English dropdown-ico

Manual Vulcan-Hart GR85F

24 pages 3.23 mb
Download

Go to site of 24

Summary
  • Vulcan-Hart GR85F - page 1

    A product of VULCAN-HART LOUISVILLE, KY 40201-0696 F25125 (Marc h 2003) - NOTICE - This Manual is prepared for the use o f trained Vu lcan Serv ice Te ch ni ci ans and should not be us ed by those not properly qua li fied. If you have attende d a Vulcan Se rvice School for this product, yo u m ay be qualified to pe rform all the proc edures describ ...

  • Vulcan-Hart GR85F - page 2

    GR SERIES GAS F RYERS F25125 (Marc h 2003) Page 2 of 24 TABLE OF CONTENTS G E N E R A L ................................................................................ 3 Introduction ............................................................................ 3 Single Floor Model or Battery Fryers .................................................. ...

  • Vulcan-Hart GR85F - page 3

    GR SERIES GAS F RYERS - GENERAL F25125 (March 2003) Page 3 of 24 GENERAL INTRODUCTIO N This Service Manual cover s spec ific s ervice inf orm ation related to the m odels lis ted on the front c over. SINGLE FLOOR M ODEL OR BA TTERY FRYERS Fryers with the Filter-Ready option installed, use the Mobile Filter. For service inf orm ation related to the ...

  • Vulcan-Hart GR85F - page 4

    GR SERIES GAS F RYERS - GENERAL F25125 (Marc h 2003) Page 4 of 24 KLEENSCREEN FILTERING SYSTEM The new Kleensc reen filtering s ystem has been integrated into the GR Series fryer battery . The f ilter is housed in a pull-out dr awer assem bly at the base of the f ryer. The filtering c om ponents in the drawer include a stainless steel f ilter tank ...

  • Vulcan-Hart GR85F - page 5

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (March 2003) Page 5 of 24 SPECIFICA TIONS Electrical • 120VAC supply for Filter-Ready fryers and Kleenscreen f ilter m odels only. The f ilter pum p motor draws approxim ately 5 amps. Gas Pressures Manifold (per fryer section) : • Natural - 4" W .C. • Propane - 10" W .C ...

  • Vulcan-Hart GR85F - page 6

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (Marc h 2003) Page 6 of 24 NON FILTER REA DY SHOWN 2. W hen replacing door , install sc rews and tighten top and bottom s crews enough to hold door in place. 3. Close door, chec k alignm ent and adj ust if necessar y . 4. Finish tightening sc rews to fully secure. CONTROL THERMO STA T ...

  • Vulcan-Hart GR85F - page 7

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (March 2003) Page 7 of 24 5. Remo ve the capillary tube retaining and packing nuts, fr om the bottom of fry tank. 6. Rem ove scr ews securing c apillary tube mounting c lips to the f ry tank heat tube then rem ove capillary tube. 7. Reverse proc edure to install. MAIN BURNERS WA RNING: ...

  • Vulcan-Hart GR85F - page 8

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (Marc h 2003) Page 8 of 24 NON FILTER REA DY SHOWN 4. Reverse proc edure to install. MAIN BURNER ORIFICE WA RNING: DISCONNECT T HE ELECTRICAL PO W ER TO THE MACHINE AND FOLLOW LOCKOUT / TAGO UT PRO CEDURES. WA RNING: SHUT O FF T HE GAS BEFO RE SERVICING TH E UNIT. 1. Rem ove main bur n ...

  • Vulcan-Hart GR85F - page 9

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (March 2003) Page 9 of 24 6. Reverse proc edure to install and c heck for proper operation. PILOT BURNER WA RNING: DISCONNECT T HE ELECTRICAL PO W ER TO THE MACHINE AND FOLLOW LOCKOUT / TAGO UT PRO CEDURES. WA RNING: SHUT O FF T HE GAS BEFO RE SERVICING TH E UNIT. WA RNING: ALL GAS JOI ...

  • Vulcan-Hart GR85F - page 10

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (Marc h 2003) Page 10 of 24 3. Reverse proc edure to install and c heck for proper operation. FRY TA NK ASSEMBLY WA RNING: DISCONNECT T HE ELECTRICAL PO W ER TO THE MACHINE AND FOLLOW LOCKOUT / TAGO UT PRO CEDURES. WA RNING: SHUT O FF T HE GAS BEFO RE SERVICING TH E UNIT. WA RNING: ALL ...

  • Vulcan-Hart GR85F - page 11

    GR SERIES GAS FR YERS - REMOVAL AND REPLACEMENT OF PARTS F25125 (March 2003) Page 11 of 24 21. Reverse procedure to install all the parts removed from original fry tank onto replacement fry tank, then inst all the assembly. FILTER VA LVE A ND DI SCA RD VA LVE SWITCHES WA RNING: DISCONNECT T HE ELECTRICAL PO W ER TO THE MACHINE AND FOLLOW LOCKOUT / ...

  • Vulcan-Hart GR85F - page 12

    GR SERIES GAS FR YERS - SERVICE PROCEDURES AND ADJUST MENTS F25125 (Marc h 2003) Page 12 of 24 SERVICE PROCEDURES AND ADJUSTMENTS WA RNING: CERTAIN PROCED URES IN T HIS SECTION REQUIRE EL ECTRIC AL TEST OR MEASUREMENTS W HILE POW ER IS APPLIED T O THE MACHINE. EXERCISE EXTREME CAUTION AT ALL TIMES. IF TEST POINTS ARE NOT EASILY ACC ESSIBLE, DISCONN ...

  • Vulcan-Hart GR85F - page 13

    GR SERIES GAS FR YERS - SERVICE PROCEDURES AND ADJUST MENTS F25125 (March 2003) Page 13 of 24 NON FILTER REA DY SHOWN GA S M A NIFOLD PRESSURE AD J U S T M E N T WA RNING: SHUT OFF THE GAS SUPPLY BEFORE SERVICING THE UNIT. GAS PRESSURE (INCHES W.C.) GAS TYPE MANIFOLD LINE RECOMMENDED MIN M AX Natural 4 7 5 14 Propane 10 11 11 NOTE: If the incoming ...

  • Vulcan-Hart GR85F - page 14

    GR SERIES GAS FR YERS - SERVICE PROCEDURES AND ADJUST MENTS F25125 (Marc h 2003) Page 14 of 24 NON FILTER REA DY SHOWN A. I f adjustment is necessary, continue wit h procedure. 4. Remove the adjustment screw cap from the gas combination valve. A. To increase pilot flame, turn the screw counterclockwise . To decrease pilot flame, turn the screw cloc ...

  • Vulcan-Hart GR85F - page 15

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (March 2003) Page 15 of 24 ELECTRICAL OPERATION COMP ONENT FUNCTION FRYER CONTROLS C o n t r o l T h e r m o s t a t ........... Regulates shortening temperature at t he selected set point. Temperature range from off to 200 / F thru 400 / F. T h e r m o p i l e .................. W hen heated by ...

  • Vulcan-Hart GR85F - page 16

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (Marc h 2003) Page 16 of 24 GR35 NON FIL TER READY SHOW N GR45 FILTER READY SHOWN 2GR45F KLEENSCREEN FRYER BATTERY SHOWN COMP ONENT LOCA TI ON ...

  • Vulcan-Hart GR85F - page 17

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (March 2003) Page 17 of 24 SEQUENCE OF OPERA TION Millivolt Contr ols Refer to schematic diagram 7825. 1. Conditions. A. G as shutoff valve(s) on and gas combination valve k nob/extension arm in the on position. B. Short ening at proper level in fry tank and below last set point t emperature used ...

  • Vulcan-Hart GR85F - page 18

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (Marc h 2003) Page 18 of 24 SCHEMATIC DIA GRA M Milliv olt Controls ...

  • Vulcan-Hart GR85F - page 19

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (March 2003) Page 19 of 24 WIRING DI A GRA M S Millivolt Contr ols ...

  • Vulcan-Hart GR85F - page 20

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (Marc h 2003) Page 20 of 24 Junctio n Box, Kl eenscreen Fil tering System ...

  • Vulcan-Hart GR85F - page 21

    GR SERIES GAS FR YERS - ELECTRICAL OPERAT ION F25125 (March 2003) Page 21 of 24 Frymate (Dump Sta tion) ...

  • Vulcan-Hart GR85F - page 22

    GR SERIES GAS FR YERS - TROUBLESHO OT ING F25125 (Marc h 2003) Page 22 of 24 TROUBLESHOOTING A LL M ODELS SYMPTOMS POSSIBLE CA USES Pilot burner will not light. 1. Gas s upply off . 2. High limit ther m ostat open or m alf unction. 3. I ncorrect gas type. 4. Pilot burner flame adjustment too low. 5. Pilot burner orifice obstructed or i ncorrect . 6 ...

  • Vulcan-Hart GR85F - page 23

    GR SERIES GAS FR YERS - TROUBLESHO OT ING F25125 (March 2003) Page 23 of 24 FRYMATE (DUMP STA TION) WITH OPTIONAL HEA TER SYMPTOM POSSIBLE CA USES No heat. 1. Unplugged. 2. Power switch off or inoperative. 3. Main circuit break er of f or open. 4. Malfunctioning heat as sem bly. KLEENSCREEN FILTERING SYSTEM SYMPTOM POSSIBLE CA USES Oil not filterin ...

  • Vulcan-Hart GR85F - page 24

    GR SERIES GAS FR YERS - CONDENSED SPARE PARTS LIST F25125 (Marc h 2003) Printed in U.S.A. CONDENSED SPARE PARTS LIST KLEENSCREEN FILTER PART NUMBER DESCRIPTION NOTES 411496-B4 Lighted Rocker Switch, Filt er 417792-1 Pump and Motor Assy , Filter (120VAC) GR SERIES GA S FRYERS WI TH M ILLI VOLT CONTROL PART NUMBER DESCRIPTION NOTES 419999-2 Therm ost ...

Manufacturer Vulcan-Hart Category Fryer

Documents that we receive from a manufacturer of a Vulcan-Hart GR85F can be divided into several groups. They are, among others:
- Vulcan-Hart technical drawings
- GR85F manuals
- Vulcan-Hart product data sheets
- information booklets
- or energy labels Vulcan-Hart GR85F
All of them are important, but the most important information from the point of view of use of the device are in the user manual Vulcan-Hart GR85F.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Vulcan-Hart GR85F, service manual, brief instructions and user manuals Vulcan-Hart GR85F. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Vulcan-Hart GR85F.

Similar manuals

A complete manual for the device Vulcan-Hart GR85F, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Vulcan-Hart GR85F by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Vulcan-Hart GR85F.

A complete Vulcan-Hart manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Vulcan-Hart GR85F - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Vulcan-Hart GR85F, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Vulcan-Hart GR85F, that we can find in the current document
3. Tips how to use the basic functions of the device Vulcan-Hart GR85F - which should help us in our first steps of using Vulcan-Hart GR85F
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Vulcan-Hart GR85F
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Vulcan-Hart GR85F in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Vulcan-Hart GR85F?

Use the form below

If you did not solve your problem by using a manual Vulcan-Hart GR85F, ask a question using the form below. If a user had a similar problem with Vulcan-Hart GR85F it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)