Hobart MGR36Cの取扱説明書

24ページ 8.21 mb
ダウンロード

ページに移動 of 24

Summary
  • Hobart MGR36C - page 1

    701 RIDGE AVENUE TROY, OHIO 45374-0001 937-332-3000 www.hobartcorp.com FORM 18202, Rev. B (July 2000) MODELS MGR36 AND MGR36C GAS DELI RANGES ML-103870 ML-103871 N S T R U C T I O N S I ...

  • Hobart MGR36C - page 2

    – 2 – © HOBART CORPORATION, 1994 IMPORT ANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GAS EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. POST IN A PROMINENT LOCATION THE INSTRUCTIONS TO BE FOLLOWED IN THE EVENT THE SMELL OF GAS IS DETECTED ...

  • Hobart MGR36C - page 3

    – 3 – T ABLE OF CONTENTS GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Hobart MGR36C - page 4

    – 4 – Installation, Operation and Care of MODELS MGR36 & MGR36C GAS DELI RANGES SA VE THESE INSTRUCTIONS FOR FUTURE USE GENERAL Your MGR36 or MGR36C Gas Deli Range is equipped with six open top burners. The MGR36 range has a standard oven and is supplied with one oven rack. The MGR36C has a convection oven and is supplied with three oven ra ...

  • Hobart MGR36C - page 5

    – 5 – INSTALLATION CODES AND STANDARDS For proper installation procedures in the United States of America, refer to: 1. State and local codes. 2. National Fuel Gas Code ANSI-Z223.1 (latest edition). Copies may be obtained from The American Gas Association, Inc., 1515 Wilson Blvd., Arlington, VA 22209. 3. National Electrical Code ANSI/NFPA-70 (l ...

  • Hobart MGR36C - page 6

    – 6 – Bumper Bars (Convection Oven Ranges Only) CAUTION: Failure to install bumper bars may cause motor damage and may void the warranty. Remove existing #10 screws. Position bumper bars (supplied) as shown. Replace #10 screws and secure bumper bars (Fig. 2). Fig. 2 Backsplash The standard deli range is equipped with a 23" high backsplash ...

  • Hobart MGR36C - page 7

    – 7 – Fig. 3 Fig. 4 3. Assemble the required components as shown in Fig's. 3 and 4. 4. Lift the assembly up, sliding the channels into the space provided at the rear of the range (this may require 2 people). 5. It may be necessary to pull the heat shield bottom out slightly in order to clear the oven flue box area. Be sure the backsplash i ...

  • Hobart MGR36C - page 8

    – 8 – Fig. 8 Fig. 9 Fig. 7 6. Install eight #10 sheet metal screws (4 to each channel leg) (Fig. 7). 7. From the front, install four 1 / 4 -20 x 2 5 / 16 " long machine screws and secure bolts with locknuts. Do not tighten the screws all the way down. Leave about 1 / 4 " of play in each screw (Fig. 8). 8. Lift the shelf up and slide t ...

  • Hobart MGR36C - page 9

    – 9 – LEVELING Check the leveling of the range. Place a carpenter's level inside the oven cavity across the oven rack(s). Level front-to-back and side-to-side. To adjust the leveling, tilt the range to one side and, using channel locks, unscrew the adjustable leg insert as required. Repeat this procedure as necessary for each leg. Casters ...

  • Hobart MGR36C - page 10

    – 10 – Fig. 10 WARNING: PRIOR TO LIGHTING, CHECK ALL JOINTS IN THE GAS SUPPLY LINE FOR LEAKS. USE SOAP AND WATER SOLUTION. DO NOT USE AN OPEN FLAME. After piping has been checked for leaks, all piping receiving gas should be fully purged to remove air. TESTING THE GAS SUPPLY SYSTEM When gas supply pressure exceeds 1 / 2 psig (3.45 kPa), the ran ...

  • Hobart MGR36C - page 11

    – 11 – ELECTRICAL CONNECTIONS (CONVECTION OVEN MODEL ONLY) WARNING: ELECTRICAL AND GROUNDING CONNECTIONS MUST COMPLY WITH THE APPLICABLE PORTIONS OF THE NATIONAL ELECTRICAL CODE AND/OR OTHER LOCAL ELECTRICAL CODES. WARNING: DISCONNECT ELECTRICAL POWER SUPPLY AND PLACE A TAG AT THE DISCONNECT SWITCH TO INDICATE THAT YOU ARE WORKING ON THE CIRCUI ...

  • Hobart MGR36C - page 12

    – 12 – OPERA TION WARNING: THE RANGE AND ITS PARTS ARE HOT. BE VERY CAREFUL WHEN OPERATING, CLEANING OR SERVICING THE RANGE. CONTROLS Thermostat Dial - Standard Oven — Allows operator to regulate the oven temperature from low to 500 ° F. Thermostat Dial - Convection Oven — Snap-acting type control which allows operator to regulate the oven ...

  • Hobart MGR36C - page 13

    – 13 – 3. If pilot fails to light, turn main gas supply OFF. Wait 5 minutes and repeat the above procedures. 4. After pilot is lit, turn one open top burner valve ON to remove air from the gas line. Turn burner OFF when gas begins to flow. Nightly Shutdown: Turn burner valve OFF; pilot will remain lit. Complete Shutdown 1. Turn burner valve OFF ...

  • Hobart MGR36C - page 14

    – 14 – Convection Oven Light open top burner pilots before lighting oven pilot. 1. Open kick panel (see Fig. 12) and lift up the pilot lighting hole cover. 2. Turn red gas valve ON (located behind the kick panel), purging the gas line of all air (Fig. 14). Turn gas valve and power switch OFF. Close oven door. Wait 5 minutes. Fig. 14 Fig. 15 3. ...

  • Hobart MGR36C - page 15

    – 15 – PREHEATING Standard Oven Turn thermostat to the desired cooking temperature and preheat oven for 25 minutes. To save on gas consumption, do not operate oven at maximum heat when it is not necessary. Turn thermostat down to 250 ° F or OFF when oven is not in use or during idle cooking periods. Convection Oven With power switch in the ON ...

  • Hobart MGR36C - page 16

    – 16 – RACK ARRANGEMENT - CONVECTION OVEN Capacity The convection oven is supplied with three oven racks. The oven cavity provides a five-position rack support for maximum cooking flexibility. The following arrangements are the most commonly recommended. The rack positions are numerically sequenced starting at the bottom. Arrangement #1 Three r ...

  • Hobart MGR36C - page 17

    – 17 – Fig. 19 COOKING CHART FOR CONVECTION OVEN This cooking chart is for convection ovens only. For standard ovens, use your normal recipe times and temperatures. Recommended temperatures and times in this chart are intended as a guide only. Adjustments must be made to compensate for elevation, variations in recipes, ingredients, preparation ...

  • Hobart MGR36C - page 18

    – 18 – ROASTING TEMPERATURES AND TIMES PRODUCT TEMPERATURE APPROXIMATE TIME Standing Rib Roast 250 ° F 3-4 Hrs. - Rare Oven Ready - 15 lbs. 4-4 1 / 2 Hrs. - Med. Rolled Rib Roast - 20-22 lbs. 275 ° F 4 Hrs. - Med. Veal Roast - 15 lbs. 300 ° F 3 Hrs. - Med. Well Turkey - 15-20 lbs. 300 ° F 3 Hrs. Meat Loaf - 8-10 lbs. 350 ° F 45 to 60 Min. ...

  • Hobart MGR36C - page 19

    – 19 – RECOMMENDED TEMPERATURES AND TIMES FOR BAKING, Cont'd. PRODUCT TEMPERATURE APPROXIMATE TIME (MIN.) Cookies Rolled or Pressed 350 to 400 ° F 6 to 12 Drop 350 to 400 ° F 6 to 15 Brownies 350 ° F 12 to 20 Yeast Breads NOTE: Yeast breads should be fully proofed for best results. Rolls - 1 oz. 350 to 400 ° F 5 to 10 1 1 / 2 to 2 1 / ...

  • Hobart MGR36C - page 20

    – 20 – REHEATING PREPARED FOODS PRODUCT TEMPERATURE APPROXIMATE TIME (MIN.) Frozen French Fries 400 to 450 ° F 6 to 8 Frozen TV Dinners 350 to 400 ° F 10 to 12 Frozen Entrees - 1" thick 300 to 350 ° F 10 to 20 Frozen Meals 8 oz. foil package 350 to 400 ° F 20 to 30 CASSEROLES PRODUCT TEMPERATURE APPROXIMATE TIME (MIN.) Food Service Pan ...

  • Hobart MGR36C - page 21

    – 21 – CLEANING WARNING: (CONVECTION OVEN MODEL ONLY) DISCONNECT ELECTRICAL POWER SUPPLY BEFORE CLEANING. Do not use Dawn dish detergent to clean the exterior or interior components of the range. DO NOT use scouring powder. It is extremely difficult to remove completely, and accumulations can build up that will damage the oven. Painted surfaces ...

  • Hobart MGR36C - page 22

    – 22 – CONVECTION OVENS ONLY Keep the convection tube opening (Fig. 20) clear from blockage. If usage of aluminum foil is a common practice during the operation of this oven, be sure to periodically check the convection tube for foil particles. Fig. 20 Clean the convection tube with standard oven cleaner at least once a week. Be sure to thoroug ...

  • Hobart MGR36C - page 23

    – 23 – MAINTENANCE WARNING: THE RANGE AND ITS PARTS ARE HOT. BE VERY CAREFUL WHEN OPERATING, CLEANING OR SERVICING THE RANGE. WARNING: (CONVECTION OVENS ONLY) DISCONNECT ELECTRICAL POWER SUPPLY BEFORE SERVICING THE RANGE. LUBRICATION The MGR36C convection oven motor is permanently lubricated and will not require any additional maintenance. OVEN ...

  • Hobart MGR36C - page 24

    – 24 – PROBLEM Too much bottom heat. Too low temperature. Side burning. Too much top heat. Uneven bake side-to-side. Uneven bake front-to-rear. Dried out products. Pilot outage. TOP BURNER OPERATION PROBLEM Improper burner combustion. Excessive valve handle temperatures. Sticking top burner valves. Poor ignition. POSSIBLE CAUSES 1. Insufficient ...

メーカー Hobart カテゴリー Range

Hobart MGR36Cのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- MGR36Cの取扱説明書
- Hobartの製品カード
- パンフレット
- またはHobart MGR36Cの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Hobart MGR36Cの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Hobart MGR36Cの取り付け説明書、サービスマニュアル、簡易説明書、またはHobart MGR36Cのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Hobart MGR36Cの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Hobart MGR36Cデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがHobart MGR36Cを使用するのを助ける技術的文書のことです。説明書は通常、全てのHobart MGR36Cユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Hobartの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Hobart MGR36Cの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははHobart MGR36Cの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Hobart MGR36Cに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Hobart MGR36Cデバイスの基本機能を使うにあたってのヒント。 Hobart MGR36Cのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Hobart MGR36Cに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるHobart MGR36Cのメーカー/サービスへの連絡先に関する情報。

Hobart MGR36Cについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもHobart MGR36Cの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがHobart MGR36Cで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)