-
Quadra-Fire 7068-112 - page 1
R www .quadrare.com 7068-1 12 August 19, 201 1 CASTILE & SANT A FE PELLET ST OVE Owner ’ s Manual Installation and Operation CASTILE-CE-MBK SANT AFE-CE-MBK Models: WARNING Please read this entire manual before installation and use of this pellet fuel-burning room heater . Failure to follow these instructions could result in property damage ...
-
Quadra-Fire 7068-112 - page 2
Page2 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 Hearth&Home T echnologieswelcomesyouto ourtradition of excellence! In choosing a Quadra-Fire appliance, you have our assuranceof commitmentto quality ,durability , and performance. Thi ...
-
Quadra-Fire 7068-112 - page 3
R August 19, 201 1 Page3 Castile & Santa Fe CE Pellet Stove 7068-1 12 T ABLE OF CONTENTS Safety Alert Key: • DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury . • W ARNING! Indicatesahazardoussituationwhich,ifnotavoidedcould ...
-
Quadra-Fire 7068-112 - page 4
Page4 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 ...
-
Quadra-Fire 7068-112 - page 5
R August 19, 201 1 Page5 Castile & Santa Fe CE Pellet Stove 7068-1 12 ...
-
Quadra-Fire 7068-112 - page 6
Page6 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 A. Appliance Certication B. Glass Specications D. Specications This appliance is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contact your dealerforreplace ...
-
Quadra-Fire 7068-112 - page 7
R August 19, 201 1 Page7 Castile & Santa Fe CE Pellet Stove 7068-1 12 HOT SURF ACES! Glassandothersurfacesarehotduringoperation ANDcooldown. Hot glass will cause burns. • Donottouchglassuntilitiscooled • NEVERallowchildrentotouchglass • Keepchildrena ...
-
Quadra-Fire 7068-112 - page 8
Page8 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 A. Fire Safety T o provide reasonable re safety , the following should be givenseriousconsideration: • Install at least one smoke detector and CO monitor on each oorofyourhome. •? ...
-
Quadra-Fire 7068-112 - page 9
R August 19, 201 1 Page9 Castile & Santa Fe CE Pellet Stove 7068-1 12 E. Before Your First Fire 1 . First, make sure your appliance has been properly installed and that all safety requirements have been met. Pay particular attention to the re protection, ve ...
-
Quadra-Fire 7068-112 - page 10
Page10 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 H. Fire Characteristics A properly adjusted re with the heat output control switch set on “high” has a short active ame pattern that extends out of the repot approximately 102mm. ...
-
Quadra-Fire 7068-112 - page 11
R August 19, 201 1 Page1 1 Castile & Santa Fe CE Pellet Stove 7068-1 12 3 Maintaining & Servicing Y our Appliance C. General Maintenance 1. T ypes of Fuel Depending on the type of fuel you are burning will dictate howoftenyouhavetocleanyourrepot. If the fuel you? ...
-
Quadra-Fire 7068-112 - page 12
Page12 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 2. Cleaning Firepot with Cleaning Rod & Firepot Clean-Out T ool • Frequency: Dailyormoreoftenasneeded • By: Homeowner a.The appliance must be in complete shutdown and cool and the exhaust blo ...
-
Quadra-Fire 7068-112 - page 13
R August 19, 201 1 Page13 Castile & Santa Fe CE Pellet Stove 7068-1 12 Figure 14.2 V acuum inside Exhaust V enting The amount of ash buildup in the repot will be a good guide to determine how often you should clean the heat exchangers. W ARNING Heatexchangercleanin ...
-
Quadra-Fire 7068-112 - page 14
Page14 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 Clean-Out Cover 12. Cleaning the Glass • Frequency: Whenclearviewoftherepotbecomes obscure • By: Homeowner a. Appliance must be completely cool before cleaning glass. b. V acuumyash? ...
-
Quadra-Fire 7068-112 - page 15
R August 19, 201 1 Page15 Castile & Santa Fe CE Pellet Stove 7068-1 12 D. High Ash Fuel Content Maintenance • Frequency: Asneeded • By: Homeowner Correct Flame Size, Y ellow/White in Color Correct Figure 16.3 Ash Build Up in Firebox Pellets Back Up In Feed T ube Firepot Overfills T all, Lazy Flame, Orange in Color Inco ...
-
Quadra-Fire 7068-112 - page 16
Page16 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 NOTICE: Odors and vapors are released during initial operation due to the curing of high tem - peraturepaint.Openwindowsforaircirculation.Odorsmaybeirritatingtosensitiveindividuals. ...
-
Quadra-Fire 7068-112 - page 17
R August 19, 201 1 Page17 Castile & Santa Fe CE Pellet Stove 7068-1 12 5 Getting Started Installer ’ s Guide A . Design, Installation & Location Considerations W ARNING! Risk of Fire Damaged parts could impair safe operation. Do NOT install damaged, incomplete or substitute components. 1. Ap ...
-
Quadra-Fire 7068-112 - page 18
Page18 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 B. Thermostat Location The thermostat’s location will have some effect on the appliance’soperation. When the thermostat is located close to the appliance, it may require aslightly highe ...
-
Quadra-Fire 7068-112 - page 19
R August 19, 201 1 Page19 Castile & Santa Fe CE Pellet Stove 7068-1 12 6 Dimensions and Clearances A. A ppliance Dimensions Figure 20.2- Front View Figure 20.1 - T op View Figure 20.3 -Side View Figure 20.4 - Side View with T op V ent Adapter 658mm 324mm 540mm 729mm 426mm 715mm 653mm 95mm 64mm 73mm 683mm 609mm 626mm 305mm 609mm 725mm 405m ...
-
Quadra-Fire 7068-112 - page 20
Page20 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 Straight Back Against W all Millimeters A BackW allto Appliance 50 B SideW allto Appliance 160 Corner Installation Millimeters C W allsto Appliance 50 V ertical Installation Millimeters D BackW alltoFluePipe 76 E SideW allto ...
-
Quadra-Fire 7068-112 - page 21
R August 19, 201 1 Page21 Castile & Santa Fe CE Pellet Stove 7068-1 12 Exception for Horizontal Installations: A non-combustible oor protection extending beneath the uepipeis required withhorizontalventingorunderthetop ventadapterwith verticalinstallation. Figure ...
-
Quadra-Fire 7068-112 - page 22
Page22 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 Do not terminate vent inanyenclosedorsemi-enclosed areasuchasacarport,garage,attic,crawlspace,undera sundeckorporch,narrowwalkwayorcloselyfencedarea, oranylocationthatcanbui ...
-
Quadra-Fire 7068-112 - page 23
R August 19, 201 1 Page23 Castile & Santa Fe CE Pellet Stove 7068-1 12 V ent Congurations T oreduce probability ofreverse drafting during shut-down conditions Hearth & Home T echnologies strongly recom - mends: • Installing the pellet vent with a minimum ve ...
-
Quadra-Fire 7068-112 - page 24
Page24 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 E. Chimney and Exhaust Connection 1. Chimney & Connector :Use76mmto102mmdiameter type "L" or "PL" venting system. It can be vented vertically orhorizontally . 2. Residential: The 7 ...
-
Quadra-Fire 7068-112 - page 25
R August 19, 201 1 Page25 Castile & Santa Fe CE Pellet Stove 7068-1 12 M ini umum Ver t i cal Ve nt for Thr e e El bows 0. 00 1. 00 2. 00 3. 00 4. 00 5. 00 6. 00 7. 00 0 1 2 3 4 Le ngth of H oriz ontal Se ctions (M) Minimum Vertic al Rise (M) M i ni umum Ve rt ic al Ve nt for Two Elbows 0. 00 1. 00 2. 00 3. 00 4. 00 5. 00 6. 00 012 3456 L ...
-
Quadra-Fire 7068-112 - page 26
Page26 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 8 V enting Systems NOTE: • IllustrationsreecttypicalinstallationsandareFOR DESIGNPURPOSESONL Y . • I llustrations/diagramsarenotdrawntoscale. • Actualinstallationmayvaryduetoindividualde ...
-
Quadra-Fire 7068-112 - page 27
R August 19, 201 1 Page27 Castile & Santa Fe CE Pellet Stove 7068-1 12 We strongly recommend a minimum of 1.5m vertical, however above the eave is preferred. Both installations are approved for mobile home installations. Must use 76mm to 102mm “L”or “PL” Listedpelletventing ...
-
Quadra-Fire 7068-112 - page 28
Page28 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 FireRisk InspectionofChimney: • Masonrychimneymustbeingoodcondition. W ARNING E. Masonry (SHOWN ON A SANT A FE) F. Alternate Masonry (SHOWN ON A SANT A FE) Non-combustible Hearth Pad Airtight Cleanout Door Cleanout cover Sheathing 76mm M ...
-
Quadra-Fire 7068-112 - page 29
R August 19, 201 1 Page29 Castile & Santa Fe CE Pellet Stove 7068-1 12 G. Through The W all Horizontal termination cap must be a minimum of 152mm from the wall. Approvedfor mobile home installations. Must use 76mm to 102mm “L” or “PL” listed pell ...
-
Quadra-Fire 7068-112 - page 30
Page30 August 19, 201 1 Castile & Santa Fe CE Pellet Stove R 7068-1 12 A. Outside Air Kit Instructions (Shown on SANT A FE) Flex Hose Hose Clamp Collar Assembly T rim Rin g T erminatio n Cap Assembly Hose Clamp Air Intake Channel (Discard) Parts Included in Kit: 1 piece of 51mm x 914.4mm ex hose,2 hose ...
-
Quadra-Fire 7068-112 - page 31
R August 19, 201 1 Page31 Castile & Santa Fe CE Pellet Stove 7068-1 12 1. Opendoortoexposetherebox. 2. Install the left log rst and then the right log. Figure 33.1 3. Lean the logs against the cast iron brick in the back of therebox. 4.? ...
-
Quadra-Fire 7068-112 - page 32
R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI Corporation August 19, 201 1 Page32 CONT ACT INFORMA TION : Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer logo onto www .quadrare.com DO NOT DISCARD THIS MANUAL CAUTION • ...
Quadra-Fire 7068-112についてご質問がありますか?
次のフォームを使用してください
見つけた説明書を読んでもQuadra-Fire 7068-112の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがQuadra-Fire 7068-112で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。