日本語 dropdown-ico

Vulcan-Hart GR85Fの取扱説明書

24ページ 3.23 mb
ダウンロード

ページに移動 of 24

Summary
  • Vulcan-Hart GR85F - page 1

    A product of VULCAN-HART LOUISVILLE, KY 40201-0696 F25125 (Marc h 2003) - NOTICE - This Manual is prepared for the use o f trained Vu lcan Serv ice Te ch ni ci ans and should not be us ed by those not properly qua li fied. If you have attende d a Vulcan Se rvice School for this product, yo u m ay be qualified to pe rform all the proc edures describ ...

  • Vulcan-Hart GR85F - page 2

    GR SERIES GAS F RYERS F25125 (Marc h 2003) Page 2 of 24 TABLE OF CONTENTS G E N E R A L ................................................................................ 3 Introduction ............................................................................ 3 Single Floor Model or Battery Fryers .................................................. ...

  • Vulcan-Hart GR85F - page 3

    GR SERIES GAS F RYERS - GENERAL F25125 (March 2003) Page 3 of 24 GENERAL INTRODUCTIO N This Service Manual cover s spec ific s ervice inf orm ation related to the m odels lis ted on the front c over. SINGLE FLOOR M ODEL OR BA TTERY FRYERS Fryers with the Filter-Ready option installed, use the Mobile Filter. For service inf orm ation related to the ...

  • Vulcan-Hart GR85F - page 4

    GR SERIES GAS F RYERS - GENERAL F25125 (Marc h 2003) Page 4 of 24 KLEENSCREEN FILTERING SYSTEM The new Kleensc reen filtering s ystem has been integrated into the GR Series fryer battery . The f ilter is housed in a pull-out dr awer assem bly at the base of the f ryer. The filtering c om ponents in the drawer include a stainless steel f ilter tank ...

  • Vulcan-Hart GR85F - page 5

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (March 2003) Page 5 of 24 SPECIFICA TIONS Electrical • 120VAC supply for Filter-Ready fryers and Kleenscreen f ilter m odels only. The f ilter pum p motor draws approxim ately 5 amps. Gas Pressures Manifold (per fryer section) : • Natural - 4" W .C. • Propane - 10" W .C ...

  • Vulcan-Hart GR85F - page 6

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (Marc h 2003) Page 6 of 24 NON FILTER REA DY SHOWN 2. W hen replacing door , install sc rews and tighten top and bottom s crews enough to hold door in place. 3. Close door, chec k alignm ent and adj ust if necessar y . 4. Finish tightening sc rews to fully secure. CONTROL THERMO STA T ...

  • Vulcan-Hart GR85F - page 7

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (March 2003) Page 7 of 24 5. Remo ve the capillary tube retaining and packing nuts, fr om the bottom of fry tank. 6. Rem ove scr ews securing c apillary tube mounting c lips to the f ry tank heat tube then rem ove capillary tube. 7. Reverse proc edure to install. MAIN BURNERS WA RNING: ...

  • Vulcan-Hart GR85F - page 8

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (Marc h 2003) Page 8 of 24 NON FILTER REA DY SHOWN 4. Reverse proc edure to install. MAIN BURNER ORIFICE WA RNING: DISCONNECT T HE ELECTRICAL PO W ER TO THE MACHINE AND FOLLOW LOCKOUT / TAGO UT PRO CEDURES. WA RNING: SHUT O FF T HE GAS BEFO RE SERVICING TH E UNIT. 1. Rem ove main bur n ...

  • Vulcan-Hart GR85F - page 9

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (March 2003) Page 9 of 24 6. Reverse proc edure to install and c heck for proper operation. PILOT BURNER WA RNING: DISCONNECT T HE ELECTRICAL PO W ER TO THE MACHINE AND FOLLOW LOCKOUT / TAGO UT PRO CEDURES. WA RNING: SHUT O FF T HE GAS BEFO RE SERVICING TH E UNIT. WA RNING: ALL GAS JOI ...

  • Vulcan-Hart GR85F - page 10

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (Marc h 2003) Page 10 of 24 3. Reverse proc edure to install and c heck for proper operation. FRY TA NK ASSEMBLY WA RNING: DISCONNECT T HE ELECTRICAL PO W ER TO THE MACHINE AND FOLLOW LOCKOUT / TAGO UT PRO CEDURES. WA RNING: SHUT O FF T HE GAS BEFO RE SERVICING TH E UNIT. WA RNING: ALL ...

  • Vulcan-Hart GR85F - page 11

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (March 2003) Page 11 of 24 21. Reverse procedure to install all the parts removed from original fry tank onto replacement fry tank, then inst all the assembly. FILTER VA LVE A ND DI SCA RD VA LVE SWITCHES WA RNING: DISCONNECT T HE ELECTRICAL PO W ER TO THE MACHINE AND FOLLOW LOCKOUT / ...

  • Vulcan-Hart GR85F - page 12

    GR SERIES GAS FR YERS - SERVICE PROCEDURES AND ADJUST MENTS F25125 (Marc h 2003) Page 12 of 24 SERVICE PROCEDURES AND ADJUSTMENTS WA RNING: CERTAIN PROCED URES IN T HIS SECTION REQUIRE EL ECTRIC AL TEST OR MEASUREMENTS W HILE POW ER IS APPLIED T O THE MACHINE. EXERCISE EXTREME CAUTION AT ALL TIMES. IF TEST POINTS ARE NOT EASILY ACC ESSIBLE, DISCONN ...

  • Vulcan-Hart GR85F - page 13

    GR SERIES GAS FR YERS - SERVICE PROCEDURES AND ADJUST MENTS F25125 (March 2003) Page 13 of 24 NON FILTER REA DY SHOWN GA S M A NIFOLD PRESSURE AD J U S T M E N T WA RNING: SHUT OFF THE GAS SUPPLY BEFORE SERVICING THE UNIT. GAS PRESSURE (INCHES W.C.) GAS TYPE MANIFOLD LINE RECOMMENDED MIN M AX Natural 4 7 5 14 Propane 10 11 11 NOTE: If the incoming ...

  • Vulcan-Hart GR85F - page 14

    GR SERIES GAS FR YERS - SERVICE PROCEDURES AND ADJUST MENTS F25125 (Marc h 2003) Page 14 of 24 NON FILTER REA DY SHOWN A. I f adjustment is necessary, continue wit h procedure. 4. Remove the adjustment screw cap from the gas combination valve. A. To increase pilot flame, turn the screw counterclockwise . To decrease pilot flame, turn the screw cloc ...

  • Vulcan-Hart GR85F - page 15

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (March 2003) Page 15 of 24 ELECTRICAL OPERATION COMP ONENT FUNCTION FRYER CONTROLS C o n t r o l T h e r m o s t a t ........... Regulates shortening temperature at t he selected set point. Temperature range from off to 200 / F thru 400 / F. T h e r m o p i l e .................. W hen heated by ...

  • Vulcan-Hart GR85F - page 16

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (Marc h 2003) Page 16 of 24 GR35 NON FIL TER READY SHOW N GR45 FILTER READY SHOWN 2GR45F KLEENSCREEN FRYER BATTERY SHOWN COMP ONENT LOCA TI ON ...

  • Vulcan-Hart GR85F - page 17

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (March 2003) Page 17 of 24 SEQUENCE OF OPERA TION Millivolt Contr ols Refer to schematic diagram 7825. 1. Conditions. A. G as shutoff valve(s) on and gas combination valve k nob/extension arm in the on position. B. Short ening at proper level in fry tank and below last set point t emperature used ...

  • Vulcan-Hart GR85F - page 18

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (Marc h 2003) Page 18 of 24 SCHEMATIC DIA GRA M Milliv olt Controls ...

  • Vulcan-Hart GR85F - page 19

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (March 2003) Page 19 of 24 WIRING DI A GRA M S Millivolt Contr ols ...

  • Vulcan-Hart GR85F - page 20

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (Marc h 2003) Page 20 of 24 Junctio n Box, Kl eenscreen Fil tering System ...

  • Vulcan-Hart GR85F - page 21

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (March 2003) Page 21 of 24 Frymate (Dump Sta tion) ...

  • Vulcan-Hart GR85F - page 22

    GR SERIES GAS FR YERS - TROUBLESHO OT ING F25125 (Marc h 2003) Page 22 of 24 TROUBLESHOOTING A LL M ODELS SYMPTOMS POSSIBLE CA USES Pilot burner will not light. 1. Gas s upply off . 2. High limit ther m ostat open or m alf unction. 3. I ncorrect gas type. 4. Pilot burner flame adjustment too low. 5. Pilot burner orifice obstructed or i ncorrect . 6 ...

  • Vulcan-Hart GR85F - page 23

    GR SERIES GAS FR YERS - TROUBLESHO OT ING F25125 (March 2003) Page 23 of 24 FRYMATE (DUMP STA TION) WITH OPTIONAL HEA TER SYMPTOM POSSIBLE CA USES No heat. 1. Unplugged. 2. Power switch off or inoperative. 3. Main circuit break er of f or open. 4. Malfunctioning heat as sem bly. KLEENSCREEN FILTERING SYSTEM SYMPTOM POSSIBLE CA USES Oil not filterin ...

  • Vulcan-Hart GR85F - page 24

    GR SERIES GAS FR YERS - CONDENSED SPARE PARTS LIST F25125 (Marc h 2003) Printed in U.S.A. CONDENSED SPARE PARTS LIST KLEENSCREEN FILTER PART NUMBER DESCRIPTION NOTES 411496-B4 Lighted Rocker Switch, Filt er 417792-1 Pump and Motor Assy , Filter (120VAC) GR SERIES GA S FRYERS WI TH M ILLI VOLT CONTROL PART NUMBER DESCRIPTION NOTES 419999-2 Therm ost ...

メーカー Vulcan-Hart カテゴリー Fryer

Vulcan-Hart GR85Fのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- GR85Fの取扱説明書
- Vulcan-Hartの製品カード
- パンフレット
- またはVulcan-Hart GR85Fの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Vulcan-Hart GR85Fの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Vulcan-Hart GR85Fの取り付け説明書、サービスマニュアル、簡易説明書、またはVulcan-Hart GR85Fのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Vulcan-Hart GR85Fの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Vulcan-Hart GR85Fデバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがVulcan-Hart GR85Fを使用するのを助ける技術的文書のことです。説明書は通常、全てのVulcan-Hart GR85Fユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Vulcan-Hartの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Vulcan-Hart GR85Fの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははVulcan-Hart GR85Fの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Vulcan-Hart GR85Fに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Vulcan-Hart GR85Fデバイスの基本機能を使うにあたってのヒント。 Vulcan-Hart GR85Fのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Vulcan-Hart GR85Fに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるVulcan-Hart GR85Fのメーカー/サービスへの連絡先に関する情報。

Vulcan-Hart GR85Fについてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもVulcan-Hart GR85Fの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがVulcan-Hart GR85Fで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)