Weil-McLain 78の取扱説明書

32ページ 2.05 mb
ダウンロード

ページに移動 of 32

Summary
  • Weil-McLain 78 - page 1

    This manual must only be used by a qualified heating installer/service technician . Failure to comply could result in severe personal injury , death or substantial property damage. Part No. 550-141-705/0600 78 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Boiler Manual • Installation • Start-Up • Maintenance • Parts Installer: L ...

  • Weil-McLain 78 - page 2

    Part No. 550-141-705 W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Contents 1. Before Installing Boiler .............................................................. page 3 2. Set Packaged Boiler or Block Assembly in Place ................ page 5 3. Assemble Block ........................................................... ...

  • Weil-McLain 78 - page 3

    • Installation • Start-Up • M aintenance • Pa r t s Befor e Installing Boiler 1a Installation must comply with: • State, provincial and local plumbing, heating and electrical codes. • Regulations of serving utilities. • National codes where applicable. Before selecting boiler location: • Check for nearby connections to: – fuel sup ...

  • Weil-McLain 78 - page 4

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Befor e Installing Boiler 1b Provide clearances for servicing around boiler: • Back, for breeching - 30 inches. • Left side, for cleaning and tankless heater removal - 34 inches • Allow sufficient space on remaining sides for cleaning, servicing and burner installation. Se ...

  • Weil-McLain 78 - page 5

    • Installation • Start-Up • M aintenance • Pa r t s Set Packaged Boiler or Block Assembly in Place 2a For packaged boiler: 1. Remove top jacket panel. Set aside until after boiler is piped. 2. Remove lag screws (2 in front, 2 in rear) from shipping rails. 3. Remove boiler from skid. Cables are already attached to block assembly . See Liftin ...

  • Weil-McLain 78 - page 6

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Assemble Block 3a Sections are top heavy . Unbolted sections may fall if not supported, resulting in severe personal injury or death. Install back refractory blanket: 1. Lay back section on floor with ports face up. 2 Apply water glass as an adhesive to blanket. 3. Press blanket ...

  • Weil-McLain 78 - page 7

    ...

  • Weil-McLain 78 - page 8

    Prepare remaining sections: 1. Follow “Prepare intermediate section” for remaining intermediate and front sections: a. Remove any grit from threads inside tapped holes with clean rag. Do not use petroleum-based cleaning or sealing compounds in boiler system. Severe damage to system components can result, causing substantial property damage. b. ...

  • Weil-McLain 78 - page 9

    ...

  • Weil-McLain 78 - page 10

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Assemble Block 3e Prepare flue collector hood assembly: Make sure gaskets are intact, not torn or otherwise damaged. These conditions can cause possible flue gas leakage and carbon monoxide emissions, resulting in severe personal injury or death. 1. Stand one collector hood modu ...

  • Weil-McLain 78 - page 11

    • Installation • Start-Up • M aintenance • Pa r t s Assemble Block 3f Install flue collector hood assembly: 1. Place hood on top of sections with open end of hood tightly against flue collar . Make sure flue collar gasket is in place, not broken, bent or folded. 2. Install 5/16" x 2" carriage bolts, flat washers and regular nuts o ...

  • Weil-McLain 78 - page 12

    ...

  • Weil-McLain 78 - page 13

    General water piping information: • System water supply and return piping should be installed and piping connections attached to boiler before erecting jacket or installing controls. • Do not pipe in through supply and out through return. This creates reverse water flow through boiler that must not be used. • When three-way valves are used fo ...

  • Weil-McLain 78 - page 14

    ...

  • Weil-McLain 78 - page 15

    • Installation • Start-Up • M aintenance • Pa r t s Connect Steam Boiler Piping 6a General steam piping information: • Hartford Loop piping arrangement and wet return are required for steam boilers. • Maintain 24-inch minimum from waterline to bottom of header (56-1/4" from bottom o f section). • When using condensate receiver, f ...

  • Weil-McLain 78 - page 16

    ...

  • Weil-McLain 78 - page 17

    ...

  • Weil-McLain 78 - page 18

    ...

  • Weil-McLain 78 - page 19

    ...

  • Weil-McLain 78 - page 20

    ...

  • Weil-McLain 78 - page 21

    ...

  • Weil-McLain 78 - page 22

    ...

  • Weil-McLain 78 - page 23

    ...

  • Weil-McLain 78 - page 24

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Install Bur ner 12a Wiring and Fuel Piping 13a T o install burner: 1. Unpack burner . 2. Place gasket around air tube and against burner mounting flange. If sealing rope is used, apply 1/8" continuous bead of rope adhesive around burner mounting flange and apply sealing rop ...

  • Weil-McLain 78 - page 25

    • Installation • Start-Up • M aintenance • Pa r t s Make Final Adjustments 14a T o fill water boilers: 1. Close manual air vents and drain cocks. 2. Fill to correct system pressure. Correct pressure will vary with each installation. 3. Starting on lowest floor , open air vents one at a time until water squirts out. Close vent. Repeat with r ...

  • Weil-McLain 78 - page 26

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Make Final Adjustments 14b Skim steam boilers: Clean all newly install steam boilers to remove oil. Failure to properly clean can result in violent water level fluctuations, water passing into steam mains, or high maintenance costs on strainers, traps and vents. Skim boiler only ...

  • Weil-McLain 78 - page 27

    • Installation • Start-Up • M aintenance • Pa r t s Data and Dimensions 15a Data Dimensions Supply T appings Return T appings Quantity Quantity And Size* And Size* Boiler Model W ater Steam W ater Steam A B D E H W L 378 2 - 4" 2 - 4" 2 - 3" 2 - 3" 13-1/8 -- 8 42-1/2 13-1/2 20-3/8 21-1/2 478 2 - 4" 2 - 4" 2 - 3 ...

  • Weil-McLain 78 - page 28

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Data and Dimensions 15b Part No. 550-141-705 28 Front Back Side Intermediate Minimum for heater removal 3" NPT return W=Boiler section length 4" NPT supply outlets 3" NPT return W ater line ...

  • Weil-McLain 78 - page 29

    • Installation • Start-Up • M aintenance • Pa r t s Part No. 550-141-705 29 Parts 16a B A C O N E G F D J K L P Q K M P I H ...

  • Weil-McLain 78 - page 30

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Parts 16b Figure No. Description W-M Sales Ref. No. A Front Section (7813) 1 1B329 B Intermediate Section Regular (7815) 1 1B330 Intermediate Section Supply - Steam (7814) 1 1B331 C Intermediate Section T ankless (7816) 1 1B332 D Back Section (7818) 1 1B333 Section Assembly Kit ...

  • Weil-McLain 78 - page 31

    • Installation • Start-Up • M aintenance • Pa r t s Ratings 17a Part No. 550-141-705 31 ◆ I=B=R Burner ✝ ✝ Boiler Water Capacity Net I=B=R Ratings ❏ Content Gals. Packaged ✝ ■ * * Positive Boiler * * Gross Net Stack Presure I=B=R Weight Light ❍ ■ I=B=R ■■ Firebox Gas In V ent Steam Less Oil Gas Output Steam Steam W ater ...

  • Weil-McLain 78 - page 32

    Part No. 550-141-705/0600 32 ...

メーカー Weil-McLain カテゴリー Burner

Weil-McLain 78のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 78の取扱説明書
- Weil-McLainの製品カード
- パンフレット
- またはWeil-McLain 78の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Weil-McLain 78の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Weil-McLain 78の取り付け説明書、サービスマニュアル、簡易説明書、またはWeil-McLain 78のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Weil-McLain 78の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Weil-McLain 78デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがWeil-McLain 78を使用するのを助ける技術的文書のことです。説明書は通常、全てのWeil-McLain 78ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Weil-McLainの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Weil-McLain 78の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははWeil-McLain 78の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Weil-McLain 78に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Weil-McLain 78デバイスの基本機能を使うにあたってのヒント。 Weil-McLain 78のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Weil-McLain 78に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるWeil-McLain 78のメーカー/サービスへの連絡先に関する情報。

Weil-McLain 78についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもWeil-McLain 78の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWeil-McLain 78で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)