Manuale per l’uso Weil-McLain 78

32 pagine 2.05 mb
Scarica

Vai alla pagina of 32

Summary
  • Weil-McLain 78 - page 1

    This manual must only be used by a qualified heating installer/service technician . Failure to comply could result in severe personal injury , death or substantial property damage. Part No. 550-141-705/0600 78 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Boiler Manual • Installation • Start-Up • Maintenance • Parts Installer: L ...

  • Weil-McLain 78 - page 2

    Part No. 550-141-705 W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Contents 1. Before Installing Boiler .............................................................. page 3 2. Set Packaged Boiler or Block Assembly in Place ................ page 5 3. Assemble Block ........................................................... ...

  • Weil-McLain 78 - page 3

    • Installation • Start-Up • M aintenance • Pa r t s Befor e Installing Boiler 1a Installation must comply with: • State, provincial and local plumbing, heating and electrical codes. • Regulations of serving utilities. • National codes where applicable. Before selecting boiler location: • Check for nearby connections to: – fuel sup ...

  • Weil-McLain 78 - page 4

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Befor e Installing Boiler 1b Provide clearances for servicing around boiler: • Back, for breeching - 30 inches. • Left side, for cleaning and tankless heater removal - 34 inches • Allow sufficient space on remaining sides for cleaning, servicing and burner installation. Se ...

  • Weil-McLain 78 - page 5

    • Installation • Start-Up • M aintenance • Pa r t s Set Packaged Boiler or Block Assembly in Place 2a For packaged boiler: 1. Remove top jacket panel. Set aside until after boiler is piped. 2. Remove lag screws (2 in front, 2 in rear) from shipping rails. 3. Remove boiler from skid. Cables are already attached to block assembly . See Liftin ...

  • Weil-McLain 78 - page 6

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Assemble Block 3a Sections are top heavy . Unbolted sections may fall if not supported, resulting in severe personal injury or death. Install back refractory blanket: 1. Lay back section on floor with ports face up. 2 Apply water glass as an adhesive to blanket. 3. Press blanket ...

  • Weil-McLain 78 - page 7

    ...

  • Weil-McLain 78 - page 8

    Prepare remaining sections: 1. Follow “Prepare intermediate section” for remaining intermediate and front sections: a. Remove any grit from threads inside tapped holes with clean rag. Do not use petroleum-based cleaning or sealing compounds in boiler system. Severe damage to system components can result, causing substantial property damage. b. ...

  • Weil-McLain 78 - page 9

    ...

  • Weil-McLain 78 - page 10

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Assemble Block 3e Prepare flue collector hood assembly: Make sure gaskets are intact, not torn or otherwise damaged. These conditions can cause possible flue gas leakage and carbon monoxide emissions, resulting in severe personal injury or death. 1. Stand one collector hood modu ...

  • Weil-McLain 78 - page 11

    • Installation • Start-Up • M aintenance • Pa r t s Assemble Block 3f Install flue collector hood assembly: 1. Place hood on top of sections with open end of hood tightly against flue collar . Make sure flue collar gasket is in place, not broken, bent or folded. 2. Install 5/16" x 2" carriage bolts, flat washers and regular nuts o ...

  • Weil-McLain 78 - page 12

    ...

  • Weil-McLain 78 - page 13

    General water piping information: • System water supply and return piping should be installed and piping connections attached to boiler before erecting jacket or installing controls. • Do not pipe in through supply and out through return. This creates reverse water flow through boiler that must not be used. • When three-way valves are used fo ...

  • Weil-McLain 78 - page 14

    ...

  • Weil-McLain 78 - page 15

    • Installation • Start-Up • M aintenance • Pa r t s Connect Steam Boiler Piping 6a General steam piping information: • Hartford Loop piping arrangement and wet return are required for steam boilers. • Maintain 24-inch minimum from waterline to bottom of header (56-1/4" from bottom o f section). • When using condensate receiver, f ...

  • Weil-McLain 78 - page 16

    ...

  • Weil-McLain 78 - page 17

    ...

  • Weil-McLain 78 - page 18

    ...

  • Weil-McLain 78 - page 19

    ...

  • Weil-McLain 78 - page 20

    ...

  • Weil-McLain 78 - page 21

    ...

  • Weil-McLain 78 - page 22

    ...

  • Weil-McLain 78 - page 23

    ...

  • Weil-McLain 78 - page 24

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Install Bur ner 12a Wiring and Fuel Piping 13a T o install burner: 1. Unpack burner . 2. Place gasket around air tube and against burner mounting flange. If sealing rope is used, apply 1/8" continuous bead of rope adhesive around burner mounting flange and apply sealing rop ...

  • Weil-McLain 78 - page 25

    • Installation • Start-Up • M aintenance • Pa r t s Make Final Adjustments 14a T o fill water boilers: 1. Close manual air vents and drain cocks. 2. Fill to correct system pressure. Correct pressure will vary with each installation. 3. Starting on lowest floor , open air vents one at a time until water squirts out. Close vent. Repeat with r ...

  • Weil-McLain 78 - page 26

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Make Final Adjustments 14b Skim steam boilers: Clean all newly install steam boilers to remove oil. Failure to properly clean can result in violent water level fluctuations, water passing into steam mains, or high maintenance costs on strainers, traps and vents. Skim boiler only ...

  • Weil-McLain 78 - page 27

    • Installation • Start-Up • M aintenance • Pa r t s Data and Dimensions 15a Data Dimensions Supply T appings Return T appings Quantity Quantity And Size* And Size* Boiler Model W ater Steam W ater Steam A B D E H W L 378 2 - 4" 2 - 4" 2 - 3" 2 - 3" 13-1/8 -- 8 42-1/2 13-1/2 20-3/8 21-1/2 478 2 - 4" 2 - 4" 2 - 3 ...

  • Weil-McLain 78 - page 28

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Data and Dimensions 15b Part No. 550-141-705 28 Front Back Side Intermediate Minimum for heater removal 3" NPT return W=Boiler section length 4" NPT supply outlets 3" NPT return W ater line ...

  • Weil-McLain 78 - page 29

    • Installation • Start-Up • M aintenance • Pa r t s Part No. 550-141-705 29 Parts 16a B A C O N E G F D J K L P Q K M P I H ...

  • Weil-McLain 78 - page 30

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Parts 16b Figure No. Description W-M Sales Ref. No. A Front Section (7813) 1 1B329 B Intermediate Section Regular (7815) 1 1B330 Intermediate Section Supply - Steam (7814) 1 1B331 C Intermediate Section T ankless (7816) 1 1B332 D Back Section (7818) 1 1B333 Section Assembly Kit ...

  • Weil-McLain 78 - page 31

    • Installation • Start-Up • M aintenance • Pa r t s Ratings 17a Part No. 550-141-705 31 ◆ I=B=R Burner ✝ ✝ Boiler Water Capacity Net I=B=R Ratings ❏ Content Gals. Packaged ✝ ■ * * Positive Boiler * * Gross Net Stack Presure I=B=R Weight Light ❍ ■ I=B=R ■■ Firebox Gas In V ent Steam Less Oil Gas Output Steam Steam W ater ...

  • Weil-McLain 78 - page 32

    Part No. 550-141-705/0600 32 ...

Fabbricante Weil-McLain Categoria Burner

I documenti che otteniamo dal fabbricante del dispositivoWeil-McLain 78 possono essere suddivisi in diversi gruppi. Questi sono tra gli altri:
- disegni tecnici Weil-McLain
- manuali per l’uso 78
- schede prodotto Weil-McLain
- opuscoli
- o etichette energetiche Weil-McLain 78
Tutti sono importanti, ma le informazioni più importanti dal punto di vista di utilizzo del dispositivo possono essere trovate nel manuale per l’uso Weil-McLain 78.

Un gruppo di documenti denominato manuali per l’uso, è anche suddiviso in tipi più specifici, come: Manuali di installazione Weil-McLain 78, manuali di manutenzione, brevi manuali o manuali utente Weil-McLain 78. A seconda delle esigenze, si dovrebbe cercare il documento necessario. Nel nostro sito web, puoi visualizzare il manuale più popolare per l'uso del prodotto Weil-McLain 78.

Manuali per l’uso simili

Manuale completo del dispositivo Weil-McLain 78, come deve essere?
Il manuale per l’uso, denominato anche istruzioni per l’uso, o semplicemente il manuale è un documento tecnico progettato per aiutare ad utilizzare Weil-McLain 78 dagli utenti. I manuali sono di solito scritti da uno scrittore tecnico, ma in un linguaggio accessibile a tutti gli utenti Weil-McLain 78.

Il manuale per l’uso completo Weil-McLain, dovrebbe includere vari elementi di base. Alcuni di loro sono meno importanti, come ad esempio: copertina / pagina del titolo o pagina di autore. Tuttavia, la parte rimanente, dovrebbe fornire informazioni importanti dal punto di vista dell'utente.

1. Introduzione e la guida su come utilizzare il manuale Weil-McLain 78 - All'inizio di ogni manuale, dovremmo trovare indizi su come utilizzare il documento. Dovrebbe contenere informazioni sulla posizione dell’indice Weil-McLain 78, FAQ o i problemi più comuni : i punti che sono più spesso cercati dagli utenti di ogni manuale
2. Indice - elenco di tutti i suggerimenti per Weil-McLain 78 che possono essere trovati nel documento corrente
3. Suggerimenti su come utilizzare le funzioni di base del dispositivo Weil-McLain 78 - che ci dovrebbe aiutare nei primi passi durante l'uso Weil-McLain 78
4. Troubleshooting - sequenza sistematica delle attività che vi aiuterà a diagnosticare e, successivamente, risolvere i problemi più importanti del Weil-McLain 78
5. FAQ - domande più frequenti
6. Dettagli di contatto Informazioni su dove cercare il contatto con il fabbricante / servizio Weil-McLain 78 in un dato paese, se il problema non può essere risolto da noi stessi.

Hai una domanda su Weil-McLain 78?

Utilizza il modulo sottostante

Se non hai risolto il problema con Weil-McLain 78 con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con Weil-McLain 78 è probabile che voglia condividere il modo di risolverlo.

Riscrivi il testo dall’immagine

Commenti (0)