-
Hobart MGR36C - page 1
701 RIDGE AVENUE TROY, OHIO 45374-0001 937-332-3000 www.hobartcorp.com FORM 18202, Rev. B (July 2000) MODELS MGR36 AND MGR36C GAS DELI RANGES ML-103870 ML-103871 N S T R U C T I O N S I ...
-
Hobart MGR36C - page 2
– 2 – © HOBART CORPORATION, 1994 IMPORT ANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GAS EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. POST IN A PROMINENT LOCATION THE INSTRUCTIONS TO BE FOLLOWED IN THE EVENT THE SMELL OF GAS IS DETECTED ...
-
Hobart MGR36C - page 3
– 3 – T ABLE OF CONTENTS GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...
-
Hobart MGR36C - page 4
– 4 – Installation, Operation and Care of MODELS MGR36 & MGR36C GAS DELI RANGES SA VE THESE INSTRUCTIONS FOR FUTURE USE GENERAL Your MGR36 or MGR36C Gas Deli Range is equipped with six open top burners. The MGR36 range has a standard oven and is supplied with one oven rack. The MGR36C has a convection oven and is supplied with three oven ra ...
-
Hobart MGR36C - page 5
– 5 – INSTALLATION CODES AND STANDARDS For proper installation procedures in the United States of America, refer to: 1. State and local codes. 2. National Fuel Gas Code ANSI-Z223.1 (latest edition). Copies may be obtained from The American Gas Association, Inc., 1515 Wilson Blvd., Arlington, VA 22209. 3. National Electrical Code ANSI/NFPA-70 (l ...
-
Hobart MGR36C - page 6
– 6 – Bumper Bars (Convection Oven Ranges Only) CAUTION: Failure to install bumper bars may cause motor damage and may void the warranty. Remove existing #10 screws. Position bumper bars (supplied) as shown. Replace #10 screws and secure bumper bars (Fig. 2). Fig. 2 Backsplash The standard deli range is equipped with a 23" high backsplash ...
-
Hobart MGR36C - page 7
– 7 – Fig. 3 Fig. 4 3. Assemble the required components as shown in Fig's. 3 and 4. 4. Lift the assembly up, sliding the channels into the space provided at the rear of the range (this may require 2 people). 5. It may be necessary to pull the heat shield bottom out slightly in order to clear the oven flue box area. Be sure the backsplash i ...
-
Hobart MGR36C - page 8
– 8 – Fig. 8 Fig. 9 Fig. 7 6. Install eight #10 sheet metal screws (4 to each channel leg) (Fig. 7). 7. From the front, install four 1 / 4 -20 x 2 5 / 16 " long machine screws and secure bolts with locknuts. Do not tighten the screws all the way down. Leave about 1 / 4 " of play in each screw (Fig. 8). 8. Lift the shelf up and slide t ...
-
Hobart MGR36C - page 9
– 9 – LEVELING Check the leveling of the range. Place a carpenter's level inside the oven cavity across the oven rack(s). Level front-to-back and side-to-side. To adjust the leveling, tilt the range to one side and, using channel locks, unscrew the adjustable leg insert as required. Repeat this procedure as necessary for each leg. Casters ...
-
Hobart MGR36C - page 10
– 10 – Fig. 10 WARNING: PRIOR TO LIGHTING, CHECK ALL JOINTS IN THE GAS SUPPLY LINE FOR LEAKS. USE SOAP AND WATER SOLUTION. DO NOT USE AN OPEN FLAME. After piping has been checked for leaks, all piping receiving gas should be fully purged to remove air. TESTING THE GAS SUPPLY SYSTEM When gas supply pressure exceeds 1 / 2 psig (3.45 kPa), the ran ...
-
Hobart MGR36C - page 11
– 11 – ELECTRICAL CONNECTIONS (CONVECTION OVEN MODEL ONLY) WARNING: ELECTRICAL AND GROUNDING CONNECTIONS MUST COMPLY WITH THE APPLICABLE PORTIONS OF THE NATIONAL ELECTRICAL CODE AND/OR OTHER LOCAL ELECTRICAL CODES. WARNING: DISCONNECT ELECTRICAL POWER SUPPLY AND PLACE A TAG AT THE DISCONNECT SWITCH TO INDICATE THAT YOU ARE WORKING ON THE CIRCUI ...
-
Hobart MGR36C - page 12
– 12 – OPERA TION WARNING: THE RANGE AND ITS PARTS ARE HOT. BE VERY CAREFUL WHEN OPERATING, CLEANING OR SERVICING THE RANGE. CONTROLS Thermostat Dial - Standard Oven — Allows operator to regulate the oven temperature from low to 500 ° F. Thermostat Dial - Convection Oven — Snap-acting type control which allows operator to regulate the oven ...
-
Hobart MGR36C - page 13
– 13 – 3. If pilot fails to light, turn main gas supply OFF. Wait 5 minutes and repeat the above procedures. 4. After pilot is lit, turn one open top burner valve ON to remove air from the gas line. Turn burner OFF when gas begins to flow. Nightly Shutdown: Turn burner valve OFF; pilot will remain lit. Complete Shutdown 1. Turn burner valve OFF ...
-
Hobart MGR36C - page 14
– 14 – Convection Oven Light open top burner pilots before lighting oven pilot. 1. Open kick panel (see Fig. 12) and lift up the pilot lighting hole cover. 2. Turn red gas valve ON (located behind the kick panel), purging the gas line of all air (Fig. 14). Turn gas valve and power switch OFF. Close oven door. Wait 5 minutes. Fig. 14 Fig. 15 3. ...
-
Hobart MGR36C - page 15
– 15 – PREHEATING Standard Oven Turn thermostat to the desired cooking temperature and preheat oven for 25 minutes. To save on gas consumption, do not operate oven at maximum heat when it is not necessary. Turn thermostat down to 250 ° F or OFF when oven is not in use or during idle cooking periods. Convection Oven With power switch in the ON ...
-
Hobart MGR36C - page 16
– 16 – RACK ARRANGEMENT - CONVECTION OVEN Capacity The convection oven is supplied with three oven racks. The oven cavity provides a five-position rack support for maximum cooking flexibility. The following arrangements are the most commonly recommended. The rack positions are numerically sequenced starting at the bottom. Arrangement #1 Three r ...
-
Hobart MGR36C - page 17
– 17 – Fig. 19 COOKING CHART FOR CONVECTION OVEN This cooking chart is for convection ovens only. For standard ovens, use your normal recipe times and temperatures. Recommended temperatures and times in this chart are intended as a guide only. Adjustments must be made to compensate for elevation, variations in recipes, ingredients, preparation ...
-
Hobart MGR36C - page 18
– 18 – ROASTING TEMPERATURES AND TIMES PRODUCT TEMPERATURE APPROXIMATE TIME Standing Rib Roast 250 ° F 3-4 Hrs. - Rare Oven Ready - 15 lbs. 4-4 1 / 2 Hrs. - Med. Rolled Rib Roast - 20-22 lbs. 275 ° F 4 Hrs. - Med. Veal Roast - 15 lbs. 300 ° F 3 Hrs. - Med. Well Turkey - 15-20 lbs. 300 ° F 3 Hrs. Meat Loaf - 8-10 lbs. 350 ° F 45 to 60 Min. ...
-
Hobart MGR36C - page 19
– 19 – RECOMMENDED TEMPERATURES AND TIMES FOR BAKING, Cont'd. PRODUCT TEMPERATURE APPROXIMATE TIME (MIN.) Cookies Rolled or Pressed 350 to 400 ° F 6 to 12 Drop 350 to 400 ° F 6 to 15 Brownies 350 ° F 12 to 20 Yeast Breads NOTE: Yeast breads should be fully proofed for best results. Rolls - 1 oz. 350 to 400 ° F 5 to 10 1 1 / 2 to 2 1 / ...
-
Hobart MGR36C - page 20
– 20 – REHEATING PREPARED FOODS PRODUCT TEMPERATURE APPROXIMATE TIME (MIN.) Frozen French Fries 400 to 450 ° F 6 to 8 Frozen TV Dinners 350 to 400 ° F 10 to 12 Frozen Entrees - 1" thick 300 to 350 ° F 10 to 20 Frozen Meals 8 oz. foil package 350 to 400 ° F 20 to 30 CASSEROLES PRODUCT TEMPERATURE APPROXIMATE TIME (MIN.) Food Service Pan ...
-
Hobart MGR36C - page 21
– 21 – CLEANING WARNING: (CONVECTION OVEN MODEL ONLY) DISCONNECT ELECTRICAL POWER SUPPLY BEFORE CLEANING. Do not use Dawn dish detergent to clean the exterior or interior components of the range. DO NOT use scouring powder. It is extremely difficult to remove completely, and accumulations can build up that will damage the oven. Painted surfaces ...
-
Hobart MGR36C - page 22
– 22 – CONVECTION OVENS ONLY Keep the convection tube opening (Fig. 20) clear from blockage. If usage of aluminum foil is a common practice during the operation of this oven, be sure to periodically check the convection tube for foil particles. Fig. 20 Clean the convection tube with standard oven cleaner at least once a week. Be sure to thoroug ...
-
Hobart MGR36C - page 23
– 23 – MAINTENANCE WARNING: THE RANGE AND ITS PARTS ARE HOT. BE VERY CAREFUL WHEN OPERATING, CLEANING OR SERVICING THE RANGE. WARNING: (CONVECTION OVENS ONLY) DISCONNECT ELECTRICAL POWER SUPPLY BEFORE SERVICING THE RANGE. LUBRICATION The MGR36C convection oven motor is permanently lubricated and will not require any additional maintenance. OVEN ...
-
Hobart MGR36C - page 24
– 24 – PROBLEM Too much bottom heat. Too low temperature. Side burning. Too much top heat. Uneven bake side-to-side. Uneven bake front-to-rear. Dried out products. Pilot outage. TOP BURNER OPERATION PROBLEM Improper burner combustion. Excessive valve handle temperatures. Sticking top burner valves. Poor ignition. POSSIBLE CAUSES 1. Insufficient ...
¿Tienes una pregunta acerca de Hobart MGR36C?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Hobart MGR36C, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Hobart MGR36C probablemente compartirá una forma de solucionarlo.