English dropdown-ico

Manual Lopi Answer Wood Stove

44 pages 0.67 mb
Download

Go to site of 44

Summary
  • Lopi Answer Wood Stove - page 1

    TM A n s w e r Wood Stove Owner's Manual • Freestanding Stove • Mobile-Home Approved • Alcove Approved • Hearth-Stove Approved • Masonry Fireplace Insert • Zero-Clearance (Metal) Fireplace Insert S A FE TY N OTIC E : If thi s appl i anc e i s not properl y i ns t al l ed, a hous e fi re ma y result. F or your safety, foll ow the in ...

  • Lopi Answer Wood Stove - page 2

    2 Introduction Travis Industries 93508131 4 020327 Introduction We welcome you as a new owner of a Lopi Answer wood-burning stove. In purchasing a Lopi Answer you have joined the growing ranks of concerned individuals whose selection of an energy system reflects both a concern for the environment and aesthetics. The Lopi Answer is one of the finest ...

  • Lopi Answer Wood Stove - page 3

    Table of Contents 3 Travis Industries 93508131 4 020327 General Information Introduction & Important Information ......................2 Safety Precautions .............................................4 Features & Specifications ....................................6 Stove Installation Planning The Installation .............................. ...

  • Lopi Answer Wood Stove - page 4

    4 Safety Precautions Travis Industries 93508131 4 020327 • The viewing door must be closed and latched during operation. • Never block free airflow through the air vents on this appliance. Gas • Gasoline or other flammable liquids must never be used to start the fire or "Freshen Up" the fire. Do not store or use gasoline or other fl ...

  • Lopi Answer Wood Stove - page 5

    Safety Precautions 5 Travis Industries 93508131 4 020327 Mobile Home • When installed in a mobile home, this appliance must be bolted to the floor, have outside air, and not be installed in the bedroom (Per H.U.D. requirements). Check with local building officials. • Do not place clothing or other flammable items on or near this appliance. • ...

  • Lopi Answer Wood Stove - page 6

    6 Features & Specifications Travis Industries 93508131 4 020327 Installation Options: • Freestanding • Freestanding in an Alcove • Freestanding in a Mobile Home • Masonry Fireplace Insert • Factory-Built (Z.C.) Fireplace Insert Features: • EPA Phase II Approved • 1 .6 Cubic Foot Firebox Volume • Single Operating Control • Acce ...

  • Lopi Answer Wood Stove - page 7

    Stove Installation (for qualified installers only) 7 Travis Industries 93508131 4 020327 S AFE TY NOTICE : P lease r ead t h is ent ir e m anu al b ef o r e you in st all and u se yo u r new r o o m h ea t e r . F ailu r e t o f o llo w in s t r u c t io n s m a y r es u lt in p r o p e r t y dam age, b o d ily injur y, or even d eat h . Con t act ...

  • Lopi Answer Wood Stove - page 8

    8 Stove Installation (for qualified installers only) Travis Industries 93508131 4 020327 Floor Protection Requirements • Stove must be placed on the Travis Industries legs or Pedestal. • Must be non-combustible and at least .018" thick (26 gauge) Minimum 35-5/8 ” Minimum 38-1/4 ” Min. 16 ” Min. 6 ” Min. 6 ” Floor protection must ...

  • Lopi Answer Wood Stove - page 9

    Stove Installation (for qualified installers only) 9 Travis Industries 93508131 4 020327 Stove Placement Requirements Clearances may be reduced by methods specified in NFPA 211, listed wall shields, pipe shields, or other means approved by local building or fire officials. • Stove must be placed so that no combustibles are within, or can swing wi ...

  • Lopi Answer Wood Stove - page 10

    10 Stove Installation (for qualified installers only) Travis Industries 93508131 4 020327 Chimney Requirements • DO NOT CONNECT THIS UNIT TO A CHIMNEY FLUE SERVING ANOTHER APPLIANCE. • Chimney connector must be a minimum 24 MSG black or 26 MSG blued steel (6" diameter). Chimney must be used from the first floor or wall penetration to the c ...

  • Lopi Answer Wood Stove - page 11

    Stove Installation (for qualified installers only) 11 Travis Industries 93508131 4 020327 Chimney Termination Requirements • Must have an approved cap (to prevent water from entering) • Must not be located where it will become plugged by snow or other material • Must terminate at least 3' above the roof and at least 2' above any por ...

  • Lopi Answer Wood Stove - page 12

    12 Stove Installation (for qualified installers only) Travis Industries 93508131 4 020327 Alcove Installation Requirements Whenever the stove is placed in a location where the ceiling height is less than 7' tall, it is considered an alcove installation. Because of the reduced height, the special installation requirements listed below must be m ...

  • Lopi Answer Wood Stove - page 13

    Stove Installation (for qualified installers only) 13 Travis Industries 93508131 4 020327 Mobile Home Requirements • Outside air must be installed - see "Outside Air Requirements" on page Error! Reference source not found. 11 • Chimney connector and chimney must be one of the following types: • DURAVENT model DVL with DURATEC chimne ...

  • Lopi Answer Wood Stove - page 14

    14 Stove Installation (for qualified installers only) Travis Industries 93508131 4 020327 Standard Ceiling with a Factory Built Chimney Chimney Cap (See the section "Chimney Termination Requirements" for more details) Chimney Sections Minimum Air Space to Combustibles (See Chimney Manufacturer's Instructions - usually 2") Chimne ...

  • Lopi Answer Wood Stove - page 15

    Stove Installation (for qualified installers only) 15 Travis Industries 93508131 4 020327 Exterior Factory Built Chimney NOTE: Exterior chimneys are subject to greater moisture and creosote accumulation due to the lower temperatures. An insulated chase will reduce these accumulations (the proper clearances to the chimney must be maintained). Chimne ...

  • Lopi Answer Wood Stove - page 16

    16 Stove Installation (for qualified installers only) Travis Industries 93508131 4 020327 Hearth Stove Direct Connection NOTE: Direct connections require installation of an airtight, non- combustible block-off plate or damper adapter. Block-off plate or damper adapter Remove damper or wire it open Airtight Insulated Clean-Out Stainless steel chimne ...

  • Lopi Answer Wood Stove - page 17

    Insert Installation (for qualified installers only) 17 Travis Industries 93508131 4 020327 S AFE TY NOTICE : P lease r ead t h is ent ir e m anu al b ef o r e you in st all and u se yo u r new r o o m h ea t e r . F ailu r e t o f o llo w in s t r u c t io n s m a y r es u lt in p r o p e r t y dam age, b o d ily injur y, or even d eat h . Con t ac ...

  • Lopi Answer Wood Stove - page 18

    18 Insert Installati on (for qualified installers only) Travis Industries 93508131 4 020327 Insert Size Requirements (see Illustration below) a c e f Masonry Fireplace Z.C. (Metal) Fireplace Minimum Fireplace Size a b c d e f g h i j Height (front) Height (rear) Width (front) Width (rear) Depth Hearth Depth* Hearth Width Facing Width Facing Height ...

  • Lopi Answer Wood Stove - page 19

    Insert Installation (for qualified installers only) 19 Travis Industries 93508131 4 020327 Masonry Fireplace Requirements • Chimney must have a clay tile liner or a stainless steel liner (positive connection) • Entire fireplace, including chimney, must be clean and undamaged. Any damage must be repaired prior to installation of the insert • C ...

  • Lopi Answer Wood Stove - page 20

    20 Insert Installati on (for qualified installers only) Travis Industries 93508131 4 020327 Block-Off Plate Installation Whenever this appliance is installed with a direct connection a block-off plate, or other non- combustible seal-off device (e.g. damper adapter), will need to be installed. This device is used to seal the chimney, insuring no smo ...

  • Lopi Answer Wood Stove - page 21

    Insert Installation (for qualified installers only) 21 Travis Industries 93508131 4 020327 Insert with Positive Connection NOTE: Most factory-built chimney manufacturers make stainless steel chimney liners, either flexible or rigid. This provides a wide variety of installation options. Make sure to follow the manufacturer's instructions for in ...

  • Lopi Answer Wood Stove - page 22

    22 Insert Installati on (for qualified installers only) Travis Industries 93508131 4 020327 Insert with Direct Connection (Z.C. Fireplace) NOTE: Direct connections require installation of an airtight block-off plate or damper adapter (see "Block-off Plate Installation" on page 20). Block-off plate or damper adapter Stainless steel chimney ...

  • Lopi Answer Wood Stove - page 23

    Operating Your Appliance 23 Travis Industries 93508131 4 020327 Safety Notice: If this appliance is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation inspection requirements in your area. Read and follow all of the warnin ...

  • Lopi Answer Wood Stove - page 24

    24 Operating Your Appliance Travis Industries 93508131 4 020327 Starting a Fire Since the dawn of time man has debated the best way to start a fire. Some use the boy-scout "tee- pee", some prefer the "tic-tac-toe" stack. Either way, review the hints and warnings below to ensure proper fire starting. • Make sure the air control ...

  • Lopi Answer Wood Stove - page 25

    Operating Your Appliance 25 Travis Industries 93508131 4 020327 Adjusting the Burn Rate Use the air control slider to control the burn rate of the stove. See the illustration below for details. Low Burn (air control closed) High Burn (air control open) Use the air control to change the burn rate. Approximate Air Control Settings: Overnight Burn ... ...

  • Lopi Answer Wood Stove - page 26

    26 Operating Your Appliance Travis Industries 93508131 4 020327 Optional Blower Operation The blower will turn on once the stove is up to temperature. This is typically 15 to 30 minutes after starting the fire. Follow the directions below to alter the blower speed. OFF Turn the dial all the way counter- clockwise until it clicks off. BLOWER CONTROL ...

  • Lopi Answer Wood Stove - page 27

    Operating Your Appliance 27 Travis Industries 93508131 4 020327 Hints for Burning • Get the appliance hot before adjusting to low burn • Use smaller pieces of wood during start-up and high burns to increase temperature • Use larger pieces of wood for overnight or sustained burns • Stack the wood tightly together to establish a longer burn ? ...

  • Lopi Answer Wood Stove - page 28

    28 Operating Your Appliance Travis Industries 93508131 4 020327 Troubleshooting Problem Possible Cause Smoke Enters Room During Start-Up • Cold Air Blockage - burn a piece of newspaper to establish a draft. • Close the doors - if the flame is not getting enough air, first make sure the air control is open (all the way in). If additional air is ...

  • Lopi Answer Wood Stove - page 29

    Maintaining Your Appliance 29 Travis Industries 93508131 4 020327 Failure to properly maintain and inspect your appliance may reduce the performance and life of the appliance, void your warranty, and create a fire hazard. Daily Maintenance (while stove is in use) Remove Ash (if necessary) Ash removal is not required once it builds up. 1/2" to ...

  • Lopi Answer Wood Stove - page 30

    30 Maintaining Your Applia nce Travis Industries 93508131 4 020327 Monthly Maintenance (while appliance is in use) Make sure the appliance has fully cooled prior to conducting service. Door and Glass Inspection The door must form an air-tight seal to the firebox for the stove to work correctly. Inspect the door gasket to make sure it forms an air-t ...

  • Lopi Answer Wood Stove - page 31

    Maintaining Your Appliance 31 Travis Industries 93508131 4 020327 Yearly Maintenance Make sure the appliance has fully cooled prior to conducting service. Touch Up Paint Included with the owner's pack of this appliance is a can of Stove-Brite ® paint. To touch up nicks or dulled paint, apply the paint while the appliance is cool. Sand rusted ...

  • Lopi Answer Wood Stove - page 32

    32 Maintaining Your Applia nce Travis Industries 93508131 4 020327 Door Parts 9/16" Wrench 5/16" Nutdriver 5 10 8 9 12 7 6 3 4 1 2 11 NOTE : Attach the glass gasket to the perimeter of the glass. NOTE : Attach the door gasket to the door retainer. ID # Description Qty Part # ID # Description Qty Part # 1 Door Shell - Brass Door Shell - Bl ...

  • Lopi Answer Wood Stove - page 33

    Maintaining Your Appliance 33 Travis Industries 93508131 4 020327 Firebox Parts 3 2 1 4 5 6 7 5 5 5 5 5 5 5 5 5 ID # Description Qty Part # ID # Description Qty Part # 1 Baffle Support "S" Bar 1 99900294 2 Air Tube with Sleeve 3 98900232 3 Air Tube Push Pins 6 98900353 4 Air Tube Retainer Sleeve 3 98900356 5 Brick - 9" x 4.5" un ...

  • Lopi Answer Wood Stove - page 34

    34 Maintaining Your Applia nce Travis Industries 93508131 4 020327 Air Tube Removal & Replacement All three air tubes are identical. a b Remove the left pin on the air tube collar (it may be a roll pin or push pin). Air Tube Collar Air Tube Push Pin Slide the air tube to the left, swing it down and remove from the firebox. Roll Pin Baffle Remov ...

  • Lopi Answer Wood Stove - page 35

    Warranty 35 Travis Industries 93508131 4 020327 To register your TRAVIS INDUSTRIES, INC. 7 Year Warranty, complete the enclosed warranty card and mail it within ten (10) days of the appliance purchase date to: TRAVIS INDUSTRIES, INC., 10850 117th Place N.E., Kirkland, Washington 98033. TRAVIS INDUSTRIES, INC. warrants this appliance (appliance is d ...

  • Lopi Answer Wood Stove - page 36

    36 Listing Label Travis Industries 93508131 4 020327 CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT INSTALLATION AND RESTRICTIONS IN YOUR AREA. ROOM HEATER SOLID FUEL TYPE APPLIANCE ALSO FOR USE IN MOBILE HOMES SUITABLE FOR USE IN FACTORY-BUILT (Z.C.) FIREPLACES AND MASONRY FIREPLACES. PREVENT HOUSE FIRES - Install and use only in accordance with t ...

  • Lopi Answer Wood Stove - page 37

    Optional Equipment 37 Travis Industries 93508131 4 020327 Stove Leg Installation (Brass # 99200500, Cast Black # 99200800, Black Steel # 99200100) Raise the stove 8" (use lumber). Attach each leg following the instructions below. Attach each leg to the stove by inserting a bolt and washer through the hole or slot in the leg and into the thread ...

  • Lopi Answer Wood Stove - page 38

    38 Optional Equipment Travis Industries 93508131 4 020327 2. Lift the stove and place a piece of wood along one side to keep it elevated. Use a screwdriver to pry out the forward knock-out underneath the stove (it is 4" wide and 2" deep). 3. Attach the stove to the pedestal with the included bolts. Tuck the included insulation underneath ...

  • Lopi Answer Wood Stove - page 39

    Optional Equipment 39 Travis Industries 93508131 4 020327 Rear Blower Installation (Part number 99000138) The rear blower improves heat transfer by pushing heated air through the convection channel. Operating instructions are described in the section "Blower Operation" on page Error! Bookmark not defined. . 1 The stove should be in place ...

  • Lopi Answer Wood Stove - page 40

    40 Optional Equipment Travis Industries 93508131 4 020327 Outside Air Boot Installation (Part number 99200134) The outside air boot routes outside air to the stove for combustion. Refer to the section "Outside Air Requirements" on page Error! Bookmark not defined. for installation concerns. The directions below detail installation. 1 Inst ...

  • Lopi Answer Wood Stove - page 41

    Optional Equipment 41 Travis Industries 93508131 4 020327 Surround Panels (see part #'s below) Rectangular Panels: Surround Panel Size Size on Appliance (Including Trim) PART # 8" 40 1/8" width by 28 1/4" height 99300106 10" 44 1/8" width by 30 1/4" height 99300107 Arched Panels (Part # 99300108) 40-1/4 ” 31-3/4 ...

  • Lopi Answer Wood Stove - page 42

    42 Optional Equipment Travis Industries 93508131 4 020327 3. Place the insert into the fireplace and connect the flue (if using a positive or direct connection). Install the top panel and trim following the directions below. Install the top panel so the two tabs insert into the joggle clips on the top panel. Top Panel "L" Bracket Double-B ...

  • Lopi Answer Wood Stove - page 43

    Optional Equipment 43 Travis Industries 93508131 4 020327 Front Blower (part # 99000128) TO SWITCH THE POWER CORD TO THE LEFT SIDE: Use a pair of pliers to disconnect the strain relief which holds the power cord in place. With the power cord slackened, the molex connectors that attach the power cord to the blower assembly may be disconnected. Pry t ...

  • Lopi Answer Wood Stove - page 44

    44 Index Travis Industries 93508131 4 020327 Air Control ....................................................2 5 Air Tube Part Number ....................................3 3 Air Tube Removal & Replacement .................... 3 4 Alcove .........................................................1 2 Ash Disposal ................................... ...

Manufacturer Lopi Category Stove

Documents that we receive from a manufacturer of a Lopi Answer Wood Stove can be divided into several groups. They are, among others:
- Lopi technical drawings
- Answer Wood Stove manuals
- Lopi product data sheets
- information booklets
- or energy labels Lopi Answer Wood Stove
All of them are important, but the most important information from the point of view of use of the device are in the user manual Lopi Answer Wood Stove.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Lopi Answer Wood Stove, service manual, brief instructions and user manuals Lopi Answer Wood Stove. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Lopi Answer Wood Stove.

Similar manuals

A complete manual for the device Lopi Answer Wood Stove, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Lopi Answer Wood Stove by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Lopi Answer Wood Stove.

A complete Lopi manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Lopi Answer Wood Stove - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Lopi Answer Wood Stove, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Lopi Answer Wood Stove, that we can find in the current document
3. Tips how to use the basic functions of the device Lopi Answer Wood Stove - which should help us in our first steps of using Lopi Answer Wood Stove
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Lopi Answer Wood Stove
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Lopi Answer Wood Stove in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Lopi Answer Wood Stove?

Use the form below

If you did not solve your problem by using a manual Lopi Answer Wood Stove, ask a question using the form below. If a user had a similar problem with Lopi Answer Wood Stove it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)