pin into hole onto bottom of Bin Front Panel. Tab at top of Trim Panel goes against back surface of Bin Front Panel. Holding Trim Panel and Bin Front Panel together, slide hole on bottom left side of Bin Front Panel onto ...
-
Kenmore 122.1643101 - page 12
Fig. 16 BB 10. Cart Beam, Back Assembly Use 4 AA Round Head Screws and 4 BB Lock Washers to attach Cart Beam, Back (Z) to Left Back Cart Leg (C) and Right Back Cart Leg (F). See Fig. 16. NOTE: Flat side of Cart Beam, Back (Z) must face cart exterior. 11. Gas Tank Barrier Bar Assembly a). Use 2 AA Round Head Screws and 2 BB Lock Washers to secure Ga ...
-
Kenmore 122.1643101 - page 13
12. Charcoal Bin Cover Assembly Use 4 JJ Flat Head Screws to connect hinges of Charcoal Bin Cover (ZC) to Cart Beam, Front (X). See Fig. 19. 13. Firebox Assembly NOTE: Obtain the aid of an assistant to lift the Firebox. Be sure that the hose and regulator hang inside the cart when placing Firebox. a). With the aid of an assistant, raise the Firebox ...
-
Kenmore 122.1643101 - page 14
15. Electronic Ignition Battery Installation Unscrew the electronic ignition button and place the Battery (ZE) into the housing with the positive terminal (+) facing outward. Replace the ignition button after the battery has been installed as shown in Fig. 23. 16. Install the Grease Tray & Charcoal Ash Tray Install the Grease Tray (ZF) from the ...
-
Kenmore 122.1643101 - page 15
18. Connecting LP Gas Tank to LP Grill Fig. 26 1. From rear of the Cart, place the foot ring of 20-1b tank into the hole of the Bottom Panel (J). Make sure the tank valve is in OFF position. Use the tank bolt to secure the tank in a fixed position with tank valve facing out to side of Cart. 2. Check the tank valve to ensure it has proper external m ...
-
Kenmore 122.1643101 - page 16
Checking for LP gas leaks Never test for leaks with a flame. Prior to first use, at the beginning of each season, or every time your LP gas tank is changed, you must check for gas leaks. , 2. , Make a 50/50 (soap/water) mild soap solution. Turn the control knobs to full OFF position; then turn gas ON at supply tank. Apply the soap solution with a c ...
-
Kenmore 122.1643101 - page 17
Z_ WARNING Never lean over the grill cooking area while lighting your gas grill. Keep your face and body a safe distance (at least 18 inches) from the cooking grid surface when lighting your grill by match. Manually Lighting Your Grill by Match 1. Insert a match into the lighting stick. 2. Follow steps 1 through 5 of the Basic Lighting Procedure. 3 ...
-
Kenmore 122.1643101 - page 18
To ensure a proper working unit the following proper care and maintenance is suggested. Cleaning Cooking Grids We suggest you wash your cooking grids in a mild soap and warm water solution. You can use a wash cloth or soft brush to clean your cooking grids. Cleaning Heat diffusers Periodically you should wash the heat diffusers in a soap and warm w ...
-
Kenmore 122.1643101 - page 19
Regardless of which burner cleaning procedure you use, we recommend you also complete the following steps to help prolong burner life. 1. Use a fiber pad or nylon brush to clean the entire outer surface of each burner until free of food residue and dirt. 2. Clean any clogged ports with a stiff wire, such as an open paper clip. 3. Inspect each burne ...
-
Kenmore 122.1643101 - page 20
WARNING Keep a fire extinguisher nearby at all times. This grill is for outdoor use only, in well-ventilated areas. The use of alcohol, prescription or non- prescription drugs may impair the user's ability to properly assemble and safely operate this unit. Use caution when lifting and moving the unit to avoid back strain or back injury. Two pe ...
-
Kenmore 122.1643101 - page 21
1. Open grill lid, as well as damper vents on side of grill. 2. Raise the hinged section of Charcoal Grid to add charcoal to the Charcoal Tray. 3. Turn crank to adjust charcoal tray to middle height position. 4. Pour 5 pounds of regular charcoal briquets into charcoal tray and arrange into a pile. Make sure charcoal does not go above the Charcoal G ...
-
Kenmore 122.1643101 - page 22
WARNING; To ensure that it is safe to eat, food must be cooked to the minimum internal temperatures listed in the _ble below. USDA* Safe Minimum Internal Temperatures t45 ° F 160 ° F 160 ° F 145 ° F 160 ° F 165 ° F t65 ° F Fish Pork Egg Dishes Steaks and Roasts of Beef, Veal or' Lamb Ground Beef, Veal or Lamb Whole Poultry (Turkey, Chic ...
-
Kenmore 122.1643101 - page 23
i 21 67 _30 i 23 ...
-
Kenmore 122.1643101 - page 24
KEY# PARTS DESCRIPTION QUANTITY KEY# PARTS 1 718-001 Main Lid, grill 1 37 718-037 2 718-002 Main Lid, Charcoal 1 38 718-038 3 718-003 Damper 1 39 718-039 4 718-004 Main Lid Screw 4 40 718-040 5 718-005 Temperature Gauge 2 41 718-041 6 718-006 Logo 1 42 718-042 7 718-007 Hood Buffer 4 43 718-043 8 718-008 Charcoal Tray Rasing BracketA 2 44 718-044 9 ...
-
Kenmore 122.1643101 - page 25
Your Home For exped troubleshooting and home solutions advice: ww-w_managemyhome.com For repair - in your home -of a!! major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it:, no matter who sold it! For the replacement pa_s, accessories and owner's manuals that you need to doqt_yourself. For Se ...
У вас вопрос, касающийся Kenmore 122.1643101?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Kenmore 122.1643101, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Kenmore 122.1643101 со всей вероятностью он захочет поделиться методом ее решения.