Manuel d’utilisation Field Controls PVU-300

16 pages 0.87 mb
Télécharger

Aller à la page of 16

Summary
  • Field Controls PVU-300 - page 1

    2630 Airport Road · Kinston, NC 28504 Phone: 252-522-3031· Fax: 252-522 -0214 www.fieldcontrols.com POWER VENTER SYSTEM Mode l: PVU-300 Included is one ETL LISTED po wer venter to be used fo r side wall venting of a single 120/24 VAC controlled furnace, boiler, or water heater which burns natural or LP gas, or oil. The PVU may also be used to ven ...

  • Field Controls PVU-300 - page 2

    Page 2 UNIT SPECIFICATIONS (See Table 1 and Figure 1 ) Table 1 UNIT DIMENSIONS (INCHES) MODEL “H” “W” “D” I/O* PVU-300 7.5 11.5 7.0 4/4 * Inlet and outlet diameter. ELECTRICAL RATINGS MODEL VAC Hz RPM WATT AM P TP** PVU-300 115 60 3000 145 2.1 YES ** Thermally protected motor. SIDEWALL VENT HOODS (Model SWH-1) Sidewall vent hoods are av ...

  • Field Controls PVU-300 - page 3

    Page 3 P ROCEDURE F OR C AL CULA TIN G T OTAL E QUIVALENT P IPE L ENGTH I N F EET 1. Calculate the total equivalent feet for each type of fitting used in the v enting system from the following chart. 2. Calculate the total amount of feet fo r the straight lengths of vent pipe. 3. Add the equivalent feet for the fittings with the total amount of fee ...

  • Field Controls PVU-300 - page 4

    Page 4 8. Air flow adjustment M U ST be made t o ensure applianc e efficiency. Thi s should be done at the appliance exhaust outlet with a velocity meter, draft gau ge or by the "match test procedure". The match test is in accordance with National Fuel Gas Code A. N.S.I.Z223.1, Section 8.6. 9. On heating a ppliances not equipped with a dr ...

  • Field Controls PVU-300 - page 5

    Page 5 S IDE W ALL V ENT H OO D I NSTALLATION 1. Use the inside wall plate as a template to mark the hole location. Cut a hole 1 inch larger than the marked hole to facilitate easy insta llation (See Figure 4) 2. Center vent hood through the hole from outsid e. Fasten the vent hood to the outside wall with the appropriate type of mounting screws. 3 ...

  • Field Controls PVU-300 - page 6

    Page 6 O PTIONAL G SK -3 E XHAUST G AS S PILLAGE D ETECTOR S WITCH I NSTALLATION NOTE: Installation of the GSK-3 secondary safety switch is reco mmended for LP and Natural gas fired appliances with a draft hood. This switch will detect exhaust gas spillage out of the draft hood due to a blocked vent system and/or inadequate draft during operation. ...

  • Field Controls PVU-300 - page 7

    Page 7 GENERAL WIRING INSTRUCTIONS CAUTION: Disconn ect electrical power before wiring p owe r venter! Connect line voltage (110/120 VAC) through j unction box acce ss hole labeled "120 VAC Only". Connect l ow voltage control wiring through ju nction box access hole label ed "24 VAC Control Wiring Only". VENTER MUST BE GROUNDED! ...

  • Field Controls PVU-300 - page 8

    Page 8 Diagram E – Wiring with a 30mV Water Heate r NOTE: A CK-20FV or CK-20FG control kit MUST be added to the sy stem to properl y control the venter with the operation of a 30mV water heater. Refer to Diagra m E for proper wiring specifications. ADJUSTING THERMOSTAT ANTICIPATOR If connecting the Power Venter system to a gas appliance with a th ...

  • Field Controls PVU-300 - page 9

    Page 9 AIR FLOW ADJUSTMENTS 1. To properly adjust the venter air fl ow, loosen the inlet ring screws and open the choke plate approximately 1/2 to 3/4 open. (S ee Figure 9) Start the heating appliance following the manufacturer specified proce dure, and set the thermostat to call for heat. 2. After the system has operated for seve ral minutes to st ...

  • Field Controls PVU-300 - page 10

    Page 10 SYSTEM CONTROL CHECK PROCEDURES 1. Adjust the thermostat to cal l for heat and observe th e power ventin g system for proper operation sequence. Repeat as necessary. a. Thermostat calls for heat. b. Venter relay is energized which starts venter motor. c. Pressure switch closes whi ch allows burner to fire. d. Thermostat is satisfied, burner ...

  • Field Controls PVU-300 - page 11

    Page 11 Diagram F – Multiple Wiring with 24 VAC Furnace and 30mV Water Hea t e r MULTIPLE VENTING SYSTEMS 1. To vent a 24 VAC controlled boiler or furna c e and a 30 millivolt residential water heater usi ng one PVU power venter refer to the following. a. Follow the instructions for safe a nd proper venting previously specified in this manual. Ma ...

  • Field Controls PVU-300 - page 12

    Page 12 Diagram G – Multiple Wiring with two 24 VAC Appliances 2. To vent two 24 VAC appliances using one PVU power venter refer to the following. a. Follow the instructions for safe and proper venting pr eviously specified in this manual. Make sure that the combined gross BTU/Hr in put and equivalent vent pipe length does not ex ceed the maximum ...

  • Field Controls PVU-300 - page 13

    Page 13 Diagram H – Multiple Wiring with two 120 VAC Appliances 3. To vent two 120 VAC appliances using one PVU power venter refer to the following. c. Follow the instructions for safe and proper venting pr eviously specified in th is manual. Make sure that the combined gross BTU/Hr in put and equivalent vent pipe length does not ex ceed the maxi ...

  • Field Controls PVU-300 - page 14

    Page 14 PV SERIES POWER VENTER: VERTICAL VENTING OPTION Natural gas, lp gas or #2 fuel oil appliance rated at 75% or greater non-co nde nsing type of appliance. Maximum input temperature at power venter: 575°f Diagram I – Vertical Venting Option ...

  • Field Controls PVU-300 - page 15

    Page 15 VENTING SYSTEM OPERATIONAL INFORMATIO N Date: Heating appliance BTU/Hr input Gas valve operation pressure Vent system draft above draft hood or below barometric draft control CO 2 measurement CO measurement Appliance outlet flue gas temperature INSTALLATION INFORMATION MODEL NO.: ____________________________________________________________ ...

  • Field Controls PVU-300 - page 16

    Page 16 P/N 46517200 Rev B 11/06 ...

Fabricant Field Controls Catégorie Ventilation Hood

Les documents que nous recevons du fabricant de l'appareilField Controls PVU-300 peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Field Controls
- manuels d’utilisations PVU-300
- fiches produit Field Controls
- dépliants
- ou étiquettes-énergie Field Controls PVU-300
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Field Controls PVU-300.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Field Controls PVU-300, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Field Controls PVU-300. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Field Controls PVU-300.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Field Controls PVU-300, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Field Controls PVU-300 par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Field Controls PVU-300.

Le manuel d’utilisation complet Field Controls, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Field Controls PVU-300 - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Field Controls PVU-300, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lField Controls PVU-300 qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Field Controls PVU-300 - qui devraient nous aider dans les premières étapes lors de l'utilisation Field Controls PVU-300
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Field Controls PVU-300
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Field Controls PVU-300 dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Field Controls PVU-300?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Field Controls PVU-300, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Field Controls PVU-300 il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Commentaires (0)