ページに移動 of 64
P ar t No . 550-110-260/0107 This manual must only be used by a qualified heating installer/ser vice technician. Before installing , read all instructions, including this manual, the burner manual and any related supplements. P erform steps in the order given. Failur e to comply c ould result in sever e personal injury , death or substantial prope ...
Part number 550-110-260/0107 2 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual How it works . . . ① Control module The control module responds to signals from the room ther mostat, air pr essure sw itch and boiler limit circuit to operate the boiler circulat or , pilot burner , g as valve and inducer . Whe n room thermostat calls for heat, the ...
Part number 550-110-260/0107 3 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual GOLD CGs Gas-Fir ed Induced-Draft W ater Boiler ...
Part number 550-110-260/0107 4 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Contents Hazar d definitions The following defined terms ar e used throughout this manual to bring attention to the presence of hazards of various risk le v els or to important information concerning the life of the product. Indicates presence of hazards that will c ...
Part number 550-110-260/0107 5 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Please r ead befor e pr oceeding Installer Read all instr uctions befor e in- stalling. Follo w all inst ructions in prop er order to pre vent p ers ona l injury or death. • A lso refer to CGs V enting Supplements . • C on sid er pi pin g an d ins tal lat ion when ...
Part number 550-110-260/0107 6 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual P r e p a r e b o i l e r l o c a t i o n — codes & checklist 1a Installations must follow these codes: • Local, state, provincial, and national codes, laws, regulations and or dinances. • N ational Fuel Gas Code, ANSI Z223.1–latest edition. • Standard f ...
Part number 550-110-260/0107 7 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Pr epar e boiler location — clearances 1b Figure 2 Required MINIMUM clearances Figure 1 Recommended SER VICE clearances (see W ARNING below) Recommended SERVICE clearances (Fig. 1) 1. Pr ovide clearances for cleaning and servicing the boiler and for acc ess t o c on ...
Part number 550-110-260/0107 8 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Pr epar e boiler location — vent system 1c Failur e to follow all inst ructions can result in flue gas spillage and carbon mono xide emissions, causing se v ere personal injury or death. W he n r em o vi n g b oi l e r f r o m a n e xi s ti n g c o mm o n v en t sy ...
Part number 550-110-260/0107 9 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Pr epar e boiler location — contamination 1d T able 1 Corrosive or destructive contaminants and likely locations T o pr event potential of sever e personal injury or death, check for products or areas listed below befor e installing boiler . If an y of these contami ...
Part number 550-110-260/0107 10 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Pr epar e boiler location — air openings 1e Special considerations Tight construction A NS I Z 2 23 . 1 d ef i ne s u nu s ua l ly t ig h t c on st r u ct i on where: 1. W a lls and ce iling s exp osed to t he ou tside at mo- sphere have a continuous water vapor re ...
Part number 550-110-260/0107 11 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Figure 3 Sizing air openings for CGs installations ✷ ...
Part number 550-110-260/0107 12 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Place boiler/crate near position 1. Lea ve boiler in crate and on pallet until installation site is read y . 2. M ove entire cr ate and pallet next to selected lo ca- tion. 3. R emove crate. 4. R emove boiler fr om pallet. Do not dro p boiler or bump j ack et on flo ...
Part number 550-110-260/0107 13 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Pr epar e boiler — pr essure test 2b Hydr ostatic pressur e test Pr essure tes t boil er bef or e attaching water or gas piping (ex cept as noted below) or electrical supply . Prepar e boiler for test 1. R emove the shipping nipple (fr om CGs supply tap- pin g) and ...
Part number 550-110-260/0107 14 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual W ater piping — general information 3a T able 3 Water pipe size (based on 20°F rise) General piping information If installation is to c omply with ASME or Canadian requir ements, an ad- ditional high t emperatur e limit is needed. Install c ontrol in suppl y pipin ...
Part number 550-110-260/0107 15 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Wa te r pi pi ng — s in gl e- zo ne s ys te m 3b Figure 4 Di a p h r a gm - o r b l a dd e r -t y p e e x p a ns i o n t a n k Piping to single-zone system See T able 3 for piping sizes. Figure 5 Closed-type expansion tank Piping to single-zone system See T able 3 ...
Part number 550-110-260/0107 16 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual W ater piping — multiple zones 3c Piping multiple zones Follo w instruc tions on pages 14 and 15 to install near- boiler or single-zone piping. (Also refer to Piping for radiant heating systems or con ver ted gr avity sys- tems , below , if applicable.) See Figure ...
Part number 550-110-260/0107 17 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Figure 6 Zoning with circulators — return water 130°F or higher . Figure 7 Zoning with zone valves — return water 130°F or higher . 1 Boiler isolation (balancing) valves 2 Flow/check val ve 3 Syst em or zone circulat or 5 Zone valv e 6 Drain valve 9 Relief valv ...
Part number 550-110-260/0107 18 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Pip in g — low temp systems 3d Failur e to prevent low return water temperature t o the boiler could cause corrosion of the boiler sections or bur ners, res ulting in severe p ersonal injur y , death or substantial property damage. Radiant heating system piping sho ...
Part number 550-110-260/0107 19 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual 1 Boiler isolation (balancing) valv es 2 Flow/check val ve 3 Syst em or zone circulat or 4 Syst em temperature gauges 5 Zone valv e 6 Drain valve 7 Syst em temperature valves (see instruc- tions to the left for adjusting val ves) 8 Blend temperature gauge 9 Relief va ...
Part number 550-110-260/0107 20 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Failur e to prevent low return water temperature t o the boiler could cause corrosion of the boiler sections or bur ners, res ulting in severe p ersonal injur y , death or substantial property damage. Radiant heating system piping should include a means of regulating ...
Part number 550-110-260/0107 21 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual 1 Boiler isolation (balancing) valv es 2 Flow/check val ve 3 Syst em or zone circulat or 4 Syst em temperature gauges 5 Zone valv e 6 Drain valve 7 Sy stem tempera ture valv es ( see i nstructions to the le ft for adjusting valv es) 8 Blend temperature gauge 9 Relief ...
Part number 550-110-260/0107 22 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Failur e to prevent low return water temperature t o the boiler could cause corrosion of the boiler sections or bur ners, res ulting in severe p ersonal injur y , death or substantial property damage. Radiant heating system piping should include a means of regulating ...
Part number 550-110-260/0107 23 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual 3 Syste m or zone circulato r 7 Syste m temperature valves (see inst ructions to the left for adjusting valv es) 8 Blend temperature gauge 9 Relief valve 10 A utomatic air vent (with diaphrag m-ty pe expan- sion tank), or connect t o tank fitting (closed-t ype ex pa ...
Part number 550-110-260/0107 24 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Ve nt in g an d co mb us ti on a ir 4 CG s Boi ler must be v ent ed and sup pli ed wit h co mbu s- tion and ventilation air as describ ed in W eil-M cLain CGs V enting Supplements pac ked i n envelop e a s- sembly with boiler . Failure to do so w ill cause severe per ...
Part number 550-110-260/0107 25 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Gas piping 5 T able 4 Pipe capacity for 0.60 specific gravity natural gas Natural Gas: 1. R efer to T able 4 for pipe length and diamet er . Base on ra ted b oile r inpu t (di vide b y 1,00 0 to obtai n cubi c feet per hour). T able 4 is o nly for gas with specific ...
Part number 550-110-260/0107 26 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Field wiring 6 Thermostat 1. Connect thermostat as sho w n on w iring diagr am on boiler . 2. Install on inside wall aw ay from influences of draf ts, hot or cold water pipes, lighting fixt ures, television, sunra ys, or fir eplaces. 3. If thermostat has a heat an ...
Part number 550-110-260/0107 27 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Start-up — pr eparation 7a Fill the system with water 1. Close manual and auto matic air vents and boiler drain cock. 2. Fill to correct system pressure . Co rrec t pr e ss ur e w i ll v a r y w i t h e ac h a pp li c at i o n. T y pi cal cold w ate r fill pr essu ...
Part number 550-110-260/0107 28 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Start-up — operate boiler 7b Inspect system water piping Aft er filling the boiler an d sy stem with wate r , inspec t all piping th roughout the system for leaks. I f found, repair immediately . R epeat this inspection after the boiler has been started and the sy ...
Part number 550-110-260/0107 29 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Start-up — operate boiler (continued) 7b Figure 16 T ypical pilot burner flame Figure 17 T ypical main burner flame Check bur ner flames V iew pilot and ma in fla mes through the i nspection port in the A ir inlet box front c ove r . Pilot burner flame ( Figur ...
Part number 550-110-260/0107 30 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Check-out pr ocedur e — checklist 8 ❏ Boiler and heat distribution units filled w ith water? ❏ A utomatic air v ent, if used, o pen one full turn? ❏ Air purged from sy stem? ❏ Air purged from gas piping? Piping c hecked for leaks? ❏ Correc ...
Part number 550-110-260/0107 31 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Operation — sequence 9a Figure 18 Control module sequence of operation — status light indications 1. Read appropr iat e Operating instructions i n Section 9c . This infor mation is also lo cated on a label on the inside of the boiler jack et door panel. 2. Raise ...
Part number 550-110-260/0107 32 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Operation — wiring diagrams 9b Figure 19 Schematic wiring diagram ...
Part number 550-110-260/0107 33 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Figure 20 Ladder wiring diagram ...
Part number 550-110-260/0107 34 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual 9c Operating instructions CGs-3 to CGs-6 • Spark pilot • Natural or propane gas • Gas valve: Hone ywell VR8204/VR8304 ...
Part number 550-110-260/0107 35 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Operating instructions CGs-3 to CGs-6 • Spark pilot • Natural or propane gas • Gas valve: White-Rodgers 36E 9c ...
Part number 550-110-260/0107 36 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual 9c Operating instructions CGs-3 to CGi-6 • Spark pilot • Natural or propane gas • Gas valve: White-Rodgers 36C ...
Part number 550-110-260/0107 37 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T able 5 Service and maintenance schedules Service and maintenance — schedule 10a Follo w the Service and maintenance procedur es given throughout this manual and in com- ponent literature shipped with the b oiler . Failure to p erform the ser vice and maintenance ...
Part number 550-110-260/0107 38 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Service & maintenance — annual start-up 10b Air openings 1. V erify that comb ustion and v entilati on air open ings to the b oiler room and/or building are open and unobstr ucted . 2. V erify that boiler vent discharge is clean and free of obstr uctions . Flue ...
Part number 550-110-260/0107 39 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual ❏ Inspect . . . Burners, base and inlet air box Th e b oil er co nta in s ce ra mi c fib er a nd fi be rg la ss materials. U se care when handling these mat erials per instr uctions on page 68 of this manual. Failur e to co mply could result in sev ere personal i ...
Part number 550-110-260/0107 40 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Service & maint. — annual start-up continued 10b ❏ Check/test . . . Gas piping 1. Sniff near floor and around boiler area for an y in- dication of a gas leak . 2. T est gas piping using bubble test, per Sect ion 5 of this manual, if there is any indication o ...
Part number 550-110-260/0107 41 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Safety relief val ves should be reinspected A T LEAST ONCE EVER Y THREE YEARS , by a licensed plumbing contra ctor or authori zed inspection ag ency , to ensur e that the pr oduct has not been affected b y corrosi ve water conditions and to ensure that the val ve and ...
Part number 550-110-260/0107 42 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Service & maint. — annual start-up 10b ❏ Review with owner 1. R ev iew the User’ s Information Manual w ith the owner . 2. Emphasize the need to perform the maintenance s c h e du l e s p e c i f i e d i n t h e User’ s Information Manual (and in this man ...
Part number 550-110-260/0107 43 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — pr ocedure 11a Label all wires prior t o disc onnection when servicing c ontro ls. W iring errors can cause impr oper and dangerous operation. Nev er ju mper (byp ass) rollout t hermal fuse elem ent or any other device ex cept for momentar y tes ...
Part number 550-110-260/0107 44 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — air pr essure switch 11b Air pr essure switch Mak e s ure boiler wat er t emperature is 100 °F or cooler b efore st artin g pr oc ed u re t o o b ta i n a p pro pr i a te readings. Check pressur e switch setting 1. See Figur e 24 and T able 6 . ...
Part number 550-110-260/0107 45 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — contr ol module 11c Contr ol module So lde r or wa te r spl att er betw een plu gs and cir cui t boa rd can c aus e impr ope r oper atio n of c ontr ol m odul e. Plac e a shield ove r the boiler internal control s and compone nts during installa ...
Part number 550-110-260/0107 46 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — contr ol module (continued) 11c Figure 25 Control module connections ...
Part number 550-110-260/0107 47 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — contr ol module lights 11d CHART 1 — Troubleshooting POWER light status Electrical shock haza rd — Wherever you see ▲ TURN OFF POWER ▲ , follow the instructions. Fai lu re to follow instructions could result in severe personal injury, de ...
Part number 550-110-260/0107 48 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — contr ol module lights 11d Electrical shock hazard — Wherever you see TURN OFF POWER , follow the instructions. Failure to follow instructions could result in severe personal injury, death or substantial property damage. CHART 2 — TSTAT CIRC ...
Part number 550-110-260/0107 49 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — contr ol module lights (cont.) 11d CHART 3 — PRESS SWITCH & POWER lights flashing Electrical shock hazard — Wherever you see s TURN OFF POWER s , follow the instructions. Failure to follow instructions could result in severe personal inj ...
Part number 550-110-260/0107 50 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual 11d T r oubleshooting — contr ol module lights (cont.) • Turn off power to the boiler at service switch or breaker. • Wait at least 45 seconds. • Turn on power to boiler. • Restart boiler, following Operating instr uctions in this manual (Section 9c ). • ...
Part number 550-110-260/0107 51 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — contr ol module lights (cont.) 11d • TURN OFF POWER to boiler at service switch or breaker. • Remove air inlet box cover (see Figure 27 , page 56 for lo cation). • Verify inlet gas pressure at gas valve: Natural gas — 5.0" w.c. min ...
Part number 550-110-260/0107 52 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual 11d T r oubleshooting — contr ol module lights (cont.) CHART 6 — PRESS SWITCH light flashing and POWER light on steady Electrical shock hazard — Wherever you see � TURN OFF POWER �, follow the instructions. Failure to follow instructions could result in sev ...
Part number 550-110-260/0107 53 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual T r oubleshooting — contr ol module lights (cont.) 11d CHART 7 — Insufficient heat or no heat to system ( POWER light on steady) Electrical shock hazard — Wherever you see TURN OFF POWER , follow the instructions. Failure to follow instructions could result in ...
Part number 550-110-260/0107 54 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Replacement parts 12a Section assembly .............................................. 55 Base .................................................................. 56 Jacket ............................................................... 58 T rim ....................... ...
Part number 550-110-260/0107 55 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Replacement parts — section assembly 12b Figure 26 Section assembly ...
Part number 550-110-260/0107 56 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Replacement parts — base 12c Figure 27 Base assembly ...
Part number 550-110-260/0107 57 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Replacement parts — base (continued) 12c Item Description Weil-McLain part number Base insulation kit (includes insul ation for all base parts above plus gasket material needed between bloc k assembly and base) CGs-3 CGs-4 CGs-5 CGs-6 381 -356-515 381 -356-516 381 ...
Part number 550-110-260/0107 58 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Replacement parts — jacket 12d Figure 28 Jacket assembly ...
Part number 550-110-260/0107 59 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Boiler Model 1 2 3 4 5 6 Boiler Model Junction box, 2 x 4 Panel, left side , with insulation Panel, right side , with insulation Panel, top fr ont , with insulation Panel, top r ear , with insulation Panel, door Natural Gas Propane Gas W eil-McLain part number CGs-3 ...
Part number 550-110-260/0107 60 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Replacement parts — trim 12e Figure 29 T rim assembly Item number Description Manufacturer Manufacturer ’ s part number Weil-McLain part num ber 1 Pressur e relief valve, ASME, 30 PSIG, ¾" male inlet Pressure r elief valve, ASME, 30 PSIG, ¾ " female i ...
Part number 550-110-260/0107 61 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Replacement parts — contr ols 12f Figure 30 Gas control assembly Item number Description Manufacturer Manufacturer ’ s part number Weil-McLain part number Natural gas components 1 Gas valve, ½" x ½", CGs-3 through CGs-6 Honeywell VR8204A20 0 1 51 1-04 ...
Part number 550-110-260/0107 62 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Dimensions 13a Figure 31 Dimensional drawing ...
Part number 550-110-260/0107 63 GOLD CGs Gas-Fired W ater Boiler — Boiler Manual Ratings T able 7 Boiler ratings DOE 13b (N ote 5) CGs boilers for r esidential radiant panel systems, con verted gravity heating system s or other low water tempera- ture applications should be installed w ith balancing valves and by pass piping equal to the supply a ...
64 Part Number 550-110-260/0107 GOLD CGs Gas-F ired W ater Boiler — Boiler Manual Handling ceramic fiber and fiber glass materials REMOV AL OF COMBUSTION CHAMBER LINING OR BASE P ANELS The combustion chamber li ning or base insulation pane ls in this prod- uct c ontain ce ramic fiber mat erials. C er a m i c f i b e rs c a n b e c onv e r te d ...
Weil-McLain 550-110-260/0107のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 550-110-260/0107の取扱説明書
- Weil-McLainの製品カード
- パンフレット
- またはWeil-McLain 550-110-260/0107の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Weil-McLain 550-110-260/0107の取扱説明書に含まれています。
取扱説明書と呼ばれる文書のグループは、Weil-McLain 550-110-260/0107の取り付け説明書、サービスマニュアル、簡易説明書、またはWeil-McLain 550-110-260/0107のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Weil-McLain 550-110-260/0107の製品を使用するにあたって最も人気のある説明書を閲覧できます。
Weil-McLain 550-110-260/0107デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがWeil-McLain 550-110-260/0107を使用するのを助ける技術的文書のことです。説明書は通常、全てのWeil-McLain 550-110-260/0107ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。
Weil-McLainの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。
1. Weil-McLain 550-110-260/0107の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははWeil-McLain 550-110-260/0107の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Weil-McLain 550-110-260/0107に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Weil-McLain 550-110-260/0107デバイスの基本機能を使うにあたってのヒント。 Weil-McLain 550-110-260/0107のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Weil-McLain 550-110-260/0107に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるWeil-McLain 550-110-260/0107のメーカー/サービスへの連絡先に関する情報。
Weil-McLain 550-110-260/0107についてご質問がありますか？
次のフォームを使用してください
見つけた説明書を読んでもWeil-McLain 550-110-260/0107の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWeil-McLain 550-110-260/0107で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。