Ice-O-Matic CD300の取扱説明書

21ページ 1.48 mb
ダウンロード

ページに移動 of 21

Summary
  • Ice-O-Matic CD300 - page 1

    Service/Installation Manual Hotel Dispenser Model - CD300 Mile High Equipment 1 1 100 East 45th A ve Denver , Colorado 80239 Part Number 9081292-01 Print Date 04/02 ...

  • Ice-O-Matic CD300 - page 2

    Introduction CD300 Page 1 To the ow ner or user: This product manu al is a s ource of inform ation about th e installation, start up, clea ning, maint enance an d repair of the product. Table of Contents Introduction Page 1 Specificati on/Limitati ons Page 2 Diag rams Page 3 Uncrating Page 4 Ice Machine I nstallation Page 5 Utility Connections Page ...

  • Ice-O-Matic CD300 - page 3

    Specificatio ns CD300 Page 2 Specificati ons and Limitations This dispenser is designed to dispense cubed ice only and to be installed and operated indoors, in a controlled enviroment. Its minimum and maximum operating temperature limits are the same as those for the ice machine. Limitations: l Must meet the sa me limitations as the cuber installed ...

  • Ice-O-Matic CD300 - page 4

    Diagrams CD300 Page 3 ...

  • Ice-O-Matic CD300 - page 5

    Uncratin g CD300 Page 4 Remove th e carton from the skid. C ut the plastic stra ps that secure the leg kit to the ski d and rem o ve t he bo x. Use the di spenser carton as a cushion and l ay the dispens er down on it s back. Re move the bolts holding th e skid to the mac hine, and separ ate the skid f rom the di spenser. Install t he dispens er le ...

  • Ice-O-Matic CD300 - page 6

    Ice Mach ine Install atio n CD300 Page 5 All models: P lace the dispenser in the location where it will be used. Level the top edge of the dispenser front to back an d left to right w ith the adjusta ble legs. Place the i ce machi ne on the dis penser and sec ure it to the dispenser w ith the hardwar e and straps. Install it according t o the instr ...

  • Ice-O-Matic CD300 - page 7

    Util ity C onnections C D300 Page 6 Drain Connections -Follow all appli cable codes. As ice mel ts in the dispenser , the water must be drain ed away. It i s critical that a pr oper drain b e connected to the dispenser. Remember that this i s a grav it y drai n system, the drai n tubing must slope dow n a minimum of ¼ inch per foot of horiz ontal ...

  • Ice-O-Matic CD300 - page 8

    Init ial Start U p and U se CD300 Page 7 Final Check List 1. Is the ice machine properl y installed? 2. Is the disp enser level? 3. Has the w ater supply been co nnected to the i ce machine? 4. Has the pr oper pow er been conn ected to the i ce mac hine and disp enser? Note: When electrical power is supplied to the dispenser the rot or will rotate ...

  • Ice-O-Matic CD300 - page 9

    Sanitatio n / Maintena nce CD300 Page 8 Schedule An ice sy stem repres ents a sizable i nvestment of ti me and money in any compa ny’s busi ness. In order to receiv e the best retur n on that i nvestment, peri odic maintenance is required. I t is the user responsibility to see t hat the machine is properly m aintained . Maintenance and cleaning s ...

  • Ice-O-Matic CD300 - page 10

    Component Identificati on CD300 Page 9 View w hen sink assembly i s removed. Rotor as seen fr om the top. Inside v iew of ice chute. Rot or shaft. ...

  • Ice-O-Matic CD300 - page 11

    Main tenance CD300 Page 10 Regular inspection and m aintenanc e will provi de the bes t assurance o f trouble f ree operation . Begin by removing the si nk assembly . Check the a ction of the ice chute a nd return spr ings. Retu rn Sprin gs Check and T ighten Fast eners Clean out t he lower drai n pan. Pour h ot water into the drain to be sure that ...

  • Ice-O-Matic CD300 - page 12

    Service Diagnosis CD 300 Page 11 Symptom Probable Cause Possible Corre ction Does not disp ense. No power to dispenser. Check for power . Ice chute not all the w ay up. Push ice chu te up. No ice in hopper. Check ice mac hine, it may be off or the dispenser’s storage cap acity may hav e been ex ceeded. Dispenser ON- Off switch is OFF. Mov e switc ...

  • Ice-O-Matic CD300 - page 13

    Ad justments CD300 Page 12 The gear motor cam mu st be properly adj ust ed to properly position the dispensing rotor. 1. Disconnect el ectrical power to the di spenser. 2. Locate t he sink key , unlock sink and r emov e it from the dispenser . 3. Observe the position of th e rotor throug h the cube chute. The rotor and cam sw itch must be in the po ...

  • Ice-O-Matic CD300 - page 14

    Removal and Replacement CD300 Page 13 Rotor 1. Disconnect el ectrical power to the di spenser and i ce machine. 2. At the back, r emov e two bolts s ecuring the ice mac hine to the dis penser. If a bin thermostat i s being used, p ull the ther m ostat capillary tube up and out of the ho pper. 3. Push the ice machine ba ck 51/2 inched from its origi ...

  • Ice-O-Matic CD300 - page 15

    Wirin g Diagra m CD300 Page 14 Button Dispensing Model CD300P ...

  • Ice-O-Matic CD300 - page 16

    Schematic Diagram CD300 Page 15 Button Dispensing Model CD300P ...

  • Ice-O-Matic CD300 - page 17

    Wirin g Diagra m CD300 Page 16 Coin Mechanism CD300C ...

  • Ice-O-Matic CD300 - page 18

    Schematic Diagram CD300 Page 17 Coin Mechanism CD300C CD300C ...

  • Ice-O-Matic CD300 - page 19

    Wirin g Diagra m CD300 Page 18 Key Card CD300K ...

  • Ice-O-Matic CD300 - page 20

    Schematic Diagram CD300 Page 19 Key Card CD300C CD300K ...

  • Ice-O-Matic CD300 - page 21

    Befo re Callin g Fo r Service CD300 Page 20 Check thes e things. 1. Is the disp enser plugged i n? 2. Has the dispe nser’s internal sw itch been switched to the ON position? 3. Is the ice machine plug ged in? 4. Has the ice machine’s int ernal sw itch been switched to the ON position? 5. Is there ic e in the dispenser ? 6. Is the ice ch ute all ...

メーカー Ice-O-Matic カテゴリー Beverage Dispenser

Ice-O-Matic CD300のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- CD300の取扱説明書
- Ice-O-Maticの製品カード
- パンフレット
- またはIce-O-Matic CD300の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Ice-O-Matic CD300の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Ice-O-Matic CD300の取り付け説明書、サービスマニュアル、簡易説明書、またはIce-O-Matic CD300のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Ice-O-Matic CD300の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Ice-O-Matic CD300デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがIce-O-Matic CD300を使用するのを助ける技術的文書のことです。説明書は通常、全てのIce-O-Matic CD300ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Ice-O-Maticの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Ice-O-Matic CD300の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははIce-O-Matic CD300の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Ice-O-Matic CD300に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Ice-O-Matic CD300デバイスの基本機能を使うにあたってのヒント。 Ice-O-Matic CD300のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Ice-O-Matic CD300に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるIce-O-Matic CD300のメーカー/サービスへの連絡先に関する情報。

Ice-O-Matic CD300についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもIce-O-Matic CD300の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがIce-O-Matic CD300で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)